2011 Chrysler 200 engine problems

ENGINE

2011 Chrysler 200, 156k miles, Original owner. At Highway Speeds engine will shut off! Extremely dangerous as you lose power steering and brakes on a busy interstate. No warning lights. No check engine. Issue just started happening and has happened multiple times in last 3 weeks. Car is unsafe to drive. After occurrence car will restart after about 30 minutes. I do not know why NHTSA or Chrysler hasn't done anything to initiate an investigation and recall. This issue is widely reported on many forums. After second instance, a repair shop reproduced issue and saw U1403 so they updated PCM/ECU as they couldn't find anything else. It has happened since then and my scanner showed DTC codes P061C status code 30 and U0401 status code 20.

NHTSA complaint #11685507 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2011 Chrysler 200. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle lost motive power. Additionally, the contact stated that the vehicle occasionally failed to start-up as needed. The vehicle was taken to several independent mechanics however, the failure persisted. The vehicle was not repaired. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 149,000.

NHTSA complaint #11588902 — an unverified report by a vehicle owner.

ENGINE

I BOUGHT A 2011 CHRYSLER 200 SEDAN IN THE SUMMER OF 2021. IN DECEMBER OF2021, I TOOK MY CAR TO A DEALERSHIP BECAUSE MY HEATER DIDN'T WORK. UPON THEIR DIAGNOSIS, THEY SAID I HAD A BAD HEATER CORE. BECAUSE I HAD JUST PURCHASED THE CAR, THEY AGREED TO TAKE OFF $400 OFF THE REPAIR. IT STILL COST ME $1100.00. FAST FORWARD TWO YEARS AND THE SAME THING HAPPENED. UNFORTUNATELY, THE WARRANTY EXPIRED 1 MONTH EARLIER. I BELIEVE THIS IS BAD DESIGNED UNIT. UPON RESEARCHING PROBLEMS WITH THIS CAR, IT COMES UP AS A PRETTY COMMON OCCURANCE. I KNOW THEY DON'T BUILD THIS VEHICLE ANYMORE. I BELIEVE CHRYSLER SHOULD'VE COME UP WITH A DESIGN FIX FOR THIS.

NHTSA complaint #11570592 — an unverified report by a vehicle owner.

ENGINE

I already have a compliant from back in January of 2022 and original incident date of December 2021. I am still having the same issue with the engine stalling while driving. This keeps happening on highways. At this point the government and Chrysler are a joke. This is supposed to be highway safety yet you guys are letting us with Chryslers deal with this and put our life at risk. Not everyone has the ability to have another car to drive, or just has money to trade their vehicle in. I dont get how this "problem" was so called fixed yet EVERYONE IS HAVING THE ISSUE STILL. Wasting thousands of dollar to not find a solution. If something happens to me because of this I promise you I will sue NHTSA and Chrysler Dealer and make sure I make you guys just a miserable as we Chrysler owners are.

NHTSA complaint #11534264 — an unverified report by a vehicle owner.

ENGINE

My car will die sometimes upon acceleration and does not restart for up to an hour sometime. No check engine light comes on. From my research online, a lot of people are having the same issue and are reporting it to be a faulty PCM (Powertrain Control Module). My RPM drops to zero and I have to coast to the shoulder of the road. It happens at least once a week.

NHTSA complaint #11497308 — an unverified report by a vehicle owner.

ENGINE

The vehicle repeatedly stalls out when coming to a stop or when sitting at a stop light or in traffic, and has also shut off while driving at higher speeds on the freeway. This has put myself and passengers in danger, as power steering goes out when the engine is off and braking becomes much harder. The car will not turn back on if the problem occurs at higher speeds, but will turn back on if it occurs at lower speeds and stops. I have taken the car to several shops and they have confirmed this is an issue but cannot pinpoint what exactly is causing it, which has gotten to be very costly. I have yet to take it to the dealership for their insight into the issue. There are no warning lights on the dash, and the only slight codes I have in the system are unrelated to the way the car would drive as explained by the mechanics at the shops I have taken it to.

NHTSA complaint #11495970 — an unverified report by a vehicle owner.

ENGINE

i will be driving at the speed limit and the vehicle engine will turn off. power steering and control of the vehicle will stop. the car will not restart leaving me stranded on the road. this appears to be an issue that others are reporting. there is NO check engine light or any notification that the engine is about to stop.

NHTSA complaint #11490512 — an unverified report by a vehicle owner.

ENGINE

car keeps shutting off with no warning loss of brakes and steering and no acellation this issue was brought up before but not addresse on

NHTSA complaint #11465670 — an unverified report by a vehicle owner.

ENGINE

The car begins to buck hard and drive sluggish on the highway around 45 miles per hour. And when stopped idle at the light stalls regularly. I took it to the dealer and they had me replace the cam shift sensor. The repair did not work. It continues to stall

NHTSA complaint #11458967 — an unverified report by a vehicle owner.

ENGINE

On multiple occasions, the car will stall while driving, locking up the whole system and forcing the driver to coast to the side of the road. The car will not restart for 30-40 minutes while you sit stranded on the side of the road. Searches on the car reveal this is not the only one it is happening to. This needs to be investigated as a car stalling on the freeway in 0 degree weather is a major hazard.

NHTSA complaint #11452237 — an unverified report by a vehicle owner.

ENGINE

My engine is misfiring out of the clear blue. And when I say misfire I mean my vehicle will literally shut off mid-drive as you’re in traffic. Everything completely shuts off and the wheel will lock up. So if you’re not somewhere where you can pull over a pile up will ensue. I have taken it to a shop when the car cut off on the highway for the 3rd with what I thought was the issue. I spent large amounts of money for the shutting off to continue. When I picked it up from the shop the car shut off again about two weeks later or so. I brought it back to the same place and they took my car for the day to see what the issue could be. They gave it back and told me they have no idea why the car keeps shutting off and they have done all they possibly could. This problem could’ve have caused multiple accidents as most of the incidents have resulted of loss of power on the highway. To be going at a steady speed with other cars around you and suddenly shut off can cause everyone including myself to be injured if not worse. This is a common problem among these vehicles as I have read up on and no one has done anything about it. This is scary and something needs to be done. These brand cars are discontinued and I can only imagine why. This is ridiculous that I’m risking my life everyday because I don’t know if this will be the day an accident happens. Consumer stated on Feb 9th at 653am consumer was driving with my 3 year old nephew and the car was completely cut off in the middle of traffic. Unfortunately the car took over 3 hours to decide to start again. Happened again on Feb 17th, 2022.

NHTSA complaint #11449583 — an unverified report by a vehicle owner.

ENGINE

1) The engine suddenly cut off, power braking and power steering were gone. This happens randomly under any circumstances, with absolutely no precursors. The car will not start for about an hour, and after that time it starts with absolutely no issues, no check engine light, nothing. Yes, it is available for inspection upon request. 2) While driving on the highway at about 65mph, all power was lost, and ability to control the car was extremely limited, and this happened multiple times. Only by pure fortune I avoided a fatal crash when the car died in rush hour. 3) After the first time this has happened the car was taken to a mechanic, and they were not able to replicate the issue under any circumstances that they tried, and there was nothing wrong with the car that would warrant this, as it has never been in an accident, and was well maintained. 5) No, has not been inspected by anyone besides the standard state inspection and the mechanic that attempted to fix it. 6) There was never and still isn't anything wrong with the car that I know of, no weird noises, no engine light, no issues whatsoever besides it randomly dying and then coming back to life like nothing happened. ------------------------- As you may see, there are multiple cases of this happening and it was never adressed: https://www.carcomplaints.com/Chrysler/200/2011/engine/engine_dies_while_driving.shtml

NHTSA complaint #11448637 — an unverified report by a vehicle owner.

ENGINE

Yesterday, when I was dropping Christmas, presents off to my son at his moms' house. My 2011 Chrysler 200, Convertible limited with 3.6L v6 Pentastar flex-fuel motor. temp gauge went all the way up into Red. Which had to cross lanes on highway so I could get off on the freeway ramp. which I made it a block and the car stalled in below-freezing temps with no heat figuring out what to do as I get out of the vehicle I noticed brown motor oil bubbling and gushing out a Coolant reservoir With oil streaks all the way down passenger side car including through rims. I researched flaws and issues that Chrysler acknowledges, like that class-action lawsuit for vehichlwes not covered under extended vehicles that have the same issue, and problems Also how come even tho my vehicle 2011 Chrysler is not covered when covered is 2012 - 2017 even thos my car motor is identical as 2012 - 2013 Which was the first generation with faulty Oil cooler. or when they used sand casting molds to make cylinder heads which some of the sand stayed and circulated through the system, Causing oil cooler lines and coolant passageways. Pretty much was left stranded in freezing below temps with a car where motor oil spueling out of coolant overflow tank, over the windshield where I could barely see when trying to pull over. also oil all down passenger side of vehicle wet from front to back . not to mention other faults with the multi systems. Please visit this link https://www.ecogard.com/chryslers-problem-pentastar-v6-oil-filter-housing-cooler-assembly-what-means-oil-filter-installers/ .

NHTSA complaint #11445008 — an unverified report by a vehicle owner.

ENGINE

THIS IS THE THIRD TIME THE ENGINE COMPLETELY SHUT OFF IN THE MIDDLE OF DRIVING. FIRST TIME IT STARTED BACK UP AFTER 5 MINUTES. SECOND TIME STARTED BACK UP AFTER BEING JUMPED EVENTHOUGH THE BATTERY HAD CHARGE. THIS LAST TIME THE CAR WOULD NOT START. IT HAS THE POWER IT WAS TURNING OVER BUT THE ENGINE WOULD NOT START. POWER STEERING TURNED OFF IN BOTH OCCASIONS. I HAD TO HAVE ME VEHICLE TOWED AND IT STILL WILL NOT START. I WAS DRIVING APPROXIMATELY 60 MPH ON A PAVED HIGHWAY ROUTE 244, IT TURNED OFF ON A STRAIGHT AWAY, NO HILLS OR TURNS.

NHTSA complaint #11415001 — an unverified report by a vehicle owner.

ENGINE

HEATER CORE PLUGS FROM THE DEXCOOL BRAKING DOWN, THEN FINALLY STARTS TO LEAK CAUSING LACK OF HEAT, EVENTUALLY FOGGING THE WINDOWS SO YOU CAN'T SEE CAUSING MULTIPLE SAFETY HAZARDS. COMMON PROBLEM FROM WHAT I SEE ON LINE! YOU DON'T REALIZE IN SUMMER WHEN YOU BUY THE CAR TILL YOU GO TO USE IT IN THE SPRING AND IT'S NOT COVERED UNDER WARRANTY!

NHTSA complaint #11376119 — an unverified report by a vehicle owner.

ENGINE

RECALL ON CATYLITIC CONVERTER

NHTSA complaint #11374768 — an unverified report by a vehicle owner.

ENGINE

DRIVING ON THE ROAD IN MOTION, THE ENGINE SHUT DOWN WITH NO WARNING. HAD IT TOWED TO SHOP WHERE IT STARTED UPON ARRIVAL (APPROX. 1 HOUR). NO CHECK ENGINE LIGHT CAME. RAN ENGINE SCAN AND NO CODES CAME UP. DIAGNOSTIC PROVIDED NO INFORMATION. CONDITION COULD NOT BE REPEATED. NOTHING WAS RESOLVED. HAPPENED SEVERAL MORE TIMES WHILE IN MOTION OVER THE NEXT 2 MONTHS. SOMETIMES ON THE FREEWAY, SOME ON A ROAD. ALWAYS STARTS AGAIN AFTER 45 MINUTES. HAS BEEN TO MULTIPLE SHOPS WHERE NOTHING IS DIAGNOSED. PROBLEM PERSISTS TO THIS DAY. WE INSTALLED AN ENGINE SCANNER TO DETECT ANY CODES GIVEN WHEN ENGINE QUITE. CODES ARE AS FOLLOWS: ANTI LOCK BRAKES CODE U0401 - ACTIVE/MIL - IMPLAUSIBLE DATA RECEIVED FROM ECM/PCM AND POWERTRAIN CONTROL MODULE CODE P061C ETC LEVEL 2 RPM PERFORMANCE

NHTSA complaint #11365949 — an unverified report by a vehicle owner.

ENGINE

THE CAR DIES WHILE DRIVING DOWN THE HIGHWAY

NHTSA complaint #11350425 — an unverified report by a vehicle owner.

ENGINE

WHILE DRIVING, USUALLY DECELERATING OR GETTING READY TO STOP OR ALREADY STOPPED AND GETTING READY TO ACCELERATE THE ENGINE WILL STALL OR COMPLETELY SHUT OFF, WILL BE COMPLETELY HOT, WILL TAKE ABOUT 15-20 MINUTES AND THEN WILL START AGAIN. THIS HAS CAUSED MY SON SAFETY ISSUES WHERE HE'S COMPLETELY STOPPED RUNNING ON A BUSY ROAD AND THEN HAD TO PUSH THE CAR INTO EITHER A PARKING LOT WITHOUT POWER STEERING (HARD TO DO BY HIMSELF AT 18 YO) OR INTO A DRIVEWAY. THIS HAS ALSO HAPPENED IN THE COUNTRY AT NIGHT. NO LIGHTS COME ON EXCEPT ONCE WHEN THE ABS AND TRACTION LIGHTS CAME ON. THE VEHICLE WILL VIBRATE SLIGHTLY BEFORE EACH EPISODE. THE LAST EPISODE WE HAD TO HAVE IT TOWED. HAS HAPPENED ABOUT 6 TIMES. NOW NO LONGER DRIVING DUE TO SAFETY!!

NHTSA complaint #11340568 — an unverified report by a vehicle owner.

ENGINE

WHILE DRIVING, THE VEHICLE LOSES ALL POWER. JUST SHUTS DOWN. NO WARNING. NO WARNING LIGHTS. NO CODE. NO CHECK ENGINE LIGHT.

NHTSA complaint #11338666 — an unverified report by a vehicle owner.

ENGINE

THE CHRYSLER 200 WILL STALL OUT OF THE BLUE AND THE ENGINE WILL COMPLETELY SHUT OFF. IT HAS HAPPENED 3 TIMES WITHIN THE PAST MONTH. IT ALWAYS HAPPENS WHEN YOU LET UP ON THE ACCELERATOR. ALL THE TIMES IT HAPPENED WAS WHILE IN THE CITY. IT HAPPENS WHILE ALWAYS IN DRIVE AND ON THE ROAD. 3 TIMES HAD TO GET IT TOWED. AND EVERY TIME AFTER WE GOT IT HOME IT WOULD START UP LIKE NOTHING HAPPENED. PLEASE HELP. ITS VERY FRUSTRATING

NHTSA complaint #11318989 — an unverified report by a vehicle owner.

ENGINE

THE CAR STALLS WHEN IT SLOWS DOWN OR COMES TO A STOP (FOR EXAMPLE AT A RED LIGHT). SO FAR, IT STARTS UP WITH NO PROBLEM. HOWEVER, I BELIEVE THIS IS POTENTIALLY DANGEROUS IF IT STALLS IN HEAVY TRAFFIC. THERE IS NO CHECK ENGINE LIGHT AND DESPITE ATTEMPTING A VARIETY OF FIXES, SO FAR NOTHING HAS SOLVED THE PROBLEM.

NHTSA complaint #11311779 — an unverified report by a vehicle owner.

ENGINE

THE CAR HAS STARTED TO OVERHEAT AND HEATER DID NOT WORK BUT THAT HAS SINCE STARTED WORKING ON ITS OWN. NOW CAR OVERHEATED AND WHEN DRIVING IT SOUNDS AS IF WATER OR SOMETHING IS TRYING TO GO THROUGH PIPE BUT MAYBE ISNT ALSO STARTED TO LEAK ALL COOLANT. AND BATTERY IS BEING DRAINED. HAD THE CAR CHECKED AND REPLACED THERMOSTAT BUT THAT DIDNT FIX ISSUE.ALSO WHEN DRIVING ALL LIGHTS ON DASH TURNED ON AND STARTED TO BEEP. WAS JUST ARRIVING AT A STORE AND WHEN I CAME OUT CAR DID NOT TURN ON. HAD A TOW TRUCK COME OUT AND THEY JUMP STARTED ME AND SAID SOMETHING WAS DRAINING MY BATTERY. ALSO WHEN PUMPING GAS IT CONSTANTLY STOPS AND YOU HAVE TO KEEP PRESSING HANDLE OR MOVE IT AROUND.

NHTSA complaint #11307972 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2011 CHRYSLER 200. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. AN APPOINTMENT WAS MADE TO HAVE THE VEHICLE DIAGNOSED AT AN INDEPENDENT MECHANIC WHICH WAS STILL PENDING. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED OR INFORMED OF THE ISSUE. THE FAILURE MILEAGE WAS 94,000.

NHTSA complaint #11299773 — an unverified report by a vehicle owner.

ENGINE

THE VEHICLE STALLS WHILE DRIVING. THIS IS A VERY DANGEROUS SITUATION AS 3 TIMES IT HAS STALLED AT 50 +MPH AND THIS HAS OCCURRED ON THE HIGHWAY. ANOTHER STALL OCCURRED ON A CURVY STATE ROAD ON A BEND WITH NO SHOULDER. NO WARNING LIGHT OF ERROR CODE HAS BEEN PRODUCED BY THE VEHICLE.

NHTSA complaint #11296638 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2011 CHRYSLER 200. WHEN THE VEHICLE WAS TAKEN TO SAFFORD CHRYSLER JEEP DODGE RAM FIAT OF WINCHESTER (1659 BERRYVILLE PIKE, WINCHESTER, VA 22603, (540) 667-5532) FOR INSPECTION, THE CONTACT WAS INFORMED THAT THE VEHICLE WAS CONTAMINATED WITH SLUDGE IN THE SYSTEM. ALSO, THE DEFROSTER WAS INOPERABLE, AND THE HEATER CORE, ENGINE OIL, COOLANT, AND RADIATOR CAP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS 108,210.

NHTSA complaint #11286575 — an unverified report by a vehicle owner.

ENGINE

DRIVING A VEHICLE WHEN THE ENGINE SHUT OFF GOING APPROXIMATELY 35 MI THIS HAS HAPPENED BEFORE MANY TIMES

NHTSA complaint #11283019 — an unverified report by a vehicle owner.

ENGINE

I WAS STOPPED AT A RED LIGHT AND LIGHT TURNED GREEN WENT TO PRESS GAS AND CAR COMPLETELY SHUT OFF NO WARNING AT ALL NO LIGHTS ON DASHBOARD I PUT IT IN PARK SHUT IT OFF AND STARTED IT RIGHT BACK UP WITH NO PROBLEM THIS HAS HAPPENED TWO TIMES IN THE LAST WEEK ALSO NO CODES COMING UP ON SCANNER

NHTSA complaint #11279173 — an unverified report by a vehicle owner.

ENGINE

WHILE DRIVING ON THE HIGHWAY, MY CAR CUT OFF COMPLETELY. I HAD TO TRY AND MANEUVER TO THE SIDE OF THE HIGHWAY TO GET OUT OF TRAFFIC. THE CAR DID NOT START BACK UP AFTER 30 MINUTES. I HAVE HAD PROBLEMS FOR A MONTH WHERE THE CAR DOES NOT RESTART AFTER I GO TO THE STORE.

NHTSA complaint #11265918 — an unverified report by a vehicle owner.