Suzuki Boulevard M109R transmission problems

POWER TRAIN

SEVERE CLUTCH SHUDDER IN FIRST GEAR AND DROPS OUT OF SECOND FROM TIME TO TIME. EXTREMELY DANGEROUS

NHTSA complaint #11180509 — an unverified report by a vehicle owner.

POWER TRAIN

MY SUZUKI M109R 2007. 9K MILES START HAVING 2ND GEAR PROBLEM. LOUND CLUNKY SOUND AND MISSED SHIFTING 2ND GEARS. I'M SCARED TO END UP I'M THE MIDDLE OF THE ROAD . I'M AT THE STOPLIGHT 1ST GEAR OK AND ONCE I HIT MY 2ND GEARS I SUDDENLY SLOW DOWN AND DOWN OR UP SHIFT TRYING TO FIGURE OUT HOW TO SPEED UP AGAIN WHILE CAR BEHIND ME HONKING AT ME LIKE CARZY

NHTSA complaint #11124075 — an unverified report by a vehicle owner.

POWER TRAIN

MY 2006 SUZUKI M109R HAD BEEN JUMPING OUT OF 2ND GEAR, INTO NEUTRAL WHEN I ACCELERATE, AND THE REAR WHEEL LOCKED UP AFTER THAT, WHICH PUT ME INTO A 150' SKID ON THE HIGHWAY, WHICH WAS VERY UNSAFE, AND I COULD HAVE EASILY DIED AS A RESULT OF THIS SERIOUS, RE-OCCURRING MECHANICAL FAILURE THAT SUZUKI DOES NOT WANT TO BE RESPONSIBLE FOR. SUZUKI NEEDS TO BE RESPONSIBLE FOR COVERING THESE COMMON, UNACCEPTABLE, HIGH-RISK SAFETY PROBLEMS, BEFORE OTHERS ARE INJURED, OR KILLED, AND THEN THEY GET SUED FOR IT. THIS IS A VERY DANGEROUS SITUATION, AND IT CANNOT BE TAKEN LIGHTLY, IF YOU ARE A SUZUKI M109R OWNER, WE NEED TO GET TOGETHER, AND HOLD SUZUKI ACCOUNTABLE FOR THIS FAULTY DESIGN. THE SUZUKI M109R HAS A LOT OF TORQUE, AND POWER, AND IT SHOULD HAVE BEEN EQUIPPED WITH A MORE ROBUST, HEAVY DUTY TRANSMISSION, THAT WOULD HAVE BEEN SAFE, BUT IT WAS NOT, AND SUZUKI NEEDS TO FIX THE PROBLEM RESPONSIBLY. ATTACHED PICTURE SHOWS 150' SKID MARK.

NHTSA complaint #11090478 — an unverified report by a vehicle owner.

POWER TRAIN

2ND GEAR TRANSMISSION ISSUE. AS I PULLED OFF FROM A GREEN LIGHT IN THE CITY I MOVED INTO 2ND GEAR AND THE BIKE LOST POWER LIKE IT WASN'T IN GEAR AND THEN IT LAUNCHED ITSELF AND I ALMOST HIT THE CAR IN FRONT OF ME. WHEN I WENT TO 3RD AND 4TH GEAR EVERYTHING WAS FINE UNTIL I HAD TO GO INTO 2ND GEAR IT WOULD POP OUT OF GEAR.

NHTSA complaint #11081073 — an unverified report by a vehicle owner.

POWER TRAIN

I HAVE A 2006 M109R THAT HAS A MAJOR DEFECT IN THE POWERTRAIN. THIS BIKE ONLY HAVE A LITTLE OVER 5,000 MILES ON IT AND IT TENDS TO FALL OUT OF SECOND GEAR BACK INTO NEUTRAL. THIS IS VERY UNSAFE AND COULD VERY WELL CAUSE YOU TO LOOSE CONTROL OF THE BIKE. THERE HAS BEEN A NUMBER OF PEOPLE THAT I HAVE COME ACROSS WITH THE SAME ISSUE. SUZUKI NEEDS TO ADDRESS A RECALL CONCERNING THIS ISSUE BEFORE SOMEONE GETS HURT OR KILLED. THIS WILL BE THE LAST OF ANY SUZUKI PRODUCT THAT I WILL EVER PURCHASE FOR NOW OR THE NEAR FUTURE BECAUSE THEY OR NOT STANDING BEHIND THERE BRAND EVEN IF IT IS A RISK TO MANY PEOPLE LIVES ACROSS THE COUNTRY.

NHTSA complaint #11078889 — an unverified report by a vehicle owner.

POWER TRAIN

EXPERIENCED " INTERMITTENT " CLUTCH ENGAGEMENT SHUDDER IN 1ST GEAR DURING ENGINE WARM UP AND AFTER ENGINE IS WARM. SHUDDER IS SUDDEN AND OCCURS DURING THE MIDPOINT RANGE OF CLUTCH RELEASE. SHUDDER IS SOMETIMES VIOLENT. ISSUE COULD RESULT IN TRAFFIC ACCIDENT IF ROAD CONDITIONS ARE SLICK. WET OR SANDY. THIS ISSUE IS DEFINITELY A SAFETY HAZARD THAT COULD RESULT IN SERIOUS INJURY OR DEATH.

NHTSA complaint #10947933 — an unverified report by a vehicle owner.

POWER TRAIN

I AM THE OWNER OF A 2006 SUZUKI BOULEVARD M109R AND I HAVE BEEN HAVING TROUBLE WITH MY TRANSMISSION FOR OVER A YEAR NOW, MY SECOND GEAR DOES NOT STAY ENGAGED , AS SOON AS I SHIFT INTO SECOND GEAR AND ACCELERATE IT GOES BACK INTO NEUTRAL, I ATTEMPT TO SHIFT INTO SECOND GEAR AGAIN AND THE SAME THING HAPPENS ALL OVER AGAIN, NO SECOND GEAR, APPARENTLY I AM NOT THE ONLY OWNER WHO'S HAVING THIS PROBLEM FROM WHAT I'VE READ ON THE INTERNET ON MANY DIFFERENT FORUMS AND LOCAL FRIENDS THAT HAVE THE YEAR, MAKE AND MODEL MOTORCYCLE AS MINE. IT IS VERY UNSAFE TO SHIFT FROM FIRST TO THIRD GEAR, NOT TO MENTION THE WEAR AND THE STRESS IT PUTS ON THE MOTORCYCLE AND POSSIBLY CAUSING MORE MECHANICAL ISSUES.

NHTSA complaint #10924423 — an unverified report by a vehicle owner.

POWER TRAIN

MOTORCYCLE LOST 2ND GEAR. WAS ON THE FREEWAY AND ALMOST GOT RAN OVER DUE TO THE ISSUE. AFTER DOING FURTHER RESEARCH I FOUND THAT MANY OTHER OWNERS OF THE SAME BIKE ARE HAVING THE SAME ISSUES. AFTER TALKING TO SUZUKI CORPORATE THEY STATED THAT THEY HAVE HAD MANY CALLS ON THE ISSUE AND THAT THEY UPDATED THE PART NUMBER. WHEN I GOOGLE SEARCHED THE ISSUE THERE ARE HUNDREDS OF OTHER OWNERS HAVING THE SAME PROBLEM. TO FIX THE ISSUE IS COSTING THE OWNER 2000 TO 3000 TO REPAIR. THIS IS HAPPENING ANYWHERE FROM 8000 MILES AND UP. THERE EVEN APPEARS TO BE COURT CASES WHERE SUZUKI SETTLED.

NHTSA complaint #10919865 — an unverified report by a vehicle owner.

POWER TRAIN

WHEN SHIFTING INTO 2ND GEAR, THE BIKE FEELS AS IF IT IS IN 2ND. UPON ACCELERATION FOR ABOUT 3 SECONDS, THE BIKE IMMEDIATELY DUMPS INTO NEUTRAL! IN ORDER TO RIDE, I HAVE TO LIFT THE GEAR SHIFTER WITH MY FOOT AND HOLD IT IN 2ND GEAR TO ENSURE I CAN GET ENOUGH SPEED TO SHIFT TO 3RD. SOMETIMES, I HAVE TO DOUBLE SHIFT INTO 3RD BECAUSE ONCE I REMOVE MY FOOT, THE BIKE SOMETIMES DUMPS ITSELF ONTO NEUTRAL AGAIN. AS LONG AS I BARELY (I MEAN BARELY) APPLY ANY ACCELERATION IN 2ND GEAR, THE BIKE WILL STAY IN GEAR A BIT LONGER - BUT IT WILL STILL DUMP ITSELF INTO NEUTRAL IF I DON'T SHIFT TO 3RD BEFORE IT HAPPENS! I'VE ALMOST BEEN REAR ENDED SO MANY TIMES, IT'S NOT EVEN FUNNY. TURNING A CORNER IN 2ND GEAR IS ALMOST IMPOSSIBLE, AS THE BIKE WILL LOSE POWER IN A TURN AND I HAVE TO HURRY AND DOUBLE CLICK INTO 3RD AND JUST RIDE AT A LOWER RPM UNTIL THE BIKE PICKS UP SPEED. FOR ABOUT A YEAR, I'VE BEEN HOLDING IT INTO 2ND WITH MY TOE LIFTING THE SHIFT LEVER (MORE THAN NOT) TO ENSURE I CAN MAKE ENOUGH SPEED TO EASE INTO A DECENT 3RD GEAR. I FEEL THE MORE I DO IT, THE MORE I'M ALLOWING DAMAGE TO OCCUR TO PARTS THAT I NEED TO HAVE FIXED BEFORE THIS BEAUTIFUL MACHINE BECOMES LAWN FURNITURE.

NHTSA complaint #10919739 — an unverified report by a vehicle owner.

POWER TRAIN

SHIFTS VERY HARD WHEN UP-SHIFTING LOUD CLASH SOUND WHILE IN MOTION DOES THIS ALL THE TIME EVERY SHIFT. I DONT WANT TO BE REARENDED WHILE ATTEMPTING TO SHIFT

NHTSA complaint #10894482 — an unverified report by a vehicle owner.

POWER TRAIN

I BOUGHT MY MOTORCYCLE A SUZUKI BOULEVARD M10R LIMITED 2011LIMITED NEW ON MARCH 2012. THE MOTORCYCLE HAS ALWAYS SHIFTED HARD FROM FIRST TO SECOND GEAR. ON APRIL 18, 2015 I WAS RIDING FOR ABOUT A HOUR EVERYTHING WAS FINE UNTIL I MERGED TO A MAIN HIGHWAY AND I NOTICED THE LOSS OF POWER AT 55 MPH . WAS STUCK IN THE A CENTER LINE WHERE CARS ARE GOING UP 70 MILES. I WAS ATTEMPTING TO PASS A CAR BUT THE BIKE WAS LOOSING POWER RAPIDLY IT WAS NOT GOING FASTER THAN 40 MPH. I TRIED SHIFTING UP AND STARTING HAVING PROBLEMS SHIFTING . I WAS LUCKY TO BE ABLE TO PULL TO THE SIDE OF THE ROAD . THE MOTORCYCLE ENGINE CUTOFF AS SOON I BRAKED. I TOOK THE BIKE TO THE SHOP AND THEY SAID THE CLUTCH AND THE CLUTCH BASKET WERE GONE DUE TO LOOSENING BOLTS. SEARCHING THE INTERNET FOR THE CAUSE AND I DISCOVERED SIMILAR COMPLAINTS. WHEN SUZUKI WILL FIX THE PROBLEM? THIS REPAIR WILL COST ME AROUND $1500.00.

NHTSA complaint #10714402 — an unverified report by a vehicle owner.

POWER TRAIN

WHEN RIDING ON THIS MOTORCYCLE IT WILL JUMP OUT OF 2 GEAR IT CAN MAKE YOU GO DOWN.

NHTSA complaint #10676564 — an unverified report by a vehicle owner.

POWER TRAIN

I STARTED TO EXPERIENCE WHAT THE OTHER OWNERS OF THE SUZUKI BOULEVARD M109R'S ARE CALLING CLUTCH SHUDDER. THE SYMPTOM IS WHEN ONE IS STOPPED AND BEGINNING TO ACCELERATE. THE CLUTCH DOES NOT ENGAGE RIGHT AWAY. FEELS LIKE IT IS STUCK SO IT BARELY GETS A GOLD OF THE PLATES CAUSING ONE OF TWO THINGS TO HAPPEN. 1. YOU RELEASE THE CLUTCH TOO MUCH AND IT LOOSENS TOO QUICKLY CAUSING THE BIKE TO SHUT OFF WHILE STOPPED. 2. THE CLUTCH BARELY ENGAGES CAUSING A VIOLENT VIBRATION SIMILAR TO WHAT A STANDARD CAR COULD DO IF THE CLUTCH ISN'T ENGAGED OR DISENGAGED CORRECTLY. AFTER THE VIOLENT "CLUTCH SHUDDER" THE BIKE MAY TURN OFF IN TRAFFIC OR GET ENOUGH SPEED TO ENGAGE INTO 2ND GEAR. AT THIS POINT EVERYTHING WORKS WELL. SUZUKI WILL ONLY FIX THIS IF THE MOTORCYCLE IS UNDER WARRANTY. HOWEVER, THE PART IS NOT THE SAME ANYMORE. IT HAS GONE FROM A FLAT WASHER TO A WAVY WASHER. THEY MUST HAVE CHANGED THE PART BECAUSE THEY KNOW PEOPLE ARE HAVING ISSUES BUT THERE IS NO RECALL.

NHTSA complaint #10672020 — an unverified report by a vehicle owner.

POWER TRAIN

MY 2007 SUZUKI BOULEVARD M109R IS A DEATH TRAP! IT WILL FALL OUT OF SECOND GEAR AT ACCELERATION. MY GIRLFRIEND AND I WERE RIDING AND I WAS ENTERING THE FREEWAY ,MY M109R FELL OUT OF SECOND GEAR INTO NEUTRAL,THAT WAS A VERY SCARY SITUATION. I HAD TO IMMEDIATELY DOUBLE CLUTCH AND JUMP IT INTO THIRD GEAR WITH A FULL THROTTLE IN ORDER NOT TO BE REAR ENDED BY ON COMING TRAFFIC. SUZUKI SHOULD STEP UP TO THE PLATE AND FIX WHAT THEY KNOW IS A MANUFACTURE DEFECT BEFORE SOMETHING TRAGIC HAPPENS. I PAID GOOD MONEY FOR MY MOTORCYCLE SUZUKI NEEDS TO STAND BEHIND THE PRODUCTS THEY SELL AND MAKE SURE THEY ARE 100%SAFE BEFORE SELLING THEM TO THE PUBLIC. THEY SHOULD ALSO DO WHAT'S RIGHT AND FIX THE DEFECT SO WE CAN ENJOY THE BIKE THE WAY WE SHOULD BE ABLE TO, WITH PEACE OF MIND.

NHTSA complaint #10643210 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2007 SUZUKI M109 BOULEVARD. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE FAILED TO SHIFT DOWN TO SECOND GEAR. THE CONTACT MENTIONED THAT THE FAILURE WAS EXPERIENCED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE SHIFTING FORK WAS WORN OUT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 98,020.

NHTSA complaint #10586622 — an unverified report by a vehicle owner.

POWER TRAIN

THIS BIKE HAS A PROBLEM SHIFTING INTO 2ND GEAR. WHEN STARTING FROM A COMPLETE STOP, THE BIKE CONSTANTLY REFUSES TO GO INTO 2ND GEAR. THIS IS DANGEROUS WHEN THERE IS TRAFFIC BEHIND YOU AND THEY EXPECT YOU TO CONTINUE TO MOVE FORWARD. HAVING TO FISH FOR 2ND PUTS US RIDERS IN JEOPARDY. DEALERS ONLY STATE THAT IS IS A CHARACTERISTIC OF THE BIKE. THIS CHARACTERISTIC PRESENTS A CLEAR AND PRESENT DANGER FOR THE RIDERS OF THIS BIKE AND THE MANUFACTURER SHOULD BE REQUIRED TO CORRECT IT.

NHTSA complaint #10578768 — an unverified report by a vehicle owner.

POWER TRAIN

I'M THE OWNER OF A 2006 SUZUKI M109R I WAS RIDING AT 35 MILES AN HOUR AND MY BIKE POP OUT OF SECOND GEAR INTO NEUTRAL SCARING THE HELL OUT OF ME LUCKILY I KEEP MY COOL AND NEW HOW TO HANDLE THE CYCLE THE BIKE HAS A SERIOUS PROBLEM WITH SECOND GEAR SOMETHING HAS TO BE DONE OR SOMEONE IS GOING TO SERIOUSLY GET HURT OR EVEN KILLED.

NHTSA complaint #10576925 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2006 SUZUKI BOULEVARD M109R MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE MOTORCYCLE WOULD LUNGE FORWARD WHENEVER HE SHIFTED INTO SECOND GEAR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE CLUTCH WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT SHORTLY AFTER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 6,000 AND THE CURRENT MILEAGE WAS 10,000.

NHTSA complaint #10573843 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2008 SUZUKI BOULEVARD M109R MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE SHIFTED OUT OF GEAR AND INTO NEUTRAL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REBUILT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 32,000 AND THE CURRENT MILEAGE WAS 33,000.

NHTSA complaint #10573194 — an unverified report by a vehicle owner.

POWER TRAIN

THE BIKE WOULD JUMP HORRIBLY WHEN IN SECOND GEAR. AFTER ABOUT A HUNDRED MILES RIDING LIKE THIS, NOW THE BIKE WILL JUMP INTO NEUTRAL WHILE I'M RIDING IN SECOND GEAR; VERY DANGEROUS. THIS PROBLEM HAS BEEN REPORTED BY HUNDREDS, IF NOT THOUSANDS, OF SUZUKI M109R RIDERS. SUZUKI SHOULD PAY FOR THIS NOW!

NHTSA complaint #10564358 — an unverified report by a vehicle owner.