46 of the
799 complaints about the 2001 Chrysler PT Cruiser are about the
braking system — 6% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
32,000 miles.
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. WHILE DRIVING OUT OF THE DRIVEWAY AT APPROXIMATELY 10 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND HEARD A CRACKING SOUND. THE BRAKE PEDAL IMMEDIATELY STUCK TO THE FLOORBOARD ON TOP OF THE ACCELERATOR PEDAL, WHICH CAUSED THE VEHICLE TO ACCELERATE OUT OF CONTROL. THE CONTACT MANAGED TO SLOW DOWN THE VEHICLE AND CRASHED INTO TWO TREE TRUNKS. THE FAILURE OCCURRED WITHOUT WARNING. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THE VEHICLE SUSTAINED FRONT END DAMAGE AND WAS TOWED TO A LOCAL DEALER. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE MANUFACTURER STATED THAT THE FAILURE WOULD BE INVESTIGATED. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000.
NHTSA complaint #10909694 — an unverified report by a vehicle owner.
at 130,000 milesJjeromesville, OH
SERVICE BRAKES
MY CAR JUST SHUTS OFF LEAVING ME NO CONTROL TO STOP, TURN, OR GET OUT OF THE WAY OF TRAFFIC BEHIND ME..... @ 55MPH TO NOTHING IS ASKING TO BE HIT FROM BEHIND. OR IF TURNING ACROSS A DIVIDED HIGHWAY, TO BE LEFT STUCK WITH 2 LANES OF SEMI COMING FOR ME AND MY KIDS. NOW IT SOMETIMES WONT EVEN DO ANYTHING WHEN I CRANK OVER THE IGNITION (LIKE THERE IS NO BATTERY) OR IF IT CRANKS AND STARTS IT WILL SHUT OFF RIGHT AWAY. IT WANTS TO IDLE DOWN AT STOPS AND STALL. I HAVE HAD IT IN THE SHOP MORE THAN I LIKE N SPENT MORE MONEY TO HAVE TO BE TOLD THEY CAN'T FIND ANYTHING. I READ OF SO MANY OTHER OWNERS WITH THE SAME PROBLEMS WHO END UP JUNKING THESE CUZ THEY JUST STOP STARTING....SAD, WE NEED OUR CARS TO RUN. CHRYSLER KNOWS THEY R RIDDLED WITH SERIOUS ISSUES INCLUDING THE LIGHTS AND TRANSMISSIONS.....THESE ARE A BAD COMBINATION ON THE ROAD. SOMEONE NEEDS TO LOOK @ SOME STATS! THANKS.
NHTSA complaint #10626759 — an unverified report by a vehicle owner.
at 111,145 milesGolden Valley, MN
SERVICE BRAKES
TL* THE CONTACT OWNS 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY ACCELERATED WITHOUT WARNING AFTER STARTING THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO BE DIAGNOSIS. THE DEALER STATED THAT THE POWER BRAKE BOOSTER HOSE WAS NOT CONNECTED TO THE ENGINE. THE VEHICLE WAS REPAIRED. THE DEALER ALSO STATED THAT THERE WAS NEVER A CLAMP HOLDING THE POWER BRAKE IN PLACE. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 111,145. THE CURRENT MILEAGE WAS 112,416.
NHTSA complaint #10564360 — an unverified report by a vehicle owner.
at 46,200 milesWoodbury, NJFire
SERVICE BRAKES
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED WHILE TRAVELING 50 MPH HE SMELLED SOMETHING BURNING. THE CONTACT MERGED TO THE SIDE OF THE ROAD TO ASSESS THE SITUATION. UPON INSPECTION IT WAS FOUND THAT THE DRIVER FRONT BRAKES WERE SMOKING. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSE THAT THE BRAKE TUBE HAD FAILED AND NEEDED TO BE REPLACED. THE CONTACT WAS MADE AWARE THAT THERE WAS A RECALL THAT MIGHT BE RELATED TO THE FAILURE SIMILAR TO NHTSA CAMPAIGN ID NUMBER 04V481000 (SERVICE BRAKES, HYDRAULIC: ANTILOCK). THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 46,200.
NHTSA complaint #10482837 — an unverified report by a vehicle owner.
at 40,000 milesAmerican Canyon, CA
SERVICE BRAKES, HYDRAULIC
WEB SITE TOPIX WILL CONFIRM THE INCREDIBLE # OF FOLKS THAT HAVE HAD FOG LAMPS TURN ON AFTER CAR IS SHUT DOWN CAUSING BATTERY DRAIN. 100'S HAVE PAID FOR REPLACEMENT PART MULTI-FUNCTION SWITCH. THIS CONTROLS FOG, HEAD, ACCESSORY, & DASH LIGHTING. TO PREVENT THE FOG LAMPS FROM COMING ON BY THEMSELVES, MOST HAVE REMOVED FUSE # 8 TO REMOVE THE FOG LAMPS FROM THE CIRCUIT. PEOPLE REPORT SMOKE COMING FROM TURN SIGNAL LEVER, & THE COMPLETE LOSS OF ALL LIGHTING IS QUITE COMMON. I PERSONALLY HAVE REPLACED THE MULTI-FUNCTION SWITCH 3 TIMES ON MY WIFE'S 2001 P.T. CRUISER WITH ONLY 50,000 TOTAL MILES & SHE BEING ORIGINAL OWNER. BY PARKING HER CAR MINUS FUSE # 8, NOT USING DOME LIGHTING, & ALWAYS PARKING WITH THE SIGNAL LEVER IN THE DOWN OR LEFT TURN POSITION HAS PREVENTED THE MYSTERY FOG LAMP ISSUE, & KEPT HER BATTERY FUNCTIONING. THIS "TEMP" SOLUTION HAS ALLOWED HER ABOUT 6 OR 8 MONTHS OF DRIVING W/O THE PROBLEMS OTHER PT OWNERS STRUGGLE WITH. SOONER OR LATER SOMEONE WILL LOSE LIGHTING OR A FIRE WILL OCCUR INSIDE THE STEERING WHEEL WHICH WILL CAUSE SERIOUS INJURY, LOSS OF VEHICLE & POSSIBLY DEATH. CHRYSLER DENIES ANY KNOWLEDGE, BUT WANTS MORE THAN $1,000.000 TO ANALYZE & REPAIR. THROUGH THE TOPIX P.T FORUM I WAS ABLE TO LEARN HOW TO DO THE WORK MYSELF FOR FAR LESS THAN $100. MANY ARE GETTING RIPPED OFF FOR HUNDREDS WHILE CHRYSLER KNOWS FULL WELL OF THE ISSUE. NO LESS THAN AN INVESTIGATION, PERHAPS STARTED WITH THE TOPIX FORUM WILL DEMONSTRATE THE INCREDIBLE NUMBER OF FAILURES THAT STILL PLAGUE THE P.T. ON LATER MODELS SUCH AS 2001 THRU 06 OR 08. ALSO NEED 3RD. BRAKE JOB, & THE RIMS DO NOT SEAL CAUSING LOW TIRES THAT HURT MPG. DRIVING COMFORT, & SAFETY. DEALER & I HAVE TRIED MICHELIN TIRES HOPING THE PROBLEM WAS WITH THE FACTORY INSTALLED GOODYEARS. I STILL HEAR EVERY 100 MILES OR SO THAT MY WIFE'S P.T NEEDS ADDITIONAL AIR PRESSURE.
NHTSA complaint #10457944 — an unverified report by a vehicle owner.
at 34,837 milesMardela Springs, MD
SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT SHE REPLACED HER ENTIRE BRAKE SYSTEM IN AUGUST 2008; HOWEVER, THE FAILURE HAS RECURRED. A SECOND CHRYSLER DEALER ALSO ADVISED HER THAT SHE HAD TO REPLACE THE ENTIRE BRAKE SYSTEM. THE CHRYSLER MANUFACTURER INFORMED THE CONTACT TO TAKE HER VEHICLE TO A DEALER TO HAVE IT REPAIRED. THERE WERE NO RECALLS AND THE WARRANTY HAS EXPIRED. THE FAILURE MILEAGE WAS 34,837 AND THE CURRENT MILEAGE WAS 47,420.
NHTSA complaint #10302949 — an unverified report by a vehicle owner.
at 68,000 milesWisconsindells, WI
SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT PURCHASED THE VEHICLE IN NOVEMBER OF 2007 AND THE WIRING HARNESS WAS REPLACED DUE TO ELECTRICAL FAILURES. IN APRIL OF 2008, WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE ACCELERATED ON ITS OWN. THE VEHICLE WAS TOWED TO THE DEALER AND THEY REPLACED THE BRAKE PADS AND CALIPERS. RECENTLY, THE ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER'S DIAGNOSTIC INDICATED THAT THE TRANSMISSION SOLENOID SWITCH NEEDED TO BE REPLACED, ALONG WITH THE POWER STEERING PUMP. THE DEALER STATED THAT THE WARRANTY DOES NOT COVER THE PARTS. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS THAT APPLIED TO HER VIN. THE FAILURE MILEAGE WAS 68,000 AND CURRENT MILEAGE WAS 75,551.
NHTSA complaint #10236394 — an unverified report by a vehicle owner.
at 14,420 milesOrangevale, CA
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
) ON 9/2/03 I HAD TO TAKE THE CAR IN TO HAVE THE BRAKES CHECKED. PROBLEM FOUND WAS THE FRONT RIGHT CALIPER PISTON STUCK > CLOSED CAUSING UNEVEN WEAR > OF BRAKES PADS ( METAL TO METAL ON FRONT RIGHT AND 50% PADS ON OTHER THREE). DEALER REPLACED THE CALIPER PISTON, REPLACED PADS AND MACHINED ROTORS. HAD TO GET A RENTAL FOR ONE DAY. 2) ON 2/21/05 HAD THE CAR IN THE SHOP AGAIN TO HAVE THE TIRES ROTATED AND BRAKES CHECKED. DEALER SAID ALTHOUGH THE PADS WHERE WEARING EVENLY NOW, THEY STATED "BUT WORN OUT FRONT AND REAR", NEED TO BE REPLACED. BRAKES FRONT AND REAR, REPLACED FRONT ROTORS, RESURFACED REAR ROTORS" THIS TIME I HAD TO HAVE A RENTAL FOR THREE DAYS. 3) ON 3/12/05 NOT EVEN A MONTH LATER, WHILE I WAS DRIVING ON THE FREEWAY TO WORK THE, ENTIRE WINDSHIELD BECAME ENGULFED WITH STEAM, I COULD NOT SEE A THING AND THE WIPERS COULD NOT TAKE THE STEAM AWAY, SO AGAIN I HAD TO HEAD BACK TO THE DEALERSHIP TO HAVE THIS CHECKED OUT. DEALER STATED "FOUND ENGINE COOLING FAN NOT WORKING & RADIATOR CAP NOT HOLDING PRESSURE" " REPLACED FAN AND RADIATOR CAP". ANOTHER RENTAL FOR TWO DAYS. 4) ON 6/14/06, 161 MILES AFTER THE EXTENDED WARRANTY RUNS OUT, I HAVE A MAJOR TRANSMISSION PROBLEM. ENGINE LIGHT COMES ON, I GET THE CAR TO THE SHOP AND THE DEALER STATES TRANSMISSION SOLENOID PACK SHORTED OUT AND DAMAGED THE CONTROLLER AND I HAD TO HAVE THIS ITEM REPLACED. NO RENTAL REQUIRED THIS TIME BUT THE BILL WAS $1055.66 ON MY DIME. NOW ....THE GRAND DADDY OF THEM ALL! 5) THE CAR WAS BACK AT THE DEALER ON 8/1/06 FOR THE SAME FRONT RIGHT CALIPER PISTON ISSUE AS ON 9/2/03, BUT ON MY DIME THIS TIME.
NHTSA complaint #10164200 — an unverified report by a vehicle owner.
at 132,400 milesBaltimore, MDCrashFire
PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE
2001- PT CRUISER -EMERGENCY BRAKE DISENGAGED WHILE RUNNING. WAS IN NEUTRAL (MANUAL TRANSMISSION) AND ON AN INCLINE. THE CAR DRIFTED BACKWARDS DOWN THE DRIVE AND INTO A UTILITY POLE ACROSS THE ROAD. ON OTHER INSTANCES THE BRAKE HANDLE WAS PULLED UPWARD AND IMMEDIATELY DISENGAGED (LIKE A BROKEN SPRING). WHEN PARKING BRAKE WAS REAPPLIED, IT WORKED PROPERLY? ALSO, THE CAR HAS DRIFTED BACKWARDS ON STEEPER INCLINES WHILE IN GEAR. AT THIS POINT THE LATEST INCIDENT WAS REPORTED, BUT NO ACTION WAS TAKEN THUS FAR.
NHTSA complaint #10149345 — an unverified report by a vehicle owner.
at 60,000 milesStorrs Mansfield, CT
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 04V268000 CONCERNING THE STEERING HYDRAULIC POWER ASSIST HOSES, PIPING, AND CONNECTIONS. THIS VEHICLE EXPERIENCED THE SAME SYMPTOMS AS INDICATED IN THE RECALL, BUT THIS AFFECTED THE BRAKE FLUID LINES AS WELL. SHE REPAIRED THE VEHICLE AT HER OWN EXPENSE PRIOR TO RECEIVING THE RECALL LETTER.
NHTSA complaint #10143345 — an unverified report by a vehicle owner.
at 69,000 milesLockborne, OH
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
DT THE BRAKE LINES COLLASPED AND HAS NOT ALLOWED THE BRAKE FLUID TO GO THROUGH. HAS TO GRIP STEERING WHEEL AND PULL OVER IN ORDER TO GET THE VEHICLE TO STOP SHAKING. STANDING NEXT TO THE BRAKES CONSUMER CAN FEEL THE HEAT COMING OFF THE BRAKES. THIS HAPPENED IN MAR 2005. TUFFY FIXED IT, THEY SAID HAD OTHER PT CRUISER'S IN FOR THE SAME DEFECT. THE SECOND TIME THIS HAPPENED IT ALMOST CAUSED AN ACCIDENT WHEN HITTING THE BRAKES IT SHOOK BADLY. IT WAS UNCONTROLABLE AT THAT POINT.
NHTSA complaint #10129410 — an unverified report by a vehicle owner.
at 400 milesLockbourne, OH
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
DT THE BRAKE LINES COLLAPSED AND WERE NOT ALLOWING THE FLUID TO GO THROUGH, CAUSING THE VEHICLE TO SHAKE TREMDOUSLY WHEN HITTING THE BRAKES, HAD TO STOP THE VEHICLE IN ORDER TO GET THE VEHICLE TO QUIT SHAKING. HAD THE BRAKE LINES REPLACED AT BRAKE SHOP. THEY SAW S THIS MANY TIMES WITH THE PT CRUISER. HAD NEW BRAKES AND ROTORS PUT ON. IF CONSUMER WOULD STAND BESIDE THE BRAKES SHE COULD FEEL THE HEAT COMING OUT OF THEM. THIS WAS ONGOING A COUPLE YEARS, AND MOSTLY RECENTLY HAPPENED ON MAY 30,2005.
NHTSA complaint #10129052 — an unverified report by a vehicle owner.
at 32,000 milesDetroit, MI
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
CONSUMER BOUGHT CAR THAT HAD NOT BEEN THOROUGHLY INSPECTED. AFTER TWO WEEKS A NOISE IN BOTH THE BACK AND FRONT OF THE CAR WAS HEARD. THE CONSUMER TOOK THE VEHICLE BACK TO THE DEALERSHIP, PLACED A SUPPORT BECAUSE BRAKE PADS WERE GONE, METAL ON METAL. THE MOTOR MOUNT BROKE, NEEDED ROTORS/SPARK PLUGS, AND TUNE UP ALONG WITH A PVC VALVE. NEEDED TO BE FIXED, BUT DEALER REFUSED TO FIX ANYTHING.
NHTSA complaint #10119847 — an unverified report by a vehicle owner.
at 32,000 milesDetroit, MI
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
CONSUMER BOUGHT CAR THAT HAD NOT BEEN THOROUGHLY INSPECTED. AFTER TWO WEEKS A NOISE IN BOTH THE BACK AND FRONT OF THE CAR WAS HEARD. THE CONSUMER TOOK THE VEHICLE BACK TO THE DEALERSHIP, PLACED A SUPPORT BECAUSE BRAKE PADS WERE GONE, METAL ON METAL. THE MOTOR MOUNT BROKE, NEEDED ROTORS/SPARK PLUGS, AND TUNE UP ALONG WITH A PVC VALVE. NEEDED TO BE FIXED, BUT DEALER REFUSED TO FIX ANYTHING.
NHTSA complaint #10119847 — an unverified report by a vehicle owner.
at 17,000 milesMuskogee, OK
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
CONSUMER STATES THE BRAKES WEAR OUT PREMATURELY.
NHTSA complaint #10107122 — an unverified report by a vehicle owner.
at 10,000 milesCanoga Park, CA
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
THE BRAKE PADS FAILED AT 10,000 MILES. THE BRAKE LIGHT ILLUMINATED APPROXIMATELY 200 MILES LATER AFTER HAVING THEM CHECKED THERE WAS A LOUD MOANING NOISE. FOUND THAT THE PADS HAD CUT INTO THE ROTORS, AND THE ROTOR DISHED WAS BENT VERY BADLY. NOW AT 15000 MILES THE VEHICLE NEEDED NEW BRAKE PADS AND ROTORS.
NHTSA complaint #10103239 — an unverified report by a vehicle owner.
at 10,000 milesCanoga Park, CA
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
THE BRAKE PADS FAILED AT 10,000 MILES. THE BRAKE LIGHT ILLUMINATED APPROXIMATELY 200 MILES LATER AFTER HAVING THEM CHECKED THERE WAS A LOUD MOANING NOISE. FOUND THAT THE PADS HAD CUT INTO THE ROTORS, AND THE ROTOR DISHED WAS BENT VERY BADLY. NOW AT 15000 MILES THE VEHICLE NEEDED NEW BRAKE PADS AND ROTORS.
NHTSA complaint #10103239 — an unverified report by a vehicle owner.
at 34,000 milesToledo, OH
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
BRAKES: NOTICED SQUEALING AND LOTS OF BRAKE DUST (6/04). HAD TO REPLACE PADS AND ROTORS. AFTER REPAIR, PASSENGER FRONT BRAKE STILL SQUEELED. TOOK BACK, ROTOR REPLACED AGAIN. MY FRONT RIGHT BREAK STILL SQUEELS AND BOTH FRONT BRAKES ARE SHOOTING OFF MUCH BREAK DUST. THIS IS VERY FRUSTRATING. I WOULD THINK AFTER A MONTH THE SEMI-METALIC BREAKS WOULD HAVE BEEN BROKEN IN BY NOW.
NHTSA complaint #10083163 — an unverified report by a vehicle owner.
at 34,000 milesToledo, OH
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
BRAKES: NOTICED SQUEALING AND LOTS OF BRAKE DUST (6/04). HAD TO REPLACE PADS AND ROTORS. AFTER REPAIR, PASSENGER FRONT BRAKE STILL SQUEELED. TOOK BACK, ROTOR REPLACED AGAIN. MY FRONT RIGHT BREAK STILL SQUEELS AND BOTH FRONT BRAKES ARE SHOOTING OFF MUCH BREAK DUST. THIS IS VERY FRUSTRATING. I WOULD THINK AFTER A MONTH THE SEMI-METALIC BREAKS WOULD HAVE BEEN BROKEN IN BY NOW.
NHTSA complaint #10083163 — an unverified report by a vehicle owner.
at 21,440 milesLand O' Lakes, FL
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
WHILE DRIVING AT ANY SPEED ABS WARNING LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE ABS PUMP NEEDED TO BE REPLACED. THIS INFORMATION WAS PROVIDE ROWLAND JONES HUSBAND OF BARBARA JONES.
NHTSA complaint #10081491 — an unverified report by a vehicle owner.
at 5,000 milesPahrump, NV
PARKING BRAKE
PARKING BRAKE OCCASIONALLY FAILS TO ENGAGE. IT ALSO HAS DISENGAGED BY ITSELF. ONCE IT ROLLED AWAY AND KNOCKED OVER A SIGN. DEALER UNABLE TO REPLICATE PROBLEM.
NHTSA complaint #10074857 — an unverified report by a vehicle owner.
at 68,000 milesLondonderry, NH
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
THE FRONT BRAKES AND TIRES EXHIBIT EXTREME WEAR AND TEAR. FRONT TIRES REPLACED APPROX. 40,000 MILES, REAL OK AT 68,000. FRONT BRAKES REPLACED TWICE SO FAR, WITH ROTORS AND CALIPERS NEEDING REPLACEMENTS. THE FRONT SUSPENSION SYSTEM APPEARS TO BE OVERLY STRESSED DUE TO VEHICLE DESIGN.
NHTSA complaint #10063731 — an unverified report by a vehicle owner.
at 25,602 milesWarwick, RI
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
MY 01 CHRYSLER PT CRUISER, 25,602 MILES, HAD A STIFF BRAKE PEDAL. CAR FELT AS IF I WAS DRIVING W/FOOT ON BRAKE. CHRYSLER TOWED CAR TO DEALER. THEY SAID I HAD CONTAMINATED BRAKE FLUID, REPAIRS NOT COVERED BY REGULAR OR EXT. WARRANTY. MY BILL FOR REPAIR WAS $2643.48. THEY REPLACED ALL BRAKE SYSTEM COMPONENTS.
NHTSA complaint #10058218 — an unverified report by a vehicle owner.
at 25,602 milesWarwick, RI
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
MY 01 CHRYSLER PT CRUISER, 25,602 MILES, HAD A STIFF BRAKE PEDAL. CAR FELT AS IF I WAS DRIVING W/FOOT ON BRAKE. CHRYSLER TOWED CAR TO DEALER. THEY SAID I HAD CONTAMINATED BRAKE FLUID, REPAIRS NOT COVERED BY REGULAR OR EXT. WARRANTY. MY BILL FOR REPAIR WAS $2643.48. THEY REPLACED ALL BRAKE SYSTEM COMPONENTS.
NHTSA complaint #10058218 — an unverified report by a vehicle owner.
at 25,602 milesWarwick, RI
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
MY 01 CHRYSLER PT CRUISER, 25,602 MILES, HAD A STIFF BRAKE PEDAL. CAR FELT AS IF I WAS DRIVING W/FOOT ON BRAKE. CHRYSLER TOWED CAR TO DEALER. THEY SAID I HAD CONTAMINATED BRAKE FLUID, REPAIRS NOT COVERED BY REGULAR OR EXT. WARRANTY. MY BILL FOR REPAIR WAS $2643.48. THEY REPLACED ALL BRAKE SYSTEM COMPONENTS.
NHTSA complaint #10058218 — an unverified report by a vehicle owner.
at 47,000 milesEnterprise, AL
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
THE DRIVER HEARD A SQUEALING NOISE WHEN BRAKING. TOOK VEHICLE TO THE DEALER, AND MECHANIC REPLACED THE FRONT ROTORS.
NHTSA complaint #10053415 — an unverified report by a vehicle owner.
Enterprise, AL
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
I OWN A 2001 PT CRUSIER AND HAVE HAD TO REPLACE THE FRONT ROTORS BECAUSE OF EXESSEIVE WHEAR AND THE CAR HAS LESS THAN 50K MILES PLEASE ADVISE .
NHTSA complaint #10051153 — an unverified report by a vehicle owner.
Roanoke, TX
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
FRONT BRAKE PADS CRYSTALIZE REQUIRING ROTOR REPLACEMENT EVERY 30000 MILES. BRAKE SHOP SAYS EVERY PT COMES IN THIS WAY. REAR BRAKES DO NOT ADJUST OUT AND THE FRONT BRAKES STAY PARTIALLY ENGAGED. THIS OVER HEATS THE BRAKES CAUSING MANY COMPONENTS TO FAIL. IN ADDITION TO THE EXPENSE OF REPLACEING THEESE PARTS, I AM WORRIED THAT I COULD HAVE A BRAKE SYSTEM FAILURE LEADING TO A CRASH.
NHTSA complaint #10039341 — an unverified report by a vehicle owner.
at 12,000 milesHuntington Beach, CA
SERVICE BRAKES, HYDRAULIC
ON 1/22/ 03 WE TOOK OUR 2001 PT CRUISER (ODOMETER 12,000 MILES) INTO THE DEALER BECAUSE THE FRONT DISC BRAKES WERE SQUEALING. WE HAD PREVIOUSLY NOTED THAT THE PASSENGER SIDE FRONT DISC BRAKE HAD LOCKED WHEN WE TRIED TO BACK THE CAR OUT OF THE GARAGE. AFTER HITTING THE BRAKES SEVERAL TIMES, THE BRAKE FINALLY UNLOCKED. THE DEALERSHIP TOLD US THAT THE FRONT ROTORS ON BOTH SIDES WERE GROOVED AND COULD NOT BE TURNED BECAUSE THE METAL WAS SO THIN TO BEGIN WITH THAT THERE WAS NOT ENOUGH TO MACHINE EVEN ON A BRAND NEW ROTOR. THE DEALER ALSO TOLD US WE DIDN'T NEED TO REPLACE THE PADS YET, JUST THE ROTORS. WE OPTED TO REPLACE BOTH THE PADS AND THE ROTORS AT THE TIME DUE TO THE LABOR COSTS. IT IS NOW 8 MONTHS AND 5,671 MILES LATER AND THE BRAKES ARE AGAIN SQUEALING. WE CALLED THE DEALERSHIP TO SEE IF THEY WOULD DO SOMETHING ABOUT THE PROBLEM. THEY SAID THEIR HANDS WERE TIED AND THEY COULD NOT HELP US OTHER THAN TO REPLACE WITH THE SAME PARTS. ACCORDING TO THE SERVICE MANAGER, CHRYSLER IS VERY MUCH AWARE THERE IS A PROBLEM WITH THE DISC BRAKE ROTORS AND PREMATURE WEAR, BUT THEY REFUSE TO TAKE ANY REMEDIAL STEPS. WE HAVE THE SAME TIRES THAT ORIGINALLY CAME ON THE CAR AND THEY ARE BARELY WORN INDICATING WE ARE NOT THE KIND OF DRIVERS WHO ARE HARD ON A CAR. THE SERVICE MANAGER APPEARS TO BE JUST A FRUSTRATED WITH CHRYSLER'S LACK OF ATTENTION TO THIS PROBLEM AS WE ARE. OUR ONLY REASONABLE AND INTELLIGIBLE RECOURSE IS TO HAVE THE ROTORS AND PADS REPLACED WITH AFTER MARKET PRODUCTS. WE WILL NOT USE OEM ROTORS & PADS AGAIN. THIS IS NOT NORMAL WEAR AND TEAR. THIS IS FAULTY MANUFACTURING OR FAULTY DESIGN OR BOTH. IN CHECKING YOUR WEBSITE FOR 2001/2002 PT CRUISERS, WE SEE THAT SEVERAL OTHER OWNERS HAVE HAD THE SAME PROBLEMS WITH THEIR DISC BRAKES. THIS IS A SAFETY ISSUE AS WELL AS A MONETARY ISSUE. PLEASE INVESTIGATE.
NHTSA complaint #10039149 — an unverified report by a vehicle owner.
at 30,077 milesNashua, NH
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
VEHICLE WAS PARKED FOR APPROX. TWO DAYS, STARTED VEHICHLE AND ALL LIGHTS ON THE INSTRUMENT PANEL STAYED ON; BRAKE LIGHT, ABS LIGHT, ENGINE LIGHT, SECURITY LIGHT, CRUSIE CONTROL, ETC. AS WELL AS WORDS "NO BUG" OVER THE ODEMETER/MILEAGE GAGE. THESE LGHTS WOULD NOT GO OFF AFTER TURNING THE ENGINE ON AND OFF SEVERAL TIMES. THE ENGINE LIGHT STAYS ON AND WILL NOT SHUT OFF. SCHEDULED AN APPOINTMENT WITH DEALER TO CONNECT TO COMPUTER.
NHTSA complaint #10021131 — an unverified report by a vehicle owner.