41 of the 148 complaints filed about the Saab 9-2X are about the fuel system — 28% of everything owners reported. The worst model year for it is 2005.
41
Complaints
28%
Share of all complaints
0
Crashes
0
Fires
FUEL/PROPULSION SYSTEM
FUEL SMELL IN COLD WEATHER. THIS SEEMS TO HAPPEN IN COLD WEATHER ONLY. WHEN I START THE CAR, I GET A SMELL OF FUEL IN THE CABIN. THE CAR IS PARKED. WHEN I HAVE THE AIR RECIRCULATION BUTTON PRESSED, THE SMELL DOES NOT ENTER THE CABIN.
NHTSA complaint #11171294 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
THE SMELL OF RAW FUEL IN THE CABIN ON COLD WEATHER STARTS. FURTHER INVESTIGATION REVEALED A FUEL LEAK UNDERNEATH THE INTAKE AND FUEL SPRAYING AND POOLING ON TOP OF THE ENGINE BLOCK. SO MUCH FUEL LEAKING THAT IT RAN DOWN AND MADE A PUDDLE UNDER THE CAR.
NHTSA complaint #11056615 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TAKATA RECALL FOR AIRBAG AND FUEL LEAK ON FUEL RAIL SAME AS SUBARU WRX
NHTSA complaint #10940288 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
AT BELOW FREEZING TEMPERATURES, THE FUEL LINE LEAKS RAW GASOLINE ONTO THE ENGINE, NEAR THE TURBOCHARGER, CREATING A FIRE RISK. THE EVAPORATED GASOLINE IS IMMEDIATELY PUMPED INTO THE PASSENGER CABIN CREATING A HEALTH RISK. THIS IS A KNOWN ISSUE FOR THE SUBARU WRX AND A RECALL WAS ISSUED. THE 2005 SAAB 9-2X IS MECHANICALLY IDENTICAL IN THIS REGARD TO THE WRX, BUT NO RECALL WAS ISSUED. DETAILS: HTTPS://FORUMS.NASIOC.COM/FORUMS/SHOWTHREAD.PHP?T=1893471 EXAMPLES: HTTP://WWW.CARCOMPLAINTS.COM/SAAB/9-2X/2005/FUEL_SYSTEM/FUEL_PROPULSION_SYSTEM.SHTML DISCUSSION: HTTP://SAAB92X.COM/VIEWTOPIC.PHP?ID=17792&P=1
NHTSA complaint #10940181 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHEN TEMPERATURE IS BELOW FREEZING, THERE IS A STRONG SMELL OF FUEL IN THE CABIN UNTIL THE ENGINE REACHES OPERATING TEMPERATURE. IT IS NOTED THAT THE FUEL LINES ARE LEAKING NEAR THE CLAMPS UNDER THE INTAKE MANIFOLD ON THE PASSENGER SIDE. APPROX. 1 DRIP EVERY 2 SECONDS UNTIL THE ENGINE IS WARM AND THE RUBBER SEALS AGAIN. IT APPEARS THIS IS A KNOWN ISSUE WITH MANY SUBARU MODELS, HOWEVER THERE HAS ONLY BEEN A PARTIAL TSB AND THE 2005MY HAS NOT BEEN INCLUDED AT THE TIME OF THIS POSTING. THE SMELL IS VERY STRONG WHEN STOPPED, AND GOES AWAY ONCE IN MOTION. ONCE THE CAR WARMS UP, THERE IS NO SIGN OF ANY SMELL. FUEL LEAK LOCATION IS ALSO VERY NEAR THE TURBOCHARGER, WHICH GETS TO VERY HIGH TEMPERATURE.
NHTSA complaint #10826070 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
BESIDE THE TAKATA RECALL, THE CAR IS LEAKING GAS WHEN THE TEMPERATURE DROPS BELOW 20 DEGREES. THE INTERIOR IS FILLED WITH THE SMELL OF FUEL WHEN IT IS COLD. OBVIOUSLY THE SAME PROBLEM IS HAPPENING TO MORE CARS AND ALL YOU HAVE TO DO IS A SEARCH ON GOOGLE FOR GAS SMELL WRX WHEN IT'S COLD. OR SIMILAR. APPARENTLY THE FUEL LINES SHRINK WHEN IT'S COLD AND THE CLAMPS DO NOT HOLD AND LEAK GAS ON A HOT ENGINE RIGHT BY THE MANIFOLD. IT MOST CERTAINLY CAN CAUSE A FIR AND SHOULD BE RECALLED. ESPECIALLY WHEN SO MANY PEOPLE HAVE HAD THE EXACT SAME PROBLEM.
NHTSA complaint #10821328 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
THIS VEHICLE, BEING MADE BY SAAB AND SUBARU OF AMERICA, IS EXIBITING THE SAME EXACT ISSUE AS DESCRIBED BY THE 2002-2003 SUBARU WRX FUEL LEAK RECALL INITIATED BY THE NHTSA IN 2003 (I BELIEVE). THIS ISSUE IS STARTING TO APPEAR, EVEN IN MILD CLIMATES LIKE MINE IN CALIFORNIA, ON VEHICLES WELL BEYOND THE 02-03MY. MY VEHICLE IS EQUIVALENT TO THE 2005 SUBARU WRX WAGON. IT USES THE SAME ENGINE/FUEL SYSTEM. IT DOESN'T GET VERY COLD HERE, BUT ON A 50 DEGREE F DAY THIS MORNING, I HAD A STRONG SMELL OF FUEL FOR THE SECOND TIME IN A ROW. I ANTICIPATE THIS WILL HAPPEN EVERY MORNING, FROM NOW ON. THIS IS AN OBVIOUS FIRE AND SAFETY HAZARD, PROVEN BY THE FACT THE NHTSA ALREADY HAD SOA ISSUE A RECALL PREVIOUSLY FOR THE SAME ISSUE. THE "FIX" IS NOT WORKING LONG TERM, SINCE MY VEHICLE FELL INTO MANUFACTURE YEARS AFTER THE FACT. MANUFACTURING CHANGES DID NOT REMEDY THE ISSUE, THE ISSUE REMAINS, EVEN UP TO THE 2005 MY. I URGE THE NHTSA TO SERIOUSLY INVESTIGATE THIS FUEL LEAKING ISSUE FOR ALL 2002-UP SUBARU BOXER ENGINES. IT'S STILL A MAJOR ISSUE. RAW FUEL EVAPORATING INTO THE ATMOSPHERE, AND NOXIOUS VAPORS ENTERING THE VEHICLE CABIN WHILE BEING DRIVEN, NOT A GOOD SITUATION.
NHTSA complaint #10788281 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
EVERY TIME VEHICLE IS STARTED IN BELOW FREEZING TEMPERATURES THERE IS STRONG CABIN SMELL RAW GASOLINE FUMES. IT ONLY GOES AWAY AFTER SEVERAL MINUTES OF DRIVING. POSSIBLE FIRE HAZARD. PLEASE HELP.
NHTSA complaint #10691737 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I NOTICE A STRONG SMELL OF GAS IF THE TEMPERATURE DROPS BELOW 20 DEGREES. THIS SEEMS TO BE A FIRE HAZARD AND ALSO A HEALTH HAZARD. THE SAME PROBLEM EXISTED ON THE SUBARU WRX WHICH IS THE SAME CAR AND IT WAS RECALLED. THE SAME NEEDS TO BE DONE FOR THE SAAB WHICH WAS BUILT BY SUBARU.
NHTSA complaint #10681054 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
EVERY TIME VEHICLE IS STARTED IN BELOW FREEZING TEMPERATURES GASOLINE SPRAYS OUT OF FUEL LINES UNDER INTAKE MANIFOLD AND LEAKS ALL OVER ENGINE, INTERIOR CABIN SMELLS OF STRONG GASOLINE FUMES DURING THIS TIME AND ALSO WHILE DRIVING, POSSIBLE FIRE CONDITION MAY OCCUR.
NHTSA complaint #10659242 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
IN COLD TEMPERATURES MY CAR BEGINS TO SMELL OF FUEL AND BASED ON A MECHANICS DIAGNOSIS, IT HAS TO DO WITH THE FUEL LINE CLAMPS NEEDING TO BE TIGHTENED. IT SEEMS LIKE MANY OF SAAB 9-2X AERO MODELS HAVE THIS ISSUE. THIS IS UNACCEPTABLE AND SHOULD BE RECALLED BY THE COMPANY. IF THIS MANY PEOPLE ARE HAVING ISSUES, THERE IS CLEARLY A PROBLEM.
NHTSA complaint #10658998 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
UPON COLD WEATHER STARTUPS (LESS THAN 20 DEGREES) STRONG SMELL OF RAW FUEL IN CABIN UNTIL CAR WARMS UP.
NHTSA complaint #10608910 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHEN THE TEMPERATURE IS BELOW FREEZING OR CLOSE TO 45 DEGREES F, THIS CAR WILL LEAK GASOLINE FROM THE FUEL LINES UNDER THE INTAKE IN THE ENGINE BAY. THIS FUEL POOLS ONTO THE HOT ENGINE BLOCK AND CAUSES A FIRE HAZARD. IT ALSO CREATES A SMELL OF GASOLINE INSIDE THE VEHICLE CABIN THAT IS SO STRONG THAT THE WINDOWS NEED TO BE LOWERED TO BREATHE PROPERLY AND FOR THE HEALTH OF THE PASSENGERS. THE MAKER OF THIS CAR, FUJI HEAVY INDUSTRIES (SUBARU) AND THE SELLER (GENERAL MOTORS), KNOWS ABOUT THIS PROBLEM AND HAVE DONE NOTHING TO PREVENT A FIRE THAT IS WAITING TO HAPPEN OR MAKE ANY SAFETY RECALLS FOR THIS CAR.
NHTSA complaint #10608477 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHEN THE OUTSIDE TEMPERATURE IS APPROXIMATELY 35 DEGREES F OR LESS, THERE IS A STRONG RAW FUEL SMELL IN THE VEHICLE FROM COLD STARTUP. THE PROBLEM DISSIPATES AFTER THE VEHICLE COMES UP TO OPERATING TEMPERATURE. MECHANIC DIAGNOSED IT AS A LEAKING FUEL LINE UNDER THE INTAKE MANIFOLD. THE COST OF THIS REPAIR IS APPROXIMATELY $700. THIS ISSUE APPEARS TO BE COMMON IN BOTH THE SAAB 9-2X AND ITS SUBARU EQUIVALENT, THE IMPREZA WRX. BOTH MODELS WERE BUILT BY SUBARU. THERE WAS A RECALL FOR THE 2002 AND 2003 SUBARU WRX, BUT NOTHING HAS BEEN ISSUED REGARDING THIS VEHICLE.
NHTSA complaint #10574714 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FOR THE WINTER A RAW FUEL SMELL FILLED THE ENGINE AND PASSENGER COMPARTMENT, ESPECIALLY IN COLD WEATHER ON A COLD STARTUP. MECHANIC DIAGNOSED IT AS A LEAKING FUEL LINE UNDER THE INTAKE MANIFOLD. THIS PROBLEM APPEARS TO BE QUITE COMMON AFFECTING BOTH SAAB 9-2X AND ITS SUBARU EQUIVALENT THE WRX (BOTH MODELS BUILT BY SUBARU). THERE WAS A RECALL ISSUED FOR 02-03 WRX'S, BUT IT APPEARS NOTHING HAS BEEN DONE TO FIX THIS HAZARDOUS ISSUES IN LATER MODELS.
NHTSA complaint #10573133 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHEN WEATHER REACHES BELOW 20F RAW FUEL SEEPS OUT OF A LINE RUNNING ON THE ENGINE. SMELL OF GAS IS APPARENT UNTIL CAR IS FULLY WARM.
NHTSA complaint #10565729 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
DURING COLD WEATHER THERE ARE FUMES COMING FROM THE RIGHT SIDE OF THE ENGINE, AND STRONG GASOLINE SMELL INSIDE THE CABIN, THE DRIVING IS ONLY POSSIBLE WITH WINDOWS ROLLED DOWN. THE DRIVING AT NIGHT IS NOT POSSIBLE WHEN THE WARM AIR IS TURN ON, MORE GASOLINE SMELL COMES INSIDE. I DON'T UNDERSTAND SINCE SUBARU HAD SIMILAR PROBLEM WITH IMPREZA WRX AND THERE WAS A RECALL, WHY THEY IGNORE THIS WITH SAAB 9-2X THAT HAS SUBARU ENGINE.
NHTSA complaint #10562784 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
THIS CAR WHILE BEING BADGED AS A SAAB IS EXACTLY THE SAME AS THE 05 SUBARU IMPREZA WRX. THE SAAB 92X LEAKS RAW FUEL. I'M NOT SURE WHERE IT'S COMING FROM. IN THE 02-03 IMPREZA HAD A RECALL FOR THIS SAME PROBLEM WHICH UNFORTUNATELY DOES NOT COVER 05. HOWEVER THE FUEL LEAK PROBLEM STILL EXISTS AND NEEDS TO BE ADDRESSED BY SUBARU OR GM ANY FUEL LEAK IS HAZARDOUS ESPECIALLY ONE LIKE THIS. THIS NEEDS TO BE A RECALL. IT'S NOT SAFE.
NHTSA complaint #10561289 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
DURING COLD WEATHER, FUEL LINES LEAK/SEEP RAW FUEL INTO ENGINE COMPARTMENT. IF LEFT UNTREATED, COULD POTENTIALLY CAUSE ENGINE FIRE, LEADING TO INJURY AND DEATH. PLEASE GET SUBARU/SAAB TO FIX ASAP.
NHTSA complaint #10561281 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
STRONG FUEL SMELL INSIDE OF CAR. INSPECTED UNDER HOOD AND DETERMINED THAT THE FUEL SMELL WAS EMANATING FROM THE RIGHT SIDE OF THE ENGINE.
NHTSA complaint #10560904 — an unverified report by a vehicle owner.