My Kia Stinger then give me troubles with the six cylinder. He fixed it couple of months down the line the problem reoccurred so-called fixed it two months down a line. The problem occurred, and now the problem reoccurred took it into the dealership. The dealership said my engine harness is melted that can be the cause of the issue and now knowing that could’ve been the cause of the issue from the get-go. They don’t want to fix it because it’s out of warranty
NHTSA complaint #11757011 — an unverified report by a vehicle owner.
On XXX my son picked up his 2018 Kia Stinger (VIN [XXX]) from Ken Garff Honda Riverdale, UT after a routine oil change, filter change, and tire rotation (RO# 5026743). About 3 hours later, while driving on [XXX] near [XXX], he noticed a burning smell, then saw smoke coming from the front of the vehicle, followed by flames from the engine compartment. He pulled over and exited safely before the vehicle was fully engulfed. No other people or vehicles were struck, but the fire occurred on a public highway shoulder next to dry grass, creating a wildfire risk in addition to the risk to him and other traffic. On XXX, this same vehicle received recall SC300 (NHTSA Campaign 24V169000) at Jerry Seiner Kia in [XXX], which replaced the left turbocharger oil feed pipe and hose assembly. This addressed the exact component Kia's recall identifies as a fire risk from oil leaking near the exhaust manifold. This system, and/or the oil change performed hours before the fire, may be connected to the failure, but this has not yet been confirmed by a professional inspection. The problem has not been reproduced or confirmed by a dealer or independent shop. No inspection by police/insurance/manufacturer has occurred yet. No dashboard warning lights or messages appeared before the fire; the only symptom noticed was a burning smell shortly before smoke and flames appeared. The vehicle is located at [XXX] with an address [XXX] Lot [XXX] and remains available for inspection upon request. I have a pending insurance claim with Bear River Mutual. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755487 — an unverified report by a vehicle owner.
I bought this car brand new and since I purchased it in December of 2021. Every summer this car leaves me stranded everytime I shut the car off and its hot outside I took it to several kia dealerships while in warranty but because it was not showing a code they couldn't fix it. The warranty ran out and this car still won't start if its hot outside but has no issues in the winter. After 3 yrs of dealerships doing nothing to fix it because there was nothing wrong a dealership replaced the computer because they said that maybe thats why its not showing a code. I got my car back from the dealership drove across the street shut the car off and stranded for another 8 hrs. This car is the most unreliable car I have ever owned. To have a brandnew car leave you stranded in the 1st 6 months and the manufacturer do nothing to fix it is unheard of but to still be dealing with it after 4 yrs and kia doing nothing to correct the issue I will be finding a lawyer and suing kia for all my lost hrs of work for the money I paid for this junk car and for the pain and suffering it has caused since they refuse to fix it.
NHTSA complaint #11752064 — an unverified report by a vehicle owner.
Oil pressure sensor failure on the engine, there is an open TSB for this same issue/same engine on other Kia models but not the Stinger. Dealer verified that the oil pressure is fine and that it is the sensor, independently verified by a third party shop. Dealer charge is over $3k for the repair and third party is just about $2k.
NHTSA complaint #11743225 — an unverified report by a vehicle owner.
My 2019 Kia Stinger GT2 with approximately 25,000 miles has been out of service since February 12, 2026 for diagnosis and repair of a system issue. The vehicle has remained at the dealership for over two months. Multiple repair attempts have been made, including escalation to Kia corporate engineering. Despite these efforts, the issue has not been clearly diagnosed and no permanent repair has been completed. The vehicle is currently unusable, and the inability to identify the root cause raises concerns that the issue could result in unpredictable or recurring system behavior. Given the reliance on electronic and computer-controlled systems, there is concern about safe and reliable operation if the vehicle is returned without a confirmed fix. The manufacturer has not provided a clear resolution or timeline.
NHTSA complaint #11732324 — an unverified report by a vehicle owner.
I am reporting a Failure of the Remedy for NHTSA Recall 23V634000 (Kia Recall SC281). The original recall attempted to "fix" a High-Pressure Fuel Pump (HPFP) issue via a software update to the Engine Control Unit (ECU). This remedy has failed. My vehicle is currently experiencing the exact safety hazard described in the recall: loss of motive power and stalling at various speeds due to HPFP failure. Despite the software "patch" performed in 2024, the physical hardware (HPFP) has now suffered a mechanical failure, rendering the vehicle unsafe to drive. Description of the Incident: On or about March 15, 2026, the vehicle began lose power and stuttered while in motion, posing a significant risk of a rear-end collision. Diagnostic scans (OBD-II) confirmed code [Insert Code if known, e.g., P0087 for Low Fuel Rail Pressure]. A secondary diagnosis at Courtesy Kia (Mesa, AZ) on March 18, 2026, confirmed the HPFP has failed. Failure of Manufacturer to Act: The manufacturer (Kia America, Case #XXX) is currently refusing to replace the failed component under the recall mandate. They are categorizing the repair as "Goodwill" because the recall was "closed" by the unsuccessful software update. The manufacturer’s refusal to remediate a known mechanical defect that causes stalling in traffic is a direct violation of the spirit and legal requirement of the National Traffic and Motor Vehicle Safety Act. Current Location of Vehicle: Courtesy XXX. The vehicle is grounded as it is unsafe to operate.
NHTSA complaint #11728277 — an unverified report by a vehicle owner.
My 2022 Kia Stinger first went into the dealership because it would not accelerate properly even at full throttle, creating an immediate safety risk in traffic. Over multiple visits, the dealership replaced the ECM, ABS module, brake booster, vacuum pump, and a fuel injector, and confirmed repeated electrical shorts across major systems including throttle control, braking, and fuel delivery. Despite months of repairs, the loss of power, brake assist issues, ABS faults, and electrical failures continued, and the dealership never identified the root cause. The problems were reproduced and documented by the dealer, the vehicle was inspected multiple times on behalf of the manufacturer, and warning lights and drivability symptoms appeared before each failure. The vehicle is currently not in my possession, and all replaced components are available for inspection. The combination of engine hesitation, brake system failures, and repeated electrical shorts makes the vehicle unsafe and unreliable to operate.
NHTSA complaint #11724259 — an unverified report by a vehicle owner.
My vehicle is experiencing active symptoms consistent with the defects described in recalls SC279 and SC281. These include: - Sputtering and hesitation under acceleration - Severe drop in fuel mileage - Check Engine Light - Fuel‑rail pressure fault code - Black soot at the tailpipe - Loss of power The vehicle is unsafe to drive and may stall. My dealership confirmed that the recall parts are on national backorder and cannot repair the vehicle. Kia Corporate has refused to authorize towing or a loaner vehicle upfront, leaving me without safe transportation. This is a serious safety issue, and Kia is unable to provide a timely remedy.
NHTSA complaint #11715301 — an unverified report by a vehicle owner.
Transmission light appeared and a loud knocking noise followed by white smoke bellowing out of the exhaust. I took it to a shop and they said it now needs an engine replacement.
NHTSA complaint #11712123 — an unverified report by a vehicle owner.
My oil light came on around 91,000 miles. Kia is known for this issue being an oil pressure sensor issue. Happens around 80,000-100,000 miles. Its a pretty common issue and the labor for a $80 part costs up to $2,000.
NHTSA complaint #11694772 — an unverified report by a vehicle owner.
Since April I have been having the same issue. Sometimes when I am stopped and the autostop is supposed to shut down the engine, the engine just sputters and if I hit the gas nothing happens. I have to put the car in park and shut it down then restart it. I try to shut the auto stop off when I get in the car but sometimes I forget. It has happened at over 20 times that I have documented over the last couple of thousand miles, many times in dangerous locations, in the middle of interactions or waiting for a light. The engine light has also gone on and off over the last couple of months. The car is now at the dealership and they say the high pressure fuel pump is leaking. I see there has been a recall in specific Kia Stingers, should my car be involved in this recall? The issue began around 45000 miles and continues at 52000.
NHTSA complaint #11690875 — an unverified report by a vehicle owner.
The contact owns a 2018 Kia Stinger. The contact stated that while driving at an undisclosed speed, there was an abnormal ticking sound coming from the engine compartment. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 24V169000 (Engine and Engine Cooling). The vehicle was taken to the dealer, where it was diagnosed that the left turbocharger oil feed pipe and hose assembly had failed and needed to be replaced. The contact was also informed that the engine had failed and needed to be replaced. The vehicle received the turbocharger oil feed pipe and hose assembly repair. The manufacturer was notified of the failure. The failure mileage was approximately 83,270.
NHTSA complaint #11683444 — an unverified report by a vehicle owner.
I have a check engine light related to the high pressure fuel pump. Because i brought the car in for the recall before the code appeared for the high pressure fuel pump, Kia claims the recall is complete and will not perform the related recall repairs. I also have since developed a engine code related to the catalytic converter which i am told by a separate mechanic that this can be caused by the high pressure fuel pump error. All in the repair estimate is $8,006.26, not including the $235 for Kia to give me this information without fixing anything.
NHTSA complaint #11674408 — an unverified report by a vehicle owner.
The contact owns a 2018 Kia Stinger. The contact stated while driving 45 MPH, the engine started knocking for approximately six minutes. There were no warning lights illuminated. The vehicle was taken to the local dealer, who declined the repair, due to gaps in between oil changes. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 93,300.
NHTSA complaint #11663871 — an unverified report by a vehicle owner.
The contact owns a 2018 Kia Stinger. The contact stated that occasionally while starting the vehicle, the vehicle failed to start immediately. The contact stated that oil was leaking from the vehicle during each failure. The contact stated that while attempting to accelerate from a light, at 5 MPH the vehicle lost automotive power, with the check engine and ABS warning lights illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the fuel pump and vacuum pump were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 99,000.
NHTSA complaint #11661509 — an unverified report by a vehicle owner.
The contact owns a 2018 Kia Stinger. The contact received notification of NHTSA Campaign Number: 24V169000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that there was a burning odor coming from underneath the hood of the vehicle near the engine compartment. There was a warning light illuminated, however the contact was unsure what warning light was illuminated. The contact described the warning light as a circle with a line symbol in the center but was not sure of the symbol. The dealer was contacted, and an appointment was made. The vehicle was taken to the dealer, and it was confirmed that parts were not available and might take an additional 3 days for the repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 70,000. Parts distribution disconnect.
NHTSA complaint #11647646 — an unverified report by a vehicle owner.
I brought my vehicle in for the recall SC300 and they discovered that my oil pressure switch is leaking which is on top of the engine. This is causing a leak and oil pressure light to come on intermittently. Same part as the Kia Sorento, cadenza, and the Sedona that all had the warranty extended recall to 15 years or 150,000 miles. Every Kia forum has people complaining about the same issue and being charged $3000-5000. This can cause an engine fire if left unchecked just like the recall SC300. There is a backlog for that part to come in to fix the issue and people are driving with the light flickering because they don’t know the oil pressure switch is leaking over there engine and down to the EPU which could start a fire as well.
NHTSA complaint #11647756 — an unverified report by a vehicle owner.
Confirmed that the Oil Pressure Switch had to be replace. Kia had a recall begin July 3, 2019 that the part was faulty and did extend to eligible vehicles to 15 years or 150,000 miles. This part is known problem in the make and model of the Kia Stinger. My 2018 Stinger GT2 was not included in the recall. The dealer did replace and confirmed that the part number is 24V169000 which was included in the recall "SC300" by Kia but my VIN was not included. Apparently they did not recall all the vehicles that have this safety hazard.
NHTSA complaint #11639447 — an unverified report by a vehicle owner.
Oil Pressure Switch is bad. Kia had a recall begin July 3, 2029 that the part was faulty and did extend to eligible vehicles to 15 years or 150,000 miles. This part is known problem in the make and model of the Kia Stinger and I now have this issue with my 2018 Stinger GT2 with 115,000 miles. Many complaint on forums related to this but it seems that Kia has selected specific vehicles only. Oil light comes on when care is stopped at an idle. Then goes off and does happen when car is cold.
NHTSA complaint #11630695 — an unverified report by a vehicle owner.