49 of the 365 complaints filed about the Ford Ford Truck are about the transmission — 13% of everything owners reported. The worst model year for it is 2002.
49
Complaints
13%
Share of all complaints
1
Crashes
2
Fires
POWER TRAIN
FORD F 250 TRITON V10 NO. 2 SPARK PLUG AND COIL BLEW OUT OF THE ENGINE HEAD. APPARENTLY THIS IS A COMMON PROBLEM WITH THIS MODEL AND OTHERS. FORD WILL CHARGE 650.00 TO FIX.
NHTSA complaint #10660238 — an unverified report by a vehicle owner.
POWER TRAIN
WHILE DRIVING ON HIGHWAY AT HIGHWAY SPEEDS AND WHEN THROTTLE IS APPLIED AT FULL CAPACITY, THROTTLE PEDAL STICKS FOR UP TO THIRTY (30) SECONDS BEFORE SELF RELEASING. ENGINE RPM REACHES NEAR MAXIMUM AND VEHICLE SPEED INCREASES UNTIL VEHICLE IS PLACED IN 'NEUTRAL' AND THROTTLE SELF RELEASES. PROBLEM HAS ONLY OCCURRED WHILE ON HIGHWAY AND CAN NOT BE DUPLICATED WHILE STATIONARY OR IN 'PARK.' PROBLEM WAS DUPLICATED BY DRIVER TWO TIMES WHILE ENTERING HIGHWAY ON RAMP AT APPROXIMATE SPEED OF 60MPH. PROBLEM OCCURRED TWO TIMES WITHIN FIVE (5) MINUTES.
NHTSA complaint #10439350 — an unverified report by a vehicle owner.
POWER TRAIN:DRIVELINE
2000 FORD WINDSTAR SEL -THE ACTIVE CONTROL LIGHT GOES ON SLIGHT BUMPS OR ROUGH ON HIGHWAYS-GOES OFF, BUT RECENTLY AFTER THE REAR AXLE RECALL AND CHECK OF BY DEALERSHIP ON OCT 4, 2010, OUR CAR HAS ON MORE THAN THREE OR FOUR TIMES WENT INTO THE ACTION CONTROL MODE WHEN THE LIGHT ON DASH WENT ON --AND THIS AT HIGH INTERSTATE OR PARKWAY SPEEDS OF 65 MPH, AND ON DRY SURFACES---IT HAS , I GUESS, BECAUSE OF DRY-NON SLIP CONDITIONS CAUSED DIFFICULTY IN MAINTAINING CONTROL OF VEHICLE. ON SECONDARY SLOWER SPEED HIGHWAYS ONLY THE LIGHT HAS GONE ON --NO REAL NOTICE OF ENGAGING OF ACTIVE CONTROL ACTION, SO TO SPEAK. WE HAVE REPORTED ALL THIS TO OUR DEALERSHIP AND FORD CUSTOMER RELATIONS. ALSO TAKE NOTE THAT AT AROUND 10-19-09 WHEN CAR AT 112,468 MILES OUR DEALERSHIP REPLACED A REAR RIGHT SPEED SENSOR AT PRICE OF $149.19 --ON THAT OCCASION FOR THE REPORT BY US OF ACTIVE CONTROL LIGHT GOING ON AND STAYING ON. THAT WAS NOT AS NOW -AS THE VEHICLE NEVER WENT INTO THE ACTIVE CONTROL ACTION THAT DOING NOW AT AROUND THE MILES OF 114,980. THIS VEHICLE HAS BEEN GARAGE KEPT AND ALL SERVICE RECORDS KEPT-FIRST BY THE OWNER I PURCHASED FROM AND NOW BY US ON OUR HOME PAGE FORD SERVICE RECORDS ACCOUNT.
NHTSA complaint #10362961 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
AUTOMATIC TRANSMISSION SLIPPING AND HARD BANG WHEN IT GO INTO GEAR. FORD SERVICE DEPT.DIAOGNOSE TRANS OP, NO CODES,LINE PRESSURE TEST.R110-N-75 OD95 L-95. R&R TRANSMISSION PAN FOR INSPECTION, PIECES OF BRASS BUSHINGS IN PAN. R&R TRANS TO OVERHAUL. REPLACED OD PLANETARY ASSY .BUSHINGS BETWEEN GEARS COME APART) FLUSHED COLLING LINES,REPLACED CONVERTER(METAL CONTAMINATION.) REPLACED VALVE BODY(VALVES STICKING). CLEARED PCM MEMORY & REFLASHED PCM. ROAD TEST. ALL THE ABOVE WORK WAS DONE ACCORDING TO THE INVOICE. WHEN I DROVE THE TRUCK I COULD HEAR A NOISE THAT WASN'T THERE BEFORE, I TOOK THE TRUCK BACK TO THE DEALER AND CHECKED THINGS OUT AND TOLD ME EVERY THING WAS FINE, BUT IT WASN'T.
NHTSA complaint #10215891 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
AUTOMATIC TRANSMISSION SLIPPING AND HARD BANG WHEN IT GO INTO GEAR. FORD SERVICE DEPT.DIAOGNOSE TRANS OP, NO CODES,LINE PRESSURE TEST.R110-N-75 OD95 L-95. R&R TRANSMISSION PAN FOR INSPECTION, PIECES OF BRASS BUSHINGS IN PAN. R&R TRANS TO OVERHAUL. REPLACED OD PLANETARY ASSY .BUSHINGS BETWEEN GEARS COME APART) FLUSHED COLLING LINES,REPLACED CONVERTER(METAL CONTAMINATION.) REPLACED VALVE BODY(VALVES STICKING). CLEARED PCM MEMORY & REFLASHED PCM. ROAD TEST. ALL THE ABOVE WORK WAS DONE ACCORDING TO THE INVOICE. WHEN I DROVE THE TRUCK I COULD HEAR A NOISE THAT WASN'T THERE BEFORE, I TOOK THE TRUCK BACK TO THE DEALER AND CHECKED THINGS OUT AND TOLD ME EVERY THING WAS FINE, BUT IT WASN'T.
NHTSA complaint #10215891 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
AUTOMATIC TRANSMISSION SLIPPING AND HARD BANG WHEN IT GO INTO GEAR. FORD SERVICE DEPT.DIAOGNOSE TRANS OP, NO CODES,LINE PRESSURE TEST.R110-N-75 OD95 L-95. R&R TRANSMISSION PAN FOR INSPECTION, PIECES OF BRASS BUSHINGS IN PAN. R&R TRANS TO OVERHAUL. REPLACED OD PLANETARY ASSY .BUSHINGS BETWEEN GEARS COME APART) FLUSHED COLLING LINES,REPLACED CONVERTER(METAL CONTAMINATION.) REPLACED VALVE BODY(VALVES STICKING). CLEARED PCM MEMORY & REFLASHED PCM. ROAD TEST. ALL THE ABOVE WORK WAS DONE ACCORDING TO THE INVOICE. WHEN I DROVE THE TRUCK I COULD HEAR A NOISE THAT WASN'T THERE BEFORE, I TOOK THE TRUCK BACK TO THE DEALER AND CHECKED THINGS OUT AND TOLD ME EVERY THING WAS FINE, BUT IT WASN'T.
NHTSA complaint #10215891 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
DRIVING MY VEHICLE WITH MY 2 CHILDREN 2 AND 10 YEAR. DROPPING THE 2 YEAR OLD OFF TO SCHOOL. STOP THE VEHICLE GO TO PUT THE SHIFT GEAR INTO PARK, BREAKS RIGHT OFF IN HAND, IF THE RUBBER WASN'T AROUND IT, I COULD HAVE WALKED OUT OF THE CAR WITH IT. I WAS STUCK THERE KEEPING MY FOOT ON THE BRAKES BECAUSE THE GEAR WAS ALSO STUCK BETWEEN REVERSE AND PARK.
NHTSA complaint #10212470 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
TRANSMISSION TAKES 3-5 SECONDS TO GO INTO REVERSE THIS IN ITS SELF DANGEROUS WHEN NEEDING A QUICK REVERSE. THE MAIN REASON FOR A COMPLAINT IN TRANSMISSION NEEDING TO BE REBUILT AFTER ONLY 45,000 I DON'T TOW ANYTHING AND AM A GOOD DRIVER I KNOW OTHERS WITH SAME VEHICLE SAME PROBLEM TAKE NOTE UHAUL WILL NOT RENT TO EXPLORER OWNERS BECAUSE OF THE PROBLEMS WITH THIS TRANSMISSION (CALL UHAUL AND FIND THIS OUT).
NHTSA complaint #10207245 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
UNSAFE TRANSMISSION FORD CAN T FIX IT LOCKED TRANSMISSION UP AND I SHOWED UP AT DEALER WITH WHITE SMOKE CLOUD BEHIND THE CAR FORD STILL INSISTS NOTHING WRONG.
NHTSA complaint #10200757 — an unverified report by a vehicle owner.
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
74400 MILES. NOISE COMING FROM REAR END AND FEELS LIKE THE BRAKES ARE DRAGGING WHEN SLOWING DOWN. THE NOISE WAS WORSE WHEN ENGAGING THE 4-WD HIGH. THE DEALER DIAGNOSED THE PROBLEM AS A BAD TRANSFER CASE ASSEMBLY. WAITED 2 DAYS BECAUSE THE FACTORY REPRESENTATIVE HAD TO APPROVE THE REPAIR. WAS TOLD THE MAIN SHAFT HAD CRACKED AND WAS ENGAGING THE 4-WD EVEN THOUGH IT DID NOT SHOW UP ON THE INSTRUMENT PANEL. AFTER PICKING UP THE VEHICLE IT SEEMED TO BE BETTER EVEN THOUGH NOT COMPLETELY GONE. MY MISTAKE FOR NOT RETURNING THE TRUCK BECAUSE IT STARTED TO GET WORSE AT 75400 , AND NOW THE FORD CUSTOM CARE CERTIFIED THE TRUCK AS A USED CAR COVERING DRIVE TRAIN UNTIL 75000 MILES, AND IT WOULD NOT AUTHORIZE ANY FURTHER WORK EVEN THOUGH THE PROBLEM STILL HAD THE SAME SYMPTOMS FROM 2 OTHER VISITS AT THE SAME DEALER. EVEN THOUGH THE SERVICE ADVISOR AT THE DEALERSHIP RECOMMEND THAT THE WORK BE DONE.
NHTSA complaint #10185998 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
75400 MILES. NOISE FROM REAR END BECOMING MORE NOTICEABLE. ALSO, THE TRANSMISSION SUDDENLY WON'T SHIFT FROM 2ND TO 3RD. DEALER DIAGNOSED THE REAR END PROBLEM AS BEARINGS NEEDED TO BE REPLACED AND PROBABLY THE REAR HUBS WERE BAD. THE TRANSMISSION WAS BAD, AND NEEDED TO BE REPLACED. FORD DEALER SERVICE ADVISED ME TO CONTACT FORD 800 NUMBER, AND OPERATOR AFTER PUTTING ME ON HOLD AND TALKING TO THE DEALER TURNED THE PROBLEM OVER TO THE NEXT LEVEL OF CUSTOMER CAR BECAUSE HER LIMIT OF $500 WOULD NOT BEGIN TO COVER THE REPAIRS. FORD COSTUMER CARE CALLED ME AND AFTER LETTING ME TELL MY STORY SAID THERE WAS NO PROGRAM DOLLARS AVAILABLE FOR ASSISTING IN FIXING EITHER PROBLEM, EVEN THOUGH THE REAR END PROBLEM WAS DIRECTLY RELATED TO THE PREVIOUS VISIT AT 74,400 MILES PER THE DEALERS RECOMMENDATION. ALSO INFORMED ME THAT NOT EVEN THE $500 WAS AVAILABLE ,AND THE OPERATOR HAD NO RIGHT TO OFFER THAT AMOUNT. TOOK THE CAR FROM THE DEALER AFTER PAYING $120, PLUS $100 CAR RENTAL THEY WOULD NOT COVE) SINCE THE MILEAGE WAS 400 OVER WARRANTY 75000 MILEAGE LIMIT TO DIAGNOSE A PROBLEM THEY FAILED TO CORRECTLY DIAGNOSE THE FIRST 2 TIMES.
NHTSA complaint #10186004 — an unverified report by a vehicle owner.
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
CONTINUOUS ROARING NOISE COMING FROM REAR OF OUR 2002 FORD EXPLORER. WAS DETERMINED THAT REAR DIFFERENTIAL WAS BAD. IF IT WOULD HAVE GONE OUT WHILE DRIVING, TRUCK COULD HAVE LOCKED UP. WAS TOLD BY SERVICE THAT WAS A BIG SAFETY CHANCE TO TAKE. OUT OF WARRANTY ON MILES. (BUT NOT ON 3 YEARS).SO IT COST US $1900 OUT OF POCKET TO REPAIR. HAVE ALSO BEEN TOLD FORD IS AWARE OF PROBLEM.
NHTSA complaint #10136411 — an unverified report by a vehicle owner.
POWER TRAIN:DRIVELINE
I HAVE A 2002 FORD EXPLORER. I HAVE APPROXIMATELY 85,000 MILES ON THIS CAR AND HAVE A PROBLEM WITH THE TRANSMISSION. THE O/D LIGHT CAME ON FLASHING. THEN IT REFUSED TO SHIFT INTO SECOND GEAR. IT HAS SHIFTED HARD SINCE WE PURCHASED IT USED WITH APPROXIMATELY 25,000 MILES ON IT. WHAT A PAIN. I HAVE BEEN TO MANY FORD FORUMS AND I SEE NOTHING BUT TROUBLE WITH THIS MAKE AND MODEL YEAR. FORD NEEDS TO RECALL THIS CAR PRONTO. EVERY ONE I KNOW WHO HAS THIS MAKE AND MODEL ARE HAVING SIMILAR PROBLEMS. THEY NEED TO CORRECT THIS ITEM NOW. OR WE WILL JUST HAVE TO BUY JAPANESE NEXT TIME. THEY BELIEVE IN CUSTOMER SERVICE.
NHTSA complaint #10133674 — an unverified report by a vehicle owner.
POWER TRAIN
I HAVE A 2002 FORD EXPLORER. I HAVE APPROXIMATELY 85,000 MILES ON THIS CAR AND HAVE A PROBLEM WITH THE TRANSMISSION. THE O/D LIGHT CAME ON FLASHING. THEN IT REFUSED TO SHIFT INTO SECOND GEAR. IT HAS SHIFTED HARD SINCE WE PURCHASED IT USED WITH APPROXIMATELY 25,000 MILES ON IT. WHAT A PAIN. I HAVE BEEN TO MANY FORD FORUMS AND I SEE NOTHING BUT TROUBLE WITH THIS MAKE AND MODEL YEAR. FORD NEEDS TO RECALL THIS CAR PRONTO. EVERY ONE I KNOW WHO HAS THIS MAKE AND MODEL ARE HAVING SIMILAR PROBLEMS. THEY NEED TO CORRECT THIS ITEM NOW. OR WE WILL JUST HAVE TO BUY JAPANESE NEXT TIME. THEY BELIEVE IN CUSTOMER SERVICE.
NHTSA complaint #10133674 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
REF 2002 FORD EXPLORER, TRANSMISSION PROBLEMS. THIRD GEAR WENT OUT AT 57,000 MILES. BEACH FORD REPLACED. HAVE NEVER GOTTEN THE GEARS SYNCRONIZED. HAVE TO TOUCH GEAR SHIFT SOMETIMES TO PUT IN GEAR. TONIGHT CAR IS BACK AT BEACH FORD WITH A TRANSMISSION PUMP LEAK. REPORTED THIS CAR LAST WEEK FOR ACCELERATION PROBLEMS.
NHTSA complaint #10131756 — an unverified report by a vehicle owner.
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
RIGHT AFTER 2002 EXPLORER SPORT 4X4 WAS OUT OF WARRANTY A WHINE FROM THE DIFFERENTIAL IN THE RANGE OF 40 - 80 MILE PER HOUR HAPPENS. FORD STATES TO LIVE WITH IT AND DOES NOT ACCEPT RESPONSIBILTY FOR DEFECTIVE PARTS AND MANUFACTURING OF DIFFERENTIAL.
NHTSA complaint #10129407 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
MY 2003 FORD EXPEDITION WAS PARKED ON AN INCLINE WITH THE PARKING BRAKE SET. THE VEHICLE ROLLED DOWN THE HILL AND HIT A BUILDING. IT DAMAGED THE BUILDING AND THE VEHICLE(YET TO BE DETERMINED IN AMOUNT). TOOK THE VEHICLE TO THE FORD DEALERSHIP TO HAVE IT FIXED AND THEY FOUND NOTHING WRONG. CALLED THE FORD SATISFACTION LINE AND THEY ARE LOOKING INTO IT. THE TRUCK SHOULD NOT ROLL DOWN AN INCLINE IN PARK. I WATCHED THE VEHICLE ROLL. I REFUSE TO PLACE MY 3 CHILDREN BACK IN THE VEHICLE UNTIL THE TRANSMISSION CAN BE FIXED. I BELIEVE THERE IS A DEFECT IN THE TRANSMISSION THAT IT WOULD ALLOW THE VEHICLE TO ROLL.
NHTSA complaint #10129388 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
PURCHASED A 2002 FORD EXPLORER NEW. WITH LESS THAN 45,000 MILES THE TRANSMISSION HAD TO BE REBUILT. CAR NOW HAS LESS THAN 65000 MILES AND THE ENGINE HAS TO BE REPLACE. FORD WILL NOT OFFER ANY FINANCIAL ASSISTANCE. RAPHAEL
NHTSA complaint #10126050 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
ON FEBRUARY 25, 2005, I WAS TRAVELING 55 MPH ON THE HIGHWAY IN TRAFFIC WHEN MY 1998 FORD WINDSTAR BEGAN TO LEAK OIL AND SLOW DOWN. AFTER SEVERAL NEAR COLLISIONS, I WAS ABLE TO GET TO THE SHOULDER OF THE ROAD. I INSTRUCTED EVERYONE TO GET OUT OF THE VEHICLE BECAUSE OF THE SMOKEY SMELL. I THEN CALLED KEYSTONE AAA MID-ATLANTIC MY EMERGENCY ROADSIDE ASSISTANCE SERVICE. NEXT, THE KEYSTONE AAA MID-ATLANTIC TECHNICIAN ARRIVED AND HE COMMENTED ON THE NUMBER OF FORD WINDSTARS THAT HE PICKS UP ON A DAILY BASIS. AFTER OBSERVING MY VEHICLE, HE STATED THAT IT IS PROBABLY A TRANSMISSION PROBLEM. I EXPLAINED TO HIM THAT IT COULD NOT BE THE TRANSMISSION BECAUSE I JUST GOT A BRAND ?NEW TRANSMISSION? TWO YEARS AGO. HE THEN TOWED MY VEHICLE TO SPRINGFIELD FORD IN SPRINGFIELD, PENNSYLVANIA (6 MILES AWAY). ON WEDNESDAY, FEBRUARY 26, 2005, I RECEIVED A CALL FROM SOMEONE IN THE SERVICE DEPARTMENT OF SPRINGFIELD FORD AND I WAS TOLD THAT I NEEDED A NEW TRANSMISSION AND I WAS LUCKY THAT THE VEHICLE DID NOT CATCH FIRE BECAUSE OF THE LEAKING OIL. INDEED, IF SPRINGFIELD FORD INSTALLED A ?NEW TRANSMISSION? TWO- YEARS AGO AND I NOW NEED ANOTHER ?NEW TRANSMISSION?, IT IS CLEAR THAT THE TRANSMISSIONS FOR THE 1998 FORD WINDSTARS ARE DEFECTIVE. MOREOVER, I WAS ON A BUSY HIGHWAY TRAVELING 55 MPH WHEN THIS SECOND MALFUNCTION OCCURRED.
NHTSA complaint #10116074 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
PURCHASED A 2000 FORD WINDSTAR LAST WEEK OF JANUARY 2004 FOR THE PRICE OF 13900.00. THE VAN WAS STORED OUT BACK FOR A WHILE, AND WAS UNDER 30,000 MILES WHEN I BOUGHT IT. THE DEALER NEVER GOT IT INSPECTED UNTIL TWO WEEKS AFTER I PURCHASED AND PICKED UP THE VEHICLE. BY JULY 2004, OUR VAN WAS IN THE SHOP REGARDING TRANSMISSION PROBLEMS. THEY HAD IT FOR TWO WEEKS. UPON PICKING IT UP, THEY LEFT ME NO WORK ORDER THAT WAS DONE AND CLAIMED THEY PUT IN 4,000 DOLLARS WORTH OF WORK (VERBALLY). I THEREFORE CONTACTED A LAWYER. BY DECEMBER 2004, CHRISTMAS EVE DAY, MY TRANNY BLEW. IT WOULDN'T GO FORWARD AND YET THE MOTOR WAS RUNNING FINE. IT WOULD ONLY REVERSE. TWO AUTO TECH'S CAME TO MY RESCUE AND SAID IT NEEDS TO BE FULLY REPLACED. I HAD THE VAN TOWED AFTER THE HOLIDAYS (EVERYTHING WAS CLOSED FOR THE FOUR DAY WEEKEND). SO ON MONDAY UPON MY ARRIVAL, THE COMPANY DIDN'T WANT TO PUT IN FOR THE REPAIRS WITHOUT MY PAYING. I TOLD THEM IN SIX SHORT MONTHS SINCE JULY THE TRANNY IS GONE? FIRST REPAIR WAS AT 45 THOUSAND MILES AND THE NEXT WAS AT 60 THOUSAND MILES. I AM NOW HAVING MORE TRANSMISSION PROBLEMS. THEY ONLY REPAIRED IT, NEVER REPLACED IT. FOR THE PRICE I PAY FOR MY MONTHLY PAYMENTS AND THE INSURANCE AND ALL, I DON'T THINK FORD IS BEING HONEST ABOUT THEIR CARS AND FORD DEALERS ARE LOUSY TOWARDS THEIR CUSTOMERS. I FEEL VERY RIPPED OFF. ALL I WANT IS MY MONEY REFUNDED (ALL THAT I PAID IN PAYMENTS INCLUDING INSURANCE AND REPAIRS IF ANY) SO I CAN GO AND FIND MYSELF A "SAFE" RELIABLE CAR.
NHTSA complaint #10112240 — an unverified report by a vehicle owner.