139 of the 155 complaints filed about the Ducati Sport Classic are about the fuel system — 90% of everything owners reported. The worst model year for it is 2006.
139
Complaints
90%
Share of all complaints
1
Crashes
0
Fires
FUEL/PROPULSION SYSTEM
THE STOCK PLASTIC GAS TANK EXPANDED AND IT COMES OUT OF IT'S INTENDED POSITION.
NHTSA complaint #11388630 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
2007 DUCATI SPORT 1000S - GAS TANK HAS BEEN DEFORMED. IT NO LONGER SITS PROPERLY IN THE MOUNTING POINTS ON THE SIDE. IT HAS EXPANDED BEYOND THE POINT OF SITTING PROPERLY IN THE MOUNTING POINTS IN THE FRONT. THE TANK NOW RESTS UNSECURED ON THE FRAME AND WILL SHIFT AND TEETER FROM SIDE TO SIDE WHILE THE BIKE IS IN MOTION.
NHTSA complaint #10735046 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I WAS SENDING IN A COMPLAINT DUE TO THE FACT THAT I HAVE READ THAT THERE WAS LAWSUIT REGARDING THE GAS TANKS EXPANDING ON DUCATI'S. I WANTED INFORMATION ON HOW TO GO ABOUT GETTING MINE REPLACED.
NHTSA complaint #10497756 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
GAS TANK DEFORMED AND WAS LOOSE. HAD IT REPLACED ONCE BY THE DEALER. NOW TWO YEARS LATER THE REPLACED TANK IS DEFORMED AND WILL BE LOOSE.
NHTSA complaint #10451329 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
THE GAS TANK HAS EXPANDED TO THE POINT THAT IT DOES NOT STAY IN THE HOLDING BRACKETS. THE TANK IS LOOSE AND IS A DANGEROUS DRIVING HAZARD. DUCATI IS REPLACING THE TANK WITH THE EXACT SAME MATERIAL WHICH DOES NOT SOLVE THE PROBLEM. A TANK MADE OUT OF THE SAME MATERIAL WILL RESULT IN THE SAME PROBLEM ALL OVER AGAIN. A PERMANENT SOLUTION SHOULD REQUIRE A CHANGE IN THE GAS TANK MATERIAL USED.
NHTSA complaint #10447406 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
FUEL TANK OF SAID 2006 DUCATI SPORT CLASSIC, 1.) FUEL TANK HAS EXPANDED NO LONGER FITTING INTO THE BRACKETS THAT HOLD THE FUEL TANK SECURELY IN PLACE. (FUEL TANK WOULD MOVE ABOUT) 2.) FUEL TANK DEVELOPED DEFORMATION ALONG THE TOP PORTION OF THE FUEL TANK APPROXIMATELY A 10 MM IN LENGTH AREA (LEFT OF FUEL FILLER CAP). 3.) FUEL TANK DEVELOPED PROTRUDING DIMPLES ALONG RIGHT SIDE AND LEFT SIDE OF FUEL TANK. 4.) FACTORY DECAL ON FUEL TANK DEVELOPED A 1.5 MM DIA. X .3 MM PROTRUDING BUBBLE ON THE FRONT PORTION OF THE FUEL TANK NEAR THE IGNITION SWITCH.
NHTSA complaint #10441052 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
THE FUEL TANK ON MY MOTORCYCLE HAS SPREAD AND DISTORTED ENOUGH THAT IT HAS FALLEN OFF THE FRAME OF THE MOTORCYCLE. WHILE RIDING THE MOTORCYCLE AT NORMAL HIGHWAY SPEED, WIND WILL ACTUALLY LIFT THE FUEL TANK UP AND THE RIDER MUST HOLD IT IN PLACE SO IT DOES NOT SEPARATE COMPLETELY FROM THE VEHICLE. I WAS IN FEAR FOR MY SAFETY WHEN RIDING MY MOTORCYCLE EVEN THOUGH THE DEALER INSISTS THAT DUCATI SEES THIS AS A NORMAL CONDITION. I PUSHED THE ISSUE WITH THE DEALER AND THEY HAVE REFUSED MY LATEST REQUEST FOR A REPLACEMENT FUEL TANK UNDER WARRANTY (GOOD FAITH OR OTHERWISE). THE NEW REPAIR PROVIDED WAS TO INSTALL A LARGER BRACKET ON THE FRAME OF THE MOTORCYCLE TO TRY AND RETAIN THE DEFECTIVE TANK. THIS DOES NOT SOLVE THE ORIGINAL ISSUE OF A POORLY MANUFACTURED AND FAULTY FUEL TANK ON THE VEHICLE.
NHTSA complaint #10436164 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
ON OCTOBER 28, 2011, WHILE OPERATING MY 2006 DUCATI SPORTCLASSIC I NOTICED THAT THE FUEL TANK WAS LOOSE TOWARDS THE FORWARD PART OF THE FUEL TANK. UPON FURTHER INSPECTION, I OBSERVED THAT THE FUEL TANK WAS NO LONGER SECURED BY EITHER THE LEFT-SIDE OR RIGHT-SIDE MOUNTING BRACKETS ATTACHED TO THE VEHICLE FRAME. IT IS CLEAR THAT THE DIMENSIONS OF THE PLASTIC FUEL TANK OVER TIME HAS WARPED OR CHANGED TO SUCH AN EXTENT AS TO RENDER THE TWO FORWARD SECURING BRACKETS INEFFECTIVE IN THEIR PRESENT STATE. THIS RESULTS IN THE FUEL TANK DEPENDENT SOLELY ON A SINGLE REAR MOUNTING BOLT TO SECURE THE FUEL TANK IN PLACE. AS A CONSEQUENCE, IT IS CLEAR THAT ANY OPERATOR OF THE VEHICLE RISKS INJURY SHOULD THE FUEL TANK COME LOOSE OR BECOME UNSTABLE WHILE OPERATING THE VEHICLE. IT HAS ALSO BEEN OBSERVED THAT THE FUEL TANK DIMENSIONS HAVE OVER TIME WARPED TO SUCH AN EXTENT AS TO NOW IMPEDE THE FULL USE OF THE VEHICLE STEERING MECHANISM. THIS ALSO RESULTS IN INCREASED RISK OF INJURY TO ANY OPERATOR OF THE VEHICLE. IT IS CLEAR THAT AN EFFECTIVE, PERMANENT SOLUTION IS REQUIRED OF THE MANUFACTURER TO ADDRESS THE SAFETY ISSUES RELATED TO THIS FUEL TANK AS ITS PRESENT DESIGN, MATERIALS, AND MANUFACTURE IS DEFECTIVE.
NHTSA complaint #10434369 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
NOTED FUEL LEAKING WHERE FUEL PUMP HOUSING ATTACHES TO COMPOSITE FUEL TANK. FUEL PUMP HOUSING, CONNECTIONS, AND FITTINGS HAVE NEVER BEEN REMOVED OR ALTERED IN ANY WAY, SHAPE, OR FORM BY THE OWNER OF THE VEHICLE (OWNED 4/12/2007 TO PRESENT). ISSUE APPEARS BE RELATED TO COMPOSITE (NON-METALLIC) FUEL TANK DEFORMATION OVER TIME. LEAKING FUEL IS A SERIOUS SAFETY-ISSUE THAT MAY CAUSE POTENTIALLY SERIOUS INJURY, HARM, OR DAMAGE TO THE VEHICLE OPERATOR, VEHICLE, AND OTHER PERSONS AND/OR PROPERTY.
NHTSA complaint #10434375 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
FUEL TANK IS SPREADING AND IS NOW LOOSE ON IT'S MOUNTS. POSSIBLE FOR IT TO LIFT AT THE FRONT OF THE TANK. THIS IS UNSAFE AS IT COULD COME LOOSE WHILE DRIVING/RIDING AND CAUSE A SERIOUS ACCIDENT OR LOSS OF CONTROL. ALSO POSES A RISK OF HAVING FUEL LEAKING EITHER WHILE RIDING OR PARKED WHICH I COULD BE FINED FOR. THIS IS A DEFECT THAT IS JUST BEING PATCHED UP AND NOT RECTIFIED BY DUCATI. NUMEROUS ATTEMPTS HAVE BEEN MADE TO HAVE THIS PROBLEM SOLVED BY MYSELF AND OTHERS WITH THE SAME PROBLEM. LEAKING FUEL IS ALSO A SERIOUS ENVIRONMENTAL ISSUE AS WELL.
NHTSA complaint #10424029 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
FUEL TANK (PLASTIC) HAS SWOLLEN OND NO LONGER ATTACHES TO THE FRAME OF THE MOTORCYCLE ON THE SIDES. TANK MAY COME OFF IN AN ACCIDENT OR PERHAPS RIDING. THIS COULD BE VERY SERIOUS WITH FIRE, INJURY, LOSS OF CONTROL.
NHTSA complaint #10422323 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
THE TANK ON MY 2007 DUCATI SPORT 1000 BIPOSTO HAS SPREAD HALF AN INCH ON EACH SIDE OF THE TANK. THE RUBBER PART OF THE MOUNT HAS EXTENDED ALMOST PASSED THE METAL BRACKET, MAKING IT LOOSE AND EXTREMELY UNSAFE.
NHTSA complaint #10421671 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
1. I NOTICED DIMPLES ON THE TOP OF MY GAS TANK AND THEN CHECKED THE MOUNTING BRACKETS FOR THE GAS TANK. THE GAS TANK COULD BE PULLED COMPLETELY OFF THE MOTORCYCLE WITHOUT MUCH EFFORT. 2. THIS IS A FAILURE THAT CANNOT RECTIFY ITSELF AND SLOWLY DEGRADES MORE AND MORE. 3. THE MOTORCYCLE WAS TAKEN INTO A DUCATI SERVICE SHOP AND THEY "SHIMMED" THE GAS TANK BRACKET TO PREVENT IT FROM BEING ABLE TO REMOVE IT COMPLETELY. THE TANK WAS STILL LOOSE, BUT COULD NOT BE REMOVED COMPLETELY. SINCE THE SHIMMING OF THE BRACKETS, THE TANK HAS WARPED AND SPREAD FURTHER AND IS LOOSER THAN WHEN ORIGINALLY SHIMMED. THIS CAUSES A SHAKING OF THE GAS TANK AT NORMAL OPERATING SPEED WHEN MY LEG COMES IN CONTACT WITH THE GAS TANK.
NHTSA complaint #10421650 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
FUEL TANK IS SPREADING AND IS NOW LOOSE ON IT'S MOUNTS. POSSIBLE FOR IT TO LIFT AT THE FRONT OF THE TANK.
NHTSA complaint #10420872 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2007 DUCATI SPORT CLASSIC 1000 MOTORCYCLE. WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. ALSO, THE FUEL TANK WAS ABNORMALLY STRETCHED DUE TO FUEL LINE TENSION. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 07V017000 (FUEL SYSTEM, GASOLINE: DELIVERY: HOSES, LINES/PIPING, AND FITTINGS). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO REFERRED THE CONTACT TO AN AUTHORIZED DEALER FOR SERVICE. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 3,600.
NHTSA complaint #10410681 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
GAS TANK HAS SPREAD AND IS NO LONGER SECURELY MOUNTED TO THE MOTORCYCLE.
NHTSA complaint #10397385 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
I PURCHASED A 2006 DUCATI SPORTCLASSIC FROM A DUCATI DEALER IN 2006, AND HAVE SINCE PUT APPROXIMATELY 2700 MILES ON THE BIKE. THE MOTORCYCLE HAS ALWAYS BEEN GARAGED AND PREMIUM FUEL USED. THE MOTORCYCLE'S GAS TANK IS MADE OF SOME SORT OF PLASTIC OR FIBERGLASS, AND SO IT HAS SPREAD TO THE POINT WHERE THE RUBBER CUPS THAT ARE SUPPOSED TO HOLD IT TO THE FRAME ON EITHER SIDE ARE NO LONGER IN PLACE. SINCE THE TANK IS ONLY HELD ONTO THE FRAME VIA ONE SCREW MOUNT, THE TANK CAN BE ALMOST COMPLETELY LIFTED OFF OF THE FRAME IN THE FRONT. THE TANK HAS ALSO WARPED ON THE TOP RIGHT SIDE, IN A "WAVY" PATTERN. DUE TO THE LOOSENESS OF THE TANK, IF THIS BIKE WERE TO BE IN AN ACCIDENT, THE TANK COULD COME OFF AND RESULT IN A FIRE, POSSIBLY BECOME A BOMB. IN ADDITION TO THE LOOSE TANK, SINCE IT HAS SPREAD ON THE BOTTOM, THE HANDLE BAR ON THE LEFT HAND SIDE NOW COMES INTO CONTACT WITH THE TANK, WHICH COULD CAUSE AN AESTHETIC BLEMISH, AND REDUCES THE TURNING RADIUS, IN ADDITION TO POSSIBLY CAUSING INJURY AT SLOW SPEEDS IF THE RIDER CATCHES HER HAND BETWEEN THE BAR AND TANK. I HAVE CONTACTED A DEALERSHIP NEARBY, AND THEY WILL TAKE PICTURES OF IT, AND HAVE TOLD ME THAT DUCATI WANTS THE DEALERSHIP TO "SHIM" THE TANK FIRST, MEANING THAT THEY WOULD ADD WASHERS ON EITHER SIDE TO TRY TO STABILIZE THE TANK. IF THIS IS UNABLE TO BE FIXED, DUCATI *MAY* REPLACE THE TANK WITH A TANK OF THE SAME TYPE OF MATERIAL, AND THE PROBLEM WOULD HAPPEN AGAIN. IF THE BIKE, WHICH IS A 2006, IS OUT OF WARRANTY, DUCATI MAY MAKE ME PAY FOR THE "REPLACEMENT" TANK (APPROX $1800), AND HAS (TO DATE) OFFERED NO REAL SOLUTION TO THE ISSUE (I.E. A TANK MADE OF DIFFERENT MATERIAL).
NHTSA complaint #10395551 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
2006 DUCATI SPORT CLASSIC THE FUEL TANK EXPANDED AND NO LONGER REST ON THE FORWARD SUPPORTS. THE TANK ALSO IS DEFORMED AND SMALL BLISTER APPEARED.
NHTSA complaint #10383280 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
2006 DUCATI SPORT CLASSIC MOTORCYCLE FUEL TANK HAS EXPANDED AND WARPED RESULTING IN IT BECOMING LOOSE FROM THE FRAME.
NHTSA complaint #10378049 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
GAS TANK IS DEFECTIVE AND ALREADY NEEDED TO BE REPLACED. IT WAS REPLACED WITH THE SAME EXACT TANK AND I EXPECT IT TO FAIL AND HOPEFULLY NOT WHILE I AM ON THE HIGHWAY.
NHTSA complaint #10376626 — an unverified report by a vehicle owner.