2002 Chevrolet Cavalier window and wiper problems

VISIBILITY

MULTIPLE TIMES, THE WINDSHIELD WIPER FLUID WOULD NOT FLOW ONTO THE WINDSHIELD. I WOULD FILL THE WINDSHIELD WIPER FLUID TANK SEVERAL TIMES A MONTH. FINALLY, I NOTICED THAT THE DESIGN OF THE WINDSHIELD WIPER FLUIDS TUBING INTO THE WINDSHIELD WIPERS WAS FLAWED. THE TUBING IS ROUTED SO THAT IT PASSES THE WINDSHIELD WIPER TANK AND SEATS UP AGAINST THE HOT CAR BATTERY. AT THIS JUNCTURE, THE TUBING APPARENTLY HAD ROTTED AND MELTED, AND IT CREATED A HUGE HOLE IN THE TUBING. I DO NOT KNOW WHY GENERAL MOTORS DECIDED TO PASS THE WINDSHIELD WIPER TANK, AND SEAT THIS TUBING UP AGAINST THE BATTERY, AND THEN GO DOWN AGAIN, AND FINALLY FIT INTO THE BOTTOM VALVE OF THE WINDSHIELD WIPER TANK, BUT IT SEEMS POINTLESS AND STUPID AND A DEFINITE DESIGN FLAW!!! NOW, I HAVE TO PAY TO HAVE THIS TUBING REPAIRED AND PROBABLY REROUTED THE SIMPLER ROUTE, WHICH WOULD ALLOW IT TO BYPASS THE BATTERY, COMPLETELY, INSTEAD OF PRACTICALLY WRAPPING IT AROUND THE BATTERY!!!

NHTSA complaint #10425297 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

THE WINDOW MOTORS HAVE BURNED OUT ON BOTH OF MY AUTOMATIC WINDOWS AT A LOW MILEAGE. THE PASSENGER SIDE MOTOR HAD TO BE REPLACED AT 35,000 MILES AND NOW THE DRIVER'S SIDE MUST BE REPLACED AT 60,000. I RARELY USE THE AUTOMATIC WINDOWS, SO I DON'T KNOW WHY THEY HAVE BOTH FAILED.

NHTSA complaint #10221746 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

CHEVROLET CAVALIER, 4D SED....WHICH I TAKE VERY GOOD CARE OF 1.) RIGHT FRONT WINDOW WOULD NOT GO UP HAD TO HAVE RIGHT FRONT DOOR TRIM PANEL, MOVABLE GLASS R & I & REPLACE RIGHT FRONT DOOR POWER GLASS REGULATOR $399.48 (REPAIRED: 05/09/06) THEN 2.) LEFT RIGHT WINDOW WOULD NOT GO UP. ASKED SERVICE DEPT IS CHEVROLET AWARE OF THIS PROBLEM SINCE INTERNET SHOWING OTHERS WITH SAME PROBLEMS - THEY SAY NO! "C/S WINDOW INOP LEFT REAR, 60005 LR POWER WINDOW MOTOR INTERNAL PROBLEM 1.0 REMOVE & REPLACE LR POWER WINDOW MOTOR" $356.95. (REPAIRED: 01/13/07). NOW 3.) (02/12/07) THE FLT WINDOW IS STARTING TO STOP AGAIN, JUST AS THE LAST TWO REPAIRS STARTED....I'M NOT THE ONLY ONE WITH THIS PROBLEM... GO ON LINE SEE OTHERS WITH THE SAME PROBLEMS YET CHEVROLET SAYS THERE IS NOTHING WRONG.... WHY CAN'T MANUFACTURER'S STAND BEHIND THEIR PRODUCT. IF THIS WAS AN ISOLATED PROBLEM, I WOULD UNDERSTAND BUT SOMETHING IS WRONG SO THAT I CAN NOT TAKE THE CHANCE OF ROLLING DOWN MY WINDOW SINCE I CAN NOT AFFORD, AS A SINGLE PARENT WITH A DISABLED CHILD TO REPAIR ANOTHER WINDOW. PLEASE, DO SOMETHING.

NHTSA complaint #10182624 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

HAVE HAD TO REPLACE POWER WINDOW MOTORS A TOTAL OF 5 TIMES. LESS THAN 80,000 MILES. ONE DRIVER. NO ABUSE.

NHTSA complaint #10167519 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

DT*: THE CONTACT STATED THE MOTORIZED WINDOWS DID NOT MOVE UP OR DOWN ON TWO OCCASIONS. THE DEALERSHIP DETERMINED A NEW MOTOR WAS NEEDED TO REPAIR THE POWER WINDOWS. *NM UPDATED 8/29/2006 -

NHTSA complaint #10165539 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

PURCHASED CAR IN MARCH 2003. IN NOV. 2003, FUEL PUMP AND HEAD GASKETS WENT OUT AND NEEDED REPLACING. IN SEPT. 2004 REPLACED DRIVER SIDE WINDOW REGULATOR. IN DEC. 2004 REPLACED BOTH REAR WINDOW REGULATORS. NOW, IN JUNE 2005, FRONT PASSENGER WINDOW REGULATOR GONE BAD AND NEEDS REPLACING. SURE HAVE PUT A LOT OF WORK IN A CAR THAT IS NOT VERY OLD. 4 BAD WINDOW REGULATORS IS JUST RIDICULOUS!!!

NHTSA complaint #10125658 — an unverified report by a vehicle owner.

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW

I GOT THE CAR BRAND NEW AND I HAVE ALWAYS HAD PROBLEMS STARTING THE CAR. IT IS NOT EVERYTIME BUT SOMETIMES I HAVE TO TRY 4 OR 5 TIMES JUST TO GET IT TO START. MY SEAT BELTS NO LONGER RETRACT. I'M NOT A FAT PERSON , AND I DON'T KNOW ANYONE BIG ENOUGH TO RUIN MY SEAT BELT RETRACTORS. MY REAR DEFROSTER BARELY WORKS, AND MY PASSENGER SIDE POWER WINDOW MOTOR ALREADY WENT BAD. I AM VERY DISSATISFIED WITH THIS CAR.

NHTSA complaint #10118443 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

I GOT THE CAR BRAND NEW AND I HAVE ALWAYS HAD PROBLEMS STARTING THE CAR. IT IS NOT EVERYTIME BUT SOMETIMES I HAVE TO TRY 4 OR 5 TIMES JUST TO GET IT TO START. MY SEAT BELTS NO LONGER RETRACT. I'M NOT A FAT PERSON , AND I DON'T KNOW ANYONE BIG ENOUGH TO RUIN MY SEAT BELT RETRACTORS. MY REAR DEFROSTER BARELY WORKS, AND MY PASSENGER SIDE POWER WINDOW MOTOR ALREADY WENT BAD. I AM VERY DISSATISFIED WITH THIS CAR.

NHTSA complaint #10118443 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

THE WINDOWS FAILED TO GO UP OR DOWN ON THEIR OWN. DRIVER PRESSED THE REMOTE CONTROL AND WAS ABLE TO DRIVE VEHICLE TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE ELECTRICAL WIRING INSIDE OF THE DOOR PANEL NEEDED TO BE REPLACED.

NHTSA complaint #10111489 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

THE MOTOR IN THE DRIVERS SIDE WINDOW IS NOT WORKING. ALTHOUGH MY VEHICLE HAS 60,000 MILES ON IT, I DO NOT FEEL THAT AFTER 2 YEARS THE MOTOR SHOULD BE BAD.

NHTSA complaint #10104108 — an unverified report by a vehicle owner.

VISIBILITY:WINDSHIELD WIPER/WASHER

ENGINE CHECK LIGHT STAYED ON. WHEN DRIVING LIGHTS TURNED OFF THEN FLICKERED. ALSO, WINDSHIELD WIPERS AND AUTOMATIC LOCKS OPERATED POORLY. VEHICLE WAS TAKEN TO DEALERSHIP ON SEVERAL OCCASIONS FOR THE SAME PROBLEMS.*AK ON FOR OCCASIONS CONSUMER WAS DRIVING WHEN VEHICLE HEADLIGHTS WENT OUT. ANOTHER PROBLEM CONSUMER IS EXPERIENCING IS THE WINDSHIELD WIPERS COME TO A COMPLETE STOP WHILE IN USE. THERE IS ALSO A PROBLEM WITH THE DOOR LOCKS. VEHICLE HAS BEEN SERVICED ON VARIOUS OCCASIONS FOR ELECTRICAL PROBLEMS. DURING ONE SERVICE VISIT THE BODY CONTROL MODULE WAS REPLACED AND THE THEFT DETERRENT SYSTEM WAS PROGRAMMED. EVEN AFTER SEVERAL SERVICE VISITS VEHICLE STILL EXPERIENCING PROBLEMS WITH WINDSHIELD WIPERS, DOOR LOCKS, TURN SIGNALS, AND HAZARD LIGHTS.

NHTSA complaint #10050410 — an unverified report by a vehicle owner.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

SUN ROOF WAS REPLACED 3 TIMES BECAUSE IT DEVELOPED A LEAK WHEN IT RAINED OR WHEN VEHICLE WAS WASHED. THE LEAK WAS CAUSING THE INNER LINING OF THE ROOF TO DETERIORATE BECAUSE OF THE WATER INTAKE.

NHTSA complaint #10046391 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

POWER WINDOWS FAIL-THIS IS THE SECOND TIME WITH ONE YEAR THAT THE POWER WINDOW HAS FAILED, ORIGINALLY THE LEFT DRIVER'S SIDE WINDOW FAILED, HAD THE MOTOR REPLACED, NOW THE RIGHT FRONT PASSENGER HAS FAILED AND AT TIMES THE LEFT DRIVER'S WINDOW STOPS WORKING.

NHTSA complaint #10036990 — an unverified report by a vehicle owner.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

I WAS DRIVING 65 MPH DOWN THE HIGHWAY AND MY SUNROOF EXPLODED. GLASS WENT IN THE CAR AND OUT, THE GLASS THAT WAS LEFT IN THE SUNROOF WAS ALL POINTED UP . IT WAS AROUND 35-40 DEGREES NO RAIN/HAIL. DEALER SAYING A ROCK HIT IT, NO ROCK FOUND AND THE GLASS WOULD BE POINTED DOWN IF SOMETHING STRUCK IT.

NHTSA complaint #10000599 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

THIS CAR HAS HAD MANY ELECTRICAL PROBLEMS, WINDOWS, SUNROOF AND IGNITION. MR

NHTSA complaint #767844 — an unverified report by a vehicle owner.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

THIS CAR HAS HAD MANY ELECTRICAL PROBLEMS, WINDOWS, SUNROOF AND IGNITION. MR

NHTSA complaint #767844 — an unverified report by a vehicle owner.

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

CONSUMER STATES SINCE VEHICLE WAS PURCHASE THE WINDSHIELD WIPERS ARE INOPERATIVE, HAD VEHICLE SERVICED 3 TIMES, PROBLEM STILL ACCURS. NLM

NHTSA complaint #8019792 — an unverified report by a vehicle owner.