2018 KIA Stinger fuel system problems

FUEL/PROPULSION SYSTEM

My vehicle is exhibiting a loss of drive power, particularly uphill, with a diagnostic code of P0088 (Fuel Rail/System Pressure Too High). This is the same defect addressed by recall campaign 23V634000 (Kia SC281), covering the high-pressure fuel pump / fuel control valve plunger on 2018-2021 Stinger vehicles. I had the SC281 recall repair completed on this vehicle on Novermber 16th 2024. I am now experiencing the same symptom and code the recall was meant to fix, indicating the repair did not resolve the defect. The original repair only updated the software but did not replace the fuel pump. The dealer, Jack Daniels Kia in NJ, has quoted me a $250 diagnostic fee before proceeding further. Under the National Traffic and Motor Vehicle Safety Act (49 U.S.C. § 30120), once a safety recall has been issued, the manufacturer is required to remedy the defect, including diagnosis tied to that defect, free of charge to the owner. This applies whether the issue is addressed as a continuation of SC281, a revised action (I was told a repair labeled "SC281Y" applies, though it does not currently appear in the dealer's system under my VIN), or simply as a recurrence of the same defect after an incomplete repair. The SC281Y memo from Kia is PROOF that Kia knows the original SC281 fix did NOT resolve the defect for my car. This is a dangerous situation that KIA MUST resolve. I am requesting that Kia: 1. Confirm my VIN against campaign 23V634000 and clarify the status of any SC281Y follow-up action. 2. Investigate why the original SC281 repair did not resolve the defect. 3. Waive the $250 diagnostic fee, as it is tied to a defect already covered under an open federal safety recall. 4. Perform any necessary repair at no cost to me.

NHTSA complaint #11751286 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

The oil pressure light is coming on . Even after doing oil change at dealership it’s not going away. Confirmed that the issue was with the oil pressure switch at dealership, which is a common problem for 3.3L V6 engines . Similar issue was observed in other older models with similar engine and the warranty was extended to cover this issue (WTY026).

NHTSA complaint #11723740 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My vehicle is experiencing active symptoms consistent with the defects described in recalls SC279 and SC281. These include: - Sputtering and hesitation under acceleration - Severe drop in fuel mileage - Check Engine Light - Fuel‑rail pressure fault code - Black soot at the tailpipe - Loss of power The vehicle is unsafe to drive and may stall. My dealership confirmed that the recall parts are on national backorder and cannot repair the vehicle. Kia Corporate has refused to authorize towing or a loaner vehicle upfront, leaving me without safe transportation. This is a serious safety issue, and Kia is unable to provide a timely remedy.

NHTSA complaint #11715301 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Kia Stinger. The contact stated that while driving at various speeds, the vehicle hesitated and jerked abnormally while accelerating. The check engine warning light illuminated and remained illuminated. The vehicle was taken to the local mechanic, who diagnosed the vehicle and determined that the high-pressure fuel pump was faulty and needed to be replaced. The vehicle was not repaired. The contact was informed of the NHTSA Campaign Number: 23V634000 (FUEL SYSTEM, GASOLINE). The contact was informed that parts were not yet available. The failure mileage was 115,000.

NHTSA complaint #11685758 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Fuel pump recall came back but Kia wouldn’t take it back without the recall being open

NHTSA complaint #11675791 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Casey Kia located in Newport News Virginia continues to delay the replacement of my fuel pump. I was told it was replaced but 2 weeks later I was having the same issue to the point where my car was decelerating on the interstate. After I took it back in for them to repair it I was told they would look into it. I received a call saying the fuel pump was never replaced and the only thing that had been done originally was a software update, so basically I was lied to and put in a very dangerous situation because a fire could've been caused while driving. They also said they were waiting for approval for the recall before they repaired it. Had I known it wasn't repair I wouldn't have driven the car. I was supposed to pick my car up on 07/26 but I was told they ordered the wrong part and it would be available to them on 07/29.

NHTSA complaint #11604694 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

*Notice* There has been NO ACCIDENT but it could potentially be a fatal one. When performing the auto start up process the car's RPM increases rapidly, the engine makes a sputtering sound as if the car will crank or that there is a misfire and shuts down. This results in the check engine light coming on the instrument panel and error code P0172: Replace High Pressure Fuel Pump.

NHTSA complaint #11578804 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

On 11/13/2020 my car had 26,942 miles. I experienced my first issue with my vehicle where it lost power while driving on the freeway. My vehicle was in the shop for 17 days where they replaced the fuel pump directly affected my turbo. On 10/19/2023 my vehicle had 68,366 miles on it while driving to work when I went to accelerate from a stop sign there was no power and I literally had to drift to the side of the road. My vehicle was in the shop for seven days and it was the same issue. A few weeks after my vehicle was repaired, I received the recall notice, however at this time there was no resolution it was nearly a recall campaign. On 12/29/2023 my vehicle had 70,290 miles (not even 2000 miles since my vehicle had returned from the shop) as I was leaving work, my car begin sputtering like it was going to lose power. I made it home safely however, upon trying to start my vehicle the next morning there was a warning and a message saying not to drive my vehicle. My vehicle has been in the service center since December 30, 2023 with no resolution.

NHTSA complaint #11571761 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Kia Stinger. The contact received notification of NHTSA Campaign Number: 23V634000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated while driving 75 MPH and depressing the accelerator pedal, the vehicle lost motive power inadvertently. There was no warning light illuminated. The contact was able to veer to the side of the road. The contact stated that the vehicle was stuck in second gear. The contact was able to drive to the dealer at slow speed. The dealer diagnosed that the fuel pump assembly part number: 35320-2CTB1 and bolts needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 65,000. VIN tool confirms parts not available.

NHTSA complaint #11559038 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Kia Stinger. The contact received notification of NHTSA Campaign Number: 23V634000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated while driving 45-50 MPH downhill and depressing the accelerator pedal, the vehicle failed to respond. Additionally, the contact stated that while driving uphill, the vehicle decelerated and failed to exceed 35 MPH while depressing the accelerator pedal. There was no warning light illuminated. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and advised the contact that he could repair the vehicle at his own expense, and he could then be reimbursed for the repair later. The failure mileage was approximately 77,600. VIN tool confirms parts not available.

NHTSA complaint #11558377 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Kia Stinger. The contact stated that while driving at an undisclosed speed, the vehicle briefly shuddered and displayed a "Service Vehicle Now" message. The contact smelled a gasoline odor in the interior of the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that the contact might have fueled the vehicle with insufficient fuel and provided a fuel additive for additional testing. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V634000 (Fuel System, Gasoline), and the VIN was included, but parts were not yet available. The manufacturer was not notified of the failure. The failure mileage was 49,000.

NHTSA complaint #11556238 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My vehicle has a delay in taking off from a complete stop. The car also looses a little power while driving intermittently. There was times that the car wouldn't even go at all I had to turn off the car and restarted to be able to go. That has been happening more and more the check engine light has been on the whole time. Also the rear shock or strut went out but the part that is apart of the suspension has broke and now the vehicle scrapes the tire because it is too low

NHTSA complaint #11551952 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

All of a sudden while driving on the road my vehicle lost total power in the middle of an intersection. I would pres the gas pedal and got no response the vehicle would not go. I had to turn car off and try starting it again then the vehicle got power. This keeps happening not everyday but it's happening about once a week while driving. There has been times where the car wouldn't restart for about an hour I got the car off the road and stayed stranded at night till it finally got power to move it would start but it would just putter like it wasn't getting enough fuel and my engine light came on. It is telling me something is wrong with the fuel rail , high pressure fuel pump, and it is running too rich. I have a little over 62,000 miles on it . Now there is a delay in take off it has lost a lot of power and is using a lot of fuel getting poor gas milage.

NHTSA complaint #11547591 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

The contact owns a 2018 Kia Stinger. The contact stated while driving 80 MPH, the vehicle lost motive power and stalled without warning. The vehicle failed to restart. The vehicle was towed to the residence where it was diagnosed by an independent mechanic. The contact was informed that the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and stated that there was no recall on the vehicle for the failure. The failure mileage was 62,000.

NHTSA complaint #11500841 — an unverified report by a vehicle owner.