2020 Chevrolet Malibu fuel system problems

FUEL SYSTEM, GASOLINE

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving approximately 35 MPH, the vehicle started losing motive power. The contact stated that the vehicle stalled, with the check engine warning light illuminated. The vehicle was towed to an independent mechanic, who diagnosed the vehicle and determined that the fuel injectors had failed and needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that the vehicle was hesitating and losing power with the odor of gasoline inside the cabin of the vehicle. The contact stated there was no warning light illuminated. The contact was able to drive the vehicle to the residence, but had not taken the vehicle to a dealer or mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 112,000.

NHTSA complaint #11715939 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

December 12, 2025 I had to drive 20-30 miles an hour the car would not break I had to use parking break. When I would try to Stop it would continue to roll. The pedal was Hard! This is very dangerous and other cars have crashed There are also class action lawsuits regarding just this! Vehicle vacuum pump The Bill was $5200 I am asking for reimbursement! Vehicle vacuum pump engine light on tire sensor light on Saw there have been more cases

NHTSA complaint #11710815 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Shift to park issue and fluid mixing in with engine

NHTSA complaint #11708881 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of automotive power. The check engine warning light was occasionally illuminated. The contact pulled over to the shoulder of the road and restart the vehicle; however, the failure reoccurred. The contact stated that her husband scanned the vehicle and retrieved DTC: P1101(Mass Air Flow (MAF) Sensor Circuit Performance Issue). The vehicle was repaired but the failure reoccurred. The vehicle was diagnosed by another independent mechanic as a second opinion, with a Fuel/PCM Failure. The vehicle was not repaired. The local dealer was not contacted. The contact related the failure to an unknown recall however, the VIN was not under recall. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 88,400.

NHTSA complaint #11683945 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Getting engine power reduced messsge in shop 4th time now in 3 weeks, 2 service bulletins, now they want to put new engine, found over 800 complaints about same issue on car complaint.com website and more on Reddit of same issue . Car wouldn’t go more than 5mph extremely traumatic on highway my son won’t get back in the car he is too scared.

NHTSA complaint #11673603 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

P1101 AIR FLOW SYSTEM! I replacement almost every things ,but still have the p1101 code Park to Shift!

NHTSA complaint #11668551 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:THROTTLEBODY/MANIFOLD

The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving approximately 65 MPH, the message "Transport Mode" was suddenly displayed, and the vehicle decelerated and stalled. After restarting the vehicle, the failure persisted. The vehicle was taken to the local dealer who serviced the throttle body, but the vehicle was not fixed. The manufacturer was not notified of the failure. The failure mileage was 180,000.

NHTSA complaint #11631844 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Car has stalled out, or acted like it's going to stall out several times. No check engine light on so unable to identify the issue. There are recalls for other Malibs for similar problems, but it states this model is not affected.

NHTSA complaint #11548224 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

The vehicle goes to ESC mode loses power an all gauges go frantic. All warming lights come on and the brakes go stop working. Speed decreases while in motion, unable to go past 40 mph. Warning messages such as put car in park will appear while the car is in park, steering unstable , low fuel a many others . This is a hazard and I only had the vehicle for 1 year, however I reported the first issue in April 2023 to dealer of purchase an no fix at this time .

NHTSA complaint #11544315 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Vehicle through a "service engine" and lost partial power. The vehicle slowed considerably and was not able to accelerate as expected. Fortunately, this was rush hour traffic and it was slow. Normally, the traffic moves at 60 MPH plus or minus 5 MPH. The loss of power on I10 can be extremely unsafe. The dealer revealed that our car had a scan code P0299. They cleaned the Thottle Body and stated it was the likely problem. However, they said they tested the crank case pressure and it was at 0 PSI, instead of the expected vacuum. There was no indication, that crank case pressure or the PCV was the root problem. I pointed out that crank case should be measured in INH2O. I think they mis diaganosed and were trying to lead me to replace the PCV, and ultimately the turbocharger itself. I think it is probably a sensor or perhaps another component. I took my car away from the lot and will report any other incidents or findings.

NHTSA complaint #11509405 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2020 Chevrolet Malibu. The contact stated while driving approximately 65 MPH the vehicle was jerking and then inadvertently lost motive power. The contact was able to pull over safely. The contact was unable to restart the vehicle immediately; however, eventually, the vehicle restarted and was driven to the residence. The check engine warning light was illuminated. The vehicle was taken to the dealer and diagnosed; however, the mechanic was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 60,000.

NHTSA complaint #11473710 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

while driving down a mountain in monterey tenessee from visiting a friend the car started blowing white smoke and all dash lights flickered before car shut off no brakes or steering while coasting down mountain almost got rear ended by pickup this was around 9pm it was dark i coasted into a gas station after a few attempts to start car . i called roadside assistance that night and got towed to dave kirk chevy dealer next town over after having issues with car i encountered issues with manager of dealer ship and roadside assistance neither could help til i started raising my voice i was stranded there in town for 2 days my friends felt bad the paid for my motel since i was so stressed out they didnt want to look at my car that manager said he knew nothing about after diagnosing my car they found a bad fuel injector that he said was open 100 percent so after 2 days i was on my way back to florida bad experience all the way around

NHTSA complaint #11461527 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Was traveling at about 58 mph down the highway when all my warning gauges starting going off. My digital dash went blank and the car started accelerating on its own. I kept hitting the brakes trying to make it slow down and I could hear the abs function and feel it thru the brake while trying to slow down. After about a 1/2 mile of fighting the car the dash turned back on the check engine light stayed on and the car stopped trying to accelerate but wouldn’t change gears and was stuck at 3500 rpms when I limped it off the road and had a tow truck come get it.

NHTSA complaint #11437929 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Unknown. Started vehicle for one minute and stalled. It is available for inspection. Safety was at risk cause I thought car wasn't going to start and stay idling. Problem has not been reproduced or confirmed by dealership.vehicle has not been inspected by dealership. There were no warning lamps or messages. This initial problem appeared on 5-20-21.

NHTSA complaint #11418266 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

*First incident: Unknown. Could have been stranded. Not confirmed by dealership. First appeared on 5-20-21. I started car. After car started, the cars body started to shake all over with a hard vibration. Car was inspected vaguely by dealership and I was told nothing could be found. No lights came on, no warning.*Second incident: unknown. First appeared 5-22-21. After car started, the cars idle felt shaky a little. Also the acceleration slowed down on its own to where I could not speed up and I had to pull over or I could have been hit by multiple cars. Crash safety issue and stranded! Not confirmed by dealership. Going to be inspected again on 5-24-2021. There were no warnings or lights!

NHTSA complaint #11418200 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Acceleration slowed down and didn't want to speed up when gas pedal pressed. Car is available for inspection. Safety was at risk cause a car could of hit me. Problem has not been reproduced or confirmed by dealership. Vehicle has not been inspected. There were no warnings or symptoms. Problems appeared 5-20-21, 5-22-21, and 5-23-21.

NHTSA complaint #11418210 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Vehicle slowed down alot by itself upon driving and when pushing the gas pedal the vehicle would not go any faster. I had to pull over in someones driveway to get out of the way of multiple cars behind me! Car is available for inspection. My safety was very much in danger cause what happened to the car could have caused cars to hit me from behind! The problem has not been reproduced or confirmed by dealership. The vehicle has not been inspected by the dealership. There were no warning lamps or messages.

NHTSA complaint #11418212 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Unknown. Started vehicle and warmed it up for one minute. After that the vehicle shook and vibrated then completely stalled. It Is available for inspection. Safety wasn't the greatest cause I thought the vehicle completely died and would not be able to be driven. Problem has not been reproduced or confirmed by dealership. The vehicle has not been inspected by the dealership. There were not any warning lamps or symptoms. This is the first time the car died.

NHTSA complaint #11418240 — an unverified report by a vehicle owner.