27 of the
34 complaints filed about the Acura MDX Type S
are about the transmission —
79% of everything owners reported.
The worst model year for it is 2022.
27
Complaints
79%
Share of all complaints
0
Crashes
0
Fires
Transmission & Drivetrain complaints by model year
While making a left turn from an on-ramp, I heard a loud crunch from the drivetrain and experienced a momentary loss of power. Immediately afterward, the front tires began spinning under acceleration. I realized the vehicle was no longer sending power to the rear wheels and had effectively lost its all-wheel-drive capability. The instrument display continued to indicate that power was being sent to the rear wheels even though the rear wheels were not receiving power. This gave an inaccurate indication of the vehicle’s operating condition. The vehicle was inspected by an authorized Acura dealer. The dealer confirmed that the splines between the transmission and the front power takeoff unit had stripped. The transmission/front differential assembly and power takeoff unit were replaced under warranty at approximately 52,280 miles. The dealer stated that this is a problem they have been seeing on the MDX Type S and also commented on the number of revisions that have been made to the power takeoff unit. The replacement unit installed was part number 29000-61E-070. The failure created a safety concern because it caused a momentary loss of propulsion while turning into traffic, followed by unexpected front-wheel spin and loss of all-wheel drive. There were no warning lights or advance warning before the loud crunch and loss of power. The failed components were replaced by the dealer; whether they remain available for inspection is unknown.
NHTSA complaint #11751644 — an unverified report by a vehicle owner.
The contact owns a 2023 ACURA MDX. The contact stated that while driving on the highway at 45 MPH an abnormal sound was emitted from underneath the vehicle, and the vehicles steering was being pulled to the right, no warning lights were illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed and the contact was advised that that the PTU/PTO was faulty as metal shavings were found in the transfer case and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 50,000.
NHTSA complaint #11750629 — an unverified report by a vehicle owner.
Monday, June 30th, 2025, while driving on highway trip out of state, the vehicle made severe explosion noise, and sounded like I was dragging something metal under the vehicle for approx 30 seconds. After slowing the vehicle, I confirmed there was nothing under the car and the car seemed to be driving fine. There was zero warning light displaying any type of part failure or warning light addressing anything needed attention. In hindsight, I realize that this is when the transmission transfer case malfunctioned. Entire time since I've had the brand new, premium vehicle the car has had routine, healthy maintence from the dealership and also Christian Brothers Automotive when the dealership service center was under construction. At no point, did the dealership bring this issue to my attention, despite a few multipoint inspections. Once my vehicle was out of warranty, the dealership brought the internal malfunction of the transmission transfer case to my knowledge on June 1, 2026. I am a high mileage driver, and this part malfunctioned (unbeknownst to me) while I was still under warranty, however without the warning light, I was ignorant to what actually occurred. Local acura dealership has briefly commented on this, suggesting we file a good will claim. I am reporting this, because I believe this part needs to be RECALLED. No one needs to deal with an internal part malfunction on a brand new vehicle 50-60k miles in. I have had the dealership, and Christian Brothers automotive both, look at the issue once it was brought to my attention, to confirm it is indeed no longer an AWD vehicle without the 13k repair. I am grateful that I was in a place that was flat, and not in need of the AWD when it went out, it was a very distrubing and distracting situation when it occurred, and with my living conditions I don't used AWD but a few times a year. Glad no one was injured when the part failed, it could have seriously ended differently if there was traffic around.
NHTSA complaint #11746956 — an unverified report by a vehicle owner.
The transfer case on my 2024 Acura MDX Type S failed with under 30,000 miles. I believe there's a public investigation from the NHTSA, I wanted to ensure my case was reported.
NHTSA complaint #11744800 — an unverified report by a vehicle owner.
The vehicle's all wheel drive system has malfunctioned at 77,000 miles with a known all wheel drive system issue. Because we are 7k beyond the power train warranty, Acura is not wanting to cover the repair even though this is a known issue.
NHTSA complaint #11742445 — an unverified report by a vehicle owner.
Reporting an additional case in support of ongoing defect petition investigation DP26001. 2022 Acura MDX Type S SH-AWD, currently at 63,700 miles. While driving and making a turn, I heard a grinding noise with no warning lights illuminated. I stopped immediately and shut off the engine but noticed no abnormality. I restarted the vehicle and drove with no further issues or noises. Later, during a scheduled oil change, I discovered that the area between the transmission and PTU was covered in oil. The Acura dealership diagnosed a bad PTU seal and replaced the PTU under powertrain warranty, but completely disregarded my concern regarding investigation DP26001 and the known issue with stripped splines. The leak was repaired, but several weeks later while driving in the rain, the vehicle felt very unstable during acceleration on wet pavement. I raised the vehicle on a lift and engaged drive to inspect AWD function. The rear wheels were not spinning while the front wheels were, and the driveshaft was also stationary. When I brought this to the dealership’s attention, they stated this is normal SH-AWD behavior — however, I have personally observed all four wheels spinning under identical conditions in another Acura of the same model and configuration. I am confident the transmission-to-PTU splines are stripped and am escalating this to Acura corporate for further investigation.
NHTSA complaint #11741389 — an unverified report by a vehicle owner.
Under medium acceleration vehicle shuddered a lot. Currently it’s only driven by the front wheels and it will torque steer a lot. I’m assuming my splines are stripped to transfer case. Thankfully, I am under warranty and I’m going to get this repaired.
NHTSA complaint #11741153 — an unverified report by a vehicle owner.
When about to make a left turn since oncoming traffic on to highway I hit the gas quickly after stopping and heard a loud bang. Drove till I got off the highway at a red light I hit the gas and noticed the front wheels was spinning and realized it wasn't a awd. Took it the dealer and they realzied the driveshaft was spinning by hand.
NHTSA complaint #11739430 — an unverified report by a vehicle owner.
There was a loud noise from under the car, and the car suddenly started to experience wheel spin. It's AWD and should not be spinning the tires. Suddenly losing AWD is dangerous when you expect the car to perform like an AWD car. Dealership said the transmission spline is stripped and needs replaced under warranty. Car has currently been at the dealership for 50 days. There is no known ETA on replacement parts. No warnings on anything, the car's power distribution meter still shows power going to the rear wheels even though it is not. I believe there is already an active investigation into this issue.
NHTSA complaint #11738699 — an unverified report by a vehicle owner.
The component that malfunctioned was the transfer case, the vehicle was already repaired so an inspection isn't possible anymore. The vehicle behaved as normal until the accelerator was pressed enough to make the front wheels lose traction, in which the vehicle couldn't send power to the rear, because the transfer case was shredded up. When needing to accelerate quickly in traffic, the vehicle would completely spin up the front tires, not being able to put the power down. The dealer reproduced the problem, but initially stated that it was most likely due to the salt on the road (it was winter). As spring arrived, the problem still persisted, in which the dealer checked the transfer case and found it was shredded. They replaced the transmission and transfer case under warranty. There were no warning lights, but accelerating quickly would cause the car to spin up the front tires uncontrollably. In corners, this meant severe understeer that could be dangerous in the wrong circumstances.
NHTSA complaint #11727832 — an unverified report by a vehicle owner.
Catastrophic Power Take-Off Unit (PTU) and Transmission spline failure on a 2022 Acura MDX Type-S vehicle. Had dangerous loss of traction and unexpected handling characteristics with rough shifting, RPM Surges, Sensor problem LOSS OF Power, Delayed shifting with Jerky ride, and a smell of burning oil or rubber, also would move into reverse and the Drive Letter "D" was blinking. The problem was confirmed by Independent service center and it was inspected by the manufacturer. Messages indicating engine/transmission issues appeared on Jan 4, 2026; *Transmission system problem. Paddle shifters not available. See your dealer. *Emissions system problem. Power may be reduced. See your dealer. * Transmission system problem. Avoid heavy acceleration and High speed. See your dealer. * AWD All Wheel Drive system problem. Only the Front wheels may be powered. See your dealer. Notes: (A.) Transmission system errors and infotainment warnings appeared upon concluding a round-trip 3,000+ miles from Southern California to East Texas and back home to Yuma AZ. (B.) After Honda Motor Co gave a 75% Goodwill Offer to replace control box and valves, they indicated that the transmission also need to be replaced. Furthermore, they rescinded the 75% Goodwill coverage which appears to be based solely on the incorrect assumption that third-party transmission repairs were performed and that the transmission was overfilled.
NHTSA complaint #11723962 — an unverified report by a vehicle owner.
I own a 2022 MDX Type-S. I recently read about complaints about TLX and MDX models losing their AWD system and only resulting to FWD. I was a victim of this in Montana and it was a long fight with Acura / Honda to look at the problem. It was also very dangerous as I worked up in Big Sky and would rely on the AWD system in snowy conditions. This system would always fail. After a long fight, they finally towed my vehicle back to Salt Lake City, where it was purchased from, and replaced a "sensor."
NHTSA complaint #11723357 — an unverified report by a vehicle owner.
Starting hearing issues late 24 of MDX and TLX losing all-wheel-drive due to splines stripping between the transmission and transfer case. Had car thoroughly inspected and fluid samples taken in December of 24. In February on 25 with a frame rattling bang as I was pulling out onto a street, rear wheel drive went out at 64k. No warning lights and no indicators, dash showed all 4 tires pulling. Dealership verified system was stripped as rear tires were not turning. Also discovered connection between the two units failed allowing water to get in and wash all grease out around the spines. New transmission is two parts number newer than original and transfer case is one parts number newer than original. Also noted transmission and transfer case take less fluids than original. Car feels a lot tighter and smoother on shifting with new units.
NHTSA complaint #11722903 — an unverified report by a vehicle owner.
The vehicle is experiencing a catastrophic mechanical failure of the transfer case/transmission splines, resulting in a 'Loss of Motive Power.' On two occasions while merging into high-speed highway traffic, the engine revved to high RPMs, but the vehicle failed to accelerate for approximately 5 seconds (Mechanical Neutral Drop). These incidents resulted in near-collisions. The vehicle also exhibits violent torque steer and unpredictable handling. The issue was initially reported to an authorized dealer at 70,320 miles but was misdiagnosed as 'no codes were present.' Subsequent inspection by a second dealer confirmed a mechanical failure of the drive splines. This is a purely mechanical failure that does not trigger dashboard warning lights or Diagnostic Trouble Codes (DTCs), leaving the driver unaware of the impending drivetrain failure until power is lost. First signs of a problem: Late August 2025 First loss of motive power incident: Early October 2025 Second loss of motive power incident: [XXX] Initial Dealer Report: October 28, 2025 (MetroWest Acura) Confirmation video from Acura of Boston: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11710451 — an unverified report by a vehicle owner.
Vehicle is 3 years old with 60K miles. Transfer case became defective under normal driving and with regular recommended maintenance. We did not know this occurred until a recent dealership visit for another issue. We do not know how long this has been an issue. When the transfer case malfunctioned, there were no warning lights and vehicle has been only functioning in front-wheel drive (designed to be AWD) which is extremely dangerous during the midwestern winters as the weight of the rear of the vehicle leads to sway. Issue was detected by the dealership who states the fix is to replace the entire transmission and transfer case.
NHTSA complaint #11702881 — an unverified report by a vehicle owner.
While making a left turn into a parking lot my car exhibited a loud bang noise. It felt as if the car had been hit from the rear. While applying the gas the car jerked and popped in the rear. I had the car towed to a dealership where I was informed the transfer case had " Destroyed itself". The gears broke apart internally. I was also informed that the transmission power take off was destroyed.The car only has 87000 miles on it and has been serviced at recommended intervals. The dealership quoted 19000.00 dollars to repair. The car was out of Acura"s powertrain warranty. I had a third party warranty that I used to repair the car. I was 5 hours away from home when this occurred. I was without a car for 4 weeks. I believe that this is a manufacture problem and is dangerous. There were no warning lights before or after the event. The car has been repaired. I have a video of the dealerships diagnosis of the transfer case and transmission failure.
NHTSA complaint #11700964 — an unverified report by a vehicle owner.
The transmission and transaxle malfunctioned. Evidence was a leak from the transaxle. The dealer confirmed that the vehicle was operating in 2WD mode even though it did not detect any issues from its onboard sensors, and the car thought it was still sending power to all 4 wheels. There were no warning lights that the vehicle was no longer driving in 4wd mode, so the driving dynamics would've been unexpected in conditions that 4wd would normally help, like rain and snow. Unexpectedly experienced tire spin in the rain, for example. The dealer confirmed that both the transmission and transaxle need to be replaced, under the powertrain warranty. The spline between the transaxle and transmission were worn, causing the transaxle to not spin the rear wheels.
NHTSA complaint #11700591 — an unverified report by a vehicle owner.
Upon normal highway driving a couple of months ago, began to notice shifting that was not smooth and rpm "surges" on hills despite constant throttle. Upon taking car to dealer, inspection revealed an internal spline failure between transmission and transfer case. Lead mechanic explained it was not the first he had seen of this model and that it was clearly internal and caused by a manufacturing and/or assembly defect. I caught the problem early enough to not have a complete car failure; however, left untreated, it would lead to a transmission failure. The remedy was a full transmission and transfer case replacement, with repair costs exceeding $13,000. Given car had 84,000 miles, it was not covered by 70,000 Power Train Warranty from Acura. Pictures of parts below.
NHTSA complaint #11691842 — an unverified report by a vehicle owner.