Owners have filed 216 complaints
about the 2018 Alfa Romeo Stelvio with NHTSA between 2018 and 2026.
The largest single group is the fuel & propulsion.
Across this model's run it ranks 1 of 5 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Alfa Romeo Stelvio. 50 means typical for this
model; 100 means roughly double.
Severity — 24
4.6% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 92
54% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2018 compares with every other Alfa Romeo Stelvio
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
67.1%
1,000 – 9,999 miles
1416.5%
10,000 – 24,999 miles
2124.7%
25,000 – 49,999 miles
1112.9%
50,000 – 74,999 miles
1517.6%
75,000 – 99,999 miles
1214.1%
100,000 – 149,999 miles
67.1%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
Configuration
Overall
Front
Side
Rollover
2018 Alfa Romeo Stelvio AWD
—
—
—
—
2018 Alfa Romeo Stelvio RWD
—
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 2018peak 10Aug 2026
Recalls on the 2018 Alfa Romeo Stelvio
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
25V586000
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Chrysler (FCA US, LLC) is recalling certain 2017-2019 Alfa Romeo Giulia and 2018-2019 Alfa Romeo Stelvio vehicles. The fuel pump may fail, which can result in a loss of fuel flow and loss of drive power.
Risk: A loss of drive power increases the risk of a crash.
24V510000
AIR BAGS:FRONTAL
Chrysler (FCA US, LLC) is recalling certain 2017-2024 Alfa Romeo Giulia, 2018-2025 Alfa Romeo Stelvio, 2019-2023 Fiat 500X, Jeep Renegade, and 2024 Fiat 500E vehicles. A seat belt buckle switch sensor may be improperly connected, preventing the front seat air bag from deploying as intended.
Risk: A front seat air bag that does not deploy as intended can increase the risk of injury in a crash.
23V382000
SERVICE BRAKES, HYDRAULIC
Chrysler (FCA US, LLC) is recalling certain 2017-2020 Alfa Romeo Giulia and 2018-2020 Alfa Romeo Stelvio vehicles equipped with carbon ceramic matrix brakes. During certain driving maneuvers, the brake system may exert an excessive clamp force that may fracture the rotor, decreasing the brake performance.
Risk: An unexpected decrease in brake performance increases the risk of a crash.
19V551000
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Alfa Romeo (FCA US LLC) is recalling certain 2018-2019 Giulia and Stelvio vehicles. The Body Control Module (BCM) may indicate an inaccurate fuel level that displays higher than the actual amount.
Risk: The vehicle may be operated without enough fuel in the tank causing a stall, increasing the risk of a crash.
19V148000
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
FCA US LLC (Alfa Romeo) is recalling certain 2018-2019 Alfa Romeo Stelvio and 2017-2019 Giulia vehicles. The Brake System Module (BSM) software may prevent the driver from disabling the Adaptive Cruise Control (ACC) after the traction control system detects a specific wheel slip.
Risk: The driver's inability to deactivate the ACC can increase the risk of crash.
18V635000
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
Chrysler (FCA US LLC) is recalling certain 2018-2019 Alfa Romeo Stelvio Quadrifoglio vehicles. The engine cooling hose may have inadequate webbing material allowing a coolant leak.
Risk: A loss of coolant can cause the engine to overheat and the vehicle to stall, increasing the risk of a crash.
18V636000
ELECTRICAL SYSTEM:WIRING
Chrysler (FCA US LLC) is recalling certain 2017-2018 Alfa Romeo Giulia and 2018 Alfa Romeo Stelvio vehicles, equipped with 2.0L engines. These engines may misfire causing the catalytic converter to overheat, possibly resulting in damage to the nearby wiring and engine components.
Risk: Heat damage to the engine compartment wiring or components can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.
18V205000
EQUIPMENT:ELECTRICAL
Chrysler (FCA US LLC) is recalling certain 2018 Alfa Romeo Stelvio vehicles. Water may leak into the body control module and its connectors, causing corrosion. This corrosion can cause illumination of one or more malfunction indicator lamps, a loss of windshield wiper function, a loss of exterior lighting, a loss of horn function and/or unintended turn signal activation.
Risk: Electrical malfunctions such as windshield wipers that may not work in the rain and lights that may not work at night increase the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20254633,289 units in Canada
Fuel System
Issue: On certain vehicles, the fuel delivery module could fail and cause a loss of engine power while driving. Note: This problem could cause the malfunction indicator light to turn on. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: FCA Canada will notify owners in writing and advise you to take your vehicle to a dealership to replace the fuel delivery module.
Recall 2024548314,717 units in Canada
Label
Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". Canadian regulations require the information to be listed on the label in both English and French. Safety Risk: This error does not affect vehicle safety. Corrective Actions: This is not a recall. The company has corrected the tire and loading information label for all new vehicles.
Recall 20243908,387 units in Canada
Seats And Restraints
Issue: On certain vehicles, the connector for the driver and/or passenger-front seat belt buckle sensor(s) could fail and cause the seat airbag(s) to deploy with too much force. Note: This problem would cause the airbag warning light to display on the instrument panel or the seat belt reminder chime and warning light to stay on, even if you're buckled. Safety Risk: An airbag that deploys with too much force could increase the risk of injury in a crash. Corrective Actions: FCA Canada will notify owners by mail and advise you to take your vehicle to a dealership to replace the connector for the driver and/or passenger-front seat belt buckle sensor(s).
Recall 2023312104 units in Canada
Brakes
Issue: In certain situations, the braking system could apply too much force to the brake rotors. If this happens, the brake rotors could crack and suddenly cause reduced braking. Note: This recall only affects vehicles equipped with carbon ceramic matrix brakes. Safety Risk: Reduced braking can cause an extended stopping distance and increase the risk of a crash. Corrective Actions: FCA Canada will notify owners by mail and advise you to take your vehicle to a dealership to update the brake system module (BSM) software.
Recall 2019366935 units in Canada
Fuel System
Issue: On certain vehicles, the fuel gauge may display the wrong fuel level (higher) when parked on a slope of at least 10 degrees. This could cause a driver to believe there is fuel when the tank is empty. In the worst case scenario, the vehicle could unexpectedly run out of fuel and stall. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct them to take their vehicle to a dealer to update the body control module software.
Recall 20191101,600 units in Canada
Powertrain
Issue: Under specific driving conditions, the driver may not be able to cancel the adaptive cruise control (ACC) setting. Safety Risk: If the driver does not shift to neutral or apply the brakes to stop the vehicle, this can cause a crash without warning. Corrective Actions: The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the brake system software. Drivers should not use the adaptive cruise control feature until this update is completed.
Recall 20185062,619 units in Canada
Engine
On certain vehicles equipped with a 2.0 L engine, the catalytic converter could overheat due to engine misfires. The high temperatures generated could damage the surrounding wiring or components, which could result in a loss of motive power and/or increase the risk of a fire causing injury and/or damage to property. Correction: Dealers will update the engine control module software to prevent the catalytic converter from overheating.
Recall 201850534 units in Canada
Engine
On certain vehicles, the coolant hose between the radiator and engine may leak. This could cause the engine to overheat, potentially resulting in a loss of motive power, and increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace the defective coolant hose.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 84,999 milesSouth Euclid, OHCrash2 injured
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while at a stop light, the contact pressed the accelerator pedal and the steering wheel erroneously turn to the right and the vehicle experienced unintended acceleration causing the driver to loose control of the steering and crash into a highway post. During the crash the driver sustained a concussion do to the air bag deployment and the front passenger sustained a fractured right arm. Both occupants of the vehicle were transported and treated at the hospital. The vehicle was destroyed and towed away. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The manufacturer was notified failure. The local dealer was not contacted. The failure mileage was 85,000.
NHTSA complaint #11741462 — an unverified report by a vehicle owner.
Sewickley, PAFire
ELECTRICAL SYSTEM
I own a 2018 Alfa Romeo Stelvio (VIN: [XXX] ) with approximately 102,000 miles. The vehicle recently experienced an electrical issue caused by a failed ground strap — a known problem in these vehicles that is widely reported by other owners. After the vehicle became inoperable, I observed smoke and visible signs of burned or heat-damaged wiring in multiple areas under the hood, including ground wires not located near the main strap and crumbling insulation on the ABS wiring in the front wheel wells. The vehicle was towed to an authorized Alfa Romeo dealership, where the ground strap was replaced. However, the dealer did not inspect or document the other visibly damaged wiring, despite my specific request and description of the safety issue. They claimed the vehicle showed no error codes and was safe to drive. My concern is that the failed ground strap caused additional electrical damage to safety-critical components like the ABS system, which may result in electrical fire, loss of braking, or other failures. Alfa Romeo appears to have updated the design of the replacement ground strap (now rubber-insulated), which suggests they are aware of the issue, but they have not issued a recall or TSB. I am filing this report to document the issue and request that NHTSA investigate. I believe this is a systemic problem that affects vehicle safety, and that Alfa Romeo and its dealerships are failing to address it adequately. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11682898 — an unverified report by a vehicle owner.
Muncie, INFire
ELECTRICAL SYSTEM
Ground wire to starter had corroded and broke into. Wife tried to start the vehicle and saw smoke coming up out of the hood. This caused the main wiring harness to burn and wires to fall apart. The wires run from the front wheels up into the engine bay and throughout vehicle. The vehicle could have caught fire or could have possibly caused the brakes to fail while driving. I contacted Alfa Cares but they would not help cover cost (estimated approximately $9,000). This is not only a safety issue but a non maintenance for the customer issue. This isn’t a scheduled maintenance and is a product failure by the manufacturer. This issue should be a recall for both issues.This also caused all warning lights to come on the dash including steering, ABS, and about four other warning lights. Please consider this issue as a recall as Alfa doesn’t seem to care enough to take care of it and before someone gets hurt. The issue has been noted by an independent repair shop as well as an Alfa Romeo certified mechanic.
NHTSA complaint #11664142 — an unverified report by a vehicle owner.
at 14,880 milesLA Verne, CACrash
SERVICE BRAKES
I WAS DRIVING SOUTH BOUND ON THE 605 IN STOP AND GO TRAFFIC. VEHICLE IN FRONT OF ME BROKE AND AS I ENGAGED IN THE BRAKE IT BECAME UNRESPONSIVE AND SPED UP AFTER I ENGAGED THEM. CAUSING MY VEHICLE TO COLLIDE WITH TWO OTHER VEHICLES
NHTSA complaint #11222521 — an unverified report by a vehicle owner.
at 500 milesPSL, FLCrash1 injured
WHEELS
IT IS DISGUSTING THAT AUTO MANUFACTURERS DON'T GIVE A SPARE OR RUN FLATS ON A CAR TODAY. I WAS ON I95 WITH MY FAMILY WHEN MY NEW ONE DAY OLD CAR HAD BLOWOUT AT 10PM AT NIGHT. ALFA ROADSIDE TOOK 6 HOURS TO FIND US. THIS IS SAFETY ISSUE BECAUSE I WAS STUCK SIDE OF THE BLACK DARKEN HIGHWAY WITHOUT SPARE. THE SEMI TRUCK PASSING 12 INCHES AWAY FROM MY CAR DOING 80+ MPH. HOW IS IT IN 2019 MANUFACTURERS CAN SELL A CAR WITHOUT A SPARE OR EVEN FLARES. THE WORST PART ALFA OFFER SPARE AS OPTION BUT SINCE MY CAR CAME WITHOUT IT I CAN'T ORDER A SPARE NO WHERE. ALFA DON'T OFFER TO SENT A SPARE AFTERMARKET. TIRE RACK TOLD ME THAT THEY DON'T HAVE OR ARE AVAILABLE SPARES THAT FIT MY ALFA STELVIO. A SPARE TIRE KIT WEIGH 20 LBS AND HOW MUCH GAS CAN A PERSON SAVE. I WAS TOLD IT IS MPG THING. I AM IN THE DOGHOUSE WITH MY FAMILY AND I HAVE TO BUY ANOTHER FULL SIZE WHEEL AND TIRE TO USED AS MY SPARE. THE CAR HAS 20 INCH WHEELS AND TAKES UP 1/2 TRUNK SPACE. IF I PUT ON ANOTHER ALFA SMALLER RIM LIKE 18 TO SAVE SPACE I WAS TOLD BY MANUFACTURERS MY WARRANTY IS VOID! I HAVING MY COUSIN IN ITALY SENT ME A DONUT SPARE FOR EMERGENCY. THE SPARE IS FROM ALFA ROMEO STELVIO TI MADE IN ITALY WHEEL THAT HAS SPARES INCLUDED AND SELL AFTERMARKET. THE DEALER SAYS IF I USED I LOSE MY WARRANTY. SAFETY ISSUES BEING STRUCK ON I95 WITHOUT A SPARE. HOW CAN NHTSA MAKE MANUFACTURERS GET AWAY WITH THIS IN 2019. SPARES ARE MORE IMPORTANT THAN ANY OTHER SAFETY FEATURES
NHTSA complaint #11183764 — an unverified report by a vehicle owner.
at 150 milesMaumee, OHFire
POWER TRAIN
AFTER FUELING UP THE FUEL TANK, THE VEHICLE WAS DRIVEN ON THE HIGHWAY AND SMOKE BEGAN TO EMIT OUT FROM THE VEHICLE'S HOOD. THE DRIVER WAS NOT ALERTED THERE WAS ANY ISSUE FROM THE VEHICLE'S DASHBOARD INDICATOR/WARNING LIGHTS. THE DRIVER PULLED OVER ON THE HIGHWAY SHOULDER AND THE VEHICLE WAS ON FIRE UNTIL THE FIRE/POLICE DEPARTMENT ARRIVED ON SCENE. *DT UPDATED 10/22/18
NHTSA complaint #11131138 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 120,000 milesPortland, ME
ENGINE AND ENGINE COOLING
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving 30 MPH and depressing the accelerator pedal, several unknown warning lights were illuminated, before the vehicle went into LIMP Mode. The contact stated that there was a rattling sound coming from the turbo charger. A dealer was contacted. The vehicle was diagnosed, and it was determined that the turbo charger needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 120,000.
NHTSA complaint #11757787 — an unverified report by a vehicle owner.
at 82,000 milesElgin, SC
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, the vehicle lost drive power. The message "Service Electronic Throttle" was displayed, and the check engine warning light was illuminated. The failure was a recurring failure. The contact associated the failure with NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline). The dealer was contacted; however, the part to do the recall was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but was unable to state when parts would be available. The failure mileage was approximately 82,000.
NHTSA complaint #11755945 — an unverified report by a vehicle owner.
at 54,000 milesCedar Grove, NJ
ELECTRICAL SYSTEM
The contact owns a 2018 Alfa Romeo Stelvio. While the contact’s wife was driving at an undisclosed speed, another motorist informed the driver that there was smoke coming from under the hood of the vehicle. The vehicle was immediately parked and failed to restart. The contact was called to the scene and inspected under the hood of the vehicle and discovered smoldering and melted wires. The vehicle was later towed to the local dealer, who diagnosed the vehicle and determined that the chassis-to-engine grounding strap had failed due to corrosion and needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer and dealer were made aware of the failure but offered no assistance. The failure mileage was 54,000.
NHTSA complaint #11754904 — an unverified report by a vehicle owner.
Greenwich, CT
ENGINE
Car stalled on highway leaving my life at risk and dealer has no date to repair fuel line
NHTSA complaint #11755048 — an unverified report by a vehicle owner.
Greenwich, CT
FUEL/PROPULSION SYSTEM
Car stalled on highway leaving my life at risk and dealer has no date to repair fuel line
NHTSA complaint #11755048 — an unverified report by a vehicle owner.
Phoenix, AZ
FUEL/PROPULSION SYSTEM
There is no fix for this. The fuel pump foe the Stelvio is recalled almost a year ago. The engine light comes on and the car is undriveable. I have paid for 2 new fuel pumps and control module (out of pocket) , and the check engine light will come back after a few weeks. The car is basically inoperable and bricked because of this, and Alfa has not resolved it. They should not be allowed to drag a recall out for years while owners suffer, and are in danger. Please hold Alfa Romeo accountable. It just happened again today (7/31/26) while my wife was on the highway. This is after paying thousands and thousands to resolve this whole Alfa Romeo doesn’t do anything to fix it. We are out of options.
NHTSA complaint #11754098 — an unverified report by a vehicle owner.
at 85,000 milesBarboursville, WV
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the vehicle lost power while accelerating. The check engine and throttle body warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the failure was related to the recall; however, the dealer confirmed that parts were not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
NHTSA complaint #11753439 — an unverified report by a vehicle owner.
Parlin, NJ
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
NHTSA complaint #11752639 — an unverified report by a vehicle owner.
at 80,000 milesWesley Chapel, FL
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that while driving at slow speeds, the vehicle hesitated, shuddered, and jerked while depressing the accelerator pedal. The messages "Service Engine Soon," "Service Electronic Throttle," and "Low Fuel Pump Pressure" were displayed. The vehicle was taken to the dealer, where it was diagnosed, and it was determined that the failure was associated with the recall; however, the dealer confirmed that parts were unavailable, and there was no timeline for parts availability. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 80,000.
NHTSA complaint #11752015 — an unverified report by a vehicle owner.
Stonington, CT
FUEL/PROPULSION SYSTEM
I was told I was on a priority list to have this recall fixed. My Stelvio is virtually undrivable. It continues to lose power when acceleration and goes into limp mode. I refuse to take the Stelvio onto the highway as it poses a danger to myself and passengers. This recall has been active for well over a year with a continual push back on the remedy date. Recall 93C (NHTSA 25V-586) causes a failure in the fuel delivery system which compromises acceleration and will frequently, without warning lose power as well as trip the a throttle delivery system warning light. This is a freaking joke to them. They refuse to take ownership over this recall and people are going to get into accidents.
NHTSA complaint #11752236 — an unverified report by a vehicle owner.
Nottingham, MD
FUEL/PROPULSION SYSTEM
THIS IS A FOLLOW UP TO MY PREVIOUS COMPLAINT, 11737275 AS THE VEHICLE HAS NOW DEGRADED TO PERSISTENT ACTIVE STALLING. This is a follow-up to my previous complaint 11737275 as the vehicle has now degraded to persistent active stalling. The failed component is the fuel pump assembly under active safety recall NHTSA 25V586 (Mopar 93C), and the un-remedied vehicle is completely available for physical inspection upon request. Safety is severely compromised as the vehicle experiences extreme drops in RPM, engine choking, and sudden stalling immediately after fueling because the failing, recalled pump cannot maintain proper pressure to compensate for standard EVAP canister vapor purging cycles. This dangerous driveability defect has been formally brought to Criswell Alfa Romeo, where service staff confirmed the failures but stated they cannot perform the remedy because the redesigned factory replacement component is currently unavailable. While the vehicle remains open for full review by any designated authority, it has not yet undergone formal inspection by the manufacturer, local law enforcement, or insurance investigators. The symptoms first manifested in 2021 immediately before the safety recall campaign became public knowledge, and the vehicle has suffered from these chronic, hazardous failures ever since. The manufacturer's technical summary states that 2017–2019 Alfa Romeo Stelvio vehicles may experience a loss of motive power due to a heat-susceptible fuel delivery module (FDM) losing flow rate, which FCA US will remedy by conducting a voluntary safety recall to replace the FDM with a newly updated Pump Electronic Module (PEM). My vehicle is a 2018 Alfa Romeo Stelvio TI.
NHTSA complaint #11750256 — an unverified report by a vehicle owner.
Flossmoor, IL
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was taken to Auto Zone however, the diagnostic results were unavailable. The vehicle was driven to the residence. The dealer was not made aware of the failure. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part was not yet available for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown.
NHTSA complaint #11750112 — an unverified report by a vehicle owner.
Zephyrhills, FL
POWER TRAIN
My vehicle has been subject of multiple recalls, however the current recall is a significant one and has been pending for months with no end in sight. I am concerned The manufacturer and dealers are not taking this seriously and the delay is causing additional damage to my vehicle. Additionally quickly googling my vehicle will show that it has fuel pump and acceleration jerking and lag issues that are extremely, extremely, common and troubling. I am also still having the service engine soon issues described in recalls and other forums related to throttle cable. Either none of this has been addressed by the manufacturer or the repairs so far have not been sufficient if it is still so common. On behalf of all Stelvio owners I demand these recalls and issues be addressed in a timely manner. This is going to cost us additional grief, safety issues, and repair costs. The biggest being my safety and my family's safety when we are riding in this vehicle, the acceleration issues are very noticeable and are getting worse. The symptoms are -exactly-what is described online and also as part of the recall. I don't even have the option to get it fixed there is no parts to fix available. This is a very nice vehicle, but this is getting old not having repairs done and the dealers running out of parts etc. Waiting months and months for repairs. - Fiat, Alfa Romeo and their dealerships do not seem to be taking this seriously - at all, they should have pride in their products like the owners do when we buy them. I want my Stelvio to be the best it can be, fully safe, and fully functional.
NHTSA complaint #11748640 — an unverified report by a vehicle owner.
Zephyrhills, FL
ELECTRICAL SYSTEM
My vehicle has been subject of multiple recalls, however the current recall is a significant one and has been pending for months with no end in sight. I am concerned The manufacturer and dealers are not taking this seriously and the delay is causing additional damage to my vehicle. Additionally quickly googling my vehicle will show that it has fuel pump and acceleration jerking and lag issues that are extremely, extremely, common and troubling. I am also still having the service engine soon issues described in recalls and other forums related to throttle cable. Either none of this has been addressed by the manufacturer or the repairs so far have not been sufficient if it is still so common. On behalf of all Stelvio owners I demand these recalls and issues be addressed in a timely manner. This is going to cost us additional grief, safety issues, and repair costs. The biggest being my safety and my family's safety when we are riding in this vehicle, the acceleration issues are very noticeable and are getting worse. The symptoms are -exactly-what is described online and also as part of the recall. I don't even have the option to get it fixed there is no parts to fix available. This is a very nice vehicle, but this is getting old not having repairs done and the dealers running out of parts etc. Waiting months and months for repairs. - Fiat, Alfa Romeo and their dealerships do not seem to be taking this seriously - at all, they should have pride in their products like the owners do when we buy them. I want my Stelvio to be the best it can be, fully safe, and fully functional.
NHTSA complaint #11748640 — an unverified report by a vehicle owner.
Zephyrhills, FL
FUEL/PROPULSION SYSTEM
My vehicle has been subject of multiple recalls, however the current recall is a significant one and has been pending for months with no end in sight. I am concerned The manufacturer and dealers are not taking this seriously and the delay is causing additional damage to my vehicle. Additionally quickly googling my vehicle will show that it has fuel pump and acceleration jerking and lag issues that are extremely, extremely, common and troubling. I am also still having the service engine soon issues described in recalls and other forums related to throttle cable. Either none of this has been addressed by the manufacturer or the repairs so far have not been sufficient if it is still so common. On behalf of all Stelvio owners I demand these recalls and issues be addressed in a timely manner. This is going to cost us additional grief, safety issues, and repair costs. The biggest being my safety and my family's safety when we are riding in this vehicle, the acceleration issues are very noticeable and are getting worse. The symptoms are -exactly-what is described online and also as part of the recall. I don't even have the option to get it fixed there is no parts to fix available. This is a very nice vehicle, but this is getting old not having repairs done and the dealers running out of parts etc. Waiting months and months for repairs. - Fiat, Alfa Romeo and their dealerships do not seem to be taking this seriously - at all, they should have pride in their products like the owners do when we buy them. I want my Stelvio to be the best it can be, fully safe, and fully functional.
NHTSA complaint #11748640 — an unverified report by a vehicle owner.
Claymont, DE
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the part was not yet available. A second dealer, Kerbeck Maserati (100 NJ-73, Palmyra, NJ 08065); was contacted and it was confirmed the part was not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
NHTSA complaint #11746123 — an unverified report by a vehicle owner.
at 62,000 milesDenver, CO
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that while driving 45 MPH and merging onto the highway, the vehicle entered Low Power Mode, forcing the contact to pull over to the side of the road. The contact then drove to the residence, where the vehicle was turned off and restarted, and the messages "Service Engine" and "Service Throttle Control" were displayed. The vehicle was taken to the dealer, where the fuel system was bled. The dealer later informed the contact that the high-pressure fuel pump had failed and needed to be replaced. The vehicle was not repaired. The contact stated that the high-pressure fuel pump and the fuel delivery module (FDM) were replaced in July 2025. The contact related the failure to the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 62,000.
NHTSA complaint #11744462 — an unverified report by a vehicle owner.
Montebello, CA
ELECTRICAL SYSTEM
I was driving and the car gave an error showing service throttle position. Car went into limp mode. I pulled over out of traffic. Car drove but very slow. I tried to drive back home but the car died while I was in the turning lane. It would not start again. I used my autel scanner and received codes, p01ca, p008a, p00c6, p0300, p0303, p0302. I believe it is the fuel pump and fuel pump module causing the car issues. I believe it is the 93c recall for this car. It would have been very unsafe if I was driving on the highway and this happen. The car is currently at Champion Alfa dealership. I’m waiting for the service department to get back to me. I hope the dealership or Alfa Romeo will cover the repairs cost since it is a pending recall.
NHTSA complaint #11744648 — an unverified report by a vehicle owner.
at 62,000 milesDenver, CO
ENGINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that while driving 45 MPH and merging onto the highway, the vehicle entered Low Power Mode, forcing the contact to pull over to the side of the road. The contact then drove to the residence, where the vehicle was turned off and restarted, and the messages "Service Engine" and "Service Throttle Control" were displayed. The vehicle was taken to the dealer, where the fuel system was bled. The dealer later informed the contact that the high-pressure fuel pump had failed and needed to be replaced. The vehicle was not repaired. The contact stated that the high-pressure fuel pump and the fuel delivery module (FDM) were replaced in July 2025. The contact related the failure to the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 62,000.
NHTSA complaint #11744462 — an unverified report by a vehicle owner.
Montebello, CA
FUEL/PROPULSION SYSTEM
I was driving and the car gave an error showing service throttle position. Car went into limp mode. I pulled over out of traffic. Car drove but very slow. I tried to drive back home but the car died while I was in the turning lane. It would not start again. I used my autel scanner and received codes, p01ca, p008a, p00c6, p0300, p0303, p0302. I believe it is the fuel pump and fuel pump module causing the car issues. I believe it is the 93c recall for this car. It would have been very unsafe if I was driving on the highway and this happen. The car is currently at Champion Alfa dealership. I’m waiting for the service department to get back to me. I hope the dealership or Alfa Romeo will cover the repairs cost since it is a pending recall.
NHTSA complaint #11744648 — an unverified report by a vehicle owner.
Roswell, GA
FUEL/PROPULSION SYSTEM
Intermittent hesitation when accelerating
NHTSA complaint #11742418 — an unverified report by a vehicle owner.
at 84,999 milesSouth Euclid, OHCrash2 injured
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while at a stop light, the contact pressed the accelerator pedal and the steering wheel erroneously turn to the right and the vehicle experienced unintended acceleration causing the driver to loose control of the steering and crash into a highway post. During the crash the driver sustained a concussion do to the air bag deployment and the front passenger sustained a fractured right arm. Both occupants of the vehicle were transported and treated at the hospital. The vehicle was destroyed and towed away. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The manufacturer was notified failure. The local dealer was not contacted. The failure mileage was 85,000.
NHTSA complaint #11741462 — an unverified report by a vehicle owner.
at 99,180 milesBraselton, GA
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. In addition, the vehicle overheated. The vehicle was towed to the dealer, however the contact was informed that the parts were unavailable. The contact stated that the vehicle was taken to the dealer multiple times. In addition, the contact stated that the failure was persistent. The vehicle was towed to the residence five times. In addition, the contact was advised not to drive the vehicle a far distance. The contact received a recall notification, NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline) however the parts were unavailable. The manufacturer was made aware of the failure. The failure mileage was approximately 99,180.
NHTSA complaint #11741375 — an unverified report by a vehicle owner.
at 70,000 milesAtlanta, GA
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly entered limp mode, with the start/stop warning light illuminated and a “Throttle Unavailable” warning message displayed. The contact also stated that the vehicle failed to properly accelerate. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the parts required for the recall repair were not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that the remedy parts were not yet available. The manufacturer was not made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 70,000.
NHTSA complaint #11739593 — an unverified report by a vehicle owner.
Phoenix, AZ
FUEL/PROPULSION SYSTEM
The car was recalled in September 2025 and there is no fix at this point. I have contacted the Alfa dealership and there is no fix. I am loosing money because the car was listed on turo and I cannot rent the car because of the recall
NHTSA complaint #11738804 — an unverified report by a vehicle owner.