35 of the
150 complaints filed about the Chevrolet Malibu Hybrid
are about the electrical system —
23% of everything owners reported.
The worst model year for it is 2017.
The contact owns a 2016 Chevrolet Malibu. The contact stated that while shifting into park(P), the vehicle failed to recognize that the transmission was in park(P). The contact had to manipulate and maneuver the gear shifter several times before the vehicle recognized that the gear shifter was in park(P). The message to "Shift-to Park" was illuminated. While receiving a routine oil change, the vehicle failed to start. The mechanic charged the battery; however, the vehicle failed to start. The vehicle was inspected, and it was determined that the was experiencing the "Shift to Park" failure. The contact found information of NHTSA Campaign Number: 16V502000 (Electrical System, Power Train); and linked the failure to the recall. The dealer was contacted and confirmed that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 72,000.
NHTSA complaint #11667071 — an unverified report by a vehicle owner.
Stability track warning randomly appears while driving and spontaneously causes total brake failure and the brakes fail to slow or stop vehicle. It has newer brakes but it’s very dangerous to drive. Currently being sent to Chevrolet dealership
NHTSA complaint #11666586 — an unverified report by a vehicle owner.
The check engine light came on and we brought it to the shop where they said the code is for the electronic brake system modulator. It is also causing the ABS to malfunction and be hypersensitive. There is a recall for the same make/model/year of vehicle, except the month before her car was manufactured. I believe this is a safety issue that needs to be looked into and that her car should also be a part of this recall. We purchased the car in mid November and the engine light showed up a couple weeks later. I contacted GM who said to contact this site to request further investigation for safety risks.
NHTSA complaint #11635349 — an unverified report by a vehicle owner.
The car has a reoccuring problem where is stalls in the middle of driving the vehicle. A warning comes up to shift to park. The car then restarts, runs extremely rough and stalls out. It then signals to shift to park again. The car is extremely unsafe. I took the vehicle to GM dealer and they said the car is "confused" between running on the battery and combustible engine. I have seen several similar issues with the Cheverolt Malibu Hybrid. I think GM knows they have an issue and one of the reasons they discontinued the model.
NHTSA complaint #11626907 — an unverified report by a vehicle owner.
There’s a warning on the display that says ‘shift to park’ while the vehicle is already in park. This is causing the battery to drain/die and needs jumpstart everyday. Battery was tested and does not need to be replaced. I’m surprised this hasn’t been recalled yet. Online search ‘Chevy Malibu shift to park’ shows this is a common problem. Here’s a YouTube link that includes comments to prove this further. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11611028 — an unverified report by a vehicle owner.
In 2019 I took my vehicle under warranty to the purchasing dealership to fix a "shift to park" reading after the vehicle is parked. It precludes turning off the car. Repeatedly restarting the car and shifting to park and/or jiggling the controller in park usually stopped the reading. The dealer replaced the control shifter, which fixed the problem for many years. This August, the problem started recurring and I have been attempting to make an appointment in the last week, but none of the local dealers say they can repair this for some time. Most cannot even diagnose the problem for a week or two.
NHTSA complaint #11544252 — an unverified report by a vehicle owner.
the secondary battery that sits in the trunk, above the back driver side tire had a short. the cable bunt out and my car reduced speed and it had me pull over. I did not know this is what had happened until i drove it again and i could no longer start it. the shift knob is locked and cant put it on drive or neutral. initializing wait to shift, theft deterrent system, transport mode on, stabilitrak, among other things popped up. Had that short sparked up into an actual fire, yes, my life could have been at risk as the car could have caught on fire. Due to it being a long weekend (memorial day weekend) I couldn't take it to a Chevy dealer. I am on an out of town trip for my kids soccer tournament. i currently have it sitting a tow yard waiting to take it to my house, and then towed to Chevy dealer in Hemet, CA, where I live.
NHTSA complaint #11524202 — an unverified report by a vehicle owner.
The contact owns a 2017 Chevrolet Malibu. The contact stated that after his wife parked the vehicle, the "Shift to Park" message was displayed while the gear selector was shifted into park(P). The vehicle would not turn off until after several attempts; however, the failure recurred with the doors locking the contact's wife and 3 children inside of the vehicle. The contact's wife was able to turn off the vehicle while the brake pedal was depressed and the Start/Stop button was pressed and unlocked the doors with the key fob. The dealer was made aware of the failure and sent a tow truck to retrieve the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 57,733.
NHTSA complaint #11461784 — an unverified report by a vehicle owner.
I was driving my car home from work and all of a sudden my car starting showing in the dash engine power reduced. My car literally couldn't go anywhere. So I pulled over and shut the car off for a minute started it back up and it was running great and then I happen again a few minutes later. So I took it to the dealership were i purchsed it and they replaced the gas pedal they said a sensor was bad and that was causing the problem.So picked up the car a couple days later and it happen again about two weeks later...
NHTSA complaint #11458179 — an unverified report by a vehicle owner.
As I was driving with cruise control on a freeway at 70 mph the car suddenly displayed a warning to reduce speed. I continued to try to get to the next exit but almost instantly it started reducing my power and slowed me down to a crawl. I pulled over on the freeway and it would not restart. The tow truck to it to a chevy dealer and the next morning they called asking for details as the car started right up and they drove it around for 10 minutes without issue. They kept the vehicle all day but were unable to recreate the problem so they told me there was nothing they could do. They pulled 17 codes and said that's too many to diagnose so nothing to do. I drove 15 miles home with no issues. The next day I went to get the oil changed and they tested the 12V battery and told me it failed. I went to buy a battery and drove home. The next day I drove around 10 miles and then it dies again as I was slowing down to a stoplight. I pushed it to a parking lot and installed the new battery. I took the old battery back to the store to get my core deposit back and asked them to test it. They said it tested fine but I went ahead and gave it to them as I already had the new battery installed and it's a pain in the rear to do. On the 3 mile trip home they car jerked/slipped shifting briefly and the check engine light came on. OnStar sent me a notification the first time telling me the battery was drained and I needed to charge it. The second time I received a notification that there was an issue with the "electronic drivetrain" and needed to take it in for service. I'm taking it to the dealer I purchased it from tomorrow to see if they can figure it out.
NHTSA complaint #11450678 — an unverified report by a vehicle owner.
Car voltage stays very high (between 14.8 and 15 volts) for extended periods of time. At which point the windows have fogged up and there is a raw egg smell in the cabin - probably Sulfur. Both the hybrid and the 12v car battery are located in the truck and there are vents that draw air from the cabin to ventilate those batteries. The car voltage will also stay at 12.5 to 12.6 for extended periods of time. During both high and low periods numerous internal systems have failed, including bit not limited to steering assist, anti-locks bakes, Stabilitrack, On star, Hybrid Control Processor and ECM. Car has been brought to the dealer 3 times. First time (early November 2021) it was diagnosed with an hybrid inverter and a software update was installed. Issues continued. As of 12/28/21, Coggin Chevrolet (Jacksonville, FL) has had the car for 2 weeks and can't fix or confirm what is wrong with the car. I have received numerous e-mails from On-star with engine error codes as well as 5 messages saying there is an issue with the Electric Drive Unit in the car. The car has roughly 24K miles on it.
NHTSA complaint #11445397 — an unverified report by a vehicle owner.
The contact owns a 2016 Chevrolet Malibu Hybrid. The contact stated while driving at 55 MPH, electrical system, power steering, and battery warning lights illuminated on the instrument panel. The vehicle proceeded to decelerate while the accelerator pedal was depressed. The battery saver warning light was illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the failure was due to the radio and an electrical failure. The vehicle was not included in NHTSA Campaign Number: 16V084000 (Electrical System) or 16V502000 (Electrical System, Power Train). The manufacturer was contacted and informed of the failure. The VIN was not available. The failure mileage was 49,000.
NHTSA complaint #11435131 — an unverified report by a vehicle owner.
Get "SHIFT TO PARK" after putting car in park to shut it off. I am unable to turn the car off - so do I leave it running in my garage? This is a known error that they charge to fix. https://static.nhtsa.gov/odi/tsbs/2020/MC-10186071-9999.pdf Attached is my bill to have this known error fixed.
NHTSA complaint #11430077 — an unverified report by a vehicle owner.
Engine lost power on interstate highway. While this did not result in a crash/ rear end collision, the potential for such injury seems high. 1-2 days prior there were some warning lights (check engine light). Called a dealership Tuesday morning and earliest service appointment was in one week but they assured me that the car was drivable in the meantime. On Wednesday afternoon my son was driving on the interstate and there was a new message “engine power reduced”, and a sudden loss of power. Eventually got the car to nearest Chevrolet dealership. Their technician took over a week to figure out what was wrong; eventually they replaced the ECM but still had problems. After a software update to ECM the problem finally appears to be resolved. Please note that similar problem has been reported with other Malibu models, but my Malibu Hybrid was not recalled. Please consider a recall of all GMmodels similar to the Malibu
NHTSA complaint #11421044 — an unverified report by a vehicle owner.
HYBRID BATTERY CORROSION DUE TO FAULTY BRAKE LIGHT LETTING WATER INTRUDE INTO TRUNK. I WAS OUT OF COUNTRY FOR MOST OF 2019 AND WHEN I RETURNED I WENT THROUGH MAIL AND DISCOVERED A LETTER FROM GM STATING THAT WATER CAN GET INTO TRUNK AND CABIN FROM A CHMSL. I CHECKED MY TRUNK AND IT WAS FULL OF WATER AND METAL ITEMS ARE AND WERE OXIDIZED AS WELL AS THE HYBRID BATTERY IN THE TRUNK. THIS CORROSION WILL NOT STOP ONCE ESTABLISHED ESPECIALLY WITH CHARGED ELECTRONIC COMPONENTS. AND PREMATURELY SHORTENING THE LIFE OF THE HYBRID BATTERY DUE TO POOR QUALITY AND DEFECTIVE NUTS USED TO SECURE THE CHMSL.
NHTSA complaint #11310278 — an unverified report by a vehicle owner.