2004 Chevrolet Silverado 1500 wheel problems

WHEELS

While driving the right front factory steel wheel rusted out to the point where the wheel center separated from the outer part of the rim on 4 of the 5 spokes, this caused a dangerous wobble to occur and if the vehicle wasn't being driven in the city I believe this would have resulted in a crash since the wheel was only being held on by 1 of the 5 spokes. Due to the design of these chrome clad wheels you can't see the corrosion that is occuring behind the chrome cladding. I put a spare tire on the vehicle and have since parked it until such time as I can replace all 4 of the wheels since I don't believe this vehicle is safe to be driven at this time. The chrome cladding was thrown off the right front wheel when this occured

NHTSA complaint #11574908 — an unverified report by a vehicle owner.

WHEELS

Front Suspension repaired fixed but did not fixed the vibration in front tires. Front Driver Side Hub and Bearing Assembly Failed since I had truck(used). Had front end redone but wheel still vibrated and took it too dealership July 3, 2021 and stated the Hub and Bearing grinding and growling and activates abs lights. Fuel line needs replace due to rust problems and dealership stated that the pump and retaining cam are very rusted and has a spot on the pump that is wet but not soaking wet(fail dealership looking for lawsuit for fire hazard). Fuel lines are rusted so whole truck needs repair. I spent $5400 on used truck and putting more money into it with repairs due to rust, parts and labor which is stupid as some parts do not take long if dealership have tools. I don't know incident as there no accident or anything.

NHTSA complaint #11423670 — an unverified report by a vehicle owner.

WHEELS

TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO 800. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH, THERE WAS A WOBBLE AND AN ABNORMAL SOUND COMING FROM THE DRIVER'S SIDE FRONT WHEEL. THE CONTACT STATED THAT THE WHEEL HUB DETACHED FROM THE WHEEL ASSEMBLY. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO THE RESIDENCE AND REPLACED THE WHEEL HUB AS NEEDED. THE CONTACT PREVIOUSLY EXPERIENCED THE SAME FAILURE WITH THE PASSENGER'S SIDE FRONT WHEEL HUB AND REPLACED THE WHEEL HUB AS NEEDED. THE VEHICLE WAS TAKEN TO VALLEY CHEVROLET, 180 FLETCHER AVE, SPENCER, IN 47460, BUT WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 243,000. *DT*JB*DT CONSUMER STATED RETAINER RING FELL OUT AND STARTED TO MAKE GRINDING NOISE. AFTER THAT THE FRONT END DROPPED AND THE TIRE FELL OFF AS WELL AS BREAKING THE BRAKE LINE HOSE, STABLIZER BAR AND CALIPER BRACKET.

NHTSA complaint #11311492 — an unverified report by a vehicle owner.

WHEELS:HUB

TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO 800. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH, THERE WAS A WOBBLE AND AN ABNORMAL SOUND COMING FROM THE DRIVER'S SIDE FRONT WHEEL. THE CONTACT STATED THAT THE WHEEL HUB DETACHED FROM THE WHEEL ASSEMBLY. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO THE RESIDENCE AND REPLACED THE WHEEL HUB AS NEEDED. THE CONTACT PREVIOUSLY EXPERIENCED THE SAME FAILURE WITH THE PASSENGER'S SIDE FRONT WHEEL HUB AND REPLACED THE WHEEL HUB AS NEEDED. THE VEHICLE WAS TAKEN TO VALLEY CHEVROLET, 180 FLETCHER AVE, SPENCER, IN 47460, BUT WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 243,000. *DT*JB*DT CONSUMER STATED RETAINER RING FELL OUT AND STARTED TO MAKE GRINDING NOISE. AFTER THAT THE FRONT END DROPPED AND THE TIRE FELL OFF AS WELL AS BREAKING THE BRAKE LINE HOSE, STABLIZER BAR AND CALIPER BRACKET.

NHTSA complaint #11311492 — an unverified report by a vehicle owner.

WHEELS

I WAS EXITING A HIGHWAY TRAVELING 35-40 MILES PER HOUR. THE ROAD HAD A SLIGHT TURN TO THE RIGHT WITH A SMALL PUDDLE OF WATER IN THE MIDDLE OF THE TURN. WHEN I HIT THE PUDDLE MY TRUCK BEGAN TO FISHTAIL. I FIRST THOUGHT I WAS HYDROPLAINING BUT WHEN I TRIED TO DO CORRECTIVE STEERING NOTHING WAS WORKING. THE SWERVING GOT MORE AND MORE VIOLENT AND MOVE THE TRUCK THROUGH 3 LANES OF POSSIBLE ON COMING TRAFFIC. WHEN I REACHED THE BERM ON THE OTHER SIDE OF THE ROAD THERE WAS A LOUD BANG AND MY TRUCK CANTO A SUDDEN STOP. I THOUGHT THAT I HIT THE GUARDRAIL AND WHEN I LOOKED IN MY REAR VIEW MIRROR I SAW MAY SPARE TIRE WHICH WAS MOUNTED UNDER THE BED OF MY TRUCK LAYING ON THE GROUND BEHIND ME. I EXITED MY TRUCK AND SAW I NEVER HIT THE GUARDRAIL AND THE LOUD BANG WAS WHEN THE TIRE BROOK FREE AND BENT OUT MY REAR FENDER. IT SOON BECAME EVIDENT THAT THE SPARE TIRE HANGER CAME LOOSE FROM PART OF THE BRACKET THAT WAS HOLDING IT INPLACE AND WAS SWINGING BACK AND FORTH UNTIL THE PART OF THE HANGER THAT WAS BOLTED ON FINALLY BROKE AND RELEASED THE TIRE. WHILE SWINGING BACK AND FORTH IT DAMAGED ONE OF THE SHOCKS, BENT MY TAILPIPE AND KNOCKED IT OF ITS HANGER AND DID SOME DAMAGE TO THE UNDERSIDE OF THE TRUCK I WAS VERY LUCKY BECAUSE THE LIGHT FOR THE ON COMING TRAFFIC WAS RED AND ALL POTENTIAL HARM AND PROPERTY DAMAGE WAS AVOIDED.

NHTSA complaint #10356248 — an unverified report by a vehicle owner.

WHEELS

WHEN BRAKING AT 3-5 MPH THE BRAKES PULSE LIKE THE ANTILOCKS ARE COMING ON BUT THE LIGHT FOR ANTILOCK OR LOW TRACTION DID NOT COME ON. THIS WAS HAPPENING ALMOST ALL THE TIME. BOTH THE FRONT WHEEL HUBS HAD TO BE REPLACED AT 38,000 MILES!

NHTSA complaint #10278733 — an unverified report by a vehicle owner.

WHEELS

I WOULD LIKE TO REPORT THE FAILURE OF BOTH FRONT WHEEL BEARINGS ON MY 2004 CHEVROLET SILVERADO, 1 IN JAN09 AND 1 IN APR09. I THINK THESE BEARINGS SHOULD LAST MUCH LONGER. PART #1523-3113, ONE LASTED 42,304 MILES AND THE OTHER 39543 MILES. THE TRUCK IS USED FOR PLEASURE DRIVING AND PRIOR TO FAILURE HAS NEVER BEEN USED FOR TOWING.

NHTSA complaint #10266114 — an unverified report by a vehicle owner.

WHEELS:HUB

TL*THE CONTACT OWNS A 2004 CHEVROLET SILVERADO 1500. THE CONTACT MADE A RIGHT TURN AT AN UNKNOWN SPEED AND THE BRAKE LIGHT ILLUMINATED. HE INSPECTED THE VEHICLE AND NOTICED A FAILURE WITH THE WHEEL. HE JACKED THE VEHICLE UP AND NOTICED THAT THE WHEEL WAS LOOSE, AND THE TIRE WOULD WOBBLE 3- 4 INCHES. THE CONTACT CHANGED THE WHEEL BEARINGS HUB ASSEMBLY. TWO WEEKS LATER, THE CONTACT HEARD SOMETHING COMING FROM THE WHEEL AND REPLACED THE OTHER WHEEL HUB ASSEMBLY. THE FAILURE MILEAGE WAS 72,000 AND CURRENT MILEAGE WAS 75,000. UPDATED 07/15/08 *BF UPDATED 07/15/08.

NHTSA complaint #10232421 — an unverified report by a vehicle owner.

WHEELS:HUB

TL*THE CONTACT OWNS A 2004 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE ABS SENSORS MALFUNCTIONED WHEN HE ATTEMPTED TO STOP THE VEHICLE. WHEN HE ATTEMPTED TO COME TO A COMPLETE STOP, THE VEHICLE LUNGED FORWARD AND ALMOST STRUCK A SCHOOL BUS. THE FAILURE WORSENED OVER TIME. HE STATED THAT 4 OUT OF 5 TIMES, WHEN HE WOULD ATTEMPT TO STOP THE VEHICLE, THE ABS WOULD MALFUNCTION AND PREVENT SUFFICIENT BRAKING CONTROL. HE TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE HUBS WERE CORRODED. THE CURRENT MILEAGE WAS APPROXIMATELY 52,000 AND FAILURE MILEAGE WAS APPROXIMATELY 40,000. UPDATED 6/2/08 *CN 06/02/08

NHTSA complaint #10228576 — an unverified report by a vehicle owner.