2007 Jeep Wrangler X RHD 4X4 fuel system problems

FUEL/PROPULSION SYSTEM

I TOOK MY JEEP TO THE DEALERSHIP TO TAKE A LOOK AT GAS TANK SENSOR, I HEARD THAT WAS A RECALL, EVERYTIME I FILL MY TANK, THE GAS NOZZLE DOESN'T STOP AND YOU SEE GAS SPILLING ALL OVER. THE DEALERSHIP SAID HE FIXES AS ITS SHOWN ON THEIR DIGNOSE. HAVEN'T DROVE SINCE THEN, TODAY I DROVE IT AND IT HAD 1/4 GAS IN THE TANK, I STOPPED BY THE GASTATION TO FILL UP THE TANK, FOUND OUT THAT IT DOESN'T ALLOW ANY MORE GAS IN THE TANK AND GAS SPILLING ALL OVER AGAIN, THE GAS GAUGE IS WORKING ALONG WITH FUEL WARNING SIGNAL, ITS SO WEIRD AND UNSAFE.

NHTSA complaint #11164704 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

WHILE TRYING TO PUT GAS INTO MY 2007 JEEP JK WRANGLER UNLIMITED, FUEL STARTED TO POUR OUT THE UNDERSIDE. I TOOK MY VEHICLE TO THE MECHANIC AND THEY INFORMED ME THAT A LARGE CRACK WAS ON THE FILLER NECK THAT IS ATTACHED TO THE FUEL TANK. THEY ALSO INFORMED ME THAT DUE TO THE DISCOLORATION OF THE PLASTIC INLET IT HAS BEEN LEAKING FOR A WHILE. UPON REMOVING THE TANK, THEY ALSO DISCOVERED THAT THE SPRING INSIDE THE NOZZLE IS HIGHLY DEFECTIVE. APPARENTLY, THE SPRING IS SUPPOSED TO PUSH BACK ONCE THE FUEL TANK IS FULL. AS A JEEP OWNER FOR YEARS I?M EXTREMELY ANGRY THAT AN INEXPENSIVE PART MADE POORLY COULD OF COST THE LIFE OF MY FAMILY, FRIENDS AND ANYTHING WITHIN RANGE IF A FIRE ERUPTED. CHRYSLER SHOULD RECALL THESE DEFECTIVE TANKS IMMEDIATELY. I CAN PROVIDE PHOTOS OF THE FILLER NECK AND NOZZLE.

NHTSA complaint #10593756 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FUEL SPILLS OUT OF THE SPOUT WHEN I FILL UP MY 2007 JEEP WRANGLER.

NHTSA complaint #10393098 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

WHILE FUELING MY 2007 JEEP WRANGLER WHEN THE PUMP CLICKS OFF GAS POURS OUT OF MY TANK AND HAS SPLASHED ALL OVER ME SEVERAL TIMES. THIS IS VERY DANGEROUS AND HAPPENS EVERY TIME I GET GAS. THE CAR AND MYSELF CAN CATCH FIRE. THIS CANNOT WAIT UNTIL A TRAGEDY OCCURS.

NHTSA complaint #10381153 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

JK/ GAS TANK OVERFLOWS/WILL NOT SHUT OFF. ON MORE THEN 1 OCCASION THE GAS TANK ON MY 2007 JK JEEP WRANGLER HAS FAILED TO SHUT OFF WHEN FILLING UP AND SPILLS ALL OVER THE REAR OF THE JEEP AND THE GROUND. 2 JEEP DEALERS IN FAIRFAX, VA HAVE TOLD ME THAT I NEEDED A NEW TANK. I HAVE AN EXTENDED WARRANTY WITH INTERCONTINENTAL WARRANTY SERVICE (IWS) AND THEY REFUSE TO AUTHORIZE THE WORK. I AM IN THE PROCESS OF CANCELING THE WARRANTY AND FILING A COMPLAINT AGAINST THEM. A OF RIGHT NOW I STILL NEED A GAS TANK BUT CANNOT FIND ONE ONLINE, SEEMS ONLY DEALERS HAVE THEM RIGHT NOW FOR 2007-2010 MODEL YEARS. ALSO THE SOFT TOP LEAKS VERY BAD AT THE TOP OF THE DOOR/ROOF PILLARS BOTH SIDES WHEN IT RAINS. ALSO HAVE HAD THIS IN TO THE SAME 2 JEEP DEALERS AND BOTH SAY I NEED A TO AS IT IS A DESIGN FLAW. BOTH HAS LEAK SPECIALISTS LOOK AT IT AND REPLACE HEADER AND DOOR SEALS BUT STILL LEAKS JUST AS BAD. AS A LIFE LONG JEEP OWNER I AM COMPLETELY FED UP WITH THE JEEP BRAND. A LITTLE SEARCHING ON THE INTERNET TELLS ME THAT THESE 2 ISSUES ARE WELL KNOWN BUT THAT JEEP IS REFUSING TO ADDRESS THEM SO PEOPLE LIKE ME HAVE TO PAY MORE MONEY OUT OF POCKET. THESE 2 ISSUES ARE CLEARLY SAFETY RELATED, GAS SPILLING OUT AND HITTING A HOT EXHAUST IS A MAJOR PROBLEM, THE SAME WITH WATER GETTING INTO THE ELECTRICAL SYSTEM.

NHTSA complaint #10372481 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

2007 JEEP WRANGLER JK UNLIMITED, EVERY TIME YOU PUT FUEL IN THE TANK IT BELCHES ABOUT A QUARTER GALLON OF FUEL BACK OUT THE SPOUT AND ALL OVER THE VEHICLE AND PERSON FILLING THE VEHICLE. NO MATTER HOW YOU TRY TO FILL IT DOES IT EVERY TIME. THIS IS A COMMON PROBLEM WITH ALL WRANGLERS 2007-2010. JEEP JK FORUM HAS HUNDREDS OF HITS WITH COMPLAINTS ON THIS PROBLEM. CONSEQUENCES ARE FUEL ON THE GROUND, VEHICLE AND PERSON WILL LEAD TO A FIRE AND INJURY. JEEP IS AWARE OF THIS BUT DOES NOTHING WITH A RECALL TANKS NEED TO BE REPLACED. I HAVE ENTERED TODAY DATE BUT THIS IS OCCURRING YEAR ROUND.

NHTSA complaint #10368323 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

2007 JEEP WRANGLER GAS OVERFLOW EVER TIME I FILL UP WITH GAS.. GAS COMES SPILLING OUT ALL OVER ME,MY JEEP AND WORST OF ALL OVER THE GROUND. I HEAR ABOUT ALL KINDS OF OTHER JEEP OWNERS WITH THE SAME PROBLEM. WHY HAS THERE NOT BEEN A RECALL ON THIS WITH GAS GOING ALL OVER THE GROUND AND ON PEOPLE HOW SAFE IS THAT .

NHTSA complaint #10364234 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

GAS GUSHES OUT WHEN FILLING UP GAS TANK EVEN THOUGH THE SAFETY CUTOFF ON THE PUMP HAS ENGAGED.

NHTSA complaint #10298281 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FUEL, A FEW CUPS OVERFLOWS WHEN FILLING UP, I DON'T FILL ANYMORE.

NHTSA complaint #10298186 — an unverified report by a vehicle owner.

FUEL SYSTEM, OTHER

ENGINE LIGHT COMES ON AND OFF. GAS CAP SIGNAL APPEARS AND DISAPPEARS. ENGINE HAS STALLED X2. WHEN APPLYING BRAKES GOING DOWN HILL (15MPH), VEHICLE SHOOK A LITTLE LIKE ANTI-LOCK SYSTEM WAS IN FULL EFFECT. ALL RECALL NOTICES HAVE BEEN TAKEN CARE OF AT DEALERS.

NHTSA complaint #10226536 — an unverified report by a vehicle owner.