1998 Chevrolet Silverado engine problems

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT LOW SPEEDS THE ANTI-LOCK BRAKES ACTIVATE, WHICH MADE THE VEHICLE DIFFICULT TO STOP. THIS OCCURRED INTERMITTENTLY ON DRY ROADS DURING NORMAL BRAKING WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP. THE MECHANIC REPLACED THE FRONT BRAKE PADS, WHICH DID NOT REMEDY THE PROBLEM. THE DEALERSHIP AND MANUFACTURER WERE NOT ALERTED. THE MECHANIC INSTALLED A SERPENTINE BELT. UPDATED 03/09/06.

NHTSA complaint #10149894 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

1998 CHEVROLET SILVERADO PICK-UP HAD WHAT APPEARED TO BE RADIATOR LEAK. AFTER FURTHER DIAGNOSIS, WHAT WAS ACTUALLY THE PROBLEM WAS THAT THE FITTING IN THE INTAKE MANIFOLD USED TO CONNECT THE COOLANT HOSE WAS MADE OF A DIFFERENT METAL THAN THE INTAKE MANIFOLD; THE PART CRUMBLED WHILE TRYING TO FIT THE COOLANT HOSE OVER THE FITTING BY HAND (NO TOOLS INVOLVED!). I NOW HAVE A TRUCK IN THE GARAGE THAT I CANNOT DRIVE UNTIL IT IS FIXED BECAUSE THE PART DOES NOT "FIT" DUE TO THE CORROSION WHERE THE DISSIMILAR METALS CAME INTO CONTACT AND CORRODED. THE "NECK" OF THE PART IS STILL CORRODED ON THE MANIFOLD AND A NEW PART CANNOT BE INSTALLED UNTIL THE CORRODED METAL/FITTING IS CLEANED OUT. CORRODED PART IS AVAILABLE. DIGITAL PHOTO OF CORROSION AVAILABLE. CORROSION NOT YET REPAIRED.

NHTSA complaint #10098422 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TRUCK HAS 2 BAD RODS, AND NEEDS A CRANK ONLY HAVE 52K ON IT AND IT LOOKS NEW WE JUST PUT A TRANS IN IT JAN 03 AND NOW IT NEEDS A MOTOR WOW!!!! WE HAVE 8 AUTOS ALL CHEVY THIS TRUCK IS A JUNK!!!!!T THANKS ..

NHTSA complaint #10069118 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

INTAKE MANIFOLD GASKET WAS CRACKED AND LEAKED OUT ALL WATER AND SEVERELY OVERHEATED ENGINE. THE MECHANIC HERE AT WORK SAYS THAT HE HAS CHANGED A FEW HUNDRED OF THESE HERE AT WORK WERE WE HAVE THOUSANDS OF CHEVY TRUCKS THAT ARE THIS SAME ENGINE.

NHTSA complaint #10058386 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

INTAKE MANIFOLD LEAKED COOLANT ONTO THE ENGINE. THIS CAN RESULT IN THE ENGINE OVERHEATING AND RESULT IN A FIRE.*AK THE FITTING IN THE INTAKE MANIFOLD USED TO CONNECT THE COOLANT HOSE WAS MADE OF A DIFFERENT METAL THAN THE INTAKE MANIFOLD ITSELF. THIS CAUSED DISSIMILAR METAL CORROSION IN THE FITTING ITSELF WHICH LEAD TO UNNOTICED PIN HOLE LEAKS IN THE COOLING SYSTEM. CONSUMER FELT GM SHOULD HAVE PROVIDED A BARRIER BETWEEN THE TWO METALS TO SOLVE THE PROBLEM. *PH

NHTSA complaint #10022593 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

I HAVE A 1998 CHEVY SILVERADO 4X4 1 TON PICKUP. I WAS HAVING TERRIBLE OVER HEATING PROBLEMS, SUDDENLY WHILE ON THE HIGHWAY ONE DAY AND I STOPPED AND OPENED THE RADIATOR IT LOOKED LIKE BLACK SLUDGE. AFTER TAKING IT TO BE FIXED I FIND IT IS THE COOLANT THAT CHEVY INSTALLS CALLED DEXCOOL AND IT IS CAUSING ALL KINDS OF PROBLEMS FOR MOST CHEVY CONSUMERS. WHAT CAN WE DO? I HAVE TO HAVE A NEW ENGINE AFTER THEY EMPTIED OUT 1/2 GALLON OF THE SLUDGE FROM MY VEHICLE. THANK YOU, AND I LOOK FORWARD TO HEARING FROM YOU, [XXX]. *JB INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #10018763 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

THE ENGINE COOLANT LEAKED OUT, AND THE VEHICLE OVERHEATED. THIS WAS CAUSED BY THE HEATER NIPPLE BEING CORRODED AND BREAKING OFF.

NHTSA complaint #10012375 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

WHILE MAKING A TURN VEHICLE WILL STALL ,AND WILL BE HARD FOR VEHICLE TO START BACK UP. DEALER NOTIFIED.

NHTSA complaint #8015538 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

STEERING WHEEL VIBRATED, PROBLEM EXISTED FOR A TIME. EVO SENSOR NEEDED REPLACEMENT AGAIN AS PROBLEM HAS REOCCURRED.

NHTSA complaint #8004339 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

WHILE DRIVING 40 MPH VEHICLE STALLED.ALSO, DEALER REPLACED POSITIVE POST CONNECTOR OF BATTERY.

NHTSA complaint #899904 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

ON TOP OF ENGINE ELECTRICAL WIRES ARE CONNECTED, AND FUEL IS BYPASSING INTO CONTROL MODULE. WHEN VEHICLE IS UNDER PRESSURE, IT CAUSES FUEL TO LEAK INTO ENGINE COMPARTMENT, WHICH COULD COME INTO CONTACT WITH THE MANIFOLD, CAUSING A FIRE HAZARD. CONSUMER HAS CONTACTED DEALER.

NHTSA complaint #870511 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

ONGOING PROBLEM WITH VEHICLE HESITATING / STALLING AT A STOP POSITION. WHEN APPLYING THE ACCELERATOR PEDAL CARBURETOR FLOODED. VEHICLE BEEN INSPECTED/REPAIRS ON TWO OCCASIONS, AND BEEN TO TWO DIFFERENT DEALERS, AND PROBLEM STILL REOCCURRING.

NHTSA complaint #853629 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

OXYGEN SENSOR FAILED. YH

NHTSA complaint #607342 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

ON-GOING / INTERMITTENT PROBLEM WITH VEHICLE STALLING WHILE DRIVING, THIS CONDITION HAPPENS BETWEEN 30-70 MPH. SOMTIMES VEHICLE WOULD NOT RESTART. BEEN IN/OUT OF DEALER SHOP ON FIVE OCCASIONS AND A TOTAL 45 DAYS, AND DEALER IS STILL UNABLE TO RESOLVE THE PROBLEM. CAN NHTSA PROVIDE FURTHER DETAILS IN THIS MATTER.

NHTSA complaint #844146 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

SMOG AND CHECK VALVE DIAPHRAM CRACKED AND LEAKING EXHAUST FUMES. MJS

NHTSA complaint #605985 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

ENGINE KNOCKING CONTINUALLY, NORMAL CONDITION OF VEHICLE (SERVICE BULLETIN 77-61-21). MJS

NHTSA complaint #605985 — an unverified report by a vehicle owner.