FaultScore
See all results →
All makes Worst years, ranked Problems by part Analysis Problems by model year Recalls in Canada Recall lookup Compare two cars How we grade

Volkswagen FOX recalls

NHTSA has issued 2 recalls covering the Volkswagen FOX. A recall repair is always free, however old the car is.

Check your own car by VIN

Recalls apply to specific build ranges, so a recall listed here may or may not cover your particular vehicle. NHTSA's free VIN lookup is the authority: nhtsa.gov/recalls.

1993 Volkswagen FOX Campaign 95V105000 23 May 1995

ENGINE AND ENGINE COOLING:COOLING SYSTEM

IN THE EVENT OF A COOLING SYSTEM COMPONENT FAILURE WHILE THE VEHICLE IS DRIVEN, THE COOLANT CAN OVERHEAT CAUSING THE COOLING SYSTEM PRESSURE TO RISE TO A LEVEL WHERE A LEAK IN THE HEAT EXCHANGER CAN OCCUR.

Risk: A LEAK OR FAILURE OF THE HEAT EXCHANGER LOCATED UNDER THE DASHBOARD CAN ALLOW HOT COOLANT TO ESCAPE AND CAUSE INJURY TO THE FEET OF A PASSENGER. HOT COOLANT CAN ALSO STEAM UP THE INTERIOR OF THE VEHICLE TEMPORARILY IMPAIRING THE DRIVER'S VISIBILITY, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL INSTALL A BYPASS VALVE KIT WHICH IS DESIGNED TO ROUTE EXCESSIVELY HOT COOLANT TO THE ENGINE WITHOUT FLOWING THROUGH THE HEAT EXCHANGER. DEALERS WILL ALSO INSTALL A PLASTIC COVER UNDERNEATH THE DASHBOARD ON THE PASSENGER SIDE TO ENSURE THAT THE PASSENGER IS NOT EXPOSED TO HOT COOLANT IN THE EVENT OF A LEAK.

1993 Volkswagen FOX Campaign 92V058000 14 Apr 1992

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

THE FUEL HOSE ATTACHED TO THE FUEL DISTRIBUTION RAIL ON THE ENGINE MAY SHRINK BEYOND THE CLAMP FORCE OF THE FUEL HOSE CLAMPS, ALLOWING FUEL TO LEAK.

Risk: FUEL LEAKAGE IN THE ENGINE COMPARTMENT CAN CAUSE AN UNDERHOOD FIRE IF THE FUEL COMES IN CONTACT WITH A SOURCE OF IGNITION.

Remedy: REPLACE THE FUEL HOSE ATTACHED TO THE FUEL RAIL AND INSTALL A NEW SPRING TYPE SELF-TIGHTENING CLAMP.

Volkswagen FOX recalls in Canada

Transport Canada runs its own recall programme. Its campaigns do not always mirror the American ones, so a Canadian owner reading a US-only list is reading about a different car than the one on their driveway.

1992 Volkswagen FOX Recall 1995094 13 Jun 1995 36,785 units in Canada

Heater And Defroster

DEFECT: IF THE VEHICLE IS OPERATED AFTER A COOLING SYSTEM COMPONENT HAS FAILED, THE COOLANT COULD OVERHEAT CAUSING THE COOLING SYSTEM'S PRESSURE TO RISE TO A LEVEL WHERE A LEAK IN THE HEAT EXCHANGER COULD OCCUR. THIS COULD ALLOW HOT COOLANT TO ESCAPE AND CAUSE INJURY TO THE FEET OF A PASSENGER OR STEAM UP THE INTERIOR OF THE VEHICLE. CORRECTION: A BYPASS VALVE KIT AND A PLASTIC COVER UNDERNEATH THE DASHBOARD ON THE PASSENGER SIDE WILL BE INSTALLED.

1991 Volkswagen FOX Recall 1995094 13 Jun 1995 36,785 units in Canada

Heater And Defroster

DEFECT: IF THE VEHICLE IS OPERATED AFTER A COOLING SYSTEM COMPONENT HAS FAILED, THE COOLANT COULD OVERHEAT CAUSING THE COOLING SYSTEM'S PRESSURE TO RISE TO A LEVEL WHERE A LEAK IN THE HEAT EXCHANGER COULD OCCUR. THIS COULD ALLOW HOT COOLANT TO ESCAPE AND CAUSE INJURY TO THE FEET OF A PASSENGER OR STEAM UP THE INTERIOR OF THE VEHICLE. CORRECTION: A BYPASS VALVE KIT AND A PLASTIC COVER UNDERNEATH THE DASHBOARD ON THE PASSENGER SIDE WILL BE INSTALLED.

1988 Volkswagen FOX Recall 1995094 13 Jun 1995 36,785 units in Canada

Heater And Defroster

DEFECT: IF THE VEHICLE IS OPERATED AFTER A COOLING SYSTEM COMPONENT HAS FAILED, THE COOLANT COULD OVERHEAT CAUSING THE COOLING SYSTEM'S PRESSURE TO RISE TO A LEVEL WHERE A LEAK IN THE HEAT EXCHANGER COULD OCCUR. THIS COULD ALLOW HOT COOLANT TO ESCAPE AND CAUSE INJURY TO THE FEET OF A PASSENGER OR STEAM UP THE INTERIOR OF THE VEHICLE. CORRECTION: A BYPASS VALVE KIT AND A PLASTIC COVER UNDERNEATH THE DASHBOARD ON THE PASSENGER SIDE WILL BE INSTALLED.

1990 Volkswagen FOX Recall 1995094 13 Jun 1995 36,785 units in Canada

Heater And Defroster

DEFECT: IF THE VEHICLE IS OPERATED AFTER A COOLING SYSTEM COMPONENT HAS FAILED, THE COOLANT COULD OVERHEAT CAUSING THE COOLING SYSTEM'S PRESSURE TO RISE TO A LEVEL WHERE A LEAK IN THE HEAT EXCHANGER COULD OCCUR. THIS COULD ALLOW HOT COOLANT TO ESCAPE AND CAUSE INJURY TO THE FEET OF A PASSENGER OR STEAM UP THE INTERIOR OF THE VEHICLE. CORRECTION: A BYPASS VALVE KIT AND A PLASTIC COVER UNDERNEATH THE DASHBOARD ON THE PASSENGER SIDE WILL BE INSTALLED.

1987 Volkswagen FOX Recall 1995094 13 Jun 1995 36,785 units in Canada

Heater And Defroster

DEFECT: IF THE VEHICLE IS OPERATED AFTER A COOLING SYSTEM COMPONENT HAS FAILED, THE COOLANT COULD OVERHEAT CAUSING THE COOLING SYSTEM'S PRESSURE TO RISE TO A LEVEL WHERE A LEAK IN THE HEAT EXCHANGER COULD OCCUR. THIS COULD ALLOW HOT COOLANT TO ESCAPE AND CAUSE INJURY TO THE FEET OF A PASSENGER OR STEAM UP THE INTERIOR OF THE VEHICLE. CORRECTION: A BYPASS VALVE KIT AND A PLASTIC COVER UNDERNEATH THE DASHBOARD ON THE PASSENGER SIDE WILL BE INSTALLED.

1989 Volkswagen FOX Recall 1995094 13 Jun 1995 36,785 units in Canada

Heater And Defroster

DEFECT: IF THE VEHICLE IS OPERATED AFTER A COOLING SYSTEM COMPONENT HAS FAILED, THE COOLANT COULD OVERHEAT CAUSING THE COOLING SYSTEM'S PRESSURE TO RISE TO A LEVEL WHERE A LEAK IN THE HEAT EXCHANGER COULD OCCUR. THIS COULD ALLOW HOT COOLANT TO ESCAPE AND CAUSE INJURY TO THE FEET OF A PASSENGER OR STEAM UP THE INTERIOR OF THE VEHICLE. CORRECTION: A BYPASS VALVE KIT AND A PLASTIC COVER UNDERNEATH THE DASHBOARD ON THE PASSENGER SIDE WILL BE INSTALLED.

1991 Volkswagen FOX Recall 1991148 5 Nov 1991 35,720 units in Canada

Structure

THE SECONDARY HOOD LATCH MECHANISM MAY CORRODE AND SEIZE DUE TO IMPROPER LUBRICATION. IF THE SECONDARY HOOD LATCH WAS NOT PROPERLY ENGAGED AND THE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD FLY OPEN WHILE THE VEHICLE WAS IN MOTION RESULTING IN IMPAIRED DRIVER VISION AND A POSSIBLE CRASH. CORRECTION: OWNERS AND DEALERS WILL BE ADVISED BY MAIL OF CORRECT MAINTENANCE PROCEDURES FOR THE HOOD LATCH MECHANISM.

1988 Volkswagen FOX Recall 1991148 5 Nov 1991 35,720 units in Canada

Structure

THE SECONDARY HOOD LATCH MECHANISM MAY CORRODE AND SEIZE DUE TO IMPROPER LUBRICATION. IF THE SECONDARY HOOD LATCH WAS NOT PROPERLY ENGAGED AND THE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD FLY OPEN WHILE THE VEHICLE WAS IN MOTION RESULTING IN IMPAIRED DRIVER VISION AND A POSSIBLE CRASH. CORRECTION: OWNERS AND DEALERS WILL BE ADVISED BY MAIL OF CORRECT MAINTENANCE PROCEDURES FOR THE HOOD LATCH MECHANISM.

1990 Volkswagen FOX Recall 1991148 5 Nov 1991 35,720 units in Canada

Structure

THE SECONDARY HOOD LATCH MECHANISM MAY CORRODE AND SEIZE DUE TO IMPROPER LUBRICATION. IF THE SECONDARY HOOD LATCH WAS NOT PROPERLY ENGAGED AND THE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD FLY OPEN WHILE THE VEHICLE WAS IN MOTION RESULTING IN IMPAIRED DRIVER VISION AND A POSSIBLE CRASH. CORRECTION: OWNERS AND DEALERS WILL BE ADVISED BY MAIL OF CORRECT MAINTENANCE PROCEDURES FOR THE HOOD LATCH MECHANISM.

1987 Volkswagen FOX Recall 1991148 5 Nov 1991 35,720 units in Canada

Structure

THE SECONDARY HOOD LATCH MECHANISM MAY CORRODE AND SEIZE DUE TO IMPROPER LUBRICATION. IF THE SECONDARY HOOD LATCH WAS NOT PROPERLY ENGAGED AND THE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD FLY OPEN WHILE THE VEHICLE WAS IN MOTION RESULTING IN IMPAIRED DRIVER VISION AND A POSSIBLE CRASH. CORRECTION: OWNERS AND DEALERS WILL BE ADVISED BY MAIL OF CORRECT MAINTENANCE PROCEDURES FOR THE HOOD LATCH MECHANISM.

1989 Volkswagen FOX Recall 1991148 5 Nov 1991 35,720 units in Canada

Structure

THE SECONDARY HOOD LATCH MECHANISM MAY CORRODE AND SEIZE DUE TO IMPROPER LUBRICATION. IF THE SECONDARY HOOD LATCH WAS NOT PROPERLY ENGAGED AND THE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD FLY OPEN WHILE THE VEHICLE WAS IN MOTION RESULTING IN IMPAIRED DRIVER VISION AND A POSSIBLE CRASH. CORRECTION: OWNERS AND DEALERS WILL BE ADVISED BY MAIL OF CORRECT MAINTENANCE PROCEDURES FOR THE HOOD LATCH MECHANISM.

1988 Volkswagen FOX Recall 1988161 1 Dec 1988 29,784 units in Canada

Steering

THE STEERING WHEEL ON THESE VEHICLES MAY LOOSEN ON THE STEERING SHAFT. WHEN A STEERING WHEEL IS REMOVED AFTER ASSEMBLY AND REINSTALLED, GREASE OR OIL MAY HAVE BEEN INADVERTENTLY APPLIED TO THE CONE-SHAPED FRICTION SURFACE OF THE STEERING SHAFT. GREASE OF OIL ON THIS SURFACE MAY BREAK THE FRICTION LOCK IF AFTER REWORK THE TORQUE APPLIED TO THE NUT IS LOWER THAN SPECIFIED. A LOOSE STEERING WHEEL COULD RESULT IN LOSS OF VEHICLE CONTROL AND A POSSIBLE CRASH. CORRECTION: FRICTION SURFACES WILL BE CLEANED, A SPRING RETAINER WILL BE INSTALLED AND THE STEERING WHEEL NUT WILL BE REPLACED WITH A SELF LOCKING NUT. VIN RANGE: 9BW*A030*HP000001 TO KP009988

1987 Volkswagen FOX Recall 1988161 1 Dec 1988 29,784 units in Canada

Steering

THE STEERING WHEEL ON THESE VEHICLES MAY LOOSEN ON THE STEERING SHAFT. WHEN A STEERING WHEEL IS REMOVED AFTER ASSEMBLY AND REINSTALLED, GREASE OR OIL MAY HAVE BEEN INADVERTENTLY APPLIED TO THE CONE-SHAPED FRICTION SURFACE OF THE STEERING SHAFT. GREASE OF OIL ON THIS SURFACE MAY BREAK THE FRICTION LOCK IF AFTER REWORK THE TORQUE APPLIED TO THE NUT IS LOWER THAN SPECIFIED. A LOOSE STEERING WHEEL COULD RESULT IN LOSS OF VEHICLE CONTROL AND A POSSIBLE CRASH. CORRECTION: FRICTION SURFACES WILL BE CLEANED, A SPRING RETAINER WILL BE INSTALLED AND THE STEERING WHEEL NUT WILL BE REPLACED WITH A SELF LOCKING NUT. VIN RANGE: 9BW*A030*HP000001 TO KP009988

1989 Volkswagen FOX Recall 1988161 1 Dec 1988 29,784 units in Canada

Steering

THE STEERING WHEEL ON THESE VEHICLES MAY LOOSEN ON THE STEERING SHAFT. WHEN A STEERING WHEEL IS REMOVED AFTER ASSEMBLY AND REINSTALLED, GREASE OR OIL MAY HAVE BEEN INADVERTENTLY APPLIED TO THE CONE-SHAPED FRICTION SURFACE OF THE STEERING SHAFT. GREASE OF OIL ON THIS SURFACE MAY BREAK THE FRICTION LOCK IF AFTER REWORK THE TORQUE APPLIED TO THE NUT IS LOWER THAN SPECIFIED. A LOOSE STEERING WHEEL COULD RESULT IN LOSS OF VEHICLE CONTROL AND A POSSIBLE CRASH. CORRECTION: FRICTION SURFACES WILL BE CLEANED, A SPRING RETAINER WILL BE INSTALLED AND THE STEERING WHEEL NUT WILL BE REPLACED WITH A SELF LOCKING NUT. VIN RANGE: 9BW*A030*HP000001 TO KP009988

Source: Transport Canada Vehicle Recalls Database.