1989 Ford E350 brake problems

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

INTERMITTENTLY VEHICLE LOSES BRAKE POWER WHEN THE BRAKE PEDAL IS DEPRESSED, BRAKE PEDAL GOES TO THE FLOOR AND FAILS TO STOP THE TRUCK. THE EMERGENCY BRAKES HAD TO BE ENGAGED TO STOP THE VEHICLE. MASTER BRAKE CYLINDER WAS REPLACED, BUT THE FAILURE OCCURRED WITH IN 400 MILES. DEALERSHIP REPLACED THE MASTER CYLINDER AGAIN, AND BLEED THE BRAKES. HOWEVER, FAILURE RECURRED WITHIN 1500 MILES. THEN, DEALERSHIP INDICATED THAT THIS FAILURE OCCURRED BECAUSE THE BRAKE LINE WAS ROUTED BEHIND THE ENGINE , WHICH GET HOT AND BOILED THE FLUID.

NHTSA complaint #10079553 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

INTERMITTENTLY VEHICLE LOSES BRAKE POWER WHEN THE BRAKE PEDAL IS DEPRESSED, BRAKE PEDAL GOES TO THE FLOOR AND FAILS TO STOP THE TRUCK. THE EMERGENCY BRAKES HAD TO BE ENGAGED TO STOP THE VEHICLE. MASTER BRAKE CYLINDER WAS REPLACED, BUT THE FAILURE OCCURRED WITH IN 400 MILES. DEALERSHIP REPLACED THE MASTER CYLINDER AGAIN, AND BLEED THE BRAKES. HOWEVER, FAILURE RECURRED WITHIN 1500 MILES. THEN, DEALERSHIP INDICATED THAT THIS FAILURE OCCURRED BECAUSE THE BRAKE LINE WAS ROUTED BEHIND THE ENGINE , WHICH GET HOT AND BOILED THE FLUID.

NHTSA complaint #10079553 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

BRAKE CALIPER FAILED TO RELEASE, BOILING THE BRAKE FLUID (UNBEKNOWNST TO ME UNTIL IT CAME TIME TO APPLY THE BRAKES). THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I LET IT UP COMPLETELY AND WHEN DEPRESSED, IT WENT TO THE FLOOR ONCE AGAIN. I USED THE TRANSMISSION (GEARING DOWN) AND THE EMERGENCY BRAKE TO BRING VEHICLE TO A STOP. THE MASTER CYLINDER BRAKE INDICATOR LIGHT NEVER ILLUMINATED. WHEN REPAIRS WERE COMPLETED, THE PRIMARY FAULT WAS IDENTIFIED AS EXTREMELY RUSTY FRONT BRAKE CALIPERS. ONE DID NOT RELEASE COMPLETELY AFTER A BRAKE APPLICATION, CAUSING SUFFICIENT HEAT BUILDUP TO BOIL THE BRAKE FLUID. MECHANIC SAID THE REAR BRAKES WERE BADLY OUT OF ADJUSTMENT, GIVING THE OPINION THAT WAS THE REASON THE MASTER CYLINDER INDICATOR LIGHT DID NOT ILLUMINATE. UNTIL THIS INCIDENT OCCURRED, I DID NOT KNOW THAT IT WAS INCUMBENT ON THE VEHICLE OPERATOR TO OCCASIONALLY MAKE REVERSE MOVES WITH AGGRESSIVE BRAKE APPLICATIONS (DONE SEVERAL TIMES) TO CINCH UP THE REAR BRAKE ADJUSTMENT. THUS, OVER TIME, THE FRONT BRAKES WERE BASICALLY DOING ALMOST ALL THE BRAKING EFFORT. IF I HAD HAD THE PRESENCE OF MIND TO PUMP THE BRAKE PEDAL REPEATEDLY, I PERHAPS COULD HAVE CAUSED THE REAR BRAKES TO ENGAGE, AND BRING THE VEHICLE TO A STOP WITHOUT DOWNGEARING AND USING THE EMERGENCY BRAKE.

NHTSA complaint #757383 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

BRAKE CALIPER FAILED TO RELEASE, BOILING THE BRAKE FLUID (UNBEKNOWNST TO ME UNTIL IT CAME TIME TO APPLY THE BRAKES). THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I LET IT UP COMPLETELY AND WHEN DEPRESSED, IT WENT TO THE FLOOR ONCE AGAIN. I USED THE TRANSMISSION (GEARING DOWN) AND THE EMERGENCY BRAKE TO BRING VEHICLE TO A STOP. THE MASTER CYLINDER BRAKE INDICATOR LIGHT NEVER ILLUMINATED. WHEN REPAIRS WERE COMPLETED, THE PRIMARY FAULT WAS IDENTIFIED AS EXTREMELY RUSTY FRONT BRAKE CALIPERS. ONE DID NOT RELEASE COMPLETELY AFTER A BRAKE APPLICATION, CAUSING SUFFICIENT HEAT BUILDUP TO BOIL THE BRAKE FLUID. MECHANIC SAID THE REAR BRAKES WERE BADLY OUT OF ADJUSTMENT, GIVING THE OPINION THAT WAS THE REASON THE MASTER CYLINDER INDICATOR LIGHT DID NOT ILLUMINATE. UNTIL THIS INCIDENT OCCURRED, I DID NOT KNOW THAT IT WAS INCUMBENT ON THE VEHICLE OPERATOR TO OCCASIONALLY MAKE REVERSE MOVES WITH AGGRESSIVE BRAKE APPLICATIONS (DONE SEVERAL TIMES) TO CINCH UP THE REAR BRAKE ADJUSTMENT. THUS, OVER TIME, THE FRONT BRAKES WERE BASICALLY DOING ALMOST ALL THE BRAKING EFFORT. IF I HAD HAD THE PRESENCE OF MIND TO PUMP THE BRAKE PEDAL REPEATEDLY, I PERHAPS COULD HAVE CAUSED THE REAR BRAKES TO ENGAGE, AND BRING THE VEHICLE TO A STOP WITHOUT DOWNGEARING AND USING THE EMERGENCY BRAKE.

NHTSA complaint #757383 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

WROTE AN EXPLANATION OF WHOLE PROBLEM BUT WON'T FIT HERE. PLANNING TRIP TO MOUNTAINS, BUT SCARED TO GO WITHOUT RESOLUTION TO PROBLEM. NO SAFETY DEFECT LISTED WITHIN SUMMARY.

NHTSA complaint #726170 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

BRAKES FAILED.

NHTSA complaint #512637 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

BRAKES EXPERIENCING OVERHEATING, REPLACEMENT OF THE DEFECTIVE REAR BRAKE CYLINDERS DID NOT RECTIFY OVERHEATING.

NHTSA complaint #509676 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS

BRAKES EXPERIENCING OVERHEATING, REPLACEMENT OF THE DEFECTIVE REAR BRAKE CYLINDERS DID NOT RECTIFY OVERHEATING.

NHTSA complaint #509676 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:DISC:CALIPER

BRAKE FAILURE.

NHTSA complaint #521934 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

LOST BRAKING POWER WHILE DRIVING DOWN STEEP GRADE, NO PRESSURE IN PEDAL. WAS TOLD BY A DEALER THAT CALIPERS/PADS OVERHEATED.

NHTSA complaint #809883 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

LOST BRAKING POWER WHILE DRIVING DOWN STEEP GRADE, NO PRESSURE IN PEDAL. WAS TOLD BY A DEALER THAT CALIPERS/PADS OVERHEATED.

NHTSA complaint #809883 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

BRAKE FAILURE.

NHTSA complaint #507732 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

COMING TO A STOP WHILE GOING DOWN HILL THE BRAKES FAILED/REPLACED FRONT BRAKE PADS, ROTORS AND BRAKE HOSES.

NHTSA complaint #801807 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

COMING TO A STOP WHILE GOING DOWN HILL THE BRAKES FAILED/REPLACED FRONT BRAKE PADS, ROTORS AND BRAKE HOSES.

NHTSA complaint #801807 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

COMING TO A STOP WHILE GOING DOWN HILL THE BRAKES FAILED/REPLACED FRONT BRAKE PADS, ROTORS AND BRAKE HOSES.

NHTSA complaint #801807 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FLUID

BRAKE FLUID OVERHEATED, CAUSING BRAKE FAILURE.

NHTSA complaint #505852 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

AFTER SUSTAINED AND FREQUENT USE OF BRAKES THEY APPARENTLY OVERHEAT AND PEDAL GOES TO THE FLOOR.

NHTSA complaint #966891 — an unverified report by a vehicle owner.