2006 Mercedes Benz ML350 brake problems

SERVICE BRAKES, HYDRAULIC

The contact owns a 2006 Mercedes-Benz ML350. The contact received notification of NHTSA Campaign Number: 24V298000 (Service Brakes, Hydraulic) and the vehicle was taken to the dealer for the recall repair. The contact stated that upon starting the vehicle a week later, the brake warning light and the check engine warning light were illuminated, and the message "Take to Service Center" was displayed. The vehicle was taken back to the dealer, but no assistance was provided. The contact stated while driving at various speeds and depressing the brake pedal, the brakes made an abnormal rubbing and squeaking sound, and the vehicle jerked. The vehicle was taken back to the dealer for the failure to be corrected under the recall, but no assistance was provided. The contact stated that the recall repair failed to correct the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 163,450.

NHTSA complaint #11641387 — an unverified report by a vehicle owner.

SERVICE BRAKES

Brakes feel spongy,, when letting off accelerate feels as if transmission has a brake applied

NHTSA complaint #11524733 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2006 Mercedes-Benz ML350. The contact received notification of NHTSA Campaign Number: 22V315000 (Service Brakes, Hydraulic) however, the recall repair was not performed by the dealer. The contact stated that while driving at an undisclosed speed, the vehicle intermittently experienced phantom braking with the ABS warning light illuminated. Additionally, the brake pedal went to the floorboard while depressed and made an abnormal sound; however, the brakes failed to stop the vehicle immediately. The vehicle was taken to an independent mechanic who diagnosed that the ABS sensor was faulty. The vehicle was then towed to the dealer, where it was diagnosed that the ABS sensor needed to be reset. The dealer reset the ABS sensor and informed the contact that the brake system housing was corroded and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 151,831.

NHTSA complaint #11484390 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2006 Mercedes-Benz ML350. The contact received notification of NHTSA Campaign Number: 22V315000 (Service Brakes, Hydraulic). The manufacturer was made aware of the issue and referred the contact to the dealer for assistance. The contact was given an appointment by the dealer weeks in advance and was notified in the recall notice to stop driving the vehicle immediately. The manufacturer assured the contact on multiple occasions that the dealer would provide an alternative form of transportation until the recall was serviced; however, the dealer failed to provide the contact another form of transportation. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11475279 — an unverified report by a vehicle owner.

SERVICE BRAKES

Hello, There is a safety recall from the manufacturer and they have advised not to drive the vehicle. The vehicle does take a little more press on the breaks for it to function so we are assuming that we are affected by this recall. I have writen emails and called the Mercedez hotline on June 1st 2022 and they assured me over the phone that the dealership will be able to help. When i called the dealerships in St Louis, namely Plaza motors and St Louis Mercedez they declined to inspect the vehicle and advised that i can keep driving untill they inspect the vehicle. The recall from mercedez clearly states that the vehicle should not be driven. When i told them about it they changed the story and told me they dont know when they can do the inspection. Upon calling Mercedes back, they told me that they are sorry about the misinformation ad that I can rent a vehicle for reembursement but when asked about the process of getting the money back, they could not provide an answer. We did not feel comfortable renting a vehicle before knowing the process in detail so we called Mercedes back and the next person told me that the rentals will not be reimbursed. We are really in a tough situation as the car is not safe to drive per the recall and neither Mercedes or the local dealers are willing to help even after a month of the recall notice. We are hoping that either they can inspect the vehicle, give us a loaner vehicle or reimburse us for a rental vehicle. We have a small family with a 3 year old and want to make sure that we are all safe. Thank you

NHTSA complaint #11468905 — an unverified report by a vehicle owner.

SERVICE BRAKES

Since my significant others and I purchased this 2006 Mercedes Benz SUV - ML-350, over three months ago, we were wondering why the "Engine check light was always on" so we purchased (4) sensors and replaced the sensors of where OBD tests pointed out for the engine, deleted the Engine Check Light several times but it will go back on after we driven it for another 50 to 100 miles away to normal highways and freeways driving to relearn the computer system and the Check Engine Light On again and again but not blinking? We called our friendly mechanics and he said it maybe faults recalled that part of the electronics or maybe the computer is giving that "engine check" light on because it has some safety components is malfunctioning, the braking is also hard and sometimes it is too soft when I push it with my right foot to stop the car and also the car is using too much gas. So, we kept postponement of bringing this car to the dealership for repairs because we cannot afford the repairs. Then today, I check to my email and I see the Recall email from NHTSA about MB - ML-350 / recall number 2022050015 / NHTSA # 22V315, since we cannot smog check it because of the "Engine Check On" it is always on we were puzzled why this light and this car cost too much to use and sometimes hard and sometimes soft to push on it's braking power? Please let us know on what to do next? Shall we call the MB-Dealerships to tow this car to their shop because we have stop using this car about over (3) months ago since we bought it ? Braking System is sometimes is too hard and sometimes too soft and using too much gas and the "Engine Check is always On " even we have replaced the (4) electronic sensors that the OBD machine pointed out but is still doing the same thing. Please advise us of what to do to resolve these operational safety of our 2006 - ML-350 Mercedes Benz, it is stored in our car garage. The rear reverse camera also stops working and it is saying braking lights are not functioning?

NHTSA complaint #11467959 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

TL* THE CONTACT OWNS A 2006 MERCEDES-BENZ ML350. THE CONTACT STATED WHILE DRIVING 5 MPH, THE BRAKE PEDAL WAS DEPRESSED AND WENT TO THE FLOORBOARD EXTENDING THE STOPPING DISTANCE. THE CONTACT ATTEMPTED TO USE THE PARKING BRAKE TO STOP THE VEHICLE HOWEVER, THE PARKING BRAKE FAILED TO SLOW THE VEHICLE IN A TIMELY MANNER. THE CONTACT STATED THAT THE THREE UNKNOWN WARNING LIGHTS WERE ILLUMINATED. THE CONTACT WAS ABLE TO SAFELY DRIVE THE VEHICLE TO THE RESIDENCE. THE VEHICLE WAS TOWED TO MERCEDES-BENZ OF BEDFORD LOCATED AT 18122 ROCKSIDE ROAD, BEDFORD, OH 44146, (440) 359-6826, TO BE DIAGNOSED AND REPAIRED. THE DIAGNOSTIC TEST AND REPAIR WAS STILL PENDING. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000. THE VIN WAS NOT AVAILABLE. *BF

NHTSA complaint #11341130 — an unverified report by a vehicle owner.

SERVICE BRAKES

RUSTED STEEL BREAK LINES THAT TAKES BREAK FLUID TO REAR FROM THE ENGINE COMPANTMENT

NHTSA complaint #10955437 — an unverified report by a vehicle owner.

SERVICE BRAKES

RUSTED AND LEAKING BREAK LINES ABOVE GAS TANK OF THE DRIVERS SIDE. RUSTED ALL THE ENGINE AREA. IT HAS HOLES JUST RIGHT ABOVE THE GAS TANK.

NHTSA complaint #10955439 — an unverified report by a vehicle owner.

SERVICE BRAKES

MY ML350 HAS HAD A PROBLEM WITH THE PRIMARY BRAKE LIGHTS BURNING OUT. AUTOMATICALLY THE VEHICLE IS SWITCHING TO THE SUBSTITUTE BRAKE LIGHTS. THIS IS THE SECOND SET OF BRAKE LIGHTS ON THE VEHICLE IN LESS THAN 1-MONTH. I JUST REPLACED THEM 2-DAYS AGO WITH A NEW SET OF SYLVANIA BULBS PURCHASED FROM ADVANCED AUTO AS PER THE VEHICLE MAKE, MODEL AND YEAR. I AM CONCERNED THAT THE PROBLEM COULD ORIGINATE FROM A POSSIBLE SHORT IN THE ELECTRICAL SYSTEM AND/OR POOR GROUNDING.

NHTSA complaint #10574292 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL- THE CONTACT OWNS A 2006 MERCEDES BENZ ML350. THE CONTACT STATED THAT THE PARKING BRAKE HANDLE BECAME DETACHED FROM THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. KMJ

NHTSA complaint #10504661 — an unverified report by a vehicle owner.

PARKING BRAKE

TL- THE CONTACT OWNS A 2006 MERCEDES BENZ ML350. THE CONTACT STATED THAT THE PARKING BRAKE HANDLE BECAME DETACHED FROM THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. KMJ

NHTSA complaint #10504661 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

ON N.Y. STATE THRUWAY,ON CRUISE CONTROL,BRAKES SUDDENLY APPLIED THEMSELVES. ABS AND SLS FLASHED ON DASH.CAR SUDDENLY DECELERATED. TURNED OFF CRUISE CONTROL AND PULLED OFF. ATTEMPT TO START AGAIN AND BRAKES APPLIED THEMSELVES. AFTER SEVERAL TRIES ,@20 MIN. WAS ABLE TO GET CAR MOVING. BROUGHT CAR TO DEALER WHO SAID SOME KIND OF BRAKE SENSOR WAS DEFECTIVE. CHARGED FOR REPLACEMENT.

NHTSA complaint #10324673 — an unverified report by a vehicle owner.

SERVICE BRAKES, ELECTRIC

MY ABS SYSTEM IS BROKE IN MY ML 350 MERCEDES BENZ 2006, IT ONLY 3 YEARS OLD I PURCHASE IT IN 5/2006. ITS NOT UNDER WARRANTY BECAUSE IT HAS 64,000 MILES, THIS IS STILL A SAFETY ISSUE AND THE ABS SYSTEM I WAS TOLD BY A MERCEDES SERVICE MANAGER THIS RARELY GOES OUT ON A CAR, BUT WHY NO ONE WANTS TO FIX IT. IT COSTS 3300 DOLLARS TO FIX.

NHTSA complaint #10312649 — an unverified report by a vehicle owner.

PARKING BRAKE

: IMPROPERLY ENGINEERED EMERGENCY BRAKE HANDLE THAT: WHEN A 1-2 MM PLASTIC PIECE ON THE HANDLE HOUSING THE CABLE SHEARS, WILL THEN ALLOW THE BRAKE CABLE TO DISCONNECT INSIDE OF THE DASH BOARD AND LEAVE THE OWNER STRANDED. IF WE HAD BEEN MORE ISOLATED THIS COULD BE A LIFE THREATENING PROBLEM.

NHTSA complaint #10282455 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST

BRAKE SYSTEM ON 2006 ML350 HAS EXCESSIVE PEDAL TRAVEL CAUSING UNSAFE BRAKING AND JERKY STOPPING. MANUFACTURER AND DEALER STATE THAT THIS CONDITION IS "NORMAL" FOR THE ML SERIES MERCEDES TRUCK. THIS TRAVEL CAUSES DELAYED BRAKING AND DOES NOT EXIST ON ANOTHER MERCEDES AUTOMOBILES. MANUFACTURER TO FURTHER EVALUATE THE CONDITION OR ADMIT ANY POTENTIAL SAFETY PROBLEM.

NHTSA complaint #10158192 — an unverified report by a vehicle owner.