FaultScore report
Owners have filed 20 complaints about the 1992 Chevrolet 1500 with NHTSA between 1997 and 2004. The largest single group is the windows, mirrors & wipers.
20
Complaints
0
Crashes reported
1
Fires reported
1
Injuries reported
Click any bar to open that year's report.
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
0 crashes, 1 fires
Median failure at 70,000 miles
A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.
Reports where the owner recorded a crash, a fire, an injury or a death.
SEATS:FRONT ASSEMBLY:POWER ADJUST
WIFE HIT THE KNOB TO ADJUST THE DRIVER'S SIDE POWER SEAT SMOKE FILLED THE COMPARTMENT. ALL THE WIRING ON THE SEAT CAUGHT ON FIRE.
NHTSA complaint #846757 — an unverified report by a vehicle owner.
SEATS:FRONT ASSEMBLY:RECLINER
WHILE DRIVING PASSENGER'S SIDE SEATBACK COLLAPSED, CAUSING INJURIES TO WIFE. DEALER WAS PREVIOUSLY NOTIFIED, AND THE PROBLEM WAS SUPPOSED TO BE RESOLVED. THIS PART WAS PREVIOUSLY REPLACED ON A GM RECALL, DEALER TRIED TO GET GM TO REPAIR BUT THEY REFUSED. OWNER REPAIRED SEAT HIMSELF.
NHTSA complaint #845468 — an unverified report by a vehicle owner.
In the owners' own words, exactly as filed with NHTSA.
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
WHILE DRIVING 25 MPH THE UNDER BODY SPARE MOUNTING DISINTEGRATED. AS A RESULT, THE SPARE TIRE FELL OUT INTO THE MIDDLE OF THE STREET. *AK *SC
NHTSA complaint #10081390 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
I WOULD LIKE TO REPORT A TIRE TREAD SEPARATION AND BLOW OUT ON A UNI ROYAL TIGER PAW XTM, P235/75 R15 TIRE WITH 3/16" TREAD REMAINING. THE DOT IS AVHL AA 481. OTHER NUMBERS ON THE TIRE ARE: ITEM 4165, E24405, D117C, 89C, 89B, 89A, 3452. THE TIRE FAILED ON JULY 26 AT ABOUT 10:00 PM AT THE INTERSECTION OF I255 AND I70 NORTHEAST OF ST. LOUIS. THE TIRE ORIGINALLY WAS ON A NEW 1992 CHEVROLET C1500 AND FOR THE LAST FIVE YEARS HAS BEEN ON A 16 FOOT TANDEM AXLE TRAILER WITH 3500 POUND AXLES. THE TIRE HAS NEVER BEEN RUN LOW, NOR OVERLOADED, NOT RUN HOT. AT THE TIME OF FAILURE THE TIRE WAS RELATIVELY COOL CONSIDERING THE AMBIENT TEMPERATURE. THE TIRE FAILED WITH A 3 FOOT SECTION OF THE TREAD SEPARATING FROM THE TIRE EXPOSING THE STEEL BELT WHICH THEN SEPARATED AND CAUSE A SIDEWALL TO SIDEWALL RUPTURE OF THE TIRE WITH A SUDDEN LOSS OF THE AIR PRESSUE. THE CAUSE OF FAILURE WAS DUE TO FAILURE OF THE VULCANIZATION OF THE TREAD TO THE TIRE. THERE IS A SECTION AT THE EDGE OF THE TREAD THAT IS LOOSE WHILE ANOTHER PART IS STILL TIGHTLY ADHERED TO THE TIRE. THE FAILURE DIDN'T CAUSE ANOTHER OTHER DAMAGE AS THE TRAILER IS STRONG IN THE FENDER AREA. ALSO BECAUSE IT IS A TANDEM AXLE TRAILER, THERE WAS NO STABILITY PROBLEM. THIS WAS JUST ONE OF THOSE INSTANCES WHERE THE TIRE WAS DEFECTIVE IN ONE AREA OF THE VULCANIZATION. WITH THE TREAD LOOSE IT JUST FINALLY LET GO AND THE BELT LOST ITS STRENGTH AND SEPARATED AND THEN OF COURSE THE RADIAL CORDS HAVE NO STRENGTH TO HOLD THE AIR INSIDE.
NHTSA complaint #10030603 — an unverified report by a vehicle owner.
VISIBILITY:WINDSHIELD WIPER/WASHER
WINDSHIELD WIPERS WORK INTERMITTENTLY, WHEN TAPPING ON WIPER HARNESS MOTOR THEY WILL COME BACK ON. WHEN YOUR DRIVING ON A HIGHWAY AND WINDSHIELD WIPERS STOP OPERATING ITS VERY DANGEROUS BECAUSE DRIVER CAN GET TO THAT WIPER MOTOR FROM INSIDE OF CAR.*AK
NHTSA complaint #894387 — an unverified report by a vehicle owner.
SEATS
THE VEHICLES BENCH SEAT ROCKS BACK AND FORTH EXCESSIVELY, THE CONSUMER NOTICED A CRACK IN EACH OF THE SEAT RAILS ON BOTH SIDES OF THE SEAT, THE CONSUMER WANTS THE MANUFACTURER TO REPLACE THE BROKEN RAILS. NLM
NHTSA complaint #560778 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
ORIGINAL TIRES ON A CHEVROLET, 1500, 1992, GOODYEAR HT, P23575R15 FRONT END WAS JUMPING REALLY BADLY. A MECHANIC SAID THAT 2 REAR TIRES TREAD WAS SEPARATING. *AK CONSUMER HAS REPLACED A TOTAL OF 7 GOODYEAR HT TIRES DUE TO VIBRATION. *SLC
NHTSA complaint #875656 — an unverified report by a vehicle owner.
SEATS:FRONT ASSEMBLY:RECLINER
WHILE GOING DOWN THE ROAD PASSENGER SIDE SEAT FELL ALL THE WAY BACK, AND BROKE THE CABLE THAT RELEASES THE LATCH. OWNER LATER RECEIVED A RECALL NOTICE, BUT DEALER REFUSED TO REPAIR THE VEHICLE BECAUSE IT REQUIRED MORE THAN JUST BOLTS TO BE INSTALLED.
NHTSA complaint #857892 — an unverified report by a vehicle owner.
SEATS:FRONT ASSEMBLY:RECLINER
WHILE DRIVING ON HIGHWAY AT APPROXIMATELY 40MPH LEANED BACK ON DRIVER'S SEAT AND THE SEATBACK COLLAPSED. HAD IT REPAIRED BY LOCAL MECHANIC. DIDN'T CONTACT DEALER OR MANUFACTURER.
NHTSA complaint #854307 — an unverified report by a vehicle owner.
VISIBILITY:WINDSHIELD
I AM EXPERIENCING PAINT DELAMINATION ON THIS VEHICLE. FROM THE INFORMATION I HAVE GATHERED THIS IS LIKELY TO HAVE AN EFFECT UPON WINDSHIELD RETENTION DURING IMPACT. I REQUESTED THAT CHEVROLET REMOVE ALL GLASS AND TRIM, REMOVE TRUCK BED, STRIP ALL PAINT DOWN TO BARE METAL AND REPAINT WITH PPG PRODUCTS. I HAVE ALSO REQUESTED THAT CHEVROLET PAY FOR A SUITABLE RENTAL VEHICLE DURING REPAIR. I AM ALSO IN POSSESION OF THEIR TECHNICAL SERVICE BULLETIN 92-300-10 DATED 10-92 PROVING THAT CHEVROLET WAS AWARE OF THIS PROBLEM BEFORE THEY SOLD ME THE TRUCK. I HAVE ALSO UNCOVERED THE FACT THAT THERE MAY BE A NHTSA SAFETY RECALL CONCERNING WINDSHIELD RETENTION PROBLEMS BECAUSE OF PAINT DELAMINATION. PLEASE LET ME KNOW WHAT YOU FIND CONCERNING THIS COMPLAINT. THANK YOU!
NHTSA complaint #715054 — an unverified report by a vehicle owner.
SEATS:FRONT ASSEMBLY:RECLINER
RECEIVED RECALL NOTICE & CONTACTED DEALER. TOOK VEHICLE IN ON DATE GIVEN. WAS INFORMED BY MECHANIC MORE PARTS WERE NEEDED. HAD SEATS REPAIRED AFTER PARTS CAME IN. THE BACK OF THE SEAT COULD NOT BE MOVED FORWARD/BACKWARDS. THE SEAT REPAIRED UNDER RECALL HAD FAILED AGAIN.
NHTSA complaint #849323 — an unverified report by a vehicle owner.
VISIBILITY:WINDSHIELD WIPER/WASHER
DURING IN HEAVY RAIN WINDSHIELD WIPERS FAILED TO OPERATE. NO PRIOR WARNING. CONTACTED DEALER.
NHTSA complaint #849804 — an unverified report by a vehicle owner.
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
WHILE DRIVING ON THE HIGHWAY AT APPROXIMATELY 40MPH ON THE WAY TO THE HOSPITAL IN HEAVY TRAFFIC AND RAIN STORM WINDSHIELD WIPERS JUST STOPPED WORKING.
NHTSA complaint #849521 — an unverified report by a vehicle owner.
SEATS:FRONT ASSEMBLY:POWER ADJUST
WIFE HIT THE KNOB TO ADJUST THE DRIVER'S SIDE POWER SEAT SMOKE FILLED THE COMPARTMENT. ALL THE WIRING ON THE SEAT CAUGHT ON FIRE.
NHTSA complaint #846757 — an unverified report by a vehicle owner.
SEATS:FRONT ASSEMBLY:RECLINER
WHILE DRIVING PASSENGER'S SIDE SEATBACK COLLAPSED, CAUSING INJURIES TO WIFE. DEALER WAS PREVIOUSLY NOTIFIED, AND THE PROBLEM WAS SUPPOSED TO BE RESOLVED. THIS PART WAS PREVIOUSLY REPLACED ON A GM RECALL, DEALER TRIED TO GET GM TO REPAIR BUT THEY REFUSED. OWNER REPAIRED SEAT HIMSELF.
NHTSA complaint #845468 — an unverified report by a vehicle owner.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
DOOR LATCH ON THE PASSENGER SIDE IS BROKEN AND DOES NOT LOCK IN PLACE.CONSUMER CONTACTED DEALER.
NHTSA complaint #842361 — an unverified report by a vehicle owner.
SEATS:FRONT ASSEMBLY:RECLINER
PASSENGER SEATBACK BOLT BROKE WHICH MAY CAUSE THE SEATBACK TO FALL UNEXPECTEDLY, AND MAY RESULT IN INJURIES. PLEASE PROVIDE FURTHER INFORMATION.
NHTSA complaint #841665 — an unverified report by a vehicle owner.
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
WHILE DRIVING OR AT STOP POSITION WINDSHIELD WIPER MOTOR STOPPED WORKING FOR A FEW MINUTES WITHOUT WARNING.
NHTSA complaint #839788 — an unverified report by a vehicle owner.
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
WINDSHIELD WIPER MOTOR ON THIS VEHICLE IS DEFECTIVE THE SAME WAY AS THE ONE ON THE NEWER MODEL VEHICLES, BUT THIS YEAR MODEL IS NOT INCLUDED. DEALER HAS BEEN CONTACED.
NHTSA complaint #836468 — an unverified report by a vehicle owner.
VISIBILITY:WINDSHIELD WIPER/WASHER
WINDSHIELD WIPERS HAVE ERRATIC OPERATION. WHEN WINDSHIELD WIPERS ARE SHUT OFF THEY STAY ON FOR AT LEAST ANOTHER MINUTE BEFORE STOPPING, AND WILL STOP IN THE MIDDLE OF THE WINDSHIELD. DEALER HAS BEEN CONTACTED. *AK
NHTSA complaint #834518 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
REAR BRAKE LINE RUSTED THROUGH IN THE AREA LOCATED OVER THE FUEL LINE.
NHTSA complaint #532507 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
THROTTLE: DRIVING DOWN HIGHWAY AND THE THROTTLE STICKS,C AN'T GET IT TO RELEASE . CAUSE OF PROBLEM IS UNKNOWN.
NHTSA complaint #811472 — an unverified report by a vehicle owner.