2024 Ford F-150 Lightning BEV other reported problems
12 of the
47 complaints about the 2024 Ford F-150 Lightning BEV are about the
other systems — 26% of everything
reported for this model year.
F
12
Complaints
2
Crashes
0
Fires
0
Injuries
Exactly what failed
Unknown OR Other
12100.0%
What owners said
Filed with NHTSA, in their own words.
Statesville, NC
UNKNOWN OR OTHER
Vehicle: 2024 Ford F-150 Lightning Flash — 17,240 miles ▎ Current software version: itrm-25.B04 ▎ ▎ Following an over-the-air software update in November 2025, my truck will not stay in the drive mode I select. At every startup the vehicle prompts me to confirm Sport mode and I select Yes. The truck then reverts to Normal mode on its own, without my input. ▎ ▎ This happens every single time I drive the truck. I drive it at least three times a week and it has occurred on every trip since the update. The timing is unpredictable — sometimes immediately after Android Auto connects, sometimes at the end of my driveway, sometimes at the end of my road, sometimes several minutes into the drive. The randomness is part of the hazard: I cannot anticipate when the vehicle's braking behavior will change. ▎ ▎ There is no warning of any kind when the mode changes — no chime, no message, no alert. The only indications are that the small "S" disappears from the instrument cluster and the truck's driving characteristics change. The most safety-critical difference is regenerative braking: lifting off the accelerator produces substantially less deceleration in Normal mode than in Sport. I drive to the braking behavior I selected, and the truck silently takes it away from me. ▎ ▎ I have had two close calls as a direct result: ▎ ▎ 1. A vehicle ahead of me made a late right turn onto a side road. I lifted off the accelerator expecting Sport-mode regenerative braking to slow me. The truck had silently reverted to Normal. It did not decelerate at the rate I expected and I had to slam on the brakes to avoid a collision. ▎ 2. At a blinking light at the end of my road, a vehicle ahead stopped short. Again I lifted off expecting the Sport-mode regen I had selected, again the truck had changed modes on its own, and again I had to slam on the brakes. ▎ ▎ In both cases I was relying on the deceleration characteristics of the mode I set, and the vehicle had changed them without telling me. This be
NHTSA complaint #11750210 — an unverified report by a vehicle owner.
Hillsboro, OR
UNKNOWN OR OTHER
Ford provides various driving modes for this truck, by their own description this setting changes the responsiveness of the steering, acceleration, and regenerative braking. This mode defaults to "Normal" at startup, with a short on-screen prompt to return to the previous mode. While this is incredibly frustrating, on its own probably doesn't rise to the level of a reportable issue. However sometime in November the truck received an OTA update that has introduced a bug that causes the truck to make an uncommanded return to the Normal drive mode. Regardless of how the truck is put into Sport or another mode (either the "return to mode" prompt, or going into the vehicle menu and selecting another mode) after a few minutes of driving the truck will return to Normal mode. This causes a change in steering responsiveness, and since I usually drive in Sport mode, also reduced the regenerative braking, meaning letting off the accelerator doesn't slow the truck as much as expected. A for representative mentioned on the FordLighting forums that Ford engineers were aware of the problem and looking for a solution back in January, but we haven't seen anything more from them since.
NHTSA complaint #11750342 — an unverified report by a vehicle owner.
Brookline, MACrash
UNKNOWN OR OTHER
I was the only person in the truck and there was no one nearby. I was slowly backing the Ford 150 Lighting into my driveway, going straight back. I was going slow because another car was parked at the back end corner. As I was rolling slowly back, the truck started to accelerate on its own, I had not increased pressure on the pedal. The truck was not making any beeping noises or alerts on the screen indicating that there was another car parked behind it. NO safety alerts at all. The truck was completely out of my control other than my ability to turn the steering wheel. I had lifted my foot off the gas pedal entirely at one point to make sure it was not me pressing it and the car kept moving faster without my foot. I tried to steer the truck straight back but upon realizing it would not stop and was only getting faster, I veered the steering wheel to avoid hitting our other small car and turned the truck which backed up directly into the south west corner of our house. The house is what stopped the truck. Upon impact with the house- NO airbags inflated. The truck touchscreen temporarily shined red and audibly said that it would “call 911” and no call was ever made. After this, and after I had gotten out of the truck, I realized that the entire truck shut down mechanically. The turn on button did nothing, the key did nothing, the gears would not shift - it was in a locked position. The driver's seat that I was in- got dislodged and crooked by the force of the truck to the house. My right calf is still sore because my right foot was on the pedal when the truck hit the house. My left side of my neck is very sore and I have a headache around tension around my temples and top of head, my forearms, wrists, trapezius muscles, and rhomboid muscles - all were sore after the crash.
NHTSA complaint #11746670 — an unverified report by a vehicle owner.
Knightdale, NC
UNKNOWN OR OTHER
While driving on a surface road in Columbia, MD at approximately 40 mph, the dash display of the 2024 Ford Lightning Flash went completely blank, leaving no indication of vehicle speed, battery percentage, battery temp, motor temp, cruise control status etc. Zero information was displayed, and the dash was completely cold and dark. This failure, while traveling at speed, represents a gross safety hazard, especially because the same LCD displays automatic emergency braking informaion etc. Immediately, I was able to pull over, and establish an OBD-2 connection to the ECM, and pull error logs. I also took screenshots of critical components and voltages. I cleared the codes, re-checked for codes and saved another error log showing a couple of codes. I then cycled power to the truck several times, hoping for a reboot to clear the error. I also performed a manual reset of the Ford SYNC system. Using the OBD-2 virtual dash on my reader, I was able to safely display speed and battery data, and drive immediately to the nearest Ford Dealer (Koons Ford). On the way, I phoned Crossroads Ford (Apex, NC) who did a remote error check using the vehicle's modem. The dealer may have saved this data. Upon arrival to Koons, service writers and technicians were able to witness and verify inoperability of the dash unit, and cycle the vehicle power, whereafter the problem persisted. They then took it back for service and evaluation. After approximately 4 hours, I was told that the "dash reset itself after a couple hours" and they could not get it to repeat the error after it came back. Before this, there were no warning signs of dash failure, nor since.
NHTSA complaint #11734282 — an unverified report by a vehicle owner.
Santa Rosa, CA
UNKNOWN OR OTHER
I was on the on-ramp and accelerated to get to freeway speed nothing crazy. The truck took off even with my foot off the pedal. I braked hard to avoid rear ending the vehicle in front.. Started slowing down took my foot off the brake and it did it again... braked hard again, hit the hard shoulder then it went back to normal. Lucky it was a 5 lane freeway...
NHTSA complaint #11680348 — an unverified report by a vehicle owner.
Walnut, CACrash
UNKNOWN OR OTHER
I was driving into a parking space and my 2024 Ford F-150 Lightning had a sudden unintended acceleration, which caused vehicle to crash into the concrete block wall in front of the parking space.
NHTSA complaint #11678949 — an unverified report by a vehicle owner.
Vernon Hill, VA
UNKNOWN OR OTHER
Folding shifter issues with many F150s. Gets stuck in park or drive. Seems to be a rampant issue. Stuck in park is one thing, stuck in drive is extremely dangerous... Also causes service lights.
NHTSA complaint #11661114 — an unverified report by a vehicle owner.
Lawrenceville, GA
UNKNOWN OR OTHER
Gear Shifter stuck in D with amber light blinking constantly. At the same time, the Amber Wrench symbol appeared on the dash, with "Service vehicle soon" warning message. This indicates a Powertrain malfunction/Reduced Power issue. Vehicle towed to nearest Ford dealer (Scenic Ford, Mount Airy, NC) with about 225 miles on odometer. I purchased this new '24 Lightning Lariat [XXX] online, and picked it up at Sheehy Ford in Gaithersburg, MD [XXX], with 47 miles on odometer. The above issues occurred [XXX] as I was driving the vehicle home from Maryland to my home in Georgia. These problems occurred the same day I drove the new vehicle off the dealer lot. Additionally, the Gear Shifter has never folded down as its meant to fold down, enabling a flat work surface between the two front seats. This situation was present at Sheehy Ford when I picked it up brand new on [XXX]. I have an appointment at my local dealer, Akins Ford, Winder, GA, May 14, 2025 at 10am to have these issues assessed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11660586 — an unverified report by a vehicle owner.
Portage, IN
UNKNOWN OR OTHER
The digital display on the dashboard went black and would not reappear.
NHTSA complaint #11650081 — an unverified report by a vehicle owner.
Frisco, TX
UNKNOWN OR OTHER
Instrument cluster went dark and doesnt work
NHTSA complaint #11648969 — an unverified report by a vehicle owner.
South Hamilton, MA
UNKNOWN OR OTHER
My vehicle has a broken backup camera (extremely blurry, barely or unusable). It has not functioned properly since the vehicle had about 2,500 miles on it, around 15 December 2024. It now has 7,300 miles on it and the manufacture has not remedied the situation. The backup camera is currently on back order (since January 2025) by the dealership. The dealership implied that it was likely on backorder because there was a high demand for them since they were breaking frequently.
NHTSA complaint #11649103 — an unverified report by a vehicle owner.
Elk Grove, CA
UNKNOWN OR OTHER
The cameras are of poor quality and are often blurry, including the 360 view. Cleaning the lenses does does resolve the issue.
NHTSA complaint #11629247 — an unverified report by a vehicle owner.