35 of the
124 complaints about the 2015 BMW 428I are about the
electrical system — 28% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
84,000 miles.
The contact owns a 2015 BMW 428I. The contact stated that while the vehicle was parked, while attempting to start the vehicle, it failed to start. The contact stated that the vehicle eventually started. The vehicle was taken to an independent mechanic, where it was diagnosed with coolant pump failure. The contact was informed that the coolant had been continuously running, causing the battery to completely drain. The contact was informed that the battery needed to be replaced, the radiator needed to be flushed, and the repair of a small oil leak was needed. The vehicle was repaired. The VIN was included in NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System). While driving to the dealer, the loss of communication with the coolant pump warning light illuminated. The contact was informed that the coolant pump had passed the inspection and did not need to be replaced. The contact was informed that the shield was installed as per the recall. The contact stated that upon retrieving the vehicle from the dealer, the battery was completely drained. The contact was informed that the battery needed to be replaced. The dealer was informed that the battery was replaced three weeks prior. The contact requested that the dealer replace the coolant pump according to the recall notification, however the request was denied. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.
NHTSA complaint #11715294 — an unverified report by a vehicle owner.
at 118,357 milesWolf Creek, OR
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact discovered that the water pump was continuously running after the vehicle was turned off. The contact referenced and associated the failure with NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the VIN was not included. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 118,357.
NHTSA complaint #11715401 — an unverified report by a vehicle owner.
Arlington, VA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact stated that while driving at an undisclosed speed, the coolant warning light intermittently illuminated on several occasions. The contact was informed that the VIN was included in NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM). The vehicle was taken to a dealer, where it was diagnosed that there was an electrical connector on the water pump that was exposed to water and that the water pump needed to be replaced. The contact stated that the manufacturer had removed the VIN from the recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
NHTSA complaint #11692123 — an unverified report by a vehicle owner.
Cincinnati, OH
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System). The contact called the local dealer, who confirmed that recall parts were not yet available and advised the contact to wait for another notification to arrive when parts become available. The vehicle was not diagnosed or repaired. The manufacturer was not contacted about the issue. The contact had not experienced a failure.
NHTSA complaint #11681502 — an unverified report by a vehicle owner.
Jamaica, NY
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while driving 20 MPH, the check engine warning light illuminated, and the messages "Engine Overheated" and "Please Pull Over" were displayed on the instrument panel. The contact replaced the water pump and the thermostat; however, the failure persisted, and the vehicle was taken to an independent mechanic to be diagnosed and the contact was informed that the water pump had failed and needed to be replaced. The water pump and thermostat were replaced; however, the failure persisted, and the engine kept overheating. The vehicle was taken back to the independent mechanic. The water pump and thermostat were replaced. The independent mechanic checked the electrical system. However, no cause for the failure was found. The contact stated that the failure persisted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown.
NHTSA complaint #11679826 — an unverified report by a vehicle owner.
Marietta, GA
ELECTRICAL SYSTEM
Recall #24V-609. Recall was issued in October 2024. My wife drives this car....BMW has no update. Need it repaired ASAP! Please inquire. Thank you, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11674275 — an unverified report by a vehicle owner.
Ladera Ranch, CA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11671717 — an unverified report by a vehicle owner.
Ozark, MO
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11666268 — an unverified report by a vehicle owner.
Dennis, MA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11663414 — an unverified report by a vehicle owner.
at 93,000 milesBoston, MA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact stated while driving at an undisclosed speed, the engine overheated and the vehicle started shaking with the drivetrain malfunction message displayed. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but was unable to confirm when parts would become available. The failure mileage was approximately 93,000. VIN tool confirms parts not available.
NHTSA complaint #11663531 — an unverified report by a vehicle owner.
Damascus, MD
ELECTRICAL SYSTEM
The manufacturer has failed or is unable to remedy this safety recall for my vehicle in a timely manner. Issue: 1 open recall since Aug 13, 2024 for: ENGINE COOLANT PUMP: The electrical connector of the engine coolant pump could become damaged. Small drops of liquid from the positive crankcase ventilation (PCV) system could drip down onto the electrical connector of the pump.
NHTSA complaint #11659438 — an unverified report by a vehicle owner.
at 151,940 milesLenexa, KS
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving approximately 30-40 MPH, there was smoke coming from underneath the hood of the vehicle. The dealer was not contacted. The manufacturer was made aware of the issue. The failure mileage was 151,940. VIN tool confirms parts not available.
NHTSA complaint #11659492 — an unverified report by a vehicle owner.
Grimesland, NC
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11659051 — an unverified report by a vehicle owner.
at 60,000 milesSaint Louis, MO
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving at an undisclosed speed, there was smoke coming from the engine compartment into the cabin of the vehicle. The cause of the failure was not determined, and the vehicle was not yet repaired. The failure mileage was 60,000. VIN tool confirms parts not available.
NHTSA complaint #11657267 — an unverified report by a vehicle owner.
Eastvale, CA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11652635 — an unverified report by a vehicle owner.
Irvine, CA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11650427 — an unverified report by a vehicle owner.
at 138,000 milesOakdale, CA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact stated while driving at approximately 15-20 MPH, the message “Do not Drive” was displayed. The vehicle sat overnight; however, upon starting the vehicle the next day, the messages “Do not Drive” and “Add Coolant” were displayed. There were no visible leaks found. The contact added additional BMW coolant. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact scheduled an appointment with the dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The approximate failure mileage was 138,000. VIN tool confirms parts not available.
NHTSA complaint #11646729 — an unverified report by a vehicle owner.
Watchung, NJ
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11646232 — an unverified report by a vehicle owner.
Riverside, CA
ELECTRICAL SYSTEM
Turbo lines leaking. My model vehicle is the same N20 engine components that were installed with the f30s in prior years. BMW had an in house recall for specific models and vins but did not include mine even though they were installed with the same issues that the previous models had. Now, the turbo lines are leaking, my car only has 85000. I shouldn’t have to pay over 3k for them to correct this.
NHTSA complaint #11644984 — an unverified report by a vehicle owner.
at 84,000 milesNational City, CA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The contact stated while driving at undisclosed speeds, smoke was coming from under the hood, entering the vehicle through the A/C vents. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 84,000. VIN tool confirms parts not available.
NHTSA complaint #11645175 — an unverified report by a vehicle owner.
New Hope, PA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine an Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11644122 — an unverified report by a vehicle owner.
at 61,000 milesGlendora, CA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, there was white smoke coming from under the hood. No warning light was illuminated. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 61,000. VIN tool confirms parts not available.
NHTSA complaint #11643663 — an unverified report by a vehicle owner.
at 84,000 milesRiverside, CA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact was notified of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that an abnormal oil burning odor was coming from the vehicle. The check engine warning light became illuminated. The vehicle was taken to an independent mechanic, and it was discovered that there was oil leaking from the gasket and onto the bank 1 sensor, which caused the sensor to become corroded. The mechanic linked the failure to the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The vehicle was taken to a dealer and the contact was provided an estimate for a diagnostic test. The contact stated that the vehicle was not repaired, and the engine was overheating. The failure mileage was approximately 84,000. VIN tool confirms parts not available.
NHTSA complaint #11643733 — an unverified report by a vehicle owner.
Brentwood, CA
ELECTRICAL SYSTEM
The contact's daughter owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11638020 — an unverified report by a vehicle owner.
Brockton, MA
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11633749 — an unverified report by a vehicle owner.
at 70,000 milesLancaster, CA
ELECTRICAL SYSTEM
The contact owns a 2014 BMW 428I. The contact stated while driving at an undisclosed speed, the contact noticed a smoky odor coming from the vehicle and the contact noticed smoke coming from the engine compartment. The contact pulled the vehicle over and turned the vehicle off. The vehicle was able to restart. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 70,000. VIN tool confirms parts not available.
NHTSA complaint #11633230 — an unverified report by a vehicle owner.
Oakland Park, FL
ELECTRICAL SYSTEM
The water pump electrical connector on my 2015 BMW 428i failed, as identified in Recall Campaign No. 24V-608. This defect caused repeated engine overheating, leading to damage to the oil pan gasket and valve cover gaskets. An independent service center confirmed the damage was due to overheating from the faulty water pump. The issue has worsened, with a visible oil leak contributing to frequent engine overheating, making it unsafe to drive long distances. Contact Timeline: 1.October 10, 2024: I received the recall notice from BMW for the defective water pump electrical connector. 2.October 24, 2024: I emailed BMW [XXX] and [XXX] ) to report the overheating and related damage, requesting a full inspection and repairs. 3.October 2024: I visited an independent body shop, which confirmed the damage, and later the BMW dealership in Pompano Beach, which also confirmed the issues but did not agree to cover the repairs under the recall. 4.November 8, 2024: BMW Recall Support Services confirmed the recall is open but did not address the additional damage. 5.November 11, 2024: Robert Pfeiffer from BMW left a voicemail, only noting a delay in parts but not addressing my concerns about the damage. 6.November 12, 2024: I called Robert Pfeiffer but was unable to reach him and left a voicemail. I followed up with an email, reiterating my request for BMW to cover the related repairs due to the worsening vehicle condition. Current Concern: The oil leak continues to worsen, increasing engine overheating risk. No warning lamps initially appeared, but symptoms began shortly after the recall notice. Both the independent body shop and the BMW dealership confirmed the overheating and gasket damage. I request NHTSA’s assistance, as BMW has not resolved the issue despite the clear link to the defective part. The vehicle is available for inspection, and this problem presents a serious safety risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11624758 — an unverified report by a vehicle owner.
Glen Allen, VA
ELECTRICAL SYSTEM
Water accumulation in the rear passenger side when it rains. Can hear slushing water when driving. It accumulated all the way to the luggage compartment and caused the Control unit rear electrical and the ASD module to fail causing $2564.61 in repairs. Was wondering if this is the case of the issue [XXX] . When I read online there Is a lot of complaints about this. Has BMW ever acknowledged the issue? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11624085 — an unverified report by a vehicle owner.
Shorewood, MN
ELECTRICAL SYSTEM
The contact owns a 2015 BMW 428I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11621696 — an unverified report by a vehicle owner.
at 75,000 milesLake Hiawatha, NJFire
ELECTRICAL SYSTEM
The contact owned a 2015 BMW 428i. The contact stated that while driving approximately 50 MPH, the vehicle drove over a pot and the air pressure monitoring system warning had displayed. After stopping the vehicle, flames and smoke were present coming from the front driver side wheel well. The fire department was called to the scene but the vehicle was completely engulfed in flames and was destroyed. The cause of the failure was not determined due to the extent of the fire damage. A police report was taken and the vehicle was towed away. The manufacturer was contacted regarding the failure. The local dealer was not contacted. The failure mileage was 75,000.
NHTSA complaint #11431012 — an unverified report by a vehicle owner.