The contact owns a 2017 Kia Cadenza. The contact stated that while driving at various speeds, the vehicle suddenly lost motive power. The contact waited before restarting the vehicle and continued driving. The ABS warning light was intermittently flashing. The failure became more persistent, causing the vehicle to lose power steering functionality. The power steering and traction control warning lights were illuminated. The vehicle was taken to the dealer to be diagnosed, and it was determined that the Motor Driven Power Steering (MDPS) and Electronic Control Unit or Engine Control Unit (ECU) had failed. The parts to replace were Part Number: 56340/F60, a genuine OEM Motor Driven Power Steering (MDPS) Control Module. The vehicle was not repaired. The vehicle was not repaired. The contact stated that the vehicle was previously included in Manufacturer Recall Number: WTY039. The manufacturer was made aware of the issue, and a case was opened. The failure mileage was approximately 165,000.
NHTSA complaint #11755228 — an unverified report by a vehicle owner.
While operating the vehicle, the engine suffered a catastrophic internal mechanical failure, resulting in an immediate and dangerous loss of motive power on the road. A subsequent physical diagnostic scan at an authorized Kia dealership revealed manufacturer trouble code P008800 (Fuel Rail System Pressure-Too High) along with universal engine misfire codes P030100, P030200, P030300, P030400, P030500, P030600. The dealership confirmed that the internal engine failure includes a shattered piston. Code P008800 is the primary mechanical failure indicator for active manufacturer warranty campaign WTY 0034 (High Pressure Fuel Pump Failure). The defective high pressure fuel pump suffered a primary mechanical failure, spiking fuel rail pressures to dangerous limits, causing all six cylinders to misfire, and inducing low speed pre-ignition (LSPI). This extreme combustion anomaly directly fractured the engine's internal piston. The dealership is currently attempting to clear these diagnostic trouble codes and perform an oil change, which would actively destroy the physical and electronic evidence linking the safety recalled component failure directly to the engine's catastrophic destruction. This component failure poses a severe stall hazard and a risk of total engine failure while operating at highway speeds. Photographic proof of the official dealer diagnostic report has been preserved.
NHTSA complaint #11755245 — an unverified report by a vehicle owner.
The contact owns a 2019 Kia Cadenza. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated. Additionally, upon starting the vehicle later, the contact noticed that there was an abnormal ticking sound coming from under the hood. The vehicle was taken to AutoZone, where the contact was informed that the diagnostic trouble code was associated with a tire sensor failure. The vehicle was not repaired. The dealer was not made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 74,000.
NHTSA complaint #11742797 — an unverified report by a vehicle owner.
Engine oil light is on and there is a burning smell when I drive. Fear of a fire breaking out in the engine when driving or parked. Had it looked at by a technician and they expressed those concerns to me and that brings me great worry. The service technician believed it was just the oil cap being loose but there was no evidence of that.
NHTSA complaint #11732978 — an unverified report by a vehicle owner.
I currently have a complaint 11709255 regarding the electric thermostat. I just had that part replaced in November of 2025 for the 3rd time. Last week, again I had a warning of engine problem. The next day there was cold air blowing when the heat was on. The dash thermostat immediately began to move to hot. I was thankfully close to home. I turned car off and fan continues to run under the hood. I cannot afford to keep having this part replaced. Please look into this. This is not right.
NHTSA complaint #11725993 — an unverified report by a vehicle owner.
Check engine was flashing in front of my house in Brookhaven Pa. Took to mechanic around the corner, diagnosed with a blown head gasket & oil in my anti freeze over flow. Internal engine failure. Had towed to Kia dealership in NJ
NHTSA complaint #11723674 — an unverified report by a vehicle owner.
I have and am the original owner of a Kia Cadenza 2017 with the 3.3L Lambda engine (same engine as the Sorento lawsuit). The vehicle is currently at the dealership getting repaired due to carbon buildup causing the fuel injectors to malfunction( despite of consistently being on top of maintenance and oil changes).I have read online of lots of users with failed engines due to carbon buildup in these engines. The warning lights I got were p0171,p0174, and p0191, and am worried that after the repair the engine will eventually fail due to the buildup as the main issue isn’t properly being addressed. The issue occurred about 300 miles ago where the dealership erased it. Then told the vehicle did not have any issues. Brought it back to the Kia dealership where they finally gave a proper diagnosis after being told nothing was wrong with car. I am concerned as there are lots of owners online experiencing the same issues with their Kia cadenzas and nothing done about it. Took the vehicle in after it stalled in traffic, but, as seen, the repair cost is high and a temporary band aid.
NHTSA complaint #11716465 — an unverified report by a vehicle owner.
This vehicle was inherited to me in 2019 from my father who puchased it cash on 10/13/2017. On 4/19/2018 he brought it in for a check engine light which was related to recall sa299 (ELECTRONIC THERMOSTAT). On 7/11/2018 service was performed again. On 3/4/2022 I brought in for check engine light with same recall for ELECTRONIC THERMOSTAT. On 11/10/2025 car showed engine overheating. In fear, I immediately brought to closest mechanic stating same problem, ELECTRONIC THERMOSTAT AND RADIATOR HOSE WHICH GOES HAND IN HAND. Before work began I left voice mails and emails with the service manager of Rohrman Kia in Schaumburg, Il. No one reached out. I spoke with Jim at same location on 11/10/2025 at 4:00 pm who told me it was my responsibility because the part was no longer under warranty. I filed a complaint (24149522) with BBB. on 11/13/2025 after I had to pay my mechanic $1000 to fix problem which obviously is a defect. On 12/3/2025 I spoke with Mike from Kia who said part was no longer under warranty and will not reimburse. I asked him to prove the previous thermostat was installed correctly according to the service action sa 346 and he said they have certified techs and they do not have to prove that to me. I would like Kia to accept responsibility for this part. Also carfax does not show all times Kia replaced that thermostat.
NHTSA complaint #11709255 — an unverified report by a vehicle owner.
My 2016 Kia Cadenza (VIN [XXX] ) experienced repeated overheating, coolant loss, and eventually white exhaust smoke consistent with internal coolant intrusion. The issue began mid-2025 and worsened over time. Despite reporting overheating and coolant loss to Central Kia of Plano, the dealership failed to diagnose the problem, did not escalate to Techline, and did not check or apply Kia Service Action WTY039, which was active. They returned the vehicle to me still overheating, forcing me into multiple out-of-pocket repairs for coolant, radiator, radiator fan, and water pump replacement. None resolved the issue, and the vehicle became unsafe to drive due to rising temperature and smoke. A second dealer, Mesquite Kia, performed a proper diagnosis. Kia Corporate approved an engine replacement under WTY039 on 11/6/25, and the repair was completed on 11/29/25, confirming the overheating was caused by a covered engine defect. Kia Corporate later denied reimbursement for prior repair attempts by blaming “3rd party repairs,” ignoring that the dealership’s misdiagnosis forced me to seek outside help. This defect created safety hazards including overheating while driving, risk of stalling, coolant intrusion, and visible smoke. I am requesting NHTSA review Kia’s handling of this defect and the failure of Central Kia of Plano to diagnose or escalate a known engine issue, which allowed a safety defect to worsen. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11702878 — an unverified report by a vehicle owner.
Complete engine failure due to rods and bearings (same as all other Kia engine recalls currently active). Ironically my car wasn’t included in the recall. Also I’ve noticed that Hyundai has extended the warranty for this same engine in the 2018 Santa Fe basically acknowledging it has a problem but didn’t include the 2018 Kia cadenza which has the EXACT SAME ENGINE. Now I have engine failure prematurely and they are trying to deny repairs. Also was never notified of the KSDS “upgrade” before engine failed only after and it had been to a Kia dealer for fuel pipe repair just recently in which they could have installed it before engine failure.
NHTSA complaint #11700022 — an unverified report by a vehicle owner.
No prior issues/light on dashboard as the car was just serviced for coolant hose replacement. On my way home from work, the car stalled and loss power at the light. The signs were giving engine failure due to losing power then a clicking/ticking noise. After pulling over and giving the car a break I tried to restart it, at that point the noise had change from the clicking to a weird knocking noise. I had the car towed to my trusted mechanic shop. He advised me that the engine indeed did fail and that it would need to be replaced. Verbatim he said: “The diagnosis is that the noise is an internal engine failure, rod bearing and connecting rods.” This was a major safety concern because the engine could have caught fire during that short drive I had home risking my life and surrounding vehicles. Aware of the Kia engine recalls already, I called Kia just for them to tell me it’s not on their recall list so it’s going to be an out of pocket repair. I asked if there was a way for it to be included in the engine recall as an exception due to low mileage (technically early engine failure) and the customer service rep was rude and condescending about how it’s not Kia’s problem.
NHTSA complaint #11699682 — an unverified report by a vehicle owner.
Multiple oil, engine/knocking issues. Drove the car unaware of loss of oil ( disguised as water from days rain) no oil light or engine light appeared. When I took to dealer the leak was fixed.Multiple times of loss of oil and only once did it show on dash.I kept taking to dealership for loud knocking and was told it wasn’t reproduced. But fixed a gasket/manifold more than once. overheating of engine when I was driving out driveway. I turned around parked and had it towed to dealership. Stated faulty sensor then was called back & told i needed to pay for the fan wires that kept the engine cool because they had melted in the process.i have had issues with right brake fluid and boot as well. Changed brakes.most of the time It has been loss of oil or engine knocking then needed to rebuild the engine which I had to pay $4000. Im sad and upset that most of the time I have had my car it has been in the shop or having to be parked for a length of time.( avg. 3-20 days) was called back to say it was another issue.Took to another dealer who repaired . had to take in for repeat engine issues and knocking sounds the wasn’t “reproduced” it was clearly heard when manager drove it but service provider said no. So frustrated that I have spend a lot of money for engine issues and haven’t had a chance to enjoy the vehicle, frustrated it is performed less than what I expected.have never taken my car to any other but dealership and kept up with maintenance. the rest was slow to accelerate(even after just picking up from dealership) a lot of knocking .Engine was “rebuilt” and It’s still in the shop today. Driving without oil loss notification.Now radiator hose is swollen/soft at top unsure if oil or water. And I need to pay for hose $400 now another $1000? braking feels unusual after they replaced. I notified KIA customer support/emailed all receipts and return call was told no recalls about a year ago and she would call dealership. Car was at dealership for a while at that time.
NHTSA complaint #11693269 — an unverified report by a vehicle owner.
I am submitting this complaint regarding a 2016 Kia Cadenza (VIN: [XXX] ) and Kia’s repeated failure to properly diagnose or repair a serious overheating/safety defect despite this being a well-documented and known issue affecting these engines. Vehicle and Service Information •Vehicle: 2016 Kia Cadenza (VIN: [XXX] ) •Mileage: ~129,608 •Dealer Involved: Central Kia of Plano (Plano, TX) •Repair Order #: [XXX] •Dates: [XXX] Issues 1.Overheating / Known Engine Defect •My vehicle overheats, especially with the A/C on or at idle. •Kia has already been directed to issue extended warranties on these engines due to systemic defects (including bearing wear, engine failure, and overheating). •Despite this, Kia continues to deny or delay proper repairs and instead authorized the dealer to replace only a cooling fan relay, which did not fix the defect. 2.Dealer Misconduct •Central Kia of Plano kept my vehicle for 10 days, charged me $269.92, and returned the vehicle still overheating. •I was told a Techline case would be submitted, but I have confirmed this was never done. 3.Incomplete Recall Repairs •I requested completion of open recalls: •SC232 – Windshield Bonding •SC284VG – HECU Fire Risk •The dealer marked one as complete and the other as pending, but I have no confirmation in Kia’s system that either was properly completed. 4.Corporate Inaction •I have multiple open cases with Kia Corporate, but they have failed to escalate or reassign me to a reputable dealer. •Despite the extended warranty obligation, Kia has not replaced the engine or confirmed a permanent repair. Why I Am Contacting NHTSA •This is not an isolated issue — it is a known safety defect across these engines. •Kia has been required to extend warranties for this exact defect but is failing to honor that coverage by stalling, misdiagnosing, and leaving vehicles unsafe. •My vehicle remains unsafe to drive INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11684923 — an unverified report by a vehicle owner.
The contact owns a 2014 Kia Cadenza. The contact stated while driving 70 MPH, the vehicle independently went into LIMP Mode and failed to accelerate while depressing the accelerator pedal. The contact stated that several unknown warning lights flashed on the instrument panel. The contact was able to coast the vehicle over to the shoulder of the roadway. The contact drove the vehicle to an independent mechanic, and it was discovered that there was no oil in the engine. A diagnostic test was performed; however, no oil leaks or failures were discovered. The manufacturer was then notified of the failure and the contact was advised to take the vehicle to a dealer for service. The mechanic added oil to the engine and the contact drove to the local dealer. The contact was informed that an oil change was needed; however, the cause of the failure was not yet determined. The contact was also informed that the vehicle was not covered under recall or warranty. The vehicle was not repaired. The failure mileage was approximately 177,000.
NHTSA complaint #11662295 — an unverified report by a vehicle owner.
The engine started smoking and knocking really bad. Took it to the kia dealership and was told a piston o ring and gasket went bad because of heavy oil consumption that caused antifreeze to leak inside the motor while sitting still and this was causing the burning smell because the cylinder had gone bad because of this. The dealership states this was a known issue with all kias from this year and should be under recall. So I called kia because the car only has 80k miles and they informed me it's not apart of the open recall because it's a cadenza. What if I hadn't went back outside and seen the smoke and the car caught fire and burned my home down. It seems like kia knows all of these motors are bad and trying to keep it secret
NHTSA complaint #11654893 — an unverified report by a vehicle owner.
Failure of Oil Pressure Sensor resulting in oil leaking into wiring harness, this is the same problem with 3.3L engines in other models that KIA has extended coverage. I contacted KIA Customer Care and was told they tracked VIN and not enough Cadenzas had reported the same repair. If the problem is with the engine sensor then it should apply regardless of vehicle it was installed.
NHTSA complaint #11640601 — an unverified report by a vehicle owner.
Engine seized. 3.3L Lambda II GDI. This is the 2nd Hyundai/KIA product that the engine has seized on me. Both with bearing failure. Neither on the list of recalled engines. You need to do a more thorough investigation into Hyundai/KIAs engines. The brands share the same power trains across the entire line up for a number of years. This class of engines has been produced for YEARS along with the Theta class of engines that you already forced Hyundai/KIA to recall. This seizure has cost me THOUSANDS and additional THOUSANDS that I am unable to pay. I was forced to do a voluntary surrender of the vehicle due to this repairs! BEFORE completing the suggested maintenance totaling over 5 thousand dollars the service tech should have warned me that the engine wasn't going to last much longer instead of telling me that the repairs were necessary and could be dangerous. The dealer and this company took advantage of me and who knows how many others! NHTSA needs to do something about Hyundai/KIA!
NHTSA complaint #11617971 — an unverified report by a vehicle owner.
There are thousands of vejicles with a variant of the 3.3L V6 Lambda II GDI Hyundai/KIA class of engines on the road. There are hundreds if not thousands of complaints regarding different variants of this engine throught Hyundai/KIAs line up. All of them with seized engines. There are class action lawsuits in other countries regarding this engine. They have known since before 2015 that these engines were defective! Just like with the Theta class of engines these engines also have bad engine components. The metal that is used is subpar. These engines need to be recalled. Every owner needs a replacement engine. The little people need justice. Every day someone is affected by a Hyundai/KIA product in a major way. $11,000 dollar engine. Every service completed every repair completed every recall completed thousands of dollars invested into this vehicle only to have it fail me. Now I am stuck like many others with a car that I am forced to surrender to my lender because of the negligence of a huge corporation.
NHTSA complaint #11617737 — an unverified report by a vehicle owner.