2004 Chevrolet Avalanche 1500 brake problems

SERVICE BRAKES

The brake pressure modulator valve leaks the transmission has problems and service airbags is on

NHTSA complaint #11583451 — an unverified report by a vehicle owner.

SERVICE BRAKES

VEHICLE LOOSES POWER AND BRAKES GO OUT THEN DIES,DOESN'T MATTER SPEED. IF SLOWING DOWN AND PRESS THE BRAKES, THE LOCKS, LIGHTS, AND SECURITY GOES CRAZY. THIS IS DANGEROUS AS IT IS IN INTERSECTIONS AND CAUTION FOR COLLISION. THE VEHICLE HAS TO BE OFF FOR A TIME FRAME AND RESTARTS FINE AND CAN GO. HAPPENED WHEN COMING FROM RAMP AND IN MIDDLE OF ROAD WITH SEMI TRUCK COMING DOWN BY US.

NHTSA complaint #11407052 — an unverified report by a vehicle owner.

SERVICE BRAKES

THIRD BRAKE LINE FAILURE DUE TO CORROSION. AREAS OF FAILURE ARE HIDDEN FROM VIEW ABOVE OTHER COMPONENTS. UPON BRAKE LINE FAILURE, BACKUP BRAKING WAS INOPERATIVE IN ALL CASES. VEHICLE WAS ON A CITY STREET IN MOTION ATTEMPTING TO STOP. BRAKES FAILED SUDDENLY IN ALL CASES. BRAKES WERE VERY NOTICIBLY INOPERATIVE BEFORE ANY INDICATION ON DASH BOARD. PUMPING THE PEDAL DID NOTHING- THE PEDAL WENT TO THE FLOOR. WAS TOLD MANUFACTURER NO LONGER SUPPLIES BRAKE LINES FOR THIS VEHICLE.

NHTSA complaint #11384482 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. WHILE DRIVING APPROXIMATELY 45 MPH AND MAKING A LEFT TURN, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC BRAKE PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V043000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 250,000.

NHTSA complaint #11074968 — an unverified report by a vehicle owner.

SERVICE BRAKES

THE ABS SYSTEM ENGAGES AT LOW SPEEDS WHEN STOPPING ON DRY PAVEMENT. GENERALLY THE CONDITION IS LIMITED TO SPEEDS UNDER 10 MPH WHEN PARKING OR STOPPING AT STOP SIGNS. THIS CONDITION DISENGAGED THE BREAKS AND CAUSED THE VEHICLE TO MOVE BEYOND THE TRAFFIC CONTROL SIGNAL AT A FOUR WAY INTERSECTION, NEARLY RESULTING IN A SERIOUS SIDE IMPACT COLLISION.

NHTSA complaint #11065964 — an unverified report by a vehicle owner.

SERVICE BRAKES

ABS BRAKE WENT OUT ABOUT 8 YEARS AGO BEING TOLD BY SOME MECHANICS NO POINT IN REPAIRING IT SAME THING WILL HAPPEN AGAIN SEEMS THAT IS A PROBLEM WITH THIS VECHILE WHEN IT WENT OUT I HAD 50 000 MILES AND THE 36000 MILE AND 3 YEAR WARRANITY HAS ALREADY PASSED I HEARD A FEW WEEKS AGO THAT YOU ALL HAD A RECALL BUT I WAS NEVER NOTIFIED THE VECHILE HAD BEEN PARKED AT A MALL WHEN I STARTED TO LEAVE THEIR THE LIGHT AND WARNING ALARM CAME ON

NHTSA complaint #11012612 — an unverified report by a vehicle owner.

SERVICE BRAKES

ALL THE FRAME IS RUSTED AND ALL BRAKE LINES AND FUEL LINES, AND FRONT END PARTS RUSTED

NHTSA complaint #10966178 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. WHILE ATTEMPTING TO STOP AT A TRAFFIC LIGHT, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO IMMEDIATELY STOP THE VEHICLE. THE CONTACT WAS ABLE TO STOP THE VEHICLE. THE CONTACT NOTICED THAT A BRAKE LINE WAS SEVERELY CORRODED, WHICH CAUSED A FRACTURE IN THE BRAKE LINE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT REPAIRED. THE CONTACT STATED THAT SEVERAL BRAKE LINES WERE PREVIOUSLY REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 141,000.

NHTSA complaint #10875970 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. THE CONTACT STATED THAT WHEN THE VEHICLE WAS TURNED OFF, FUEL LEAKED FROM THE FUEL LINES AND A FUEL ODOR EMITTED INTO THE VEHICLE WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE BRAKE PEDAL BECAME EXTREMELY DIFFICULT TO DEPRESS AS THE ABS WARNING LIGHT ILLUMINATED. THE CONTACT ALSO MENTIONED THAT THE SEAT BELTS FAILED TO SECURE AND RETRACT PROPERLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP MODULAR ASSEMBLY, MODULE KIT AND FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 06E043000 (FUEL SYSTEM, GASOLINE), 05V163000 (SEAT BELTS), 05V043000 (SERVICE BRAKES, HYDRAULIC). THE APPROXIMATE FAILURE MILEAGE WAS 144,000.

NHTSA complaint #10809066 — an unverified report by a vehicle owner.

SERVICE BRAKES

MY FAMILY AND I WAS TRAVELING ON A BUSY ROAD AT 45 MPH, WHEN WE HAD TO COME TO A STOP AND OUR BRAKES DID NOT WORK. WE ALMOST SLAMMED IN THE BACK OF THE CAR THAT WAS INFRONT OF US. MY HUSBAND HAD TO PUSH THE BRAKE PEDAL ALL THE WAY DOWN TO THE FLOOR AND TURN TOWARD THE GRASS SHOULDER. THANK GOD NO ONE WAS HURT. MY HUSBAND CHECKED UNDER THE VEHICLE AND SAW THAT THERE WAS BREAK FLUID RUNNING OUT OF THE BRAKE LINE. THERE WERE NO WARNING LIGHTS OR WARNING SOUNDS THAT OUR VEHICLE MADE UNTIL AFTER HE STARTED THE VEHICLE AGAIN AND THEN THE VEHICLE GAVE A WARNING SOUND AND A WARNING LIGHT. WE ARE CONTACTING OUR MECHANIC TOMORROW BECAUSE THIS HAPPENED AFTER 6PM. I HAVE BEEN READING THE OTHER COMPLAINTS ON THE AVALANCHE'S BREAK LINES AND MY HUSBAND SAID THAT I SHOULD ALSO FILE ONE.

NHTSA complaint #10734396 — an unverified report by a vehicle owner.

SERVICE BRAKES

YESTERDAY,JULY 4TH 2015 MY 2004 AVALANCHE; WITH ONLY 70K MILES , THE BRAKES FAILED. IT WAS DUE TO A RUSTED BLOWN OUT BRAKE LINE. I HAD NO BRAKES DRIVING ON A MOUNTAINOUS ROAD. I THOUGHT I WAS ALONE IN THIS FAILURE BUT AFTER INTERNET SEARCHING I FIND THIS IS COMMON PROBLEM WITH THIS VINTAGE AND MODEL. I TAKE VERY GOOD CARE OF MY VEHICLES; UNDERBODY WASHING DURING INCLEMENT WINTER CONDITIONS , I WAS APPALLED AT THE UNDERBODY RUST. HAVING OTHER VEHICLES OF SIMILIAR AGE AND MILEAGE WITH NO RUST, I FELT GM HAS USED INFERIOR MATERIALS. GM SHOULD STAND UP AND ADMIT THEIR USE OF SUBSTANDARD MATERIALS AND OFFER REMEDY. THEY SHOULD KNOW THAT AS A CONSUMER IF THEY DON'T I'LL NEVER BUY ANOTHER GM PRODUCT.

NHTSA complaint #10732321 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. THE CONTACT STATED THAT FUEL FUMES EMITTED INTO THE INTERIOR OF THE VEHICLE. THE CONTACT STATED THAT THE ABS WARNING LAMP FLASHED RANDOMLY AND THE BRAKE PEDAL BECAME EXTREMELY DIFFICULT TO DEPRESS TO STOP THE VEHICLE. THE SEAT BELTS FAILED TO WORK PROPERLY TO SECURE AND RETRACT. THE VEHICLE WAS TAKEN TO A REPAIR SHOP AND THE FUEL LINES WERE REPLACED; HOWEVER, THE FAILURE RECURRED. THE DEALER REPLACED THE CABLES ASSOCIATED WITH THE TAILGATE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 06E043000 (FUEL SYSTEM, GASOLINE), 05V163000 (SEAT BELTS), 05V043000 (SERVICE BRAKES, HYDRAULIC) AND 04V129000 (STRUCTURE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 8/17/15

NHTSA complaint #10724271 — an unverified report by a vehicle owner.

SERVICE BRAKES

THE VEHICLE'S ABS AND BRAKE LIGHTS ARE ON. I TOOK THE VEHICLE IN FOR REPAIR AND A STATE INSPECTION. THE PART TO REPAIR THE ABS AND BRAKE LIGHT ARE ON NATIONAL BACK ORDER WITH NO DEFINITE AVAILABILITY DATE. THE TRUCK IS NOT USABLE BECAUSE OF THE FAILED STATE INSPECTION.

NHTSA complaint #10712208 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE FAILED TO STOP WHEN THE BRAKE PEDAL WAS DEPRESSED TO THE FLOOR. THE CONTACT PUMPED THE BRAKE PEDAL AND THE VEHICLE CAME TO A STOP. THE CONTACT EXITED THE VEHICLE AND DISCOVERED BRAKE FLUID LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE BRAKE LINES WERE RUSTED AND FRACTURED. AS A RESULT, THE BRAKE LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,000.

NHTSA complaint #10705912 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. WHILE DRIVING AT 8 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND AND THE BRAKE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BRAKE LINE NEEDED TO BE REPLACED DUE TO CORROSION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

NHTSA complaint #10704968 — an unverified report by a vehicle owner.

SERVICE BRAKES

UPON START UP OF THE TRUCK, THE ABS LIGHT STAYED ILLUMINATED AND STARTED CHIMING AT ME. EVERYTIME I START THE TRUCK THIS HAPPENS. I HAD MY BRAKES INSPECTED AND THEY WERE FINE. I CURRENTLY DO NOT HAVE ABS. I TOOK THE TRUCK TO A MECHANIC THIS LAST WEEK AND HAD IT LOOKED INTO. IT IS A KNOWN PROBLEM WITH THE CHEVY AVALANCHE AND THEY INFORMED ME THAT THERE IS A PART FOR THIS PROBLEM BUT IT IS ON INDEFINITE BACKORDER. WHAT AND HOW DOES THAT HAPPEN? THE ABS SYSTEM IS THROWING FAULT CODES STOPPING IT FROM WORKING PROPERLY BUT THERE IS NOT A PART TO REPLACE IT. PER CHEVY!

NHTSA complaint #10692628 — an unverified report by a vehicle owner.

SERVICE BRAKES

I WAS GETTING IN MY TRUCK TO GO SHOPPING AND AFTER DRIVING FOR A SHORT DISTANCE I NOTICE MY BRAKE PEDAL WENT TO THE FLOOR CAUSING ME TO HEAD INTO TRAFFIC ALMOST CAUSING A ACCIDENT. WHEN I GOT THE TRUCK HOME I NOTICE DRIPPING OF BRAKE FLUID ON DRIVER SIDE DOOR. FURTHER CHECKING I DISCOVER MY BRAKE LINES IS RUSTING AND CAUSE A MAJOR LEAKS UNDERNEATH MY TRUCK.

NHTSA complaint #10681038 — an unverified report by a vehicle owner.

SERVICE BRAKES

AFTER APPLYING PRESSURE TO BRAKE PEDAL, THE VEHICLE FAILED TO STOP AND THE BRAKE PEDAL WAS TO THE FLOOR. ONCE THE TRUCK COASTED TO A STOP, WE PULLED TO THE SIDE OF THE ROAD AND FOUND BRAKE FLUID LEAKING UNDERNEATH THE TRUCK. WE HAD THE TRUCK TOWED TO OUR LOCAL DEALERSHIP. THE DEALERSHIP REPLACED ALL METAL BRAKE LINES THAT LEFT US WITH A BILL OF OVER $2,000 FOR PARTS AND LABOR. THE ENTIRE TRUCK IS IN BEAUTIFUL CONDITION AND RUST FREE EXCEPT FOR THE FAULTY BRAKE LINES! GM SHOULD RECALL THIS ISSUE.

NHTSA complaint #10672600 — an unverified report by a vehicle owner.

SERVICE BRAKES

I JUST PICKED UP SOME MULCH FOR AROUND MY HOUSE WITH MY 8 YEAR OLD SON AND I GOT HOME AND I WAS BACKING UP TO UNLOAD THE MULCH AND WHEN I WENT TO HIT THE BRAKES THE PEDAL WENT TO THE FLOOR AND THE BRAKES LIGHT CAME ON, LUCKILY I WASN'T DRIVING DOWN THE ROAD WHEN IT HAPPENED. THE MECHANIC SAID THE BRAKE LINE WAS RUSTED OUT, THAT SHOULDN'T BE HAPPENING ON A 5 YEAR OLD VEHICLE WITH ONLY 39,000 MILES ON IT.. IT ALSO HAPPENED A SECOND TIME NOT LONG AFTER THAT, I CANT REMEMBER THE EXACT DATE ON THAT ONE EITHER. THERE HAS BEEN LOT OF PROBLEMS WITH THIS VEHICLE : HEATING ,BRAKES SENSOR, WHEEL BEARINGS, E BRAKE PROBLEMS,FUEL PUMP ROT, WATER PUMP, RUSTED UNDER CARRIAGE, O2 SENSOR, MULTIPLE BRAKE AND ROTOR REPLACEMENTS [4], NOISE IN STEERING COLUMN AND FRONT END, GAUGE CLUSTER REPLACEMENT, WINDSHIELD FLUID RESERVOIR LEAKS,POWER WINDOW MOTORS, DOME OVERRIDE LIGHT, DEAD BATTERY PROBLEMS, I WENT THRU 4 BATTERIES IN 5 YEARS, IT JUST KEPT GOING DEAD IF I DIDN'T USE THE VEHICLE FOR A COUPLE DAYS. I ONLY HAVE 72,000 MILES ON THE VEHICLE NOW AS OF 12/19/2014. LOTS OF PROBLEMS FOR A $ 50,000 TRUCK. ILL NEVER BUY A CHEVY AGAIN.

NHTSA complaint #10667235 — an unverified report by a vehicle owner.

SERVICE BRAKES

APPLIED BRAKES AND BRAKE PEDDLE WENT TO THE FLOOR. I SWERVED TO THE RIGHT TO AVOID AN ACCIDENT .GOT OUT OF VEHICLE AND SAW THE BRAKE LINES WERE RUSTED AND HAD RUPTURED.

NHTSA complaint #10649058 — an unverified report by a vehicle owner.

SERVICE BRAKES

ON THE ABOVE LISTED DATE AT APPROXIMATELY 0730 HOURS, I WAS RUNNING ERRANDS AFTER GETTING OFF WORK AND BEFORE RETURNING HOME. I STARTED TO DRIVE DOWN A SLOPED ROAD APPROACHING A TRAFFIC LIGHT AT A FOUR WAY INTERSECTION. THE TRAFFIC LIGHT TURNED RED AS I WAS APPROACHING IT AND I APPLIED THE BRAKES WHILE TRAVELING AT 30 MPH. UPON APPLICATION OF THE BRAKES, THE PEDAL WENT STRAIGHT TO THE FLOOR WITH ZERO FUNCTIONING OF THE BRAKE SYSTEM. THE BRAKE LIGHT THEN ILLUMINATED AND A NOTIFICATION CAME ACROSS TO "SERVICE BRAKE SYSTEM". I DOWN SHIFTED DOWN FROM "D" TO "3-2-1", ALL THE WHILE PUMPING THE BRAKES. IT WASN'T UNTIL I REACHED AROUND 5 MPH THAT IT SEEMED THAT THE BRAKES HAD ANY AFFECT, AND I CAME TO A STOP IN THE MIDDLE OF THE INTERSECTION. SINCE I WAS ROUGHLY A MILE FROM MY HOUSE AT THIS POINT I LIMPED MY TRUCK HOME, MOSTLY USING GEARING "2" AND "1". I PARKED THE TRUCK, ENTERED MY HOUSE AND INFORMED MY WIFE AS TO WHAT HAPPENED. THEN I RETURNED TO THE TRUCK TO FIND A PUDDLE OF FLUID UNDER AND AROUND THE DRIVERS DOOR. I CHECKED THE MASTER CYLINDER RESERVOIR AND IT WAS COMPLETELY DRAINED AT THIS POINT. THERE IS NO DOUBT IF SOMEONE WOULD HAVE BEEN IN FRONT OF ME OR COMING THROUGH THE INTERSECTION AT THE TIME THIS INCIDENT OCCURRED I WOULD HAVE BEEN INVOLVED IN AN ACCIDENT. AT NO TIME PRIOR TO THIS HAVE I HAD ANY INDICATION OF THE BRAKES GOING BAD, IE: BRAKE WARNING LIGHT OR ABS, SOFT BRAKE PEDAL OR FLUID LOSS. IT SEEMS AS IF THIS HAPPENED ALL AT ONCE. THE VEHICLE WAS THEN TOWED TO A MECHANICS GARAGE LATER ON THAT DAY TO BE REPAIRED.

NHTSA complaint #10616161 — an unverified report by a vehicle owner.

SERVICE BRAKES

TRAVELING APPX 35MPH APPLIED BRAKES TO MAKE LEFT TURN, PEDDLE WENT TO THE FLOOR. NO TRAFFIC IN FRONT OF ME OR WE WOULD HAVE HIT THEM. BRAKE FLUID POURING FROM UNDER TRUCK, UNDER DRIVER SIDE DOOR AREA. BRAKE LINE RUPTURED DUE TO RUST. LOCAL MECHANIC REPLACED RUPTURED LINE. I INSPECTED ALL LINE FEW MONTHS LATER AND FOUND THEY WERE ALSO IN BAD SHAPE DUE TO RUST. TOOK TO LOCAL GM DEALER $550 TO REPLACE ALL BRAKE LINE. GM SHOULD HAVE PICKED UP COST FOR NOT USING NON-CORROSIVE BRAKE LINE. VERY LUCK ME AND MY KID DIDN'T GET HURT.

NHTSA complaint #10609527 — an unverified report by a vehicle owner.

SERVICE BRAKES

I CAME AROUND A CURVE AND THERE WAS ROAD WORK GOING ON AND HAD TO STOP REAL QUICK. THE BRAKE PEDAL WENT TO THE FLOOR. ALL THE BRAKE LINES WERE ROTTED. I HAD TO CHANGE EVERY BRAKE LINE ON MY TRUCK.

NHTSA complaint #10576007 — an unverified report by a vehicle owner.

SERVICE BRAKES

WAS HOOKING UP MY TRAILER TO TOW. HAD MY DAUGHTER STEP ON THE BRAKES TO CHECK THE LIGHTS. THE PEDAL WENT TO THE FLOOR AND ALARM WENT OFF. FOUND BRAKE FLUID SQUIRTING ONTO THE GROUND. HAD TO HAVE ALL THE BRAKE LINES REPLACED DUE TO RUST BEHIND THE DRIVERS FRONT WHEEL. FOUND OUT THIS IS A COMMON PROBLEM WITH THIS TYPE AND ALL THE CHEVY TRUCKS. ALL IN THE SAME AREA.

NHTSA complaint #10568340 — an unverified report by a vehicle owner.

SERVICE BRAKES

I WAS APPROACHING AN INTERSECTION WHERE THE LIGHT WAS CHANGING AND WHEN I APPLIED THE BRAKES, THE PEDAL WENT TO THE FLOOR AND I COULDN'T SLOW DOWN. I ENDED UP GOING THROUGH THE RED LIGHT WITH MY SON IN THE CAR; LUCKILY WE DIDN'T GET STRUCK. I HAD TO UTILIZE THE EMERGENCY BRAKE TO STOP ON THE SHOULDER OF THE ROAD. I LOOKED UNDER THE TRUCK AND SAW BRAKE FLUID POURING OUT OF A RUSTED BRAKE LINE UNDER THE DRIVER'S SIDE. I HAD TO HAVE THE TRUCK TOWED TO A DEALERSHIP. I HAD A FULL INSPECTION ON 12/23/13 AT HUDSON BUICK PONTIAC GMC IN POUGHKEEPSIE, NY AND ASKED THEM TO SPECIFICALLY CHECK THE BRAKES, WHICH THEY SAID WERE FINE; I GUESS THEY DON'T CHECK THE LINES DURING AN INSPECTION. I HAVE READ THAT THIS HAS OCCURRED ON SEVERAL GM VEHICLES. DOES SOMEONE HAVE TO DIE BEFORE THERE IS SOME SORT OF ACTION TAKEN TO CORRECT THIS PROBLEM?

NHTSA complaint #10566674 — an unverified report by a vehicle owner.

SERVICE BRAKES

GOING DOWN MY DRIVEWAY PUSHED ON MY BRAKES AN IT WENT TO THE FLOOR,UNDERNEATHTHE TRUCK BY THE DRIVERS DOOR THE FRAME WAS VERY WET WITH BRAKE FLUID,THE BRAKE LINE HAD BLOWN.

NHTSA complaint #10545624 — an unverified report by a vehicle owner.

SERVICE BRAKES

BOTH BRAKE LINES FROM MASTER CYLINDER TO ABS MODULE FAILED RESULTING IN NO BRAKES DUE TO EXCESS RUST ON LINES.CAR FAILED INSPECTION 1 AND SECOND YEAR DUE TO ROTTED ROTORS. ALSO RECENTLY FUEL LEAKING FROM TOP OF FUEL TANK AND FUEL LINES FROM FUEL PUMP MODULE BADLY RUSTED. WORSE YET FRAME IS DISINTEGRATING. DUE CHEAP STEEL. MY 1998 CHEVY ASTRO IS DRIVEN AND STORED IN LIKE CONDITIONS AND YET DOESN'T SHOW THE RUST LIKE THE AVALANCHE. THANKFULLY I WAS NOT ON THE HIGHWAY WHEN LINES BLEW. AVALANCHE IS THE FIRST VEHICLE TO HAVE SO MANY SAFETY RELATED PROBLEMS DUE TO DEFECTIVE MATERIALS. DIDN'T REPORT EARLIER THINKING IT WAS AN ISOLATED CASE.

NHTSA complaint #10542971 — an unverified report by a vehicle owner.

SERVICE BRAKES

BRAKE LINE RUPTURED FROM RUST. CHEV DEALER WANTED $2600 TO REPLACE/FIX 2004 CHEV AVALANCHE BRAKE LINES.

NHTSA complaint #10538280 — an unverified report by a vehicle owner.

SERVICE BRAKES

I WAS APPROACHING A STOP SIGN ON A RESIDENTIAL STREET, PUSHED THE BRAKE PEDAL AND LOST BRAKING ABILITY. THE PEDAL TRAVELED TO THE FLOOR, WHEN THAT HAPPENED THE SERVICE LIGHT CAME ON WITH AN AUDIBLE ALARM. I WAS ABLE TO GET THE TRUCK STOPPED ON THE SIDE OF THE ROAD. A LARGE AMOUNT OF SMOKE WAS COMING OUT UNDERNEATH THE HOOD FROM THE SPRAYING BRAKE FLUID. UPON INSPECTION IT WAS DETERMINED THAT THERE WAS A HOLE IN THE RIGHT FRONT BRAKE LINE. FURTHER INSPECTION REVEALED ALL BRAKE LINES TO BE IN SIMILAR CONDITION WITH A POTENTIAL FAILURE IMMINENT. ALL BRAKE LINES NEED TO BE REPLACED AND WILL COST OVER $1,000. THE TRUCK IS NOT USED EXCESSIVELY AND HAS LOW MILEAGE.

NHTSA complaint #10510783 — an unverified report by a vehicle owner.