1999 Chevrolet Venture brake problems

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

WHEN ENTERING AN INTERSECTION AFTER LEAVING A STOP SIGN THE TRACTION CONTROL LIGHT AND ABS LIGHT ON THE DASH CAME ON AND THE VAN BEGAN JERKING AND LURCHING IN INTERSECTION UNABLE TO MOVE THROUGH INTERSECTION FOR ATLEAST 10 SECONDS BEFORE THE LURCHING STOPPED. ALWAYS HAPPENS WHEN COMING FROM A STOP SUCH AS A RED LIGHT, WHEN ENTERING STREET FROM SIDE ROAD. HAPPENS INTERMITTENTLY, MORE OFTEN WHEN ENGINE IS COLD. HAVE COME CLOSE TO BEING HIT MANY TIMES, OTHER DRIVERS HAVE HAD TO SLAM THEIR BRAKES TO STOP FROM HITTING ME BECAUSE IT CAN LURCH AND JERK NOT GOING ANYWHERE FOR UP TO 30 SECONDS AT TIMES WHILE VAN IS IN INTERSECTION OR ENTERING A ROAD. ABS MOTOR WAS FOUND TO BE WEAK, BUT MECHANIC CANNOT FIND PROBLEM WITH THE TRACTION CONTROL SYSTEM IN ORDER TO FIX IT.

NHTSA complaint #10223153 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

I HAVE HAD SO MANY PROBLEMS 1. THE INNER BRAKE PADS WORE DOWN TO THE STEEL RUINING THE INSIDE OF BOTH ROTORS ABOUT 3,000 MILES. UNDER WARRANTY. BUT THE BRAKE PADS. 2. BATTERY ACID IS CORRODING ABOUT 4,000 MILES THE DEALERSHIP PAY ALL STILL UNDER WARRANTY 3. BATTERY AGAIN BUT IT TURN OUT TO BE THE ALTERNATOR ABOUT 6,500 THE DEALERSHIP PAY UNDER WARRANTY. 4. THE TREAD COMPLETELY SEPARATED FROM THE SIDEWALL. P215/70R15, FIRE STONE ON ALL FOUR TIRES. DEALERSHIP DID NOT COVER TIRE HAVE NO WARRANTY ON NEW VEHICLE 7,000 MILES 5. WATER LEAK, AND CARPET IS WET EVERY TIME IT RAINS I FEEL IT IS COMING FROM THE WINDSHIELD. WARRANTY DOES NOT COVER. 8,000 STILL DOES IT AT 50,256. 6. LIGHTER KEEP SHORTING OUT AND AC KEEP MESS UP UNDER THE WARRANTY 7. WHILE DRIVING THE CHECK OIL LIGHT AND THE BATTERY LINE CAME ON. THE VEHICLE SHUT OFF, LOOSING ALL POWER THE INTAKE MANIFOLD UNDER WARRANTY 38,000 MILES. 8. INTAKE MANIFOLD FIX CAME HOME MY LIGHTS WAS MESS UP WHEN PUT ON MY BRAKES THE FOUR WAY FLASHER CAME ON WHEN I PUT MY LEFT TURN SIGNALS THE RIGHT ONE WOULD CAME ON PUT THE RIGHT TURN SIGNALS THE LEFT ONE WOULD COME ON TOOK IT BACK THEY HAD TO REPAIRED ENTIRE WIRING SYSTEM BECAUSE OF OVER HEARTED BURN IT UP UNDER WARRANT 9. BATTERY ACID IS CORRODING THE BATTERY PAN AND SURROUNDING COMPONENTS, POSITIVE CABLE CONNECTED TO BATTERY HAS FALLEN OFF,38,500 NOT COVER 6 YEAR WAS UP. 10. POWER STEERING FLUID SPRAYING FLUID ONTO THE ENGINE AND SERPENTINE BELT THE DEALERSHIP DID NOT PUT CAP BACK ON POWER STEERING. 11. POWER LOCKS WILL NOT OPERATE FROM DOOR SWITCHES ONLY FROM THE REMOTE POWER WINDOW. BACK AC DOES NOT WORK. 12. CONNECTOR LEFT AND RIGHT MELT TAIL LIGHTS, STOP LIGHTS, TURN SIGNALS ABOUT 42,000. 13. THERE IS A THUMP NOISE WHEN STOPPING AND TAKING OFF. 14. STRONG SMELL OF FUEL WHEN PARKED. 15. CLOUDING OF LENS 16. SERPENTINE BELT REPLACE AT 50,256 17. LEAKING FROM LOWER INTAKE MANIFOLD GASKET. AT 50,000.

NHTSA complaint #10157702 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

I WAS PARKING MY CAR AT A MALL, I PUT ON THE BRAKE AND HIT BRAKE PEDAL AND ACCELERATOR PEDAL TOGETHER, THE ACCELERATOR ALMOST TOOK MY CAR INTO THE CEMENT PARKING BOLLARD, BUT I MANAGED TO STOP THE CAR 1 1/2 " FROM DAMAGING THE CAR. I HAVE COMPLAINED IN THE PAST ABOUT THIS PROBLEM OF THE HEIGHT OF THE PEDALS TO CHEVROLET DEALER WITH NO SATISFACTION. "THAT'S THEY WAY THEY ARE BUILT, THERE IS NO DEFECT". THIS SITUATION HAS CAUSED ME PROBLEMS IN THE PAST, ALMOST HITTING A CURBSTONE AND THE LIKE. I COULD BE BLAMED FOR HITTING A PEDESTRIAN BECAUSE THE ACCELERATOR TAKES OVER BEFORE THE BRAKE PEDAL IF BOTH ARE PUSHED SIMULTANEOUSLY. THE BRAKE PEDAL SHOULD BE MOUNTED SO THAT IT WILL BE PUSHED FIRST SO AS TO STOP THE CAR AND NOT ALLOW THE ACCELERATOR PEDAL TO BE PUSHED. I GOT NO HELP FROM THE DEALER. I AM AFRAID THAT I COULD GET INTO A SERIOUS ACCIDENT BECAUSE OF THIS SITUATION. IN A GREAT HURRY, MY FOOT STRUCK BOTH PEDALS AT THE SAME TIME. THE BRAKE PEDAL SHOULD BE HIGH ENOUGH TO TAKE OVER. I HAVE HAD THE BRAKES CHECKED REGULARLY, I KEEP NEW TIRES ON MY CAR. MY CAR ALWAYS PASSES INSPECTION. I DRIVE A 1999 CHEVROLET VENTURE. I BOUGHT IT AT CLAY CHEVROLET ON SEPTEMBER 15, 2002, USED WITH 33963 MILES ON THE ODOMETER. IT NOW HAS 66650 MILES.

NHTSA complaint #10108301 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

WHILE DRIVING TURN SIGNAL LIGHTS/ABS, AND SRS LIGHTS FLASHED ON AND OFF THE DASHBOARD. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO DEALER FOR INSPECTION, AND THE MECHANIC COULD NOT BE DUPLICATE THE PROBLEM.

NHTSA complaint #10087239 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

MAIN PROBLEM: JAN 03 CAM SHAFT BROKE, ENGINE MUST BE REPLACED. MAR 02 : INTAKE MANIFOLD GASKET REPLACED. LEAKING COOLANT INTO ENGINE. OCT 02 BRAKE ROTORS WARPED. SHAKES VIOLENTLY WHILE BRAKING.

NHTSA complaint #10069477 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

MY 1999 CHEVROLET VENTURE MINIVAN HAS HAD NUMEROUS PROBLEMS. THE ONE I AM MOST CONCERNED WITH IS THE AUTOMATIC TRANSMISSION. THE TRANSMISSION MAKES THE CAR JERK WHEN I EITHER SLOW DOWN OR STOP IN HEAVY TRAFFIC. THIS HAPPENS WHEN I PRESS ON THE ACCELERATOR TO GAIN SPEED AGAIN. IT DOESN'T HAPPEN EVERY TIME BUT MORE OFTEN THAN NOT. THERE ARE ALSO TIMES WHEN DRIVING DOWN THE ROAD IT WHINES. ALSO HAVE A PROBLEM WITH WHAT I FIGURE IS ELECTRICAL. SOMETIMES THE ABS LIGHT STAYS ON AND THEN EVENTUALLY GOES OFF. ALSO, THE AIR BAG LIGHT COMES ON INTERMITTENTLY. *NLM

NHTSA complaint #10049196 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

WHILE DRIVING OUTSIDE BRAKE PAD ON THE LEFT ROTOR FELL OFF. VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO FOUND THE LEFT ROTOR AND INSIDE PAD WERE RUSTED. THE MECHANIC INSTALLED ANEW LEFT ROTORS AND PADS. *AK RIGHT PAD AND ROTOR WAS REPLACED. MECHANIC STATED THE RUST ON THE LEFT PAD AND ROTOR WAS NORMAL, CONSUMER DISAGREED.

NHTSA complaint #10047991 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

WHILE DRIVING OUTSIDE BRAKE PAD ON THE LEFT ROTOR FELL OFF. VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO FOUND THE LEFT ROTOR AND INSIDE PAD WERE RUSTED. THE MECHANIC INSTALLED ANEW LEFT ROTORS AND PADS. *AK RIGHT PAD AND ROTOR WAS REPLACED. MECHANIC STATED THE RUST ON THE LEFT PAD AND ROTOR WAS NORMAL, CONSUMER DISAGREED.

NHTSA complaint #10047991 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE

SEAT BELT FRONT LEFT/RIGHT TENSIONER SHORTED. WILL NOT ACTIVATE THE FRONT AIRBAGS IN AN ACCIDENT ACCORDING TO CHRISTENSON CHEVROLET IN HIGHLAND, INDIANA ALSO, ABS BRAKE SWITCH AND TRACTION CONTROL(TCS) SWITCH WERE ALSO SHORTED.

NHTSA complaint #10028395 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:DRUM

COOLANT LEVEL KEPT DROPPING AND THE BRAKES FELT SPONGY. TOOK TO LOCAL DEALER AND FOUND THAT MAINFOLD GASKET WAS LEAKING AND NEEDED TO BE REPLACED AND THE REAR CYLINDERS WERE LEAKING AND NEEDED TO BE REPLACED. REPAIR COST $1078.00 FOR BOTH. THIS VAN ONLY HAS 56,000 MILES. GOOD TO SEE THAT OTHERS ARE HAVING PROBLEMS WITH THESE COMPONENTS, MAYBE THE MANUFACTURER NEEDS TO RECALL AND FIX THESE PROBLEMS. A VEHICLE OWNER SHOULDN'T HAVE TO SPEND THIS KIND OF MONEY(FOR THESE KIND OF REPAIRS) AND RISK THEIR FAMILY ON THE ROADSIDE ON VEHICLES WITH THIS FEW OF MILES AND AGE. I'VE ALSO HAD AN AIR BAG WARNING LIGHT ON FOR MOST OF THE TIME THAT I'VE HAD THE VEHICLE. IT WAS WORKED ON A COUPLE OF TIMES DURING THE WARRANTY PERIOD. THE DEALER SAID IT WAS AN AIR BAG SENSOR PROBLEM. THIS VEHICLE HAS FRONT AND SIDE AIR BAGS. I HOPE THE AIR BAGS DEPLOY IN CASE OF AN ACCIDENT.

NHTSA complaint #10005543 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

CONSUMER STATED THAT WHEN APPLYING THE BRAKES THE BRAKE LIGHT WILL COME ON AND STAY ON THE REMAINDER OF THE TIME VEHICLE IS BEING OPERATED. DEALER NOTIFIED. TS

NHTSA complaint #8023052 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT

CONSUMER STATES THE ANTI-LOCK BRAKE LIGHT COMES ON INTERMITTENTLY. MANUFACTURER NOTIFIED, ALSO THE FRONT BRAKE AND ROTORS HAVE BEEN REPLACED.

NHTSA complaint #566656 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

CONSUMER STATES THE ANTI-LOCK BRAKE LIGHT COMES ON INTERMITTENTLY. MANUFACTURER NOTIFIED, ALSO THE FRONT BRAKE AND ROTORS HAVE BEEN REPLACED.

NHTSA complaint #566656 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

WHILE DRIVING ABS LIGHT ILLUMINATED, TURN SIGNAL PERFORMED ERRATICALLY DUE TO PIG-TAIL, CIRCUIT BOARD SOCKET FAILURE. *AK CONSUMER STATED THAT BAD SEAL ON PIG TAIL CAUSED MOISTURE TO ENTER CIRCUIT BOARD.

NHTSA complaint #8014523 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ABS BRAKE FAILURE.

NHTSA complaint #8003498 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

THIS VEHICLE IS DESIGNED SO THAT WHEN APPLYING BRAKES, THE PEDAL GOES OVER HALF WAY TO THE FLOOR, THIS CAUSES DRIVER TO HIT BRAKE PEDAL AND GAS PEDAL AT SAME TIME, WHICH COULD CAUSE AN ACCIDENT IN A PANIC BRAKE SITUATION. *AK

NHTSA complaint #8003499 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

ROTORS WERE TURNED DUE TO BAD VIBRATION. PROBLEM CAME BACK WITH A SQUEAK. 11 MONTHS LATER, VEHICLE NEEDED ROTORS. PROBLEM CAN BE REMEDIED AT CONSUMER'S EXPENSE.

NHTSA complaint #895988 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

THE INNER BRAKE PADS WORE DOWN TO THE STEEL RUINING THE INSIDE OF BOTH ROTORS, 50% OF THE BRAKE LINING REMAINED ON THE OUTER PADS. NLM

NHTSA complaint #550264 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

CONSUMER HAD NOTICED WHEN COVERS ON SEATS GET HOT THEY WILL OPEN, SIDE AIR BAGS AND WIRES COULD BE SEEN. CONSUMER BELIEVED IT WAS A SAFETY CONCERN. *AK RIGHT THIRD ROW SEAT WAS BENT, DEALER MADE ADJUSTMENT. VEHICLE IS EXTREMELY HARD TO STOP. *SLC

NHTSA complaint #891548 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

THERE IS A THUMP NOISE WHEN STOPPING AND TAKING OFF. CONSUMER FEELS IT'S SOMETHING WITH BRAKES.

NHTSA complaint #881065 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

WHILE TRAVELING AT VARIOUS SPEEDS ENGINE WILL START TO OVER REV FOR NO REASON. PRESSING BRAKES DOES NOT SEEM TO HELP. DEALER HAS REPAIRED ENTIRE WIRING SYSTEM,AND THE PROBLEM STILL OCCURS.

NHTSA complaint #878161 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

WE HAVE HAD NOTHING BUT PROBLEMS WITH OUR "LEMON" AND WE HAVE RECEIVED NO RESPONSE FROM CHEVROLET ON OUR CONCERNS.

NHTSA complaint #737217 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

BRAKE PROBLEM, DEALER CHANGED BRAKES MANY TIMES, BRAKES FAILED

NHTSA complaint #9000721 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

PROBLEM IS ONGOING AND AWAITING ARBITRATION HEARING W/ MANUFACTURER SCHEDULED FOR APRIL 21, 2000. NO SAFETY DEFECT DISCUSSED WITHIN SUMMARY.

NHTSA complaint #720963 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

FEMALE DRIVER IN NEAR VICINITY OF ATM MACHINE AT LOCAL BANK WHEN ANOTHER VEHICLE PULLED OUT, REQUIRING QUICK REACTION AND APPLYING HARD BRAKING ACTION. THE BRAKE PEDAL REACTED WITH A SUDDEN LOSS OF PRESSURE AND A SPONGY FEEL. DRIVER ATTEMPTED TO DRIVE 4 MILES TO HOME AND RESULTED IN A TOTAL LOSS OF BRAKE PRESSURE WITH PEDAL TRAVELING TO FLOOR. VISUAL OBSERVATION BY VEHICLE OWNER DISCOVERED CHAFFING CONTACT AND SUBSEQUENT FAILURE OF BRAKE LINE WITH WINDSHIELD WIPER DRIVE BAR LOCATED UNDER HOOD. THE BRAKE LINE CHAFFED IS ONE OF FOUR LINES LEAVING THE MASTER BRAKE CYLINDER AND CONTACT MADE WITH DRIVE BAR OF WIPER SYSTEM IN THE AREA OF BRAKE LINE CONTAINING METAL BRAID ON A SMALL FLEXIBLE LENGTH. HOSE DIAMETER APPROXIMATELY .50. VEHICLE OWNER IS AN AEROSPACE DESIGN ENGINEER AND RECOGNIZES THAT FAILURE IS A VEHICLE DESIGN ISSUE DUE TO INADEQUATE CLEARANCE BETWEEN BRAKE LINE AND WIPER DRIVE BAR. THIS IS A SAFETY RELATED FAILURE.

NHTSA complaint #717786 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ABS BRAKE PROBLEMS; WHEN APPLYING THE BRAKES, DURING NORMAL BREAKING, THE PEDAL GOES ALL THE WAY TO THE FLOORBOARD IF STEADY PRESSURE OF THE PEDAL IS REQUIRED. ALSO THE PEDAL IS SPONGY. THE PROBLEM HAS BEEN REPORTED TO THE DEALERSHIP/MANUFACTURER. PROBLEM HAS NOT BEEN CORRECTED. PLEASE PROVIDE ANY FURTHER INFORMATION.

NHTSA complaint #853213 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

WHEN DRIVING ON NORMAL PAVEMENT UNDER NORMAL CONDITIONS, WHEN BRAKES ARE APPLIED, THEY PULSATE AND LOCKUP. THIS HAS CAUSED CONSUMER TO ALMOST BE TOSSED THROUGH THE WINDSHIELD IF NOT FOR THE SEAT BELTS. DEALER HAS BEEN CONTACTED, AND REPLACED ROTORS, ONCE BUT THE PROBLEM STILL OCCURS.

NHTSA complaint #853031 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

WHEN DRIVING ON NORMAL PAVEMENT UNDER NORMAL CONDITIONS, WHEN BRAKES ARE APPLIED, THEY PULSATE AND LOCKUP. THIS HAS CAUSED CONSUMER TO ALMOST BE TOSSED THROUGH THE WINDSHIELD IF NOT FOR THE SEAT BELTS. DEALER HAS BEEN CONTACTED, AND REPLACED ROTORS, ONCE BUT THE PROBLEM STILL OCCURS.

NHTSA complaint #853031 — an unverified report by a vehicle owner.