FaultScore report
Owners have filed 124 complaints about the 2003 Chevrolet Silverado 1500 HD with NHTSA between 2006 and 2020. The largest single group is the brakes. Across this model's run it ranks 1 of 5 worst.
FaultScore 66/100
Higher is worse. Measured against the other years of the Chevrolet Silverado 1500 HD.
How this is worked out124
Complaints
4
Crashes reported
3
Fires reported
3
Injuries reported
86,800 mi
Median mileage at failure
Half of reported failures happened before this
11%
Failed under 36,000 miles
Inside a typical bumper-to-bumper warranty
The letter says how bad. This says what kind — whether this year drew an unusual number of complaints, unusually dangerous ones, or failures that arrived unusually early.
Click any bar to open that year's report.
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
1 crashes, 0 fires · median 47,500 mi
Median failure at 90,468 miles
Median failure at 95,500 miles
Median failure at 142,000 miles
Median failure at 98,000 miles
Median failure at 36,000 miles
Median failure at 86,800 miles
Median failure at 18,000 miles
1 crashes, 0 fires · median 140,000 mi
Median failure at 86,800 miles
1 crashes, 0 fires · median 83,000 mi
NHTSA files every complaint against a named sub-assembly, not just a system. This is the difference between knowing it was "the engine" and knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all complaints include one.
A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.
Reports where the owner recorded a crash, a fire, an injury or a death.
SERVICE BRAKES
BRAKE LINES RUSTED THROUGH AND RUPTURED RESULTING IN TOTAL BRAKE LOSS AND A CRASH. THE LINES FAILED AT A POINT DIRECTLY UNDER THE DRIVER SEAT. IT WAS IN MOTION ON A CITY STREET AND STRUCK ANOTHER VEHICLE ALSO DAMAGING THAT.
NHTSA complaint #10909739 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TL* THE CONTACTS OWNS A 2003 CHEVROLET SILVERADO 1500 HD. THE CONTACT STATED THAT SMOKE WAS EMITTING OUT OF THE CENTER OF THE AIR VENT DUCT. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 68,403 AND THE CURRENT MILEAGE WAS 150,000.
NHTSA complaint #10606227 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 1500 HD. THE CONTACT STATED THAT THE AIR CONDITIONER WAS INOPERABLE AND THE PLASTIC WIRES THAT CAME FROM THE UNIT WERE MELTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT UNDER WARRANTY AND THERE WERE NO RECALLS ADDRESSING THE FAILURE. THE MANUFACTURER WAS NOTIFIED AND REPEATED THOSE SENTIMENTS. NO FURTHER ASSISTANCE WAS OFFERED. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT REPAIR SHOP FOR REPAIR. THE FAILURE MILEAGE WAS 127,000.
NHTSA complaint #10469379 — an unverified report by a vehicle owner.
STEERING
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 1500 HD. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH WHEN THE REAR WHEELS TURNED IN AN AWKWARD POSITION CAUSING A LOSS IN STEERING. THE VEHICLE WOULD NOT STEER IN A STRAIGHT DIRECTION. SUDDENLY, THE VEHICLE VEERED OFF THE ROAD AND CRASHED INTO A UTILITY POLE. THE CONTACT STATED THE FAILURE WAS RELATED TO THE REAR AXLE CENTERING SPRING. THE VEHICLE WAS COMPLETELY DESTROYED AND TOWED TO THE RESIDENCE. THE CONTACT SUSTAINED INJURIES TO THE NECK. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000. THE VIN WAS UNAVAILABLE.
NHTSA complaint #10378665 — an unverified report by a vehicle owner.
SUSPENSION:REAR
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 1500 HD. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH WHEN THE REAR WHEELS TURNED IN AN AWKWARD POSITION CAUSING A LOSS IN STEERING. THE VEHICLE WOULD NOT STEER IN A STRAIGHT DIRECTION. SUDDENLY, THE VEHICLE VEERED OFF THE ROAD AND CRASHED INTO A UTILITY POLE. THE CONTACT STATED THE FAILURE WAS RELATED TO THE REAR AXLE CENTERING SPRING. THE VEHICLE WAS COMPLETELY DESTROYED AND TOWED TO THE RESIDENCE. THE CONTACT SUSTAINED INJURIES TO THE NECK. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000. THE VIN WAS UNAVAILABLE.
NHTSA complaint #10378665 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 1500 HD. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE LOST COMPLETE POWER. UPON FURTHER INSPECTION, THE CONTACT NOTICED FLAMES UNDER THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES, BUT THE VEHICLE WAS COMPLETELY DESTROYED. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 60,000.
NHTSA complaint #10274707 — an unverified report by a vehicle owner.
In the owners' own words, exactly as filed with NHTSA.
ELECTRICAL SYSTEM
1) BRAKE LINE RUSTED AND HAD TO BE REPLACED. 2) A NEW BATTERY WAS INSTALLED ONLY TO BE TOTALLY DEAD WITHIN 1 WEEK 3) ALTERNATOR REPLACED AS THAT WAS THOUGHT TO BE THE PROBLEM 4) FINALLY FOUND THE PROBLEM AND IT IS THE ABS SYSTEM AS THE MODULATOR / PUMP FOR THIS SYSTEM WOULD CONTINUALLY RUN EVEN WHEN THE VEHICLE WAS TURNED OFF.
NHTSA complaint #11343857 — an unverified report by a vehicle owner.
SERVICE BRAKES
1) BRAKE LINE RUSTED AND HAD TO BE REPLACED. 2) A NEW BATTERY WAS INSTALLED ONLY TO BE TOTALLY DEAD WITHIN 1 WEEK 3) ALTERNATOR REPLACED AS THAT WAS THOUGHT TO BE THE PROBLEM 4) FINALLY FOUND THE PROBLEM AND IT IS THE ABS SYSTEM AS THE MODULATOR / PUMP FOR THIS SYSTEM WOULD CONTINUALLY RUN EVEN WHEN THE VEHICLE WAS TURNED OFF.
NHTSA complaint #11343857 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THE INSTRUMENT PANEL CLUSTER WILL STOP WORKING. NO GAUGES, SPEEDOMETER, OR TACHOMETER. USUALLY OCCURS AFTER VEHICLE HAS BEEN DRIVEN, TURNED OFF AND RESTARTED. KNOW OF SEVERAL PEOPLE HAVING/HAD THE SAME ISSUE WITH THIS YEAR MODEL. SOMETIMES THE CLUSTER WILL BECOME ACTIVE AGAIN WHILE DRIVING, BUT USUALLY DOESN'T.
NHTSA complaint #11339732 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
BRIGHT LITE INDICATOR LITE COMES ON DASH WITH NO KEY IN IGNITION, KILLS BATTERY OVER NITE. GAS GAUGE IN DASH DOESN'T ALWAYS WORK, TRUCK HAS TO GET MOVING, SOMETIMES RIGHT AWAY AND SOMETIMES A LITTLE LONGER. HAD TO REPLACE MY THROTTLE BODY CONTROL A COUPLE MONTHS PRIOR
NHTSA complaint #11289947 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
BRIGHT LITE INDICATOR LITE COMES ON DASH WITH NO KEY IN IGNITION, KILLS BATTERY OVER NITE. GAS GAUGE IN DASH DOESN'T ALWAYS WORK, TRUCK HAS TO GET MOVING, SOMETIMES RIGHT AWAY AND SOMETIMES A LITTLE LONGER. HAD TO REPLACE MY THROTTLE BODY CONTROL A COUPLE MONTHS PRIOR
NHTSA complaint #11289947 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
BRIGHT LITE INDICATOR LITE COMES ON DASH WITH NO KEY IN IGNITION, KILLS BATTERY OVER NITE. GAS GAUGE IN DASH DOESN'T ALWAYS WORK, TRUCK HAS TO GET MOVING, SOMETIMES RIGHT AWAY AND SOMETIMES A LITTLE LONGER. HAD TO REPLACE MY THROTTLE BODY CONTROL A COUPLE MONTHS PRIOR
NHTSA complaint #11289947 — an unverified report by a vehicle owner.
ENGINE
SEVERAL OF THE EXHAUST MANIFOLD BOLTS HAVE SNAPPED/SHEARED CAUSING EXHAUST LEAKS BETWEEN THE EXHAUST MANIFOLD AND EXHAUST PORT ON THE CYLINDER HEAD. I'M LEARNING THAT THIS IS A COMMON ISSUE THAT HAS GONE UNADDRESSED BY THE MANUFACTURER, BUT IS CLEARLY AN EMISSIONS AND FUNCTIONALITY ISSUE. PLEASE HELP IN HOLDING THE MANUFACTURER ACCOUNTABLE FOR THIS APPARENT MECHANICAL DEFECT. AS OF NOW, THEY OFFER NO ASSISTANCE IN REPAIRING THE ISSUE.
NHTSA complaint #11155467 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
MY WHOLE DASHBOARD STOPS WORKING THE GAUGES LIGHTS EVERYTHING JUST STOPPED WORKING. I WAS TRAVELING DOWN INTERSTATE AND EVERYTHING STOPPED WORKING BUT AFTER A FEW SECONDS IT ALL CAME BACK ON FOR ABOUT 30 SECONDS AND IT ALL SHUT OFF AGAIN AND NEVER CAME BACK ON I MADE IT HOME AND TURNED THE TRUCK OFF AND WENT INSIDE. I GOT UP THE NEXT MORNING TO GO TO WORK AND CRANKED THE TRUCK AND NO GAUGES OR LIGHTS WERE NOT WORKING STILL. I SLAMMED MY HAND DOWN ON TOP OF THE DASHBOARD AND EVERYTHING CAME ON AND WAS WORKING BUT THAT DIDN'T LAST LONG AND EVERYTHING SHUT OFF AGAIN.
NHTSA complaint #11122408 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
MY WHOLE DASHBOARD STOPS WORKING THE GAUGES LIGHTS EVERYTHING JUST STOPPED WORKING. I WAS TRAVELING DOWN INTERSTATE AND EVERYTHING STOPPED WORKING BUT AFTER A FEW SECONDS IT ALL CAME BACK ON FOR ABOUT 30 SECONDS AND IT ALL SHUT OFF AGAIN AND NEVER CAME BACK ON I MADE IT HOME AND TURNED THE TRUCK OFF AND WENT INSIDE. I GOT UP THE NEXT MORNING TO GO TO WORK AND CRANKED THE TRUCK AND NO GAUGES OR LIGHTS WERE NOT WORKING STILL. I SLAMMED MY HAND DOWN ON TOP OF THE DASHBOARD AND EVERYTHING CAME ON AND WAS WORKING BUT THAT DIDN'T LAST LONG AND EVERYTHING SHUT OFF AGAIN.
NHTSA complaint #11122408 — an unverified report by a vehicle owner.
SERVICE BRAKES
BRAKE LINES RUSTED THROUGH AND RUPTURED RESULTING IN TOTAL BRAKE LOSS AND A CRASH. THE LINES FAILED AT A POINT DIRECTLY UNDER THE DRIVER SEAT. IT WAS IN MOTION ON A CITY STREET AND STRUCK ANOTHER VEHICLE ALSO DAMAGING THAT.
NHTSA complaint #10909739 — an unverified report by a vehicle owner.
FORWARD COLLISION AVOIDANCE
265/65/16 MICHELIN LTX M/S2 TIRE, THESE TIRES WERE NEW AND PURCHASED ON 6/21/16, ON 7/11/16 LESS THEN ONE MONTH I HAD TO BRAKE HARD TO AVOID AN ACCIDENT. THE 3 ROWS OF TREADS IN THE MIDDLE OF ALL FOUR TIRES BECAME SEVERELY SEPARATED AND WORN RENDERING ALL FOUR TIRES AS JUNK CAUSING THE PICKUP TO SHAKE BADLY WHILE GOING DOWN THE ROAD. TO MAKE MATTERS WORSE MICHELIN DIDN'T WANT HONOR ANY WARRANTIES, CLAIMS, ETC., INCLUDING THE MICHELIN PLUS GUARANTY. THIS IS WHERE IF YOU ARE NOT 100% SATISFIED WITHIN 30 DAYS YOU CAN GET A REPLACEMENT FREE. AFTER ONE BRAKING INCIDENT ALL THE TIRES WAS JUNK. I WOULD NOT RECOMMEND THESE TIRES TO ANYONE. THE TREAD PATTERN OF THESE TIRES IS THE DIRECT CAUSE. I ALSO HAVE PICTURES.
NHTSA complaint #10884775 — an unverified report by a vehicle owner.
SERVICE BRAKES
JAN. 2014 IN NORTHEAST ILLINOIS I WENT TO APPLY BRAKES FOR A RED LIGHT AND PEDDLE WENT TO THE FLOOR. I WAS FORTUNATE THAT THERE WAS NOT ANOTHER VEHICLE ALREADY STOPPED AT THE LIGHT IN FRONT OF ME, AND WAS NOT HIT AS I COASTED THROUGH THE RED LIGHT. I WAS ABLE TO USE THE PARKING BRAKE FOR STOPPING WHILE I MANEUVERED TO MY HOME. UPON INSPECTION THE NEXT DAY, I FOUND THE BRAKE LINE THAT RUNS ALONG THE TRUCK FRAME AND FEEDS BRAKE FLUID TO THE FRONT BRAKES HAD RUPTURED. I WAS ASTOUND WHEN I SAW THE CONDITION OF THE REMAINING BRAKE LINES UNDER THE VEHICLE AND THE FACT THAT THE LINES WERE NOT MADE OF STAINLESS STEEL OR SOME OTHER MATERIAL THAT WOULD NOT RUST WHEN EXPOSED TO THE ROAD SALT THAT USED HEAVILY DURING THE WINTER MONTHS IN NORTHEAST ILLINOIS. I'M ALSO CONCERN ABOUT THE FUEL LINES BECAUSE THEIR CONDITION IS THE SAME AS THE BRAKE LINES AND APPEAR TO MADE OUT OF A FERROUS MATERIAL ALSO.
NHTSA complaint #10723881 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
JAN. 2014 IN NORTHEAST ILLINOIS I WENT TO APPLY BRAKES FOR A RED LIGHT AND PEDDLE WENT TO THE FLOOR. I WAS FORTUNATE THAT THERE WAS NOT ANOTHER VEHICLE ALREADY STOPPED AT THE LIGHT IN FRONT OF ME, AND WAS NOT HIT AS I COASTED THROUGH THE RED LIGHT. I WAS ABLE TO USE THE PARKING BRAKE FOR STOPPING WHILE I MANEUVERED TO MY HOME. UPON INSPECTION THE NEXT DAY, I FOUND THE BRAKE LINE THAT RUNS ALONG THE TRUCK FRAME AND FEEDS BRAKE FLUID TO THE FRONT BRAKES HAD RUPTURED. I WAS ASTOUND WHEN I SAW THE CONDITION OF THE REMAINING BRAKE LINES UNDER THE VEHICLE AND THE FACT THAT THE LINES WERE NOT MADE OF STAINLESS STEEL OR SOME OTHER MATERIAL THAT WOULD NOT RUST WHEN EXPOSED TO THE ROAD SALT THAT USED HEAVILY DURING THE WINTER MONTHS IN NORTHEAST ILLINOIS. I'M ALSO CONCERN ABOUT THE FUEL LINES BECAUSE THEIR CONDITION IS THE SAME AS THE BRAKE LINES AND APPEAR TO MADE OUT OF A FERROUS MATERIAL ALSO.
NHTSA complaint #10723881 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
THESE INCIDENTS HAPPENED DURING THE FOLLOWING YRS AT LEAST 3 TIMES A YEAR NOW FOR EACH YR FROM 2005 TILL 2015 COMING HOME FROM DAUGHTERS AND LOST ALL HEAD LAMPS AND DRIVING LIGHTS SO WAS DRIVING IN COMPLETE DARKNESS WITH NO LIGHTS , THANKFULLY WE MADE IT HOME THE LAST 2 MILES NEXT DAY TOOK TO MECHANIC AND HE REPLACED THE LAMPS , TWO WEEKS LATER GOT PULLED OVER DUE TO RUNNING LIGHTS ONE WAS OUT AND GOT WARNING ABOUT THAT .......................THIS HAS HAPPENED 12 TIMES SINCE WE OWNED THIS TRUCK SINCE 2005 AND WE HAVE HAD TO REPLACE THE WHOLE HEADLAMP ASSEMBLY BUT NOW AFTER 6 MONTHS LIGHTS GO OUT AGAIN AND GET PULLED OVER DUE TO ONLY ONE HEADLAMP IS THERE A PROBLEM WITH THE WIRING? MOSTLY THIS IS JUST ON DRIVERS SIDE HEADLAMP AND RUNNING LIGHT IT KEEPS BLOWING THE LAMPS OUT OCCASIONALLY IT BLOWS BOTH SIDES AND FRONT RUNNING LAMPS.
NHTSA complaint #10703343 — an unverified report by a vehicle owner.
SERVICE BRAKES
THE BRAKE LINES BASICALLY RUSTED OFF THE TRUCK, THE FIRST OCCURRENCE I WENT TO USE THE TRUCK AND THE BRAKE PEDAL WENT TO THE FLOOR AND I STARTED SMELLING BRAKE FLUID. HAD IT TOWED TO HAVE REPAIRS DONE (06/04/2011) THE LINES THAT SHOWED THE MAIN PROBLEM WERE CHANGED FOR NEW. EXACTLY 2 YEARS I HAD MY BIG CAR TRAILER HOOKED UP LOADED WITH MY TRACTOR. ANOTHER LINE GOING TO THE REAR OF THE TRUCK RUPTURED IN THE YARD. GOING BACK TO THE SHOP AGAIN, I HAD A COMPANY OUT WEST MAKE ALL NEW STAINLESS STEAL LINES FOR IT.(06/20/2014) AND NOW I'M AGAIN BROKEN DOWN AGAIN (03/07/2015). THIS HAS COST ME A CONSIDERABLE AMOUNT OF MONEY AND I'M NOT THROUGH I FEAR. THIS TIME THE ABS SYSTEM WANTS TO CONTINUE TO RUN AND RUNNING THE BATTERY DOWN. GM SHOULD BE ON TOP OF THIS.
NHTSA complaint #10692829 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
3 OF THE 6 EXHAUST MANIFOLD BOLTS HAVE BROKEN OFF ON LEFT SIDE ,2 ON THE RIGHT SIDE . I NOW HAVE THE EXHAUST TICKING SOUND AND ON OCCASION GET EXHAUST SMELL INSIDE CAB.I NOTICED THE FIRST BROKEN BOLT AT APPROX 55000 MILES. I NOW HAVE 112000 MILES.
NHTSA complaint #10648537 — an unverified report by a vehicle owner.
SERVICE BRAKES
WHILE USING THE TRUCK TO REMOVE A ROOT BALL WE NOTICED THAT THE BRAKE PEDAL WAS GOING TO THE FLOOR. NO BRAKE OR WARNING LIGHTS WERE SHOWING ON THE INSTRUMENT PANEL. OUR MECHANIC REPLACED FOUR BRAKE LINES DUE TO RUST, CORROSION AND LEAKS. WE ARE EXTREMELY THANKFUL THIS HAPPENED WHILE WORKING IN THE BACK YARD AND NOT WHEN TRAVELING DOWN THE INTERSTATE TOWING OUR 3000 POUND BOAT! AFTER SEEING ALL THE REPORTED PROBLEMS ON THE INTERNET I CANNOT UNDERSTAND WHY THERE HAS NEVER BEEN A RECALL BY GENERAL MOTORS.
NHTSA complaint #10633120 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
BRAKE LINES WENT OUT WITH NO WARNING - NO LIGHT SHOWING COMPRESSION OR FLUID LEAKING. STILL NO LIGHTS HAVE COME ON. IF WE HAD BEEN GOING FASTER, WE COULD HAVE HIT SOMETHING. LUCKILY MY HUSBAND WAS DRIVING AND HE KNEW HOW TO REACT BY DOWN SHIFTING TO SAVE US. THE BRAKE LINES ARE ALL RUSTED. THE TRUCK ONLY HAS 80,000 MILES ON IT AND HAS BEEN WELL TAKEN CARE OF. WE FEEL THAT GM USED CHEAP METAL FOR THESE LINES AND COULD HAVE COMPROMISED OUR LIVES.
NHTSA complaint #10631534 — an unverified report by a vehicle owner.
SERVICE BRAKES
BRAKE LINES WENT OUT WITH NO WARNING - NO LIGHT SHOWING COMPRESSION OR FLUID LEAKING. STILL NO LIGHTS HAVE COME ON. IF WE HAD BEEN GOING FASTER, WE COULD HAVE HIT SOMETHING. LUCKILY MY HUSBAND WAS DRIVING AND HE KNEW HOW TO REACT BY DOWN SHIFTING TO SAVE US. THE BRAKE LINES ARE ALL RUSTED. THE TRUCK ONLY HAS 80,000 MILES ON IT AND HAS BEEN WELL TAKEN CARE OF. WE FEEL THAT GM USED CHEAP METAL FOR THESE LINES AND COULD HAVE COMPROMISED OUR LIVES.
NHTSA complaint #10631534 — an unverified report by a vehicle owner.
SERVICE BRAKES
YES,I WAS BUYING A NEW TRAILER WHEN I WAS GOING TO STOP AT AN INTERSECTION,THE BRAKE PEDAL, WENT TO FLOOR,LUCKILY USING TRAILER BRAKES,I WAS ABLE TO GET IT STOP,NOTICE LINE BROKE DUE TO RUST,I REPLACED ALL BRAKE LINES WITH STAINLESS STEEL FROM A COMPANY WHO PRE-BEND NEW PIECES THAT SHOULD HAVE BEEN INSTALLED IN THIS TRUCK,DUE TO COST,NOW FUEL LINE LEAKING CAUSING BRAKING DOWN ON SIDE OF HIGHWAY,UNTIL AAA CAME BUT HAD TRAILER ON THAT MADE THE SITUATION HARDER,SO AFTER INCONVENIENCE,HAVE TO PUT NEW STAINLESS STEEL FUEL LINES.THANKS FOR THE TIME TO READ[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #10631122 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
YES,I WAS BUYING A NEW TRAILER WHEN I WAS GOING TO STOP AT AN INTERSECTION,THE BRAKE PEDAL, WENT TO FLOOR,LUCKILY USING TRAILER BRAKES,I WAS ABLE TO GET IT STOP,NOTICE LINE BROKE DUE TO RUST,I REPLACED ALL BRAKE LINES WITH STAINLESS STEEL FROM A COMPANY WHO PRE-BEND NEW PIECES THAT SHOULD HAVE BEEN INSTALLED IN THIS TRUCK,DUE TO COST,NOW FUEL LINE LEAKING CAUSING BRAKING DOWN ON SIDE OF HIGHWAY,UNTIL AAA CAME BUT HAD TRAILER ON THAT MADE THE SITUATION HARDER,SO AFTER INCONVENIENCE,HAVE TO PUT NEW STAINLESS STEEL FUEL LINES.THANKS FOR THE TIME TO READ[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #10631122 — an unverified report by a vehicle owner.
POWER TRAIN
OK THE PROBLEM I'M ABOUT TO STATE IS A HUGE PROBLEM WITH THE 2003 1500 HDS SINCE THEY WHERE NEW AND CHEVY HAS HAD SEVERAL COMPLAINTS OVER THE YEARS WITH A REFUSAL TO REPAIR. THE THROTTLE ACTUATOR CONTROL IS WHAT THE PEDAL SENSOR TELLS TO MOVE THE THROTTLE BODY. EVERY SO OFTEN (SOMETIMES MULTIPLE TIMES A DAY) THIS MODULE WEIRDS OUT AND PUTS THE TRUCK IN TO REDUCED ENGINE POWER (LIMP MODE) AND WON'T DO OVER 25 MPH WHICH IS VERY HAZARDOUS WHEN TRAVELING FREEWAYS AND TURN PIKES WHERE THE SPEED LIMIT IS HIGH.I MYSELF HAVE BEEN ALMOST RAN OVER BY BIG RIGS BECAUSE MY TRUCK DECIDED TO GO INTO THIS REDUCED ENGINE POWER MODE IN THE MIDDLE OF RUSH HOUR. I MYSELF HAVE BEEN ON THE PHONE MULTIPLE TIMES WITH CHEVROLET CORPORATE WITH THEM TELLING ME THAT I'M SCREWED AND TO GET OVER IT. DON'T GET ME WRONG I LOVE MY TRUCK BUT I JUST WISH CHEVY WOULD STAND BY THEIR VEHICLES INSTEAD OF BLOWING US OFF.
NHTSA complaint #10629944 — an unverified report by a vehicle owner.
ENGINE
OK THE PROBLEM I'M ABOUT TO STATE IS A HUGE PROBLEM WITH THE 2003 1500 HDS SINCE THEY WHERE NEW AND CHEVY HAS HAD SEVERAL COMPLAINTS OVER THE YEARS WITH A REFUSAL TO REPAIR. THE THROTTLE ACTUATOR CONTROL IS WHAT THE PEDAL SENSOR TELLS TO MOVE THE THROTTLE BODY. EVERY SO OFTEN (SOMETIMES MULTIPLE TIMES A DAY) THIS MODULE WEIRDS OUT AND PUTS THE TRUCK IN TO REDUCED ENGINE POWER (LIMP MODE) AND WON'T DO OVER 25 MPH WHICH IS VERY HAZARDOUS WHEN TRAVELING FREEWAYS AND TURN PIKES WHERE THE SPEED LIMIT IS HIGH.I MYSELF HAVE BEEN ALMOST RAN OVER BY BIG RIGS BECAUSE MY TRUCK DECIDED TO GO INTO THIS REDUCED ENGINE POWER MODE IN THE MIDDLE OF RUSH HOUR. I MYSELF HAVE BEEN ON THE PHONE MULTIPLE TIMES WITH CHEVROLET CORPORATE WITH THEM TELLING ME THAT I'M SCREWED AND TO GET OVER IT. DON'T GET ME WRONG I LOVE MY TRUCK BUT I JUST WISH CHEVY WOULD STAND BY THEIR VEHICLES INSTEAD OF BLOWING US OFF.
NHTSA complaint #10629944 — an unverified report by a vehicle owner.
SERVICE BRAKES
I WAS PULLING INTO MY CIRCLE COMING DOWN THE HILL AND MY BRAKES STARTED TO FEEL VERY SOFT. I WAS ABLE TO STOP AT THE BOTTOM OF THE HILL JUST BELOW THE CURB. I WAS JUST GRATEFUL THAT THERE WERE NO CARS AT THE BOTTOM OF THE HILL THIS TIME. WHEN I GOT OUT I SAW A TRAIL OF FLUID ON THE STREET COMING DOWN THE HILL UNDER MY TRUCK. I GOT DOWN AND LOOKED UNDER AND THERE WAS A HUGE PUDDLE OF BRAKE FLUID. I TOWED IT TO THE MECHANIC AND HE SAID ALL MY BRAKE LINES LOOKED LIKE THEY WERE FROM A 40 YR. OLD CAR, ALL RUSTED OUT. COST ME A BOAT LOAD TO REPLACE, THAT IS AFTER THEY TRACKED DOWN REPLACEMENT LINES (TOOK THEM OVER A WEEK). THANKS CHEVY, THIS IS OBVIOUSLY A FLAW IN THE LINES ON THIS TRUCK. I APPRECIATE YOU TAKING MY LIFE INTO CONSIDERATION AND RECALLING THESE BRAKE LINES. O WAIT, YOU DIDN'T? THAT'S RIGHT.
NHTSA complaint #10629513 — an unverified report by a vehicle owner.
SERVICE BRAKES
WHILE DRIVING TO WORK I PRESSED THE BRAKE PEDAL AND IT WENT RIGHT TO THE FLOOR. I QUICKLY PULLING INTO A DRIVEWAY AND SLAMMED ON THE EMERGENCY BRAKE BECAUSE I HAD ZERO BRAKING FROM THE PEDAL. I LOOKED UNDERNEATH THE TRUCK AND SAW A RUSTED BRAKE LINE DRIPPING FLUID. IF I WAS ON THE EXPRESSWAY I WOULD HAVE SERIOUSLY HURT SOMEONE BECAUSE I LOST ALL BRAKING FUNCTION.
NHTSA complaint #10629079 — an unverified report by a vehicle owner.