2020 KIA Telluride headlight problems

EXTERIOR LIGHTING

The factory-installed driver/passenger side LED headlight assembly suffered a sudden, total internal electrical failure while driving at night, causing an immediate loss of forward visibility and creating a severe crash hazard. This is a known, systemic manufacturing defect affecting premium trims (SX/SX-Prestige) of the 2020 Kia Telluride. The housing seals degrade prematurely, allowing condensation to become trapped inside the unit. This moisture corrodes the internal circuit boards and shorts out the electrical modules, completely disabling the high beams, low beams, and running lights. Because these LED units are entirely sealed, they cannot be serviced or repaired by changing a bulb; the entire expensive structural component must be replaced. Kia is fully aware of 2020 Telluride headlight failures and issued Safety Recall SC299 (NHTSA Campaign 24V148000) to address them. However, Kia arbitrarily limited that safety recall to lower trims utilizing halogen assemblies. Premium trims utilizing LED assemblies are experiencing the exact same catastrophic loss of nighttime illumination due to internal electrical failures, yet owners are being forced to pay out-of-pocket to fix an inherent safety defect. The NHTSA needs to mandate that Kia expand Campaign SC299 to include all 2020 Telluride trim levels equipped with LED headlight assemblies before this widespread visibility failure causes a fatal nighttime collision.

NHTSA complaint #11758772 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

SC299 (high‑beam headlight failure) is actually a safety defect tied to visibility and part of a recall which my telluride falls just outside of

NHTSA complaint #11744971 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The contact owns a 2020 Kia Telluride. The contact stated that while driving at various speeds, the high beam headlights failed to illuminate as intended, and the vehicle shuddered before losing automotive power. No warning light was illuminated. In addition, the contact stated that the warning lights failed to illuminate as designed when the engine oil level was low. The vehicle was taken to a local Auto Zone, where the relay and high beam headlights were replaced; however, the failure reoccurred. An appointment with the dealer was scheduled to inspect the vehicle. The vehicle was not yet repaired. Upon further investigation, the contact associated the failure with NHTSA Campaign: 24V148000 (Exterior Lighting); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was unavailable.

NHTSA complaint #11728510 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The headlights on this car are pointed too high. When driving on the road at night vehicles coming the other way often assume you have your bright lights on and flash you with their bright lights which can temporarily blind you - obviously a big safety problem! If this only happened once in a while I'd say no big deal but it happens EVERY SINGLE TIME YOU DRIVE THE CAR! I've spoken with other 2020 Kia Telluride owners and they report the exact same problem. I've spoken to the Kia representative at our local dealer about this and his attitude was basically "not my problem". Please, tell Kia to fix this problem. Otherwise there will be accidents that could have been avoided. Thanks.

NHTSA complaint #11709139 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The contact owns a 2020 Kia Telluride. The contact stated while attempting to have a vehicle inspected, it was discovered that there was an open recall on the VIN. The VIN was included in NHTSA Campaign Number: 24V148000 (EXTERIOR LIGHTING); however, the part to do the recall repair was not available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11673399 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

It took 8 months to repair the Recall #SC299B HALOGEN HEADLAMP-BOTH. Repair was done 04/03/2025, which appears to have not last long as high beam is low again and I am afraid to drive in early morning, dusk, or evening due to the timid, low bearing high beams. This is very unsettling as we have made three complaints due to negligence and lack of efficiency for recall repair, being in an accident due to not seeing a deer run across and we hit it, as well as, failed state inspection due to light issues (twice) that negatively impacted financial stability and job security as one driver has to have a clear safety inspection in order to work. Kia corporate has been contacted 6 times via email and called back to discuss ongoing issues, however, there does not appear to be any resolution and/or willingness to discuss ongoing issues with our car. It would be nice to discuss this matter and find a solution that alleviates hardship this recall (and apparent lack of fix as lights continue to be an issue) and Kia dealer/company has made. We would appreciate being bought out and/or provided reimbursements and buyout. Either way, we hope others do NOT face the ongoing stress and issues telluride has given us. It is not ideal or fair to continue being fearful of the safety and reliability of our car despite company’s “attempt” of fixing it.

NHTSA complaint #11664738 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

I have had mi car in multiple shops and been told they can’t repair my headlights. The bulb keeps blowing and now the headlight highbeam doesn’t work and my state inspection is coming up next month and the corporate office says there nothing they can do till the part is available. I need my car fixed for my safety and my family’s safety. I don’t know what else to do

NHTSA complaint #11649698 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

The contact owns a 2020 Kia Telluride. The contact received Kia Campaign Number: 296 for the "Halogen Headlamp High Beam". The vehicle was repaired. The contact stated that on one occasion while driving at an undisclosed speed, the high-beam lights failed to illuminate as intended. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that the failure persisted. The vehicle was taken back to the dealer. The dealer was unable to repair the vehicle. The contact stated that the failure had gotten worse. The manufacturer was notified of the failure. The failure mileage was approximately 60,000.

NHTSA complaint #11649546 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

What component or system failed or malfunctioned, and is it available for inspection upon request? POWER TRAIN, OIL CONSUMPTION, CAMSHAFT POSITION , CIRCUIT SENSORS A X 4, HEADLAMPS HIGH BEAMS DO NOT FUNCTION.CHECK ENGINE LIGHT FAILS. How was your safety or the safety of others put at risk? I DONT FEEL SAFE DRIVING AFTER SUNSET IF I CANT SEE ROAD WHEN NEEDED MY HIGH BEAMS DID NOT FUNCTION I WAS TOLD IT WAS FIXED BUT THERE WERE NO PARTS. STILL AN ISSUE. Has the problem been reproduced or confirmed by a dealer or independent service center? YES about 4 times. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO BEFORE THE 4TH WEEK OF HAVING VEHICLE AFTER 3 WEEKS OF PURCHASE WITH NO OIL.I REPORTED IT TO Y SELLER WAS TOLD TO PAY TO FIX AT SERVICE BUT I DID NOT EXPECT TO BUY A FAULTY VEHICLE AFTER THE STRUGGLE WAS TO OBTAIN SUCH VEHICE FOR MY BUSINESS.

NHTSA complaint #11648764 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

I brought veh to Covina Kia on 1-6-25 for recall (SC299B) of headlight high beams failure. George Arroyo refused to take my veh in telling me my warranty had expired. I told him the safety recall had to be addressed. I insisted mileage doesn’t not void a safety recall. He finally took veh in. My veh has been at dealership for 16 days and has not been touched. It is obvious dealership doesn’t want to perform recall because there is no money to be made for the technician and service advisor. I am getting automated texts but no person calls back to inform me about the exaggerated delays. I have filed a complaint with Kia Motors and situation has not changed, my vehicle is still parked at the dealership.

NHTSA complaint #11637456 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

 The contact owns a 2020 Kia Telluride. The contact received notification of NHTSA Campaign Number: 24V148000( EXTERIOR LIGHTING) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect

NHTSA complaint #11635247 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The contact owns a 2020 Kia Telluride. The contact received notification of NHTSA Campaign Number: 24V148000 (Exterior Lighting); however, the part to do the recall repair was unavailable. The contact stated when the vehicle was taken to the dealer, the contact was informed that the parts to perform the recall repair were on back order. The contact stated that the parts had not been made available even after waiting for a month. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11630131 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

I have had been in several times to correct the recall, they noted the seat repaired under warrenty but the service advisor was stuck when retrieving my car. Headlights have need in twice and I’m being told the fix failed to correct the headlights. Wipers stop working intermittently and paint is down to bare metal along windshield and hood. This car is crap.. rear seat folds up when sitting on it and I am repiadmy told they don’t see a problem. Seats are not electric in the rear. This has a feature of an auto close from the back for loading. And it is triggered when my kids sit in it. Only the right rear captains chair.

NHTSA complaint #11626442 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The headlights perform poorly when fully functional, one is out and when I replaced the light it still is not working and now that one is out I am scared to drive at night for fear of hitting a child or pet in my complex. And i will not allow my son to drive because he may get seriously hurt as well. This issue needs to be resolved as to why the headlights just go out and are not fixable with a bulb replacement.

NHTSA complaint #11620542 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The contact owns a 2020 Kia Telluride. The contact received notification of NHTSA Campaign Number: 24V1480000 (Exterior Lighting) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11611664 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The recall 24V148 regarding headlight High beam issue from Gebruary of thus year still has no remedy in order to fix the issue. It has been 6 months and the dealerships just say sorry we don't have any solution even though the recall associated with my car doesn't apply due to the headlamps being replaced with completely different ones already myself. Why is it being allowed that y kkntha later they still don't have a solution so this causes issues with my income because I can't rent my car out due to the open recall

NHTSA complaint #11606936 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The contact owns a 2020 Kia Telluride. The contact stated while driving at approximately 40 MPH, the contact attempted to activate the high beam headlights; however, the high-beam headlights failed to function. No warning lights were illuminated. The contact stated that the high beam headlights warning light illuminated but failed to function as intended. The contact received notification of NHTSA Campaign Number: 24V148000 (Exterior Lighting) however, the part to do the recall repair was not yet available. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 80,000.

NHTSA complaint #11597955 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The highbeams quit working Causing poor visibility

NHTSA complaint #11575876 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

Projector high beams not working. Tested the fuse and relay and both tested fine. Replaced headlights. No remedy other than replacing entire headlight assembly. This is a safety issue and should be recalled and repaired by dealer.

NHTSA complaint #11573877 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The high beams do not work. Neither one. Bulb replacement did not fix either.

NHTSA complaint #11572865 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The high beams of the vehicle are no longer operational. Changing the light bulb does not solve the problem. As per the dealer, the entire unit must be replaced. The failure occurred while driving in the night.

NHTSA complaint #11572830 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The hi-beam function in the headlights are inoperable. I recently purchased this vehicle and the service department at the dealership of purchase confirmed afterwards that the hi beam function does not work. I do not understand how this is not a safety recall on all 2020 Tellurides as there are many forums from individuals who have experienced the same issue. Simply replacing the faulty system kicks the bucket down the road. Unable to utilize the high beams in remote areas reduces safety.

NHTSA complaint #11572463 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

High beams no longer work on the front lights.

NHTSA complaint #11570067 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

Both High Beam headlights failed. Turning on the High Beam illuminates the blue indicator light on the dash, but no change occurs in exterior illumination. The dangers of high speed highway driving (70 MPH) go way up. There is no backup in case the low beam also breaks. And the cost to repair is extremely expensive.

NHTSA complaint #11569711 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS

The contact owns a 2020 Kia Telluride. The contact stated while driving at an undisclosed speed, the high-beam headlights became inoperable. The contact stated while attempting to activate the high-beam headlights, the headlights were inoperable. The vehicle was taken to the dealer where it was diagnosed with a failed headlight assembly. The contact was informed that the headlight assembly needed to be replaced. The vehicle was not repaired. The parts were ordered for the repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 99,800. The contact stated the dealership is going to replace the headlights under the extended warranty.

NHTSA complaint #11567533 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

HEADLIGHTS: have DEPLORABLE visibility, particularly around corners making it nearly impossible to see at night. It is GROSSLY DANGEROUS, and unacceptable to equip a vehicle with such low quality headlights. However, On January 13th 2024 the hi beams ceased to function at all, which has left me unable to drive at night. As a single mother this is a huge hinderance for my young sons and their activities especially this time of year getting dark at 4:30pm. DRIVER SEATBELT MALFUNCTION: The seatbelt has all but completely failed to retract upon removal, leaving the entire thing loose causing to twist and get caught in the door. It will not retract upon collision which also is a PRIORITY SAFETY CONCERN. DRIVER SIDE MIRROR: Gets stuck in the folded position, and more times than not, I then have to manually unfold it. This causes the saved position for my optimal rear visibility to get comprised and I then have to adjust while driving which is ALSO dangerous. The dealer has addressed this and said the wiring was loose to the mirror inside the driver door and assured me they fixed it, however is STILL getting stuck 90 percent of the time.

NHTSA complaint #11565981 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

High beam lights stopped working. Regular lights work. Seems like this is happening to other owners of same make and model year.

NHTSA complaint #11565984 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

Started to notice the high beams where not working. The dash light shows the high beams were on but the lights never changed. I purchased 2 new low/high beams bulbs. That did not fix the issue. My telluride has over 60k miles on it. Doing teacher everyone who has a 2020 kia telluride has this issue just after vehicle hits just over 60k miles. Never noticed before as we never drove at night time before november.

NHTSA complaint #11566153 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

My high beam headlights are not working. There is no change whether the high beams are on or off.

NHTSA complaint #11564910 — an unverified report by a vehicle owner.