Owners have filed 38 complaints
about the 2005 BMW 330CI with NHTSA between 2006 and 2024.
The largest single group is the airbags.
Across this model's run it ranks 5 of 6 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 35
Against the median year of the BMW 330CI. 50 means typical for this
model; 100 means roughly double.
Severity — 41
7.9% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 20
12% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
10,000 – 24,999 miles
211.8%
25,000 – 49,999 miles
211.8%
50,000 – 74,999 miles
423.5%
75,000 – 99,999 miles
423.5%
100,000 – 149,999 miles
317.6%
150,000+ miles
211.8%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Nov 2006peak 3Mar 2024
NHTSA investigations into the 2005 BMW 330CI
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
1
investigation is
still open.
EA15001Opened 24 Feb 2015Still openAIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
PE14016Opened 11 Jun 2014Closed 2 Mar 2015AIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
Recalls on the 2005 BMW 330CI
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
20V018000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PSPI passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
15V318000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons, and 2003 X5 3.0i and 4.4i Sports Activity Vehicles. Please note that the 5-series and X5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
07E023000
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Risk: LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
NHTSA complaint #11390033 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Greeley, CO
EXTERIOR LIGHTING
The wires inside the headlight assembly have literally snapped rendering the headlight inoperable. I’ve repaired in places just for them to break where I haven’t repaired. Access is very difficult. On a longer trip I wouldn’t be able to repair on side of the road. It’s a manufacturing defect.
NHTSA complaint #11576570 — an unverified report by a vehicle owner.
at 44,800 milesSanta Ana, CA
EXTERIOR LIGHTING:TAIL LIGHTS
The contact owns a 2005 BMW 330CI. The contact stated that while driving at an undisclosed speed, the vehicle was pulled over by law enforcement due to malfunctioning taillights. The dealer was made aware of the failure but informed the contact that he needed to pay out-of-pocket for a diagnostic test. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and the contact was informed that the VIN was not included in NHTSA Campaign Number: 11V438000 (Exterior Lighting). The failure mileage was approximately 44,800.
NHTSA complaint #11471420 — an unverified report by a vehicle owner.
NHTSA complaint #11390033 — an unverified report by a vehicle owner.
at 84,000 milesGermantown, MD
EXTERIOR LIGHTING
I HAVE OWNED THIS VEHICLE FOR A WHILE. I WAS STATIONARY WHILE I DISCOVERED THE FOLLOWING. DOOR LOCKS DID NOT WORK CONSISTENTLY WITH THE KEY FOB, CONVERTIBLE TOP ALSO, WINDOWS SOMETIMES WORKED, WIPERS ALSO. I READ FORUMS TO REALIZE THE GENERAL MODULE FAILED RELAYS IS A KNOWN PROBLEM. THIS KNOWN PROBLEM ENDANGERS THE OPERATOR, PASSENGERS, AND THE PUBLIC, AND A RECALL AND REDESIGN SHOULD BE ORDERED FOR THE SAFETY OF THE PUBLIC. I TRIED TO ADD PICTURES, BUT THE FORM CRASHES.
NHTSA complaint #11362589 — an unverified report by a vehicle owner.
at 84,000 milesGermantown, MD
ELECTRICAL SYSTEM
I HAVE OWNED THIS VEHICLE FOR A WHILE. I WAS STATIONARY WHILE I DISCOVERED THE FOLLOWING. DOOR LOCKS DID NOT WORK CONSISTENTLY WITH THE KEY FOB, CONVERTIBLE TOP ALSO, WINDOWS SOMETIMES WORKED, WIPERS ALSO. I READ FORUMS TO REALIZE THE GENERAL MODULE FAILED RELAYS IS A KNOWN PROBLEM. THIS KNOWN PROBLEM ENDANGERS THE OPERATOR, PASSENGERS, AND THE PUBLIC, AND A RECALL AND REDESIGN SHOULD BE ORDERED FOR THE SAFETY OF THE PUBLIC. I TRIED TO ADD PICTURES, BUT THE FORM CRASHES.
NHTSA complaint #11362589 — an unverified report by a vehicle owner.
at 84,000 milesGermantown, MD
VISIBILITY/WIPER
I HAVE OWNED THIS VEHICLE FOR A WHILE. I WAS STATIONARY WHILE I DISCOVERED THE FOLLOWING. DOOR LOCKS DID NOT WORK CONSISTENTLY WITH THE KEY FOB, CONVERTIBLE TOP ALSO, WINDOWS SOMETIMES WORKED, WIPERS ALSO. I READ FORUMS TO REALIZE THE GENERAL MODULE FAILED RELAYS IS A KNOWN PROBLEM. THIS KNOWN PROBLEM ENDANGERS THE OPERATOR, PASSENGERS, AND THE PUBLIC, AND A RECALL AND REDESIGN SHOULD BE ORDERED FOR THE SAFETY OF THE PUBLIC. I TRIED TO ADD PICTURES, BUT THE FORM CRASHES.
NHTSA complaint #11362589 — an unverified report by a vehicle owner.
Waxhaw,, NC
AIR BAGS
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V018000(AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED TO HENDRICK BMW (6950 E INDEPENDENCE BLVD, CHARLOTTE, NC 28227, (704) 321-4851) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER HAD NOT BEEN MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA complaint #11325541 — an unverified report by a vehicle owner.
at 157,124 milesCocoa, FL
EXTERIOR LIGHTING:HEADLIGHTS
TL* THE CONTACT OWNS A 2005 BMW 330CI. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE PLASTIC THAT COVERED THE FRONT DRIVER'S SIDE HEADLIGHT WIRING STARTED TO PEEL. THE CONTACT WAS CONCERNED THAT THE WIRES COULD BECOME EXPOSED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 157,124.
NHTSA complaint #11024102 — an unverified report by a vehicle owner.
at 157,124 milesCocoa, FL
STRUCTURE
TL* THE CONTACT OWNS A 2005 BMW 330CI. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE PLASTIC THAT COVERED THE FRONT DRIVER'S SIDE HEADLIGHT WIRING STARTED TO PEEL. THE CONTACT WAS CONCERNED THAT THE WIRES COULD BECOME EXPOSED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 157,124.
NHTSA complaint #11024102 — an unverified report by a vehicle owner.
Lithonia, GA
AIR BAGS
TAKATA RECALL HELLO, I RECEIVED A RECALL NOTICE IN THE MAIL FOR MY VEHICLE. AS I CHECKED THE NHTSA SYSTEM, IT STATED THAT BOTH PASSENGER AND DRIVER AIRBAG SYSTEM NEEDED A RECALL. TAKATA HAS A SETTLEMENT OPEN FOR MY VEHICLE. PLEASE INFORM ME ON THE NEXT STEP TO TAKE TO HANDLE THIS SITUATION, BEFORE THE WORST COULD HAPPEN. THANK,YOU FOR YOUR HELP. PLEASE CONTACT ME AT (678)983-6806. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11013831 — an unverified report by a vehicle owner.
at 132,360 milesModesto, CA
AIR BAGS
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT STATED THAT THE GLOVE COMPARTMENT THAT CONTAINED THE AIR BAG FAILED TO OPEN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 132,360. PARTS DISTRIBUTION DISCONNECT.
NHTSA complaint #10986221 — an unverified report by a vehicle owner.
Topanga, CA
AIR BAGS
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V428000 (AIR BAGS) AND 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA complaint #10917348 — an unverified report by a vehicle owner.
Ocala, FL
EXTERIOR LIGHTING
INSULATION CRACKING ON WIRES TO XENON HEAD LIGHTS LEADING TO HEAD LIGHT FAILURE DUE TO SHORTING OR WIRE BREAKAGE; NOTATION ON WHEN IT HAPPENED IS ESTIMATE BECAUSE I HAD REPLACED ONE HEADLIGHT FOR THIS ISSUE SEVERAL YEARS AGO (NOT KNOWING IT WAS THE CAUSE AT THE TIME). I BELIEVE THIS IS A MANUFACTURER'S DEFECT AFTER NOTING SIMILAR COMPLAINTS FROM OTHERS. VEHICLE HAS BEEN GARAGE KEPT. PHOTOS ARE FROM WIRES TO BOTH LIGHTS. ON LIGHT THAT WAS REPLACED NEW WIRES WERE SPLICED TO OLD WIRES BY DEALERSHIP AND PHOTO IS OF ORIGINAL WIRE.
NHTSA complaint #10916064 — an unverified report by a vehicle owner.
Lebanon, PA
AIR BAGS
TAKATA RECALL RECEIVED LETTER OF RECALL JULY 2015 AND NEVER HEARD BACK THAT REPAIR PARTS ARE IN.
NHTSA complaint #10907456 — an unverified report by a vehicle owner.
Saint Petersburg, FL
AIR BAGS
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA complaint #10899583 — an unverified report by a vehicle owner.
Newcastle, WA
AIR BAGS
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA complaint #10895973 — an unverified report by a vehicle owner.
Long Beach, CA
AIR BAGS
TL* THE CONTACT OWNS A 2005 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V428000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT TO TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 08/30/16*LJ UPDATED 10/26/16.
NHTSA complaint #10884047 — an unverified report by a vehicle owner.
Virginia Beach, VA
AIR BAGS
TAKATA RECALL I WAS NOTIFIED OF THIS RECALL IN JULY 2015 AND THE DEALER CLAIMS IT HAS NO PARTS TO REPAIR/REPLACE.
NHTSA complaint #10871734 — an unverified report by a vehicle owner.
Yardley, PA
AIR BAGS
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS). THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA complaint #10840321 — an unverified report by a vehicle owner.
LA Crescenta, CA
AIR BAGS
TL* THE CONTACT OWNS A 2005 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) HOWEVER, THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THIS FAILURE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA complaint #10821042 — an unverified report by a vehicle owner.
Carlsbad, CA
AIR BAGS
TAKATA RECALL FOUR MONTHS AGO I RECEIVED A WRITTEN NOTICE FROM BMW USA THAT MY DRIVER SIDE FRONT AIRBAG NEEDED TO BE REPLACED (RECALL CAMPAIGN NO. 15V-318), BUT THAT PARTS WERE NOT YET AVAILABLE. OVER FOUR MONTHS HAVE PASSED AND I HAVE HEARD NOTHING FURTHER ON THIS RECALL FROM BMW USA OR MY LOCAL DEALERSHIP. THE ORIGINAL NOTICE THAT I RECEIVED INDICATED THAT I COULD NOTIFY NHTSA IF THIS MATTER WAS NOT RESOLVED WITHIN A REASONABLE PERIOD OF TIME. I AM DOING SO WITH THIS MESSAGE AND ASKING WHAT RECOURSE I HAVE IN GETTING THIS MATTER ADDRESSED?
NHTSA complaint #10795093 — an unverified report by a vehicle owner.
Pelham, NY
AIR BAGS
TL* THE CONTACT OWNS A 2005 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS)HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 1/19/16 LN
NHTSA complaint #10781630 — an unverified report by a vehicle owner.
at 53,086 milesBrooklyn, NY
AIR BAGS
THE DEALER, BMW LIFE QUALITY MOTOR SALES INC. OF BROOKLYN, NY REFUSES TO COMPLETE THE TAKATA PASSENGER AIRBAG SAFETY RECALL B65 17 14.
NHTSA complaint #10779587 — an unverified report by a vehicle owner.