Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
510.2%
25,000 – 49,999 miles
12.0%
50,000 – 74,999 miles
918.4%
75,000 – 99,999 miles
1326.5%
100,000 – 149,999 miles
1632.7%
150,000+ miles
510.2%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Frontal crash test
Side barrier crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2005 Chevrolet Classic 4-DR.
—
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Oct 2005peak 7Sep 2017
Recalls on the 2005 Chevrolet Classic
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
05V054000
SUSPENSION:REAR
CERTAIN PASSENGER VEHICLES EQUIPPED WITH REAR SUSPENSION KNUCKLE BOLTS THAT ARE NOT TO SPECIFICATION AND COULD FRACTURE UNDER HIGH LOADS THAT CAN OCCUR IN SOME DRIVING CONDITIONS.
Risk: IF THE BOLT FRACTURE, THE REAR SUSPENSION LINKAGE COULD DETACH FROM THE KNUCKLE AND THE REAR WHEEL WOULD BE ABLE TO TURN INBOARD OR OUTBOARD. SUDDEN CHANGES IN VEHICLE HANDLING COULD OCCUR, PARTICULARLY AT HIGHER SPEEDS, AND THE DRIVER MAY NOT BE ABLE TO CONTROL THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 140,000 milesWahiawa, HICrashFire1 injured
AIR BAGS
AS I SLAMMED ON BRAKES CAR SHUT DOWN CAUSING STEERING TO LOCK AND BRAKES TO NOT FUNCTION WELL. I ENDED UP REAR ENDING PERSON IN FRONT. ALSO THE AIRBAG BURNED MY LEFT HAND.
NHTSA complaint #10780700 — an unverified report by a vehicle owner.
at 140,000 milesWahiawa, HICrashFire1 injured
UNKNOWN OR OTHER
AS I SLAMMED ON BRAKES CAR SHUT DOWN CAUSING STEERING TO LOCK AND BRAKES TO NOT FUNCTION WELL. I ENDED UP REAR ENDING PERSON IN FRONT. ALSO THE AIRBAG BURNED MY LEFT HAND.
NHTSA complaint #10780700 — an unverified report by a vehicle owner.
at 110,000 milesCross City, FLCrash3 injured
STEERING:HYDRAULIC POWER ASSIST SYSTEM
TL* THE CONTACT OWNS A 2005 CHEVROLET CLASSIC. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION SWITCH AND THE VEHICLE STALLED ON SEVERAL OCCASIONS. THE CONTACT STATED THAT WHILE TRAVELING ON A MAJOR HIGHWAY AT APPROXIMATELY 50 MPH, THE POWER STEERING FAILED AND THE VEHICLE STALLED. THE CONTACT LOST CONTROL OF THE VEHICLE AND THE VEHICLE TRAVELED OFF THE ROADWAY AND ROLLED OVER THREE TIMES. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT, THE FRONT PASSENGER AND A SECOND PASSENGER BECAME TRAPPED IN THE VEHICLE. THE POLICE ARRIVED AND HAD TO REMOVE ALL THREE OF THE PASSENGERS FROM THE VEHICLE WHICH WAS TURNED OVER ON THE FRONT PASSENGERS SIDE. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED INJURIES TO THE HEAD, THE RIGHT ARM ROTATOR CUP, AND A BRUISED BREAST AREA. THE FRONT PASSENGER SUSTAINED PAINS AND BRUISES IN THE PELVIC AREA AND THE THIRD PASSENGER RECEIVED MINOR ABRASIONS. THE CONTACT INDICATED THAT ALL THREE OF THE OCCUPANTS OF THE VEHICLE REQUIRED MEDICAL ATTENTION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
NHTSA complaint #10653459 — an unverified report by a vehicle owner.
at 110,000 milesCross City, FLCrash3 injured
ELECTRICAL SYSTEM:IGNITION:SWITCH
TL* THE CONTACT OWNS A 2005 CHEVROLET CLASSIC. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION SWITCH AND THE VEHICLE STALLED ON SEVERAL OCCASIONS. THE CONTACT STATED THAT WHILE TRAVELING ON A MAJOR HIGHWAY AT APPROXIMATELY 50 MPH, THE POWER STEERING FAILED AND THE VEHICLE STALLED. THE CONTACT LOST CONTROL OF THE VEHICLE AND THE VEHICLE TRAVELED OFF THE ROADWAY AND ROLLED OVER THREE TIMES. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT, THE FRONT PASSENGER AND A SECOND PASSENGER BECAME TRAPPED IN THE VEHICLE. THE POLICE ARRIVED AND HAD TO REMOVE ALL THREE OF THE PASSENGERS FROM THE VEHICLE WHICH WAS TURNED OVER ON THE FRONT PASSENGERS SIDE. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED INJURIES TO THE HEAD, THE RIGHT ARM ROTATOR CUP, AND A BRUISED BREAST AREA. THE FRONT PASSENGER SUSTAINED PAINS AND BRUISES IN THE PELVIC AREA AND THE THIRD PASSENGER RECEIVED MINOR ABRASIONS. THE CONTACT INDICATED THAT ALL THREE OF THE OCCUPANTS OF THE VEHICLE REQUIRED MEDICAL ATTENTION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
NHTSA complaint #10653459 — an unverified report by a vehicle owner.
at 76,000 milesAustin, TXCrash
STEERING
TL* THE CONTACT OWNS A 2005 CHEVROLET CLASSIC. THE CONTACT STATED THAT THE DRIVER WAS TRAVELING 30 MPH AND ATTEMPTING A RIGHT TURN WHEN THE STEERING WHEEL SEIZED WITHOUT WARNING. THE DRIVER THEN CRASHED INTO A CURB. THE DRIVER DID NOT SUSTAIN ANY INJURIES AND THE POLICE WERE NOT CONTACTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 76,000 AND THE CURRENT MILEAGE WAS 77,000.
NHTSA complaint #10492034 — an unverified report by a vehicle owner.
Chapin, SCCrash2 injured
AIR BAGS:FRONTAL
2005 CHEVY MALIBU WAS IN FRONT END COLLISION, NO AIR BAGS CAME OUT NOR DID SEAT BELTS HOLD, INJURES TO BOTH PASSENGERS.
NHTSA complaint #10262680 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 49,500 milesSacramento, CA
ELECTRICAL SYSTEM
I AM HAVING PROBLEMS WITH THE THEFT BYPASS SYSTEM, ON MY 2005 CHEVY CLASSIC. SEVERAL MONTHS AGO, I RECEIVED A RECALL NOTICE IN THE MAIL. IT WAS FOR THE IGNITION KEY ROTATION. WHEN I BROUGHT MY CAR INTO THE DEALERSHIP, I TOLD THEM THAT I WAS HAVING PROBLEMS WITH THE CAR (SUDDENLY) DYING. I TOLD THEM THAT IT HAD DIED WHEN I WAS ON THE FREEWAY (TWICE), WHILE DRIVING ON THE CITY STREETS, AND IN MY DRIVEWAY. I WAS TOLD THAT THE RECALL WOULD FIX THE PROBLEM. UNFORTUNATELY, THE PROBLEM PERSISTS. THIS PAST FRIDAY, LATE IN THE EVENING, MY CAR (SUDDENLY) DIED IN THE MIDDLE OF A BUSY INTERSECTION. THROUGH THE GRACE OF GOD, THE DRIVERS AROUND ME WERE PAYING ATTENTION -- I COULD HAVE BEEN IN AN AWFUL ACCIDENT. SEVERAL PEOPLE, KINDLY, PUSHED MY CAR INTO A PARKING LOT. WHILE IN THE PARKING LOT, A MECHANIC STOPPED TO LOOK AT THE CAR. HE TOLD ME THAT MY CHEVY IS WELL KNOWN FOR HAVING A DEFECTIVE PASS-LOCK SENSOR SECURITY SYSTEM, WHICH CAUSES THE VEHICLE TO SHUT DOWN SUDDENLY. THE MECHANIC STATED THAT THERE MIGHT BE A RECALL. YET, I HAVEN'T BEEN ABLE TO FIND THAT INFORMATION -- GM IS NOT HELPFUL! AFTER AN HOUR OR SO, THE CAR STILL WOULDN'T START. I HAD A FRIEND TOW ME HOME. I AM OLDER AND DISABLED AND MUST HAVE A RELIABLE VEHICLE. I NEED TO BE ABLE TO DRIVE TO MY DOCTOR'S APPOINTMENT, VIA THE FREEWAY. YET, I HAVE (ALREADY) EXPERIENCED MY CAR (SUDDENLY) DYING ON THE FREEWAY. I AM TERRIFIED OF GETTING INTO AN ACCIDENT AND (POSSIBLY) HURTING/KILLING MYSELF AND/OR SOMEONE ELSE. I, TRULY, BELIEVE THAT THIS DEFECT IS GM'S RESPONSIBILITY TO FIX FREE OF CHARGE. OR, PERHAPS THERE IS A RECALL THAT I'M UNAWARE OF? EITHER WAY, PLEASE HELP ME. I AM THANKING YOU IN ADVANCE.
NHTSA complaint #11021186 — an unverified report by a vehicle owner.
at 143,000 milesHolcombe, WI
STEERING
TL* THE CONTACT OWNS A 2005 CHEVROLET CLASSIC. WHILE DRIVING 30 MPH, THE CONTACT EXPERIENCED A LOSS OF STEERING ABILITY WITHOUT WARNING. THE CONTACT WAS ABLE TO REGAIN CONTROL AND TURN OFF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER, BUT THE DIAGNOSTIC RESULTS WERE NOT DISCLOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 143,000. THE VIN WAS NOT PROVIDED.
NHTSA complaint #10884891 — an unverified report by a vehicle owner.
at 117,247 milesWheeling, WV
VEHICLE SPEED CONTROL
I ARRIVED AT WORK AND WAS TOLD BY COWORKERS THAT MY BRAKE LIGHTS WERE STILL ON. THEY WOULD NOT SHUT OFF. I REMOVED THE NEGATIVE BATTERY TERMINAL TO AVOID DRAINING MY BATTERY. ON THE DRIVE HOME, AFTER RECONNECTING BATTERY, I DISCOVERED MY CRUISE CONTROL WAS NOT WORKING EITHER. I SAW ON THE INTERNET A RECALL (GM 13036) THAT COVERED THIS EXACT PROBLEM ON SEVERAL MODELS INCLUDING THE MALIBU WHICH MY CAR NEARLY IDENTICAL TO. UNFORTUNATELY IT DOES NOT COVER MY MODEL AND IT SHOULD! CLEARLY THIS IS A WIDESPREAD ISSUE AND 2005 CLASSIC SHOULD BE INCLUDED. I CURRENTLY AM DRIVING WITH THE LIGHTS STUCK ON AND HAVE TO DISCONNECT / CONNECT BATTERY TERMINAL EVERY TIME I DRIVE.
NHTSA complaint #10860398 — an unverified report by a vehicle owner.
at 117,247 milesWheeling, WV
SERVICE BRAKES
I ARRIVED AT WORK AND WAS TOLD BY COWORKERS THAT MY BRAKE LIGHTS WERE STILL ON. THEY WOULD NOT SHUT OFF. I REMOVED THE NEGATIVE BATTERY TERMINAL TO AVOID DRAINING MY BATTERY. ON THE DRIVE HOME, AFTER RECONNECTING BATTERY, I DISCOVERED MY CRUISE CONTROL WAS NOT WORKING EITHER. I SAW ON THE INTERNET A RECALL (GM 13036) THAT COVERED THIS EXACT PROBLEM ON SEVERAL MODELS INCLUDING THE MALIBU WHICH MY CAR NEARLY IDENTICAL TO. UNFORTUNATELY IT DOES NOT COVER MY MODEL AND IT SHOULD! CLEARLY THIS IS A WIDESPREAD ISSUE AND 2005 CLASSIC SHOULD BE INCLUDED. I CURRENTLY AM DRIVING WITH THE LIGHTS STUCK ON AND HAVE TO DISCONNECT / CONNECT BATTERY TERMINAL EVERY TIME I DRIVE.
NHTSA complaint #10860398 — an unverified report by a vehicle owner.
at 56,000 milesGreenfield, WI
STEERING
I HEARD SOME CLUNKING NOISE IN THE FRONT END. WAS TOLD BY A CHAIN REPAIR SHOP THAT THE STRUTS PROBABLY NEEDED REPLACING. I THOUGHT IT WAS TOO LOUD FOR THAT, BUT I TRUSTED THEIR OPINION. A FEW DAYS LATER, THE STEERING WHEEL WAS WAY OFF CENTER. AS I WENT TO MAKE A U-TURN, I LOST STEERING COMPLETELY. FORTUNATELY I WAS ABLE TO MOVE OUT OF TRAFFIC SAFELY WITHOUT AN ACCIDENT. OBVIOUSLY, THIS WOULD HAVE BEEN A DISASTER ON THE FREEWAY. THE MECHANIC SAID THAT THE MOUNTING TABS FOR THE STEERING GEAR WHERE EVERYTHING IS ATTACHED RUSTED OUT COMPLETELY FROM THE SUBFRAME AND NEEDED A CRADLE SO HE COULD RE-ATTACH THE STEERING COMPONENTS. ALSO, THE STEERING RACK WAS DAMAGED IN THE PROCESS AND NEEDED TO BE REPLACED AS WELL. TOTAL COST OF REPAIRS WAS $1390, WHICH WAS ACHIEVED BECAUSE OF FINDING USED PARTS.
NHTSA complaint #10850648 — an unverified report by a vehicle owner.
at 140,000 milesWahiawa, HICrashFire1 injured
AIR BAGS
AS I SLAMMED ON BRAKES CAR SHUT DOWN CAUSING STEERING TO LOCK AND BRAKES TO NOT FUNCTION WELL. I ENDED UP REAR ENDING PERSON IN FRONT. ALSO THE AIRBAG BURNED MY LEFT HAND.
NHTSA complaint #10780700 — an unverified report by a vehicle owner.
at 140,000 milesWahiawa, HICrashFire1 injured
UNKNOWN OR OTHER
AS I SLAMMED ON BRAKES CAR SHUT DOWN CAUSING STEERING TO LOCK AND BRAKES TO NOT FUNCTION WELL. I ENDED UP REAR ENDING PERSON IN FRONT. ALSO THE AIRBAG BURNED MY LEFT HAND.
NHTSA complaint #10780700 — an unverified report by a vehicle owner.
at 95,000 milesWaveland, MS
UNKNOWN OR OTHER
CAR WOULDN'T START. USUALLY IT STARTS RIGHT UP BUT IT WOULDN'T START UP. AFTER SEARCHING THE WEB WE FOUND IT WAS THE ANTITHEFT SYSTEM.
NHTSA complaint #10746049 — an unverified report by a vehicle owner.
Three Rivers, MI
ELECTRICAL SYSTEM
2005 CHEVROLET CLASSIC. CONSUMER WRITES IN REGARDS TO REIMBURSEMENT FOR IGNITION RECALL NOTICE REPAIRS. *SMD THE IGNITION SWITCH WAS REPLACED.
NHTSA complaint #10691428 — an unverified report by a vehicle owner.
at 80,000 milesBranford, CT
ELECTRICAL SYSTEM
THEFT SYSTEM ACTIVATED AND THE VEHICLE CUT OFF WHILE DRIVING CAUSING A SERIOUS SAFETY CONCERN, THIS HAS HAPPENED NUMEROUS TIMES, GM RECALLED THIS VEHICLE UNDER RECALL NUMBER 14350, ALL THE DEALERSHIP DID WAS APPLY SMALL TWO SMALL KEY RINGS, THIS DID NOTHING TO ALLEVIATE THE PROBLEM, WHEN I CALLED GM TO COMPLAIN THAT THE IGNITION SWITCH IS THE PROBLEM AND THEY SHOULD BE REPLACED AT NO COST TO THE OWNER, THEY SAID THAT THERE IS NO RECALL FOR THIS PROBLEM EVEN THOUGH THIS APPEARS TO BE THE EXACT FIX FOR THIS PROBLEM, I PAID MY MECHANIC TO REPLACE THE IGNITION SWITCH, I WOULD LIKE TO BE REIMBURSED BY GM. THANK YOU.
NHTSA complaint #10682627 — an unverified report by a vehicle owner.
at 114,202 milesTempe, AZ
STEERING
FOR THE 4TH TIME POWER STEERING FAILED. FOR THE 2ND TIME THE STEERING COLUMN WAS REPLACED AT NO CHARGE THE FIRST TIME IT FAILED CHAPMAN CHEVROLET IN TEMPE, AZ REPLACED THIS AND CHARGED $970 FOR REPAIRS. THE 2ND AND THIRD TIME THE ELECTRIC POWER STEERING MOTOR WAS REPLACED FOR FREE AT NO CHARGE. NUMEROUS GM CARS INCLUDING THE 2010 COBALT HAVE HAD THIS REPLACED AT NO CHARGE BUT GM AND CHAPMAN REFUSE TO REFUND TO REFUND THE INITIAL CHARGE SINCE THIS IS NOT SHOWN AS A RECALL ITEM AT THIS TIME.
NHTSA complaint #10669233 — an unverified report by a vehicle owner.
at 70,000 milesPinellas Park, FL
ENGINE
TL* THE CONTACT OWNS A 2005 CHEVROLET CLASSIC. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE SHUT OFF INDEPENDENTLY AND STOPPED ABRUPTLY. NO WARNING INDICATORS WERE ILLUMINATED. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS AN ISSUE WITH THE IGNITION SWITCH AND THE KEY. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 70,000.
NHTSA complaint #10661063 — an unverified report by a vehicle owner.
at 106,020 milesTraverse City, MI
STEERING
FRAME THAT HOLDS FRONT SYSTEM BROKE OR RUSTED THROUGH . CAUSE LOSS OF STEERING.
NHTSA complaint #10655197 — an unverified report by a vehicle owner.
at 106,020 milesTraverse City, MI
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
FRAME THAT HOLDS FRONT SYSTEM BROKE OR RUSTED THROUGH . CAUSE LOSS OF STEERING.
NHTSA complaint #10655197 — an unverified report by a vehicle owner.
Stonewall, OK
ELECTRICAL SYSTEM
2005 CHEVROLET CLASSIC. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL REPAIRS. *SMD THE CONSUMER STATED SHE LOST ALL POWER TO THE VEHICLE, WHILE DRIVING DOWN THE ROAD. SHE IS SEEKING REIMBURSEMENT FOR THE IGNITION SWITCH REPLACEMENT.
NHTSA complaint #10652258 — an unverified report by a vehicle owner.
at 151,371 milesElkhart, IN
ELECTRICAL SYSTEM
THE CAR WOULD NOT START. THE LIGHTS ON THE DASH CAME ON, BUT THERE WAS NO IGNITION, NO SOUND OF THE ENGINE TRYING TO START. I COULD HERE THE FUEL PUMP START AND STOP. IT WAS A COOL, DAMP MORNING. LATER THAT DAY, THE CAR STARTED WITH NO PROBLEM. THIS HAPPENED SEVERAL TIMES, UNTIL WE STARTED PARKING THE CAR IN THE GARAGE.
NHTSA complaint #10654061 — an unverified report by a vehicle owner.
at 110,000 milesCross City, FLCrash3 injured
STEERING:HYDRAULIC POWER ASSIST SYSTEM
TL* THE CONTACT OWNS A 2005 CHEVROLET CLASSIC. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION SWITCH AND THE VEHICLE STALLED ON SEVERAL OCCASIONS. THE CONTACT STATED THAT WHILE TRAVELING ON A MAJOR HIGHWAY AT APPROXIMATELY 50 MPH, THE POWER STEERING FAILED AND THE VEHICLE STALLED. THE CONTACT LOST CONTROL OF THE VEHICLE AND THE VEHICLE TRAVELED OFF THE ROADWAY AND ROLLED OVER THREE TIMES. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT, THE FRONT PASSENGER AND A SECOND PASSENGER BECAME TRAPPED IN THE VEHICLE. THE POLICE ARRIVED AND HAD TO REMOVE ALL THREE OF THE PASSENGERS FROM THE VEHICLE WHICH WAS TURNED OVER ON THE FRONT PASSENGERS SIDE. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED INJURIES TO THE HEAD, THE RIGHT ARM ROTATOR CUP, AND A BRUISED BREAST AREA. THE FRONT PASSENGER SUSTAINED PAINS AND BRUISES IN THE PELVIC AREA AND THE THIRD PASSENGER RECEIVED MINOR ABRASIONS. THE CONTACT INDICATED THAT ALL THREE OF THE OCCUPANTS OF THE VEHICLE REQUIRED MEDICAL ATTENTION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
NHTSA complaint #10653459 — an unverified report by a vehicle owner.
at 110,000 milesCross City, FLCrash3 injured
ELECTRICAL SYSTEM:IGNITION:SWITCH
TL* THE CONTACT OWNS A 2005 CHEVROLET CLASSIC. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION SWITCH AND THE VEHICLE STALLED ON SEVERAL OCCASIONS. THE CONTACT STATED THAT WHILE TRAVELING ON A MAJOR HIGHWAY AT APPROXIMATELY 50 MPH, THE POWER STEERING FAILED AND THE VEHICLE STALLED. THE CONTACT LOST CONTROL OF THE VEHICLE AND THE VEHICLE TRAVELED OFF THE ROADWAY AND ROLLED OVER THREE TIMES. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT, THE FRONT PASSENGER AND A SECOND PASSENGER BECAME TRAPPED IN THE VEHICLE. THE POLICE ARRIVED AND HAD TO REMOVE ALL THREE OF THE PASSENGERS FROM THE VEHICLE WHICH WAS TURNED OVER ON THE FRONT PASSENGERS SIDE. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED INJURIES TO THE HEAD, THE RIGHT ARM ROTATOR CUP, AND A BRUISED BREAST AREA. THE FRONT PASSENGER SUSTAINED PAINS AND BRUISES IN THE PELVIC AREA AND THE THIRD PASSENGER RECEIVED MINOR ABRASIONS. THE CONTACT INDICATED THAT ALL THREE OF THE OCCUPANTS OF THE VEHICLE REQUIRED MEDICAL ATTENTION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
NHTSA complaint #10653459 — an unverified report by a vehicle owner.
Tyrone, PA
ELECTRICAL SYSTEM
CHEVROLET. CONSUMER IS WRITING IN REGARDS TO GM RECALL #14350. * LD THE CONSUMER STATED THE IGNITION SWITCH FAILED. THE VEHICLE HAD TO BE TOWED, TO A REPAIR SHOP. THE IGNITION SWITCH WAS REPLACED AT A COST OF $ 289.38. SHE IS SEEKING REIMBURSEMENT.
NHTSA complaint #10648114 — an unverified report by a vehicle owner.
at 95,000 milesOmaha, NE
WHEELS
POWER STEERING ASSEMBLY BREAKS AWAY FROM ENGINE CRADLE DUE TO HEAVY CORROSION. (PHOTOS AVAILABLE) WIFE COMPLAINED OF THUMPING NOISE WHEN TURNING. I TEST DROVE A FIGURE EIGHT AND PARKED WITH PASSENGER WHEEL 30 DEGREES OUT OF ALIGNMENT. LOSS OF STEERING (NOT JUST POWER), REGARDLESS OF CAUSE, STRUCTURAL INTEGRITY OF THE CRADLE CAN'T BE ALLOWED TO FAIL, EVER. EITHER THE ORIGINAL METALLURGICAL SPECIFICATIONS WERE IN ERROR, OR SOME SUBSET OF THE SUPPLIED CRADLES DID NOT MEET SPECS. 10579587, DATED 3/12/2014 ? IS AN EARLIER ACCURATE DESCRIPTION OF SAME PROBLEM. WEB WISDOM SUGGESTS A/C CONDENSATE REPEATEDLY COLLECTS ON THE CRADLE CAUSING (HIDDEN) CORROSION. THAT SEEMS PLAUSIBLE TO ME, SINCE MY CAR IS RUST FREE, INCLUDING THE UNDERCARRIAGE, EXCEPT FOR THE HEAVILY CORRODED CRADLE. ACCORDING TO WIKIPEDIA GM PRODUCTS THAT SHARE THE SAME GMX130 PLATFORM USING THIS CRADLE ARE: 1999?2004 OLDSMOBILE ALERO 1999?2005 PONTIAC GRAND AM 1997?1999 OLDSMOBILE CUTLASS 1997?2003 CHEVROLET MALIBU 2004?2005 CHEVROLET CLASSIC I MANUALLY BROWSED NHTSA DB FOR FRONT-END RELATED 'FAILED COMPONENTS' ON THESE VEHICLES. I READ FOR A DAY. WHAT DOES A STATISTICAL SUMMARY OF FRONT-END RELATED FAILURES SAY ABOUT THE GMX130 PLATFORM? I ASSERT THAT THERE IS A CRITICAL FLAW IN SOME OR ALL CRADLES USED BY THE GMX130 PLATFORM MAKING THEM VULNERABLE TO EXTREME CORROSION, LEADING TO A VARIETY OF POTENTIALLY LIFE THREATENING COMPONENT FAILURES, INCLUDING, BUT NOT LIMITED TO LOSS OF STEERING. ... UPDATED 03/19/15*BF
NHTSA complaint #10644030 — an unverified report by a vehicle owner.
at 95,000 milesOmaha, NE
STEERING
POWER STEERING ASSEMBLY BREAKS AWAY FROM ENGINE CRADLE DUE TO HEAVY CORROSION. (PHOTOS AVAILABLE) WIFE COMPLAINED OF THUMPING NOISE WHEN TURNING. I TEST DROVE A FIGURE EIGHT AND PARKED WITH PASSENGER WHEEL 30 DEGREES OUT OF ALIGNMENT. LOSS OF STEERING (NOT JUST POWER), REGARDLESS OF CAUSE, STRUCTURAL INTEGRITY OF THE CRADLE CAN'T BE ALLOWED TO FAIL, EVER. EITHER THE ORIGINAL METALLURGICAL SPECIFICATIONS WERE IN ERROR, OR SOME SUBSET OF THE SUPPLIED CRADLES DID NOT MEET SPECS. 10579587, DATED 3/12/2014 ? IS AN EARLIER ACCURATE DESCRIPTION OF SAME PROBLEM. WEB WISDOM SUGGESTS A/C CONDENSATE REPEATEDLY COLLECTS ON THE CRADLE CAUSING (HIDDEN) CORROSION. THAT SEEMS PLAUSIBLE TO ME, SINCE MY CAR IS RUST FREE, INCLUDING THE UNDERCARRIAGE, EXCEPT FOR THE HEAVILY CORRODED CRADLE. ACCORDING TO WIKIPEDIA GM PRODUCTS THAT SHARE THE SAME GMX130 PLATFORM USING THIS CRADLE ARE: 1999?2004 OLDSMOBILE ALERO 1999?2005 PONTIAC GRAND AM 1997?1999 OLDSMOBILE CUTLASS 1997?2003 CHEVROLET MALIBU 2004?2005 CHEVROLET CLASSIC I MANUALLY BROWSED NHTSA DB FOR FRONT-END RELATED 'FAILED COMPONENTS' ON THESE VEHICLES. I READ FOR A DAY. WHAT DOES A STATISTICAL SUMMARY OF FRONT-END RELATED FAILURES SAY ABOUT THE GMX130 PLATFORM? I ASSERT THAT THERE IS A CRITICAL FLAW IN SOME OR ALL CRADLES USED BY THE GMX130 PLATFORM MAKING THEM VULNERABLE TO EXTREME CORROSION, LEADING TO A VARIETY OF POTENTIALLY LIFE THREATENING COMPONENT FAILURES, INCLUDING, BUT NOT LIMITED TO LOSS OF STEERING. ... UPDATED 03/19/15*BF
NHTSA complaint #10644030 — an unverified report by a vehicle owner.
at 95,000 milesOmaha, NE
UNKNOWN OR OTHER
POWER STEERING ASSEMBLY BREAKS AWAY FROM ENGINE CRADLE DUE TO HEAVY CORROSION. (PHOTOS AVAILABLE) WIFE COMPLAINED OF THUMPING NOISE WHEN TURNING. I TEST DROVE A FIGURE EIGHT AND PARKED WITH PASSENGER WHEEL 30 DEGREES OUT OF ALIGNMENT. LOSS OF STEERING (NOT JUST POWER), REGARDLESS OF CAUSE, STRUCTURAL INTEGRITY OF THE CRADLE CAN'T BE ALLOWED TO FAIL, EVER. EITHER THE ORIGINAL METALLURGICAL SPECIFICATIONS WERE IN ERROR, OR SOME SUBSET OF THE SUPPLIED CRADLES DID NOT MEET SPECS. 10579587, DATED 3/12/2014 ? IS AN EARLIER ACCURATE DESCRIPTION OF SAME PROBLEM. WEB WISDOM SUGGESTS A/C CONDENSATE REPEATEDLY COLLECTS ON THE CRADLE CAUSING (HIDDEN) CORROSION. THAT SEEMS PLAUSIBLE TO ME, SINCE MY CAR IS RUST FREE, INCLUDING THE UNDERCARRIAGE, EXCEPT FOR THE HEAVILY CORRODED CRADLE. ACCORDING TO WIKIPEDIA GM PRODUCTS THAT SHARE THE SAME GMX130 PLATFORM USING THIS CRADLE ARE: 1999?2004 OLDSMOBILE ALERO 1999?2005 PONTIAC GRAND AM 1997?1999 OLDSMOBILE CUTLASS 1997?2003 CHEVROLET MALIBU 2004?2005 CHEVROLET CLASSIC I MANUALLY BROWSED NHTSA DB FOR FRONT-END RELATED 'FAILED COMPONENTS' ON THESE VEHICLES. I READ FOR A DAY. WHAT DOES A STATISTICAL SUMMARY OF FRONT-END RELATED FAILURES SAY ABOUT THE GMX130 PLATFORM? I ASSERT THAT THERE IS A CRITICAL FLAW IN SOME OR ALL CRADLES USED BY THE GMX130 PLATFORM MAKING THEM VULNERABLE TO EXTREME CORROSION, LEADING TO A VARIETY OF POTENTIALLY LIFE THREATENING COMPONENT FAILURES, INCLUDING, BUT NOT LIMITED TO LOSS OF STEERING. ... UPDATED 03/19/15*BF
NHTSA complaint #10644030 — an unverified report by a vehicle owner.
at 146,000 milesBattlecreek, MI
ELECTRICAL SYSTEM
I RECEIVED A SAFETY RECALL NOTICE FROM GM ON APPROX. 09/15/2014. IT IS ABOUT THE IGNITION SHUTTING OFF ON VARIOUS GM MODELS AND YEARS. MY CAR IS APPARENTLY PART OF THIS RECALL. THEIR "FIX" APPEARS TO BE "PLACING A COVER OVER THE KEY HEAD TO LIMIT OTHER OBJECTS, I WOULD ASSUME: KEY RING, FOB, OTHER KEYS, ETC. FROM MOVING AS MUCH WHILE THE CAR IS BEING DRIVEN. THIS DOES NOT APPEAR TO ME TO "FIX" THE DEFECTIVE IGNITION.
NHTSA complaint #10638488 — an unverified report by a vehicle owner.
at 68,400 milesWestminster, CO
ELECTRICAL SYSTEM
VEHICLE IS A 2005 CHEVROLET CLASSIC IN EXTREMELY GOOD CONDITION WITH LOW MILEAGE FOR THE YEAR. I WAS TEACHING MY 15YR OLD DAUGHTER HOW TO DRIVE AND AS WE WERE TURNING THROUGH AN INTERSECTION THE CAR LOST POWER AND DIED. I HAD HER TRY TO START THE CAR AND AFTER THE THIRD TRY IT STARTED. THE CAR DIED AGAIN AS WE WERE DRIVING HOME BUT STARTED ON THE FOURTH TRY. I PARKED THE CAR AND TRIED TO GUESS WHAT MAY BE WRONG. I REPLACED THE FUEL FILTER AND HAD THE FUEL PUMP REPLACED (TWICE) FINALLY HAD TO TAKE IT TO A MECHANIC AND PAID $766.98 AND SEVERAL HOURS TO DIAGNOSE A FAULTY IGNITION SWITCH. I WOULD LIKE TO BE NOTIFIED IF THIS IGNITION SWITCH IS EVER ON A RECALL AS THIS IS A VERY DANGEROUS THING TO GO OUT WHILE DRIVING.
NHTSA complaint #10631408 — an unverified report by a vehicle owner.
at 147,100 milesSugarloaf, PA
STEERING
WHILE DRIVING ON THE INTERSTATE AT APPROXMIATELY 60 MPH, THE POWER STEERING STOPPED WORKING AND BECAME HARD TO STEER. IT HAS NOT WORKED SINCE.
NHTSA complaint #10619388 — an unverified report by a vehicle owner.
