42 of the
1,641 complaints filed about the Pontiac Sunfire
are about the body and structure —
3% of everything owners reported.
The worst model year for it is 1996.
WHILE DRIVING MY 2004 PONTIAC SUNFIRE, I HAD TO HOLD THE STEERING WHEEL TO THE LEFT IN ORDER FOR IT TO GO STRAIGHT. I THOUGHT I MIGHT NEED A FRONT END ALIGNMENT AND DROPPED THE CAR OFF AT MY NEIGHBORHOOD FIRESTONE DEALER THAT NORMALLY WORKS ON MY CARS. AFTER CHECKING THE CAR, THEY CALLED ME AND SAID THE FRAME OF THE CAR WAS RUSTED OUT AND IT WAS UNSAFE TO DRIVE. WHEN I PICKED UP THE CAR, THEY GAVE ME PICTURES OF THE FRONT PASSENGER SIDE OF THE FRAME WHICH ALL READY HAD CRACKED APART DUE TO THE RUST. THEY SAID IF YOU HIT A POTHOLE OR ANYTHING IN THE ROAD THE FRAME COULD SPLIT APART AND CAUSE AN ACCIDENT. I CALLED A BODY SHOP TO SEE IF IT COULD BE REPAIRED AND THEY SAID IT WAS TO BIG OF A JOB.. THEY RECOMMENDED JUNKING THE CAR.. THIS CAR IS IN REAL GOOD SHAPE EXCEPT FOR THIS MAJOR DEFECT. THIS HAS FORCED ME TO BUY ANOTHER CAR.. I'M VERY DISAPPOINTED IN THE QUALITY OF YOUR PRODUCT. I FEEL THERE SHOULD BE A RECALL FOR THIS PROBLEM.
NHTSA complaint #11349088 — an unverified report by a vehicle owner.
MY DAUGHTER LEFT HOME AND THE VEHICLE FRAME, OF THE 2004 PONTIAC SUNFIRE,BROKE IN TWO PARTS WHILE SHE WAS DRIVING THE VEHICLE. THE TOW TRUCK DRIVER SAID IT BROKE DUE TO IT RUSTED INTO TWO PARTS. SHE WAS NOT INJURED BUT THE CAR OF COURSE WAS INOPERABLE. THERE WAS NO WRECK OR ACCIDENT FOR THE FRAME OF THIS VEHICLE TO DISINTEGRATE. SHE COULD HAVE BEEN SERIOUSLY INJURED IF SHE WAS TRAVELING AT MORE THAN 35 MPH AND ON AN OPEN HIGHWAY. I CONTACTED GENERAL MOTORS AND THEY GAVE THIS A GM CASE NUMBER AND SUGGESTED I CONTACT YOU CONCERNING THIS PROBLEM TO MAKE OTHER VEHICLE OWNERS AWARE OF IT. THE SHOP THAT IS REPAIRING THE VEHICLE STATED HE HAD A HARD TIME FINDING A FRAME DUE TO THE FACT THIS IS VERY COMMON IN PONTIAC SUNFIRE VEHICLES. THIS IS A VERY SERIOUS SAFETY ISSUE.
NHTSA complaint #10716042 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2002 PONTIAC SUNFIRE. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DETECTED THAT THE ENTIRE FRAME WAS COMPLETELY CORRODED AND THAT THE DAMAGE WAS BEYOND REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 64,690. THE VIN WAS UNAVAILABLE.
NHTSA complaint #10438043 — an unverified report by a vehicle owner.
NUMEROUS FAILURES WITH MY CAR I AM ONLY LISTING THE ONES WHICH HAVE HAPPENED MORE THAN ONCE 1..TRANSMISSION FAILURE, TRANSMISSION FAILED 3 TIMES FIRST TIME WHILE TRAVELING 35MPH CAR CAME TO A DEAD STOP TIRES LOCKED UP, CAR WOULD NOT EVEN ROLL, CAUSING NEAR ACCIDENT. 2...WINDOW MOTORS FAILED TWICE ON EACH EACH DOOR OF MY 4 DOOR CAR 3...HEADLIGHT SWITCH HAS FAILED 3 TIMES CAUSING DANGEROUS SITUATION AT NIGHT 4...SEVERE WATER LEAK IN TRUNK AREA , WATER GETTING IN THROUGH FENDER WELL OR TRUNK UNDERBODY, CAUSED SO MUCH TO PUDDLE UP A MUSHROOM STARTED GROWING FROM BACK SEAT,... WATER PUDDLED UNDERNEATH CARPET IN SPARE TIRE AREA SO IT WAS NOT VISIBLE TO NAKED EYE, BUT WAS SLOSHING BACK AND FORTH WITH EVERY STOP AND GO OF VEHICLE STILL TO THIS DAY HAVE NOT BEEN ABLE TO PINPOINT EXACT LOCATION WATER IS GETTING IN ALTHOUGH IT FOR SURE IS FROM UNDERBODY 5... OTHER DEFECTS INCLUDE RADIO DISPLAY LIGHTS FAIL ON 2 RADIOS, SEATBELTS AND STEERING WHEEL BECOME TOO HOT IN SUMMER BRAKE PADS WEAR UNEVENLY,,,, FUEL PUMPS GO OUT OFTEN.
NHTSA complaint #10405944 — an unverified report by a vehicle owner.
THE 2003 PONTIAC SUNFIRE IS AN INFERIOR CAR. MINE CURRENTLY HAS APPROX 57,000 MILES ON THE ODOMETER. THE DAY AFTER I PURCHASED IT BRAND NEW, IT WOULD NOT START. THE DEALER CAME OUT AND REPLACED THE BATTERY. THE CAR HAD WHITE PAINT OVERSPRAY ON IT. THE DEALER REPAINTED IT. THE SUNROOF MALFUNCTIONED AND THE DEALER FIXED IT. THE TURN SIGNALS KEPT GOING OUT & IT WAS FIXED DUE TO THE RECALL. THE DASH HAD TO BE TAKEN OUT DUE TO THE FACT THAT THE AIR WAS NOT COMING OUT OF THE VENTS PROPERLY. THE POWER WINDOW DRIVER'S SIDE FAILED COMPLETELY AROUND 38,000 MILES & PASSENGER INTERMITTENTLY WOULD NOT WORK. THIS WAS FIXED AT MY EXPENSE. THE CAR HAS BEEN IN THE SHOP FOR BRAKE PROBLEMS NUMEROUS TIMES. I HAD THE DEALER CHECK THEM SEVERAL TIMES WHILE STILL UNDER WARRANTY AND THEY FINALLY REPLACED THEM AT THEIR COST BECAUSE THEY SAID IT SHOULD NOT BE NECESSARY GIVEN THE MILEAGE ON THE CAR. I'VE HAD BRAKES REPLACED TWO OTHER TIMES AT MY EXPENSE AND THEY ARE STILL SQUEAKING AND CREAKING VERY LOUDLY AND I'M TOLD THE BRAKE PADS ARE "CRACKED" BUT THAT IT WON'T HURT ANYTHING. NOW, THE NEW PROBLEM IS, THE RADIO QUIT PLAYING FOR 15 MINUTES AFTER THE CAR IS TURNED OFF AND YOU'RE IN IT. WHEN I COME TO A COMPLETE STOP, MY DOME LIGHT AND MAP LIGHTS COME ON AND STAY ON UNTIL I LET OFF THE BRAKE AND ACCELERATE. ALSO, THE HORN NO LONGER HONKS WHEN I LOCK THE CAR WITH THE REMOTE. I'VE HAD IT UP TO HERE WITH THIS CAR BUT CANNOT AFFORD TO GET RID OF IT SINCE I JUST PAID IT OFF IN JULY 2008. I WILL NEVER BUY ANOTHER PONTIAC!
NHTSA complaint #10241013 — an unverified report by a vehicle owner.
1998 SUNFIRE BEGAN TO MAKE CLUNKING NOISES ON FRONT RIGHT SIDE. UPON VISUAL INVESTIGATION, IT WAS FOUND THAT THE FRAME COMPONENT WAS COMPLETELY RUSTED THROUGH AND SEPARATED. THIS COULD BE A VERY DANGEROUS PROBLEM UNDER THE RIGHT CIRCUMSTANCE. I HAVE SENT DIGITAL FILES TO YOUR WEBMASTER EMAIL TO SHOW EXACTLY WHAT HAS HAPPENED AS I FEEL THAT THERE SHOULD BE A RECALL IMMEDIATELY , AS THIS IS A SERIOUS SAFETY MATTER.
NHTSA complaint #10223478 — an unverified report by a vehicle owner.
DT*: THE CONTACT STATED WHILE ATTEMPTING TO STOP AT 10 MPH, THE PASSENGER SIDE DOOR OPENED WITHOUT WARNING. THE CONTACT PULLED OVER AND CLOSED THE DOOR. THE VEHICLE WAS NOT SEEN BY A DEALERSHIP TO DETERMINE THE PROBLEM.
NHTSA complaint #10149972 — an unverified report by a vehicle owner.
WAS NOT NOTIFIED BY PONTIAC THAT MY SUNROOF SHOULD BE SERVICED YEARLY TO PREVENT LEAKS. I CONTACTED THE DEALER WHERE I PURCHASED THE CAR AND WAS TOLD GM HAS NO RECOMMENDED SERVICE YET EVERYWHERE I HAVE ASKED HAS TOLD ME IT NEEDS SERVICED OR YOU WILL HAVE LEAKS. DEALER SAID THERE IS NOTHING THEY CAN DO FOR ME. NOW I HAVE CLOGGED DRAIN LINES AND HAVE WATER LEAKING INTO MY TRUNK, AND THE WATER HAS DAMAGED MY BACK SPEAKERS. ALSO, I AM VERY UPSET WITH THE DESIGN OF THE SHIFTER LIGHT. I HAVE CALLED AROUND AND THE ONLY PLACE I CAN HAVE IT FIXED AT IS THE DEALER AND I AM LOOKING AT $130.00 JUST IN LABOR FOR A BAD LIGHT BULB. I THINK IT IS UNFAIR TO YOUR CUSTOMERS TO HAVE A PART, SUCH AS A LIGHT THAT WILL BURN OUT, UNREPLACEABLE BY ANYONE BUT THE DEALERS WHO THEN IN TURN CHARGE OUTRAGEOUS PRICES TO DO THE REPAIRS. SO NOW I HAVE WATER IN MY TRUNK NO BACK SPEAKERS AND CAN'T SEE WHAT GEAR I AM IN AT NIGHT ON A VEHICLE THAT IS ONLY 3 YEARS OLD WITH 42000 MILES ON IT. I ALSO HAVE BEEN TOLD THAT THE VEHICLE LOOKS WRECKED AND I AM HAVING TO REPLACE FRONT STRUTS AND MOUNTS AS WELL AS RACK AND PINION. I NEVER WRECKED THIS VEHICLE AND NO ONE ELSE DRIVES MY CAR!
NHTSA complaint #10148038 — an unverified report by a vehicle owner.
NUMEROUS OF FAILURES;AIR BAG LIGHT CAME ON AND STAYED ON, CLUTCH STICKS TO FLOOR, CAR DOESN'T WANT TO START. *BF THE TURN SIGNALS AND LIGHTS HAD GONE OUT, IT WOULD TAKE A COUPLE OF ATTEMPTS TO START THE VEHICLE, THERE WERE TIMES WHERE THE VEHICLE WOULD START ON IT'S OWN WITHOUT THE TURN OF THE KEY, THE VEHICLE USED AN EXTREME AMOUNT OF GAS, THE DASH WOULD RATTLE, THE ENGINE WOULD GROWL, THE DASH MADE A SOUND LIKE THE SPEAKER WAS BLOWN, THERE WAS A BURNING SMELL IN THE STEREO AND THERE WAS A THUMPING NOISE WHEN TURNING THE VEHICLE. (2003 PONTIAC SUNFIRE)
NHTSA complaint #10109784 — an unverified report by a vehicle owner.
UNSURE OF THE DAY IN APRIL OF 2002 THE CAR WAS PURCHASED. I DON'T KNOW THE EXACT DATE THE PROBLEMS BEGAN. THE PROBLEMS ARE WITH THE HEATING/AIR CONDITIONING SYSTEM, BRAKES, ALL SEAT BELTS, WINDOWS, ROOF LEAKS, ELECTRICAL SYSTEM AND RADIO. THE ELECTRICAL SYSTEM SHORTED OUT, HAD TO BE REPAIRED. PROBLEMS CONTINUED WITH THE HEATING/AIR SYSTEM SO I TOOK IT IN AGAIN. IT STILL WASN'T REPAIRED PROPERLY. ONE VENT OVER THE RADIO DOES NOT BLOW THE AIR OUT EFFECTIVELY LIKE THE VENT NEXT TO IT. WHEN THE HEATING/AIR CONDITIONING SYSTEM IS TURNED OFF THE AIR CONTINUES TO BLOW AIR OUT THE FLOOR VENTS THAT INCREASES WITH ACCELERATION.THE CAR DOESN'T COOL PROPERLY UNLESS THE RECIRCULATING AIR IS ON. THE WINDOW OF THE CD PLAYER/RADIO BECAME TOO HOT TO TOUCH.I WAS TOLD THIS WAS NORMAL AND NOTHING WAS WRONG WITH THE RADIO. SINCE THIS TIME,1/2 OF THE WINDOW DISPLAY IS FADED.THE ELECTRICAL WINDOWS DO NOT WORK PROPERLY. THE PASSENGER HAS PROBLEMS SIMILAR TO THE DRIVER WINDOW BUT IT DOESN'T OCCUR CONTINUOUSLY AS IN THE DRIVER'S WINDOW.IN ORDER TO ROLL THE WINDOW UP, THE OPERATOR HAS TO WAIT FOR AT LEAST 5 MINUTES, DEPRESS THE BUTTON,THE WINDOW WILL ROLL UP LESS THAN 1/2 AN INCH. THIS PROCESS CONTINUES UNTIL THE WINDOW IS UP. IT SEEMS AS THOUGH THE MOTOR IS OVERHEATING , HAS TO COOL DOWN IN ORDER TO OPERATE PROPERLY AGAIN. THE SEAT BELTS HAVE BEEN FIXED ONCE BUT NOW THE SHOULDER HARNESS ON ALL SEAT BELTS DO NOT LOCK INTO PLACE. THE BRAKES GRIND AND SQUEEK AT TIMES. THE ROOF LEAKS WHERE THE REAR WINDOW MEETS THE ROOF. WHEN GOING UP A HILL THE CAR HAS DIFFICULTY AT 20 - 30 MILES AN HOUR. THE DEALERSHIP STATED I SHOULD HAVE SPENT MORE MONEY FOR A CAR, AND NOT BOUGHT A CHEAP ONE. I HAVE BEEN TO TWO DEALERSHIPS WITHOUT ANY LUCK. I ALSO HAVE CONTACTED THE PONTIAC CUSTOMER ASSISTANCE SERVICE CENTER AND THEY REFUSE TO ASSIST ME IN LOCATING A DEALERSHIP WITH THE PROPER STAFFING, ALL THEY WILL PROVIDE IS A LIST OF DEALERSHIPS. I FEEL AS THOUGH THIS IS A SAFETY PROBLEM FOR INVESTIGATION.
NHTSA complaint #10073003 — an unverified report by a vehicle owner.
CONSUMER STATED WHILE DRIVING THE TRUNK POPPED OPEN. THE FIRST DAY THAT CONSUMER GOT THE VEHICLE HE COULD NOT OPEN THE TRUNK . THEN ,WHILE DRIVING TRUNK WOULD OPEN ON ITS OWN. THIS WAS DANGEROUS BECAUSE CONSUMER COULD NOT SEE FROM THE REAR.
NHTSA complaint #10071687 — an unverified report by a vehicle owner.
PAINT IS STARTING TO WEAR OFF ON THE TOP OF MY CAR BY THE MOON ROOF AND AROUND THE OUTSIDE EDGE OF THE DRIVERS SIDE DOOR; ALSO THE SPOILER IS BECOMING DISCOLORED AND THE SAME, THE PAINT IS WEARING OFF.
NHTSA complaint #10066244 — an unverified report by a vehicle owner.
SHE WAS INVOLVED IN A ACCIDENT WHERE THE LADY HIT HER ON THE DRIVERS SIDE OF THE CAR. I HAVE SEEN ON TV WHERE THIS CAR HAS A VERY BAD SIDE IMPACT RATING, AND ALSO ON THIS WEBSITE. THE WOMAN WHO HIT HER GOT TWO BROKEN LEGS, THE DRIVER OF THE PONTIAC SUNFIRE DIED. SHE SUFFERED A BROKEN BRAIN STEM, PELVIS, ARMS, AND FEMUR.
NHTSA complaint #10047290 — an unverified report by a vehicle owner.
SERVICE BRAKES WORE OUT PREMATURELY, AND DESTROYED THE ROTORS AND OTHER BRAKE COMPONENTS. *AK THE BRAKES SQUEALED AND MADE A GRIND NOISE, THE LEFT (DRIVER FRONT) HUB CAP RATTLED/SHAKED, WATER LEAKED IN THE BACK SEAT. THE SERVICE TECHNICIAN SAID THE METAL BRAKES DIDN'T HAVE PADS. THE FRONT END STEERING SHAKED, THE ROTOR(S) HAD WORN OUT, THE RIGHT INSIDE DOOR PANEL WAS LOOSE, THE SPEAKER HAD GONE OUT, THE POWER STEERING SQUEAKED PER INVOICE, THE AC CHIRPED, AND A WIND NOISE HAD COME FROM THE FRONT DOORS. *SCC
NHTSA complaint #10024762 — an unverified report by a vehicle owner.
EXHAUST SYSTEM WAS REPLACED DUE TO IT GETTING HOT MELTING THE CARPET AND PAINT INSIDE TRUNK, FUMES FILLED INTERIOR OF VEHICLE AT THIS TIME EXHAUST SYSTEM IS RUNNING JUST AS HOT AGAIN, DEALER STATED FACTORY REPRESENTATIVE INSTRUCTED HIM NOT TO DO ANYTHING ABOUT THE EXHAUST SYSTEM, THERE WAS NOTHING THAT COULD BE DONE.*AK CONSUMER STATES THE VEHICLE HAS BAD GAS MILEAGE, STARTER MOTOR SEIZED AND FAILED, POWER STEERING FLUID WAS LEAKING, COOLANT WAS LEAKING FROM LEFT FRONT AND BACK OF THE VEHICLE, REPLACED RADIATOR, HEATER BLOWS COLD AIR AT IDLE, TRUNK LEAKS, HEAD LAMP IS OUT OF ADJUSTMENT, GLOVE BOX WILL NOT CLOSE, MUFFLER FELL OFF, KEY COMES OUT OF IGNITION WITH VEHICLE RUNNING, TRANSMISSION HAS NO REVERSE, THERE WAS BRAKE PULSATION AT HIGH SPEED OR WHEN STOPPING, BRAKE PEDAL GOES TO FLOOR, SPEAKERS INOPERATIVE, SEAT SPRING FAILED, SUSPECTED MOTOR OIL SMELL AND REPLACED THERMOSTAT, HORN WAS INOPERATIVE, POWER AND GROUNDS DISTRIBUTION REPLACED, WINDOW WILL NOT GO DOWN ALL THE WAY, FOUND WINDOW REGULATOR FAILED, HAZARD LAMPS AND TURN SIGNAL WERE INOPERATIVE, REPLACED BLOWN FUSE, CIGARETTE LIGHTER INOPERATIVE, REPLACED BLOWN FUSE, TRACTION CONTROL INOPERATIVE, ENGINE LIGHT COMES ON, A/C HOSE LEAKING, REPLACED EVAPORATOR, HARD TO START AND ROUGH IDLE, ENGINE MAKE RATTLING NOISE AND QUIT RUNNING, REPLACED HEAD CYLINDER AND 02 SENSOR, VEHICLE PULLS TO THE LEFT, OVERFLOW BOTTLE MELTED AND 42 GOODYEAR TIRES BLEW OUT, ALSO THE HVAC WAS INOPERATIVE.
NHTSA complaint #8003978 — an unverified report by a vehicle owner.
EXHAUST SYSTEM WAS REPLACED DUE TO IT GETTING HOT MELTING THE CARPET AND PAINT INSIDE TRUNK, FUMES FILLED INTERIOR OF VEHICLE AT THIS TIME EXHAUST SYSTEM IS RUNNING JUST AS HOT AGAIN, DEALER STATED FACTORY REPRESENTATIVE INSTRUCTED HIM NOT TO DO ANYTHING ABOUT THE EXHAUST SYSTEM, THERE WAS NOTHING THAT COULD BE DONE.*AK CONSUMER STATES THE VEHICLE HAS BAD GAS MILEAGE, STARTER MOTOR SEIZED AND FAILED, POWER STEERING FLUID WAS LEAKING, COOLANT WAS LEAKING FROM LEFT FRONT AND BACK OF THE VEHICLE, REPLACED RADIATOR, HEATER BLOWS COLD AIR AT IDLE, TRUNK LEAKS, HEAD LAMP IS OUT OF ADJUSTMENT, GLOVE BOX WILL NOT CLOSE, MUFFLER FELL OFF, KEY COMES OUT OF IGNITION WITH VEHICLE RUNNING, TRANSMISSION HAS NO REVERSE, THERE WAS BRAKE PULSATION AT HIGH SPEED OR WHEN STOPPING, BRAKE PEDAL GOES TO FLOOR, SPEAKERS INOPERATIVE, SEAT SPRING FAILED, SUSPECTED MOTOR OIL SMELL AND REPLACED THERMOSTAT, HORN WAS INOPERATIVE, POWER AND GROUNDS DISTRIBUTION REPLACED, WINDOW WILL NOT GO DOWN ALL THE WAY, FOUND WINDOW REGULATOR FAILED, HAZARD LAMPS AND TURN SIGNAL WERE INOPERATIVE, REPLACED BLOWN FUSE, CIGARETTE LIGHTER INOPERATIVE, REPLACED BLOWN FUSE, TRACTION CONTROL INOPERATIVE, ENGINE LIGHT COMES ON, A/C HOSE LEAKING, REPLACED EVAPORATOR, HARD TO START AND ROUGH IDLE, ENGINE MAKE RATTLING NOISE AND QUIT RUNNING, REPLACED HEAD CYLINDER AND 02 SENSOR, VEHICLE PULLS TO THE LEFT, OVERFLOW BOTTLE MELTED AND 42 GOODYEAR TIRES BLEW OUT, ALSO THE HVAC WAS INOPERATIVE.
NHTSA complaint #8003978 — an unverified report by a vehicle owner.
ROTORS IN THE FRONT FREQUENTLY HAVE TO BE CHANGED DUE TO FRONT HUBS BEING TOO SMALL. ORIGINAL LUGS WERE DAMAGED BECAUSE ROTORS DIDN'T FIT RIGHT. VEHICLE WAS PULLING TO SIDE AND MAKING A POPPING NOISE. DEALER TEST DROVE VEHICLE ON A BUMPY ROAD, AND DIDN'T HEAR THE POPPING NOISE. DEALER STATED NOISE WAS COMING FROM CONVERTIBLE TOP.
NHTSA complaint #8001184 — an unverified report by a vehicle owner.