84 of the
754 complaints filed about the Mercury Tracer
are about the fuel system —
11% of everything owners reported.
The worst model year for it is 1995.
AFTER 27 YEARS THE RUBBER FUEL FILLER PIPE ON THE CAR CRACKED AND BEGAN LEAKING FUEL. THE FUEL FILLER PIPE WAS REPLACED WITH A NEW FUEL FILLER PIPE FROM FORD MOTORCRAFT, PART #KFL-22, FOCZ-9324-AA. THE NEW FUEL FILLER PIPE LASTED ONLY 6 MONTHS BEFORE CRACKING AND SPILLING GAS ON MY DRIVEWAY CREATING A HAZARDOUS SITUATION. THE CAR WAS REPAIRED WITH A NEW THIRD PARTY [NOT FORD] FUEL FILLER PIPE. I'M BRINGING THIS TO YOUR ATTENTION BECAUSE NUMEROUS AUTO REPAIR WEB SITES HAVE HUNDREDS OF COMPLAINTS REGARDING DEFECTIVE REPLACEMENT FORD FUEL FILLER PIPES [ALL FORD MODELS]. FUEL FILLER PIPES SHOULD LAST MORE THEN 6 MONTHS. FORD'S REPLACEMENT FUEL FILLER PIPES ARE DEFECTIVE AND SHOULD BE RECALLED FOR REPLACEMENT BY FORD TO PREVENT A VERY HAZARDOUS SITUATION SHOULD A VEHICLE BE PARKED IN A GARAGE, I.E., NEAR A WATER HEATER OR OTHER IGNITION SOURCE, CREATING A LIFE-THREATENING SITUATION. THE LEAK FROM THE FUEL FILLER PIPE OCCURS WHETHER OR NOT THE VEHICLE IS PARKED OR MOVING WHEN THE FUEL TANK IS MORE THEN 3/4'S FULL. THE PIPE DETERIORATES FROM THE OUTSIDE WITH CRACKS RUNNING THE LENGTH OF THE PIPE. THE NYLON WEBBING ON THE INSIDE OF THE PIPE DOES NOT PREVENT IT FROM LEAKING. THE ATTACHED PHOTO SHOWS THE DEFECTIVE PIPE, BUT THE HUNDREDS OF HAIRLINE CRACKS IN THE PIPE CANNOT BE SEEN IN THE PHOTO BECAUSE OF PHOTO RESOLUTION. THE PIPE HAS ONLY BEEN IN USE ON THE CAR FOR JUST SIX MONTHS. I USE 91 OCTANE GASOLINE IN THE CAR.
NHTSA complaint #11330208 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 1991 MERCURY TRACER. AFTER THE VEHICLE WAS FILLED WITH FUEL AND PARKED IN THE GARAGE, THE CONTACT SMELLED A FUEL ODOR AND NOTICED FUEL LEAKING ONTO THE GARAGE FLOOR. ALL AMERICAN FORD (3306 BRIDGE AVE, POINT PLEASANT, NJ 08742, (732) 451-3582) WAS CONTACTED AND STATED THAT THE VEHICLE WAS TOO OLD AND THEY DID NOT HAVE PARTS. THE VEHICLE WAS THEN TAKEN TO ALL AMERICAN MAZDA (575 BURNT TAVERN RD, BRICK TOWNSHIP, NJ 08724, (732) 451-6848) WHERE A DIAGNOSTIC AND REPAIR APPOINTMENT WAS SCHEDULED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.
NHTSA complaint #11222731 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 1995 MERCURY TRACER. WHILE DRIVING 30 MPH, THE CONTACT SMELLED FUEL INSIDE THE VEHICLE. ONCE THE VEHICLE WAS PARKED, THE CONTACT NOTICED A LEAK ON THE GROUND AND THE FUEL GAUGE DECREASED FROM A FULL TANK TO HALF OF A TANK. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 97V144000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.
NHTSA complaint #10610276 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 1995 MERCURY TRACER. WHILE PARKED, THE CONTACT NOTICED AN OVERPOWERING FUEL SMELL. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED A FUEL LEAK. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED THAT THE FUEL TANK WAS FRACTURED AND WOULD HAVE TO BE REPLACED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 97V144000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 109,600.
NHTSA complaint #10469963 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 1995 MERCURY TRACER. THE CONTACT STATED THAT WHEN THE VEHICLE WAS IN OPERATION OR STATIONARY, A STRONG ODOR OF GASOLINE FUEL EMITTED INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS DIAGNOSED BY A CERTIFIED MECHANIC WHO ADVISED THAT THE FUEL TANK WAS FRACTURED AS A RESULT TO A FAULTY HEAT SHIELD BRACKET. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 97V144000 (FUEL SYSTEM, GASOLINE, STORAGE; TANK ASSEMBLY) BUT THE VEHICLE WAS INELIGIBLE FOR REPAIRS DUE TO THE VEHICLE NOT BEING ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES MENTIONED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND VIN WERE UNAVAILABLE.
NHTSA complaint #10398756 — an unverified report by a vehicle owner.
TL*THE CONTACT OWNS A 1995 MERCURY TRACER. THE CONTACT STATED THAT SINCE THE YEAR 2000, SHE SMELLED A STRONG ODOR OF GASOLINE EMANATING FROM THE VEHICLE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A VEHICLE FIRE. SHE NOTIFIED THE MANUFACTURER IN REFERENCE TO RECALL 97V145000, FUEL SYSTEM, GASOLINE STORAGE TANK ASSEMBLY. SHE WAS ADVISED THAT SINCE HER VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM THE RECALL, SHE WAS INELIGIBLE FOR A FREE REMEDY. NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 76,000 AND THE CURRENT MILEAGE WAS 88,000.
NHTSA complaint #10285644 — an unverified report by a vehicle owner.
95 TRACER WAGON 9/3/97 THERE WAS A RECALL WITH THE SAME ISSUE I AM NOW HAVING. WE NEVER REC'D ANY NOTIFICATION THERE WAS ANY RECALL. THE FUEL TANK IS LEAKING NEAR THE HEAT SHIELD. A CALL WAS MADE TO STIVERS LAST NIGHT AND WE WERE TOLD NOTHING COULD BE DONE DUE TO THE LENGTH OF YEARS THAT HAD PASSED.BUT WAS TOLD TO CALL FORD MOTOR. A CALL WAS MADE THIS MORNING. WAS TOLD BY FORD MOTOR AT 800-392-3673 THAT MY CAR WAS MADE 1/95 AND THE 64000 THAT WAS RECALLED WERE BETWEEN 4/29/95 AND 10/95. THE CAR HAD BEEN IN FOR PREVIOUS SERVICING AND EVEN THEN NOTHING WAS SAID TO US ABOUT A RECALL. OUR PROBLEM IS EXACTLY THE SAME AS WHAT THE RECALL WAS FOR. AT THE TIME OF THE RECALL MY CAR WAS ONLY 2 YEARS OLD. WE FEEL THAT HEY SHOULD TAKE CARE OF A REPLACEMENT.
NHTSA complaint #10284453 — an unverified report by a vehicle owner.
TL*THE CONTACT OWNS A 1995 MERCURY TRACER. THE CONTACT STATED THAT GASOLINE WAS LEAKING FROM THE VEHICLE. UPON FURTHER INSPECTION, HE FOUND A FRACTURE IN THE FUEL TANK. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBERS 97V145000 AND 97V144000, ALTHOUGH THE FAILURES WERE IDENTICAL. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 116,000.
NHTSA complaint #10274991 — an unverified report by a vehicle owner.
FUEL TANK LEAK (STRONG ODOR - NO VISIBLE LEAKAGE) ODOR DETECTABLE IN GARAGE AND OUTSIDE FORD SAYS THERE IS NO RECALL REQUIRED AND WILL NOT CORRECT THE LEAK.
NHTSA complaint #10267937 — an unverified report by a vehicle owner.
TL*THE CONTACT OWNS A 1995 MERCURY TRACER. THE CONTACT STATED THAT HIS GAS TANK WAS LEAKING FUEL. HE PARKED HIS VEHICLE AND A PUDDLE OF GAS LEAKED OUT. CRACKS CAN DEVELOP IN THE FUEL TANK NEAR THE HEAT SHIELD ATTACHMENT, RESULTING IN FUEL LEAKAGE IF THE CRACKS GO THROUGH THE FUEL TANK WALL. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 97V144000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THE FAILURE MILEAGE WAS 142,000.
NHTSA complaint #10246402 — an unverified report by a vehicle owner.
THE PLASTIC FUEL TANK HAS CRACKED AS DESCRIBED IN THE CAMPAIGN ID 97V144000. PUTTING IN ANYMORE THAN 3 GALLONS OF GAS IN THE TANK CAUSES IT TO LEAK AND HAS PROGRESSIVELY GOTTEN WORSE. UNFORTUNATELY, THE FORD DEALERSHIP STATES THAT THEY ARE UNABLE TO REPAIR THIS UNDER THE RECALL. THE VEHICLE IS CURRENTLY NOT USABLE DUE TO THE LEAKING FUEL AND AT AN ESTIMATED $800 TO REPAIR THIS MANUFACTURERS DEFECT, I AM OUT A VEHICLE FOR AN UNDETERMINED AMOUNT OF TIME. I FEEL THAT IT WAS UNFAIR FOR THIS RECALL NOT TO INCLUDE ALL VEHICLES OF THE SAME GAS TANK DESIGN, WHICH HAS CAUSED THIS FAILURE, TO BE INCLUDED IN THE RECALL.
NHTSA complaint #10238046 — an unverified report by a vehicle owner.
TL*THE CONTACT OWNS A 1995 MERCURY TRACER. WHILE DRIVING 30 MPH, THE CONTACT SMELLED GASOLINE. HE STATED THAT NHTSA CAMPAIGN ID NUMBERS 97V144000 AND 97V145000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY) MENTIONED THE SAME FAILURES. THE VEHICLE HAS NOT BEEN DIAGNOSED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 143,300 AND FAILURE MILEAGE WAS 143,296. UPDATED 09/24/08. *LJ UPDATED 09/30/08.
NHTSA complaint #10237015 — an unverified report by a vehicle owner.
TL*THE CONTACT OWNS A 1997 MERCURY TRACER. THE CONTACT STATED WHILE DRIVING 45 MPH, SHE LOST CONTROL OF THE VEHICLE AND DROVE INTO THE MEDIAN TO AVOID ONCOMING TRAFFIC. THE ENGINE SHUT OFF AND THE CYLINDER HEAD WAS BLOWN. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE; HOWEVER, THEY STATED THAT THE ENGINE NEEDED TO BE REBUILT. . THE CONTACT STATED THAT THE CYLINDER HEAD IN THE ENGINE FAILED AND CAUSED HER TO LOSE CONTROL OF THE VEHICLE. THE VEHICLE HAS NOT BEEN REPAIRED. THE DEALER AND THE WARRANTY COMPANY STATED THAT THEY WERE UNABLE TO HONOR THE WARRANTY TO REPAIR THE VEHICLE. THE WARRANTY INFORMATION IS AVAILABLE IF NEEDED. THE FAILURE ALSO CAUSED DAMAGE TO THE FRONT DRIVER AND PASSENGER SIDE TIRES. THERE WERE NO INJURIES. ON OCTOBER 8, 2007, THE CONTACT DROVE TO THE DEALER BECAUSE THE VEHICLE WAS LEAKING COOLANT. AFTER THREE HOURS OF INSPECTING THE VEHICLE, THE CAUSE OF THE FAILURE WAS STILL UNDETERMINED. THE DEALER ADVISED HER TO BRING THE VEHICLE BACK IN A FEW DAYS. A COUPLE OF DAYS LATER, WHILE DRIVING 45 MPH, THE VEHICLE BEGAN LOSING SPEED AND THE ENGINE FAILED. THE VEHICLE WAS TOWED BACK TO THE DEALER AND THEY STATED THAT THE ENGINE FAILED. THE VEHICLE HAS AN EXTENDED WARRANTY THROUGH ANOTHER COMPANY. THE VEHICLE WAS INSPECTED BY THE WARRANTY COMPANY, BUT THEY REFUSED TO PAY FOR THE REPAIR WORK. THE DEALER REFUSED TO PERFORM THE REPAIR. THE CONTACT BELIEVED THAT THIS WAS BECAUSE SHE REPORTED THE DEALER TO THE BETTER BUSINESS BUREAU. THE CURRENT AND FAILURE MILEAGES WERE 91,698. THE FUEL GAUGE WAS INOPERATIVE. THE AC DID NOT BLOW OUT COLD AIR, THE FRONT BRAKES WERE REPLACED. UPDATED 12/12/07
NHTSA complaint #10208138 — an unverified report by a vehicle owner.
I HAVE A 97 VILLAGER AND A 94 TRACER SW. I WAS REVIEWING MY RECEIPTS FOR A RECALL FOR THE FILLER PIPE VENT HOSE ON MY VILLAGER FROM 6/2001. IT WAS FIXED THEN. IT SEEMS SAME PART IS NOW LEAKING IN OUR TRACER. IT IS DANGEROUS WHEN DOING A FILL UP FOR IT LEAKS. UPDATED 01-16-08. *KB UPDATED
NHTSA complaint #10201084 — an unverified report by a vehicle owner.
TL*THE CONTACT OWNS A 1995 MERCURY TRACER. WHILE DRIVING 65 MPH, THE CONTACT DETECTED A GAS ODOR INSIDE AND OUTSIDE THE VEHICLE. THE MECHANIC STATED THAT THERE WAS A CRACK IN THE FUEL TANK. ACCORDING TO THE MANUFACTURER, RECALL # 97V145000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY) DOES NOT APPLY TO HIS VIN. THE CONTACT FELT THAT HIS VEHICLE SHOULD BE INCLUDED IN THE RECALL. THE CURRENT AND FAILURE MILEAGES WERE 50,471.
NHTSA complaint #10194854 — an unverified report by a vehicle owner.
I SMELLED GASOLINE IN MY GARAGE ON TUESDAY JUNE 11. LAYING BETWEEN THE CARS I FOUND SEVERAL STEADY DRIPS FROM THE FUEL TANK. I PUSHED THE CAR OUT OF THE GARAGE AND TWO DAYS LATER IT HAD LEAKED TO A LEVEL FOR THE LEAK TO STOP. I CONTACTED FORD/MERC. MOTOR CO. ABOUT THE EXISTING RECALL , NOTES:MERCURY TRACER 97S79,FOR THE POTENTIAL UNITS AFFECTED 64000 VEHICLES. EVEN THOUGH I HAD A SERIOUS POTENTIAL FOR A HOUSE FIRE I WAS TOLD THAT MY VIN DID NOT QUALIFY FOR THE RECALL. I WAS FURTHER TOLD TO GET IT FIXED BY A FOR DEALER AND THEY MAY REVIEW THE DATA IN THE FUTURE. I AM LOOKING FOR IMMEDIATE RELIEF FOR THIS PROBLEM. CAN YOU HELP?
NHTSA complaint #10162426 — an unverified report by a vehicle owner.
(1) SHOULDER BELT WOULD NOT MOVE TO DRIVING POSITION, COOLANT FAN WOULD NOT RUN WHEN NEEDED WITH ENGINE RUNNING ONLY WHEN THE IGNITION WAS TURNED OFF, OIL LIGHT STAYED ON AND ALTERNATELY FLASHED WITH THE RIGHT TURN SIGNAL INDICATOR. (2) A SHORTING CONNECTOR TO THE FUEL PUMP BURNED THE WIRE BUNDLE TO THE FUEL PUMP IN THE TANK. IT ALSO BURNED WIRES BEHIND THE FUSE BLOCK AND UNDER THE DASH!!! (3) THE CONNECTOR, HARNESS UPDATE, FUEL PUMP/PUMP ASSEMBLY, LOCK RING, WERE REPLACED, BURNED WIRES WERE REPLACED BEHIND THE FUSE BLOCK. THE CAR CANNOT BE DRIVEN BECAUSE THERE ARE MORE BURNED WIRES TO REPAIR UNDER THE DASH. UPDATED01/09/06.
NHTSA complaint #10133689 — an unverified report by a vehicle owner.
(1) SHOULDER BELT WOULD NOT MOVE TO DRIVING POSITION, COOLANT FAN WOULD NOT RUN WHEN NEEDED WITH ENGINE RUNNING ONLY WHEN THE IGNITION WAS TURNED OFF, OIL LIGHT STAYED ON AND ALTERNATELY FLASHED WITH THE RIGHT TURN SIGNAL INDICATOR. (2) A SHORTING CONNECTOR TO THE FUEL PUMP BURNED THE WIRE BUNDLE TO THE FUEL PUMP IN THE TANK. IT ALSO BURNED WIRES BEHIND THE FUSE BLOCK AND UNDER THE DASH!!! (3) THE CONNECTOR, HARNESS UPDATE, FUEL PUMP/PUMP ASSEMBLY, LOCK RING, WERE REPLACED, BURNED WIRES WERE REPLACED BEHIND THE FUSE BLOCK. THE CAR CANNOT BE DRIVEN BECAUSE THERE ARE MORE BURNED WIRES TO REPAIR UNDER THE DASH. UPDATED01/09/06.
NHTSA complaint #10133689 — an unverified report by a vehicle owner.
THE PLASTIC GAS TANK ON OUR 1995 MERCURY TRACER CRACKED OPEN. THE SHOP THAT WE TOOK IT TO KNEW OF A RECALL BECAUSE HE OWNED ONE PREVIOUSLY THAT WAS RECALLED FOR THIS SPECIFIC PROBLEM. OURS IS NOT UNDER THE RECALL, BUT THE CRACK IS IDENTICAL TO WHAT IS IN RECALLS 97V145000 AND 97V144000. THE HEAT SHIELD THAT IS MOUNTED DIRECTLY TO THE GAS TANK, CRACKED THE TANK AND CAUSED WHAT COULD HAVE BEEN A POTENTIAL FIRE IF WE HAD NOT NOTICED THAT THERE WAS GAS LEAKING ONTO THE ROADWAY. THE REPAIRS HAVE BEEN MADE, BUT WE FEEL THAT THIS VEHICLE SHOULD HAVE BEEN INCLUDED UNDER THE RECALL. IT IS A 1.9L ENGINE AND WAS BUILT IN MEXICO.
NHTSA complaint #10133036 — an unverified report by a vehicle owner.