Owners have filed 598 complaints
about the 2005 Dodge Dakota with NHTSA between 2005 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 5 of 19 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 67
Against the median year of the Dodge Dakota. 50 means typical for this
model; 100 means roughly double.
Severity — 81
15.7% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 60
35% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
276.2%
1,000 – 9,999 miles
4710.9%
10,000 – 24,999 miles
439.9%
25,000 – 49,999 miles
7818.0%
50,000 – 74,999 miles
8720.1%
75,000 – 99,999 miles
5512.7%
100,000 – 149,999 miles
7116.4%
150,000+ miles
255.8%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 2005peak 15Mar 2026
NHTSA investigations into the 2005 Dodge Dakota
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
EA15001Opened 24 Feb 2015Still openAIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
EA06004Opened 9 Mar 2006Still openSTEERING
STEERING WHEEL AND STEERING SHAFT BOLTS
ON MARCH 9, 2006 ODI UPGRADED PRELIMINATRY EVALUATION PE05-056 TO ENGINEERNING ANALYSIS EA06-004 TO INVESTIGATE ALLEGATIONS OF LOOSE OR MISSING STEERING SHAFT COUPLING BOLTS AND STEERING COLUMN RETAINING BOLTS IN MODEL YEAR (MY) 2004 THROUGH 2006 DODGE DURANGO SPORT UTILITY VEHICLES AND MY 2005 THROUGH 2006 DODGE DAKOTA PICKUP TRUCKS.EITHER CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL.ALTHOUGH ODI IDENTIFIED SOME QUALITY ISSUES IN THE MANUFACTURING PROCESSES FOR THE DAKOTA AND DURANGO VEHICLES, THE DATA DO NOT INDICATE THAT A SAFETY DEFECT TREND IS PRESENT IN EITHER POPULATION.THE FAIL...
PE14016Opened 11 Jun 2014Closed 2 Mar 2015AIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
PE05056Opened 26 Oct 2005Closed 9 Mar 2006STEERING
STEERING WHEEL AND SHAFT BOLTS
ON OCTOBER 26, 2005 ODI OPENED PE05-056 TO INVESTIGATE ALLEGATIONS OF LOOSE OR MISSING STEERING WHEEL OR STEERING SHAFT COUPLING BOLTS IN MODEL YEAR (MY) 2004 AND 2005 DODGE DURANGO SPORT UTILITY VEHICLES AND MY 2005 DODGE DAKOTA PICKUP TRUCKS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION (DCC).DURING PE05-056 ODI IDENTIFIED 3 OWNER COMPLAINTS TO ODI OR DCC, 21 FIELD REPORTS TO DCC AND 142 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT CONDITIONS.THE REPORTS AND CLAIMS INCLUDED 8 INCIDENTS OF EITHER STEERING WHEEL SEPARATION OR STEERING SHAFT DECOUPLING WHILE DRIVING DUE TO LOOSE OR MISSING BOLTS...
Recalls on the 2005 Dodge Dakota
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
17V820000
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
Fiat Chrysler Automobiles US LLC (Chrysler) is recalling certain 2005 Dodge Dakota pickup trucks equipped with heated seats. These driver and passenger seats may develop hot spots that can result in the seat cushion or seat back having burn holes.
Risk: The hot spots and burn holes can injure the seat occupant and can increase the risk of a fire.
16V352000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mits
Risk: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
15V313000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
14V770000
AIR BAGS
Chrysler Group LLC (Chrysler) is recalling certain model year 2004-2005 Dodge Ram 1500, 2500, and 3500, 2004-2005 Dodge Durango, 2005 Dodge Dakota, 2005 Dodge Magnum and 2005 Chrysler 300, 300C and 300 SRT8 vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the passengers frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
09E012000
EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
05V460000
POWER TRAIN:AUTOMATIC TRANSMISSION
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Risk: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
05V002000
AIR BAGS:SIDE/WINDOW
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH THE OPTIONAL SIDE CURTAIN AIR BAG, THE CURTAIN FASTENERS MAY NOT HAVE BEEN PROPERLY TIGHTENED.
Risk: THIS COULD RESULT IN AN IMPROPER SIDE AIR BAG CURTAIN DEPLOYMENT IN CERTAIN SIDE CRASH CONDITIONS, WHICH CAN INCREASE THE RISK OF INJURY TO VEHICLE OCCUPANTS.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20176601,598 units in Canada
Accessories
On certain vehicles equipped with heated seats, the driver and/or passenger heated seat cushion or seat back may overheat. This could increase the risk of injury to the seat occupant and increase the risk of fire causing injury and/or damage to property. Correction: Dealers will enhance the seat heating system to include updated control features.
Recall 2016265459,492 units in Canada
Airbag
On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, could eventually degrade the propellant contained in the passenger frontal airbag. This could cause the airbag to deploy with more force than normal. As a result, if the vehicle were involved in a collision that warrants airbag deployment, fragments could be propelled toward vehicle occupants, and the airbag assembly could be damaged, preventing proper function. These issues could increase the risk of injury. Correction: Dealers will replace the airbag inflator. Note: Canadian climate results in the propellant degrading slowly. The recall is being conducted as a precaution to address future risk, and is expected to replace airbag inflators before their function would be affected.
Recall 2015228374,508 units in Canada
Airbag
On certain vehicles, the driver frontal airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Note: This recall supersedes special service campaign 2015-003. Correction: Dealers will replace airbag inflators. All vehicles having received a replacement inflator as part of the previous special service campaign will have a replacement inflator installed.
Recall 20150941,000 units in Canada
Airbag
Fiat Chrysler Automobiles (FCA) Canada is conducting a voluntary Safety Improvement Program involving Takata passenger airbag inflators installed in certain vehicles that were originally sold or ever registered in certain high humidity areas of the United States. Fiat Chrysler Automobiles (FCA) will replace the passenger inflator on affected vehicles. Owners who believe their vehicles may have been originally purchased or registered in Florida, Hawaii, Puerto Rico, U.S. Virgin Islands, Texas, Mississippi, Alabama, Louisiana, Georgia, Guam, American Samoa and Saipan should contact a Fiat Chrysler Automobile (FCA) dealer. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: This Safety Improvement Campaign is superseded by recall 2016-265 (FCA Recall S43). Please see <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2016265">recall 2016265</a> for more information.
Recall 20150931,000 units in Canada
Airbag
Fiat Chrysler Automobiles (FCA) Canada is conducting a voluntary Safety Improvement Program involving Takata driver and/or passenger airbag inflators installed in certain vehicles that were originally sold or ever registered in certain high humidity areas of the United States. Fiat Chrysler Automobiles (FCA) will replace the driver and/or passenger inflator on affected vehicles, depending on the vehicle involved. Owners who believe their vehicles may have been originally purchased or registered in Florida, Hawaii, Puerto Rico, and the U.S. Virgin Islands should contact a Fiat Chrysler Automobile (FCA) dealer. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: For the 2003 model year Dodge RAM, only the passenger side inflator would need replacement. Additional Note: This special service campaign was replaced by recalls 2015094 and 2015228. Please see these recalls for more information: <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2015094">Click here for more information on the 2015094 recall</a> <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2015228">Click here for more information on the 2015228 recall</a>
Recall 2015003258,600 units in Canada
Airbag
Chrysler Canada is conducting a voluntary Safety Improvement Campaign concerning the driver's airbag inflator on certain vehicles equipped with Takata airbags. Chrysler Canada will replace the driver's inflator on affected vehicles. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: This special service campaign was replaced by recall 2015228. Please see recall 2015228 for more information: <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2015228">Click here for more information</a>
Recall 200529919,747 units in Canada
Powertrain
On certain vehicles, the cup plug which retains the park pawl anchor shaft in the 42RLE automatic transmission could be missing or not properly staked in its bore, potentially allowing the shaft to move out of position and preventing the transmission from being placed in the PARK position. If this occurs and the parking brake is not applied, the vehicle may roll away and cause an accident without warning. Correction: Dealers will install a bracket to ensure that the park pawl anchor shaft is retained in the proper position.
Recall 200500369 units in Canada
Airbag
On certain vehicles, the attachment fasteners for the optional side airbags may not have been tightened properly. This could result in an improper side airbag curtain deployment in certain side crash conditions, which can increase the risk of injury to vehicle occupants. Correction: Dealers will inspect and, if necessary, replace the side airbag curtains and tighten the fasteners to the proper torque specifications.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 112,000 milesHinesville, GACrash1 injured
AIR BAGS
TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. THE CONTACT STATED WHILE DRIVING 45 MPH, A UNKNOWN VEHICLE CRASHED INTO THE VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED NECK AND SHOULDER INJURIES HOWEVER NO MEDICAL ATTENTION WAS PROVIDED. A POLICE REPORT WAS FILED. THE VEHICLE WAS ABLE TO BE DRIVEN FROM THE SCENE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 212,000. THE VIN WAS NOT AVAILABLE.
NHTSA complaint #11395913 — an unverified report by a vehicle owner.
at 171,000 milesSpring Grove, PAFire
ENGINE
TL* THE CONTACT OWNED A 2005 DODGE DAKOTA. THE CONTACT STATED THAT WHILE REVERSING INTO THE DRIVEWAY WHEN THE CONTACT ATTEMPTING TO APPLY THE BRAKES WHEN THE BRAKE PEDAL FLOORED FAILING TO STOP THE VEHICLE. THE CONTACT APPLIED THE EMERGENCY BRAKES AND LOOKED UNDER THE HOOD OF THE VEHICLE WHERE THEY NOTICED A BURNING ODOR. THE CONTACT SHORTLY NOTICED THAT THE VEHICLE HAD A FIRE NEAR THE ENGINE OF THE VEHICLE. THE CONTACT STATED THEY HAD THEIR WIFE CONTACT THE FIRE DEPARTMENT. THE FIRE DEPARTMENT PUT OUT FIRE. THERE WERE NO INJURIES AND NO MEDICAL ASSISTANCE NEEDED. VEHICLE TOWED. THE CONTACT CONTACTED THE MANUFACTURER TO INFORM THEM THAT THE FIRE REPORT REPORTED THAT THE VEHICLE'S MASTER CYLINDER BRAKE FLUID LEAK CAUSED FIRE. THE VEHICLE DEEMED TOTALED. THE MANUFACTURER OPENED A CASE REGARDING THE MATTER. THE APPROXIMATE FAILURE MILEAGE WAS 171,000.
NHTSA complaint #11331463 — an unverified report by a vehicle owner.
at 171,000 milesSpring Grove, PAFire
SERVICE BRAKES
TL* THE CONTACT OWNED A 2005 DODGE DAKOTA. THE CONTACT STATED THAT WHILE REVERSING INTO THE DRIVEWAY WHEN THE CONTACT ATTEMPTING TO APPLY THE BRAKES WHEN THE BRAKE PEDAL FLOORED FAILING TO STOP THE VEHICLE. THE CONTACT APPLIED THE EMERGENCY BRAKES AND LOOKED UNDER THE HOOD OF THE VEHICLE WHERE THEY NOTICED A BURNING ODOR. THE CONTACT SHORTLY NOTICED THAT THE VEHICLE HAD A FIRE NEAR THE ENGINE OF THE VEHICLE. THE CONTACT STATED THEY HAD THEIR WIFE CONTACT THE FIRE DEPARTMENT. THE FIRE DEPARTMENT PUT OUT FIRE. THERE WERE NO INJURIES AND NO MEDICAL ASSISTANCE NEEDED. VEHICLE TOWED. THE CONTACT CONTACTED THE MANUFACTURER TO INFORM THEM THAT THE FIRE REPORT REPORTED THAT THE VEHICLE'S MASTER CYLINDER BRAKE FLUID LEAK CAUSED FIRE. THE VEHICLE DEEMED TOTALED. THE MANUFACTURER OPENED A CASE REGARDING THE MATTER. THE APPROXIMATE FAILURE MILEAGE WAS 171,000.
NHTSA complaint #11331463 — an unverified report by a vehicle owner.
at 99,593 milesLudington, MICrash1 injured
AIR BAGS
TL* THE CONTACT OWNED A 2005 DODGE DAKOTA. WHILE DRIVING APPROXIMATELY 60 MPH ON A BRIDGE, THE VEHICLE SLID ON BLACK ICE, FISHTAILED, AND CRASHED INTO A CEMENT COLUMN. THE AIR BAGS DID NOT DEPLOY. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE CONTACT'S WIFE WAS SEATED IN THE FRONT PASSENGER SEAT AND STRUCK HER LEFT KNEE ON THE DASHBOARD. MEDICAL ATTENTION WAS NOT RECEIVED. THE CONTACT WAS NOT INJURED. POLICE REPORT NUMBER: 1916400110 WAS FILED. THE VEHICLE WAS TOTALED AND TOWED TO A GARAGE, BUT WAS LATER RETRIEVED BY THE CONTACT. THE CONTACT CALLED HEALY CHRYSLER DODGE AT 231-845-3900 (LOCATED AT 3632 W US-10, LUDINGTON, MI 49431) WHERE THE AIR BAGS WERE REPAIRED PER NHTSA CAMPAIGN NUMBERS: 16V352000 (AIR BAGS), 15V313000 (AIR BAGS), AND 14V770000 (AIR BAGS). THE TECHNICIAN INFORMED THE CONTACT THAT ALL THE RECALL REPAIRS WERE PERFORMED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT AN INVESTIGATOR WOULD CALL THE CONTACT. THE CONTACT WAS NOT CALLED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 99,593.
NHTSA complaint #11269921 — an unverified report by a vehicle owner.
Colorado Springs, COFire
SEATS
I RECEIVED A RECALL NOTICE FOR THE T80 HEATED SEATS IN MY 2005 DODGE DAKOTA I CALLED THE CHRYSLER REPRESENTATIVE SCHEDULE A REPAIR SERVICE WITH PERKINS DODGE COLORADO SPRINGS HE ORDERED THE SEATS I TOLD THE REPRESENTATIVE THAT THE PASSENGER SIDE HAD A BURN HOLE IN IT AND HAD CAUGHT FIRE WHEN THE NEW SEATS ARRIVED AT PERKINS DODGE I TOOK MY TRUCK IN TO BE REPAIRED THEY TOLD ME THEY WILL NOT DO THE PASSENGER SEAT BECAUSE OF THE BURN HOLE HAS CUT OUT PIECES. I TOLD THEM I HAD TO REMOVE SOME OF THE BURNT MATERIAL TO PUT A SEAT COVER ON AND STILL UTILIZE THE SEAT. SEATS ARE STILL UNDER RECALL THEY ORDERED THEM KNOWING THAT THERE WAS A BURN HOLE I DON'T UNDERSTAND WHY THEY WILL NOT PROCEED WITH THE REPAIR THE INFORMATION FOR THE CASE NUMBER AND REPRESENTATIVE I TALKED TO IS HERE.... MY NAME IS [XXX] FROM THE FCA CASE MANAGEMENT DIVISION, I HAVE BEEN ASSIGNED AS YOUR CASE MANAGER. HERE IS SOME INFORMATION THAT WILL BE HELPFUL FOR YOU TO HAVE: YOUR CASE NUMBER IS [XXX] THE CHRYSLER CASE MANAGEMENT TELEPHONE NUMBER IS: [XXX] MY DIRECT EXTENSION: [XXX] MY WORK HOURS ARE: 8:00 AM - 4:30 PM EASTERN STANDARD TIME (MONDAY-FRIDAY). I WILL CONTACT YOU WITHIN ONE BUSINESS DAY OF YOUR APPOINTMENT BY TELEPHONE TO REVIEW YOUR CASE WITH YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR - (RECALL RELATED INCIDENT) TS
NHTSA complaint #11217628 — an unverified report by a vehicle owner.
Colorado Springs, COFire
ELECTRICAL SYSTEM
I RECEIVED A RECALL NOTICE FOR THE T80 HEATED SEATS IN MY 2005 DODGE DAKOTA I CALLED THE CHRYSLER REPRESENTATIVE SCHEDULE A REPAIR SERVICE WITH PERKINS DODGE COLORADO SPRINGS HE ORDERED THE SEATS I TOLD THE REPRESENTATIVE THAT THE PASSENGER SIDE HAD A BURN HOLE IN IT AND HAD CAUGHT FIRE WHEN THE NEW SEATS ARRIVED AT PERKINS DODGE I TOOK MY TRUCK IN TO BE REPAIRED THEY TOLD ME THEY WILL NOT DO THE PASSENGER SEAT BECAUSE OF THE BURN HOLE HAS CUT OUT PIECES. I TOLD THEM I HAD TO REMOVE SOME OF THE BURNT MATERIAL TO PUT A SEAT COVER ON AND STILL UTILIZE THE SEAT. SEATS ARE STILL UNDER RECALL THEY ORDERED THEM KNOWING THAT THERE WAS A BURN HOLE I DON'T UNDERSTAND WHY THEY WILL NOT PROCEED WITH THE REPAIR THE INFORMATION FOR THE CASE NUMBER AND REPRESENTATIVE I TALKED TO IS HERE.... MY NAME IS [XXX] FROM THE FCA CASE MANAGEMENT DIVISION, I HAVE BEEN ASSIGNED AS YOUR CASE MANAGER. HERE IS SOME INFORMATION THAT WILL BE HELPFUL FOR YOU TO HAVE: YOUR CASE NUMBER IS [XXX] THE CHRYSLER CASE MANAGEMENT TELEPHONE NUMBER IS: [XXX] MY DIRECT EXTENSION: [XXX] MY WORK HOURS ARE: 8:00 AM - 4:30 PM EASTERN STANDARD TIME (MONDAY-FRIDAY). I WILL CONTACT YOU WITHIN ONE BUSINESS DAY OF YOUR APPOINTMENT BY TELEPHONE TO REVIEW YOUR CASE WITH YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR - (RECALL RELATED INCIDENT) TS
NHTSA complaint #11217628 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 81,892 milesVine Grove, KY
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2005 Dodge Dakota. The contact stated that the vehicle had been shipped to them. While the vehicle was parked, the contact inspected the vehicle and observed that the frame was severely corroded. The contact also noted that the frames of all the vehicle doors were corroded as well. The vehicle was taken to an independent mechanic, where it was not formally diagnosed; however, the mechanic informed the contact that the frame was severely corroded, the vehicle was structurally compromised, and they were unsure whether the vehicle could be repaired. The vehicle was not repaired. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 81,892.
NHTSA complaint #11725826 — an unverified report by a vehicle owner.
at 81,892 milesVine Grove, KY
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The contact owns a 2005 Dodge Dakota. The contact stated that the vehicle had been shipped to them. While the vehicle was parked, the contact inspected the vehicle and observed that the frame was severely corroded. The contact also noted that the frames of all the vehicle doors were corroded as well. The vehicle was taken to an independent mechanic, where it was not formally diagnosed; however, the mechanic informed the contact that the frame was severely corroded, the vehicle was structurally compromised, and they were unsure whether the vehicle could be repaired. The vehicle was not repaired. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 81,892.
NHTSA complaint #11725826 — an unverified report by a vehicle owner.
Las Vegas, NV
AIR BAGS
Seat belt light turn on and off since I own the truck.
NHTSA complaint #11717376 — an unverified report by a vehicle owner.
at 25,000 milesNew Egypt, NJ
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
The contact owns a 2005 Dodge Dakota. The contact stated that while driving at various speeds, the vehicle vibrated, pulled to the right, with a burning odor coming into the cabin of the vehicle. The contact inspected the vehicle and diagnosed that the caliper had failed. The calipers had been replaced six times; however, the failure persisted and became more frequent. The manufacturer was not made aware of the failure. The approximate failure mileage was 25,000.
NHTSA complaint #11515548 — an unverified report by a vehicle owner.
Sweetwater, TN
POWER TRAIN
*Incomplete Recall Status* ***Defect in transfer case*** Complaint of Manufacturer Defect in 2005 Dodge Dakota Quad Cab 4x4 3.7l v6. While driving at a speed of 30mph on a smooth paved highway and selector switch turned to 2 wheel drive mode; out of nowhere, the transfer case tried to engage 4 High which resulted in SVC 4X4 warning lamp illumination and a loud grinding/stuttering sound from under carriage as well as halting me to 10 mph without any help from me. after pulling over on the roadside and putting truck in park and turning the engine off, i waited a couple of minutes and SVC 4X4 indicator and 4High dash light had gone. I restarted the truck only to find that the SVC 4X4 Warning lamp immediately returned and now the 4lo illuminated dash light is constantly showing and truck is still showing in 2 wheel drive with selector switch but 4x4 will not engage at all now. Took to a mechanic shop 1/2 mile down the road and had it read for any DTCs and inspected. Code came back as C1404. Transfer case still tries to engage as soon as truck door is opened and dome light comes on. SVC 4X4 warning indicator stays on the dash lit up and 4lo warning light flashes non stop. Manufacturers communication letter has been sent to dealerships for the proper installation steps of the transfer case on the model of my truck due to improper positioning. I have noticed no Recall but have found a Campaign ID listed for this issue. I've owned this truck for only DAYS now with the intention of presenting it to daughter for her 16th birthday next month and now there's a BIG concern here for safety and the fact that a recall hasn't been issued is crazy! ....it's completely absurd and should be escalated immediately until a consumer resolution is made. This truck is NOT safe at all with this defect by manufacturer transfer case! I am demanding that this faulty part be investigated and taken considerable responsibility for just for the amount of time allowed to pass!!
NHTSA complaint #11456536 — an unverified report by a vehicle owner.
Sweetwater, TN
SUSPENSION
*Incomplete Recall Status* ***Defect in transfer case*** Complaint of Manufacturer Defect in 2005 Dodge Dakota Quad Cab 4x4 3.7l v6. While driving at a speed of 30mph on a smooth paved highway and selector switch turned to 2 wheel drive mode; out of nowhere, the transfer case tried to engage 4 High which resulted in SVC 4X4 warning lamp illumination and a loud grinding/stuttering sound from under carriage as well as halting me to 10 mph without any help from me. after pulling over on the roadside and putting truck in park and turning the engine off, i waited a couple of minutes and SVC 4X4 indicator and 4High dash light had gone. I restarted the truck only to find that the SVC 4X4 Warning lamp immediately returned and now the 4lo illuminated dash light is constantly showing and truck is still showing in 2 wheel drive with selector switch but 4x4 will not engage at all now. Took to a mechanic shop 1/2 mile down the road and had it read for any DTCs and inspected. Code came back as C1404. Transfer case still tries to engage as soon as truck door is opened and dome light comes on. SVC 4X4 warning indicator stays on the dash lit up and 4lo warning light flashes non stop. Manufacturers communication letter has been sent to dealerships for the proper installation steps of the transfer case on the model of my truck due to improper positioning. I have noticed no Recall but have found a Campaign ID listed for this issue. I've owned this truck for only DAYS now with the intention of presenting it to daughter for her 16th birthday next month and now there's a BIG concern here for safety and the fact that a recall hasn't been issued is crazy! ....it's completely absurd and should be escalated immediately until a consumer resolution is made. This truck is NOT safe at all with this defect by manufacturer transfer case! I am demanding that this faulty part be investigated and taken considerable responsibility for just for the amount of time allowed to pass!!
NHTSA complaint #11456536 — an unverified report by a vehicle owner.
Sweetwater, TN
ELECTRICAL SYSTEM
*Incomplete Recall Status* ***Defect in transfer case*** Complaint of Manufacturer Defect in 2005 Dodge Dakota Quad Cab 4x4 3.7l v6. While driving at a speed of 30mph on a smooth paved highway and selector switch turned to 2 wheel drive mode; out of nowhere, the transfer case tried to engage 4 High which resulted in SVC 4X4 warning lamp illumination and a loud grinding/stuttering sound from under carriage as well as halting me to 10 mph without any help from me. after pulling over on the roadside and putting truck in park and turning the engine off, i waited a couple of minutes and SVC 4X4 indicator and 4High dash light had gone. I restarted the truck only to find that the SVC 4X4 Warning lamp immediately returned and now the 4lo illuminated dash light is constantly showing and truck is still showing in 2 wheel drive with selector switch but 4x4 will not engage at all now. Took to a mechanic shop 1/2 mile down the road and had it read for any DTCs and inspected. Code came back as C1404. Transfer case still tries to engage as soon as truck door is opened and dome light comes on. SVC 4X4 warning indicator stays on the dash lit up and 4lo warning light flashes non stop. Manufacturers communication letter has been sent to dealerships for the proper installation steps of the transfer case on the model of my truck due to improper positioning. I have noticed no Recall but have found a Campaign ID listed for this issue. I've owned this truck for only DAYS now with the intention of presenting it to daughter for her 16th birthday next month and now there's a BIG concern here for safety and the fact that a recall hasn't been issued is crazy! ....it's completely absurd and should be escalated immediately until a consumer resolution is made. This truck is NOT safe at all with this defect by manufacturer transfer case! I am demanding that this faulty part be investigated and taken considerable responsibility for just for the amount of time allowed to pass!!
NHTSA complaint #11456536 — an unverified report by a vehicle owner.
EL Cajon, CA
AIR BAGS
GOT TRUCK SMOGGED 4/13/2021 AND WAS TOLD OF AN OUTSTANDING RECALL FOR AIRBAG. THIS RECALL WAS FIXED ON 11/13/2015. ATTACHED ARE COPIES OF NOTICE OF RECALL AFTER GETTING TRUCK SMOGGED AND PAGES 1 AND 2 OF INVOICE SHOWING REPAIR ON 11/13/2015. HOW DO WE GET THIS UPDATED IN THE SYSTEM SO IT WILL NOT SHOW UP AGAIN WHEN WE GET TRUCK SMOGGED NEXT TIME? Consumer stated vehicle has been repaired and no longer needs to be contacted.
NHTSA complaint #11408162 — an unverified report by a vehicle owner.
at 189,000 milesKansas City, MO
SEATS
WHILE DRIVING ON I-635 NORTHBOUND AT AROUND 25 TO 30 MPH WITH 4X4 ACTIVATED ON A SINGLE LINE AVAILABLE SINCE IT WAS CLEARED AND SALTED. WITHOUT WARNING I WAS THE ONLY VEHICLE THAT VEERED RIGHT HARD AND I LOST CONTROL OF THE VEHICLE ALMOST CRASHING ONTO THE METAL BEAM ALONG THE HIGHWAY. I WENT PAST THE SHOULDER AND DOWN TO THE BOTTOM OF HILL, BUT THANKFULLY VEHICLE DIDN'T TURN OFF. I HAD TO SWITCH OFF 4X4 AND BACK ON AND WAS ABLE TO CLIMB UP DESPITE THE SNOW BACK TO THE HIGHWAY WITH NO FURTHER REOCCURRENCE. UNFORTUNATELY WHEN THIS HAPPENED MY PASSENGER SEAT WENT FORWARD AND IS NOW STUCK AND I BROKE LEVER TRYING TO BRING IT BACK FROM FRONT RECLINING. BECAUSE OF THE ROUGH TERRAIN THE REAR QUARTER PANELS WHERE THE WAS SOME RUST HAVE CRACKED
NHTSA complaint #11400268 — an unverified report by a vehicle owner.
at 189,000 milesKansas City, MO
POWER TRAIN
WHILE DRIVING ON I-635 NORTHBOUND AT AROUND 25 TO 30 MPH WITH 4X4 ACTIVATED ON A SINGLE LINE AVAILABLE SINCE IT WAS CLEARED AND SALTED. WITHOUT WARNING I WAS THE ONLY VEHICLE THAT VEERED RIGHT HARD AND I LOST CONTROL OF THE VEHICLE ALMOST CRASHING ONTO THE METAL BEAM ALONG THE HIGHWAY. I WENT PAST THE SHOULDER AND DOWN TO THE BOTTOM OF HILL, BUT THANKFULLY VEHICLE DIDN'T TURN OFF. I HAD TO SWITCH OFF 4X4 AND BACK ON AND WAS ABLE TO CLIMB UP DESPITE THE SNOW BACK TO THE HIGHWAY WITH NO FURTHER REOCCURRENCE. UNFORTUNATELY WHEN THIS HAPPENED MY PASSENGER SEAT WENT FORWARD AND IS NOW STUCK AND I BROKE LEVER TRYING TO BRING IT BACK FROM FRONT RECLINING. BECAUSE OF THE ROUGH TERRAIN THE REAR QUARTER PANELS WHERE THE WAS SOME RUST HAVE CRACKED
NHTSA complaint #11400268 — an unverified report by a vehicle owner.
at 189,000 milesKansas City, MO
STRUCTURE:BODY
WHILE DRIVING ON I-635 NORTHBOUND AT AROUND 25 TO 30 MPH WITH 4X4 ACTIVATED ON A SINGLE LINE AVAILABLE SINCE IT WAS CLEARED AND SALTED. WITHOUT WARNING I WAS THE ONLY VEHICLE THAT VEERED RIGHT HARD AND I LOST CONTROL OF THE VEHICLE ALMOST CRASHING ONTO THE METAL BEAM ALONG THE HIGHWAY. I WENT PAST THE SHOULDER AND DOWN TO THE BOTTOM OF HILL, BUT THANKFULLY VEHICLE DIDN'T TURN OFF. I HAD TO SWITCH OFF 4X4 AND BACK ON AND WAS ABLE TO CLIMB UP DESPITE THE SNOW BACK TO THE HIGHWAY WITH NO FURTHER REOCCURRENCE. UNFORTUNATELY WHEN THIS HAPPENED MY PASSENGER SEAT WENT FORWARD AND IS NOW STUCK AND I BROKE LEVER TRYING TO BRING IT BACK FROM FRONT RECLINING. BECAUSE OF THE ROUGH TERRAIN THE REAR QUARTER PANELS WHERE THE WAS SOME RUST HAVE CRACKED
NHTSA complaint #11400268 — an unverified report by a vehicle owner.
at 112,000 milesHinesville, GACrash1 injured
AIR BAGS
TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. THE CONTACT STATED WHILE DRIVING 45 MPH, A UNKNOWN VEHICLE CRASHED INTO THE VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED NECK AND SHOULDER INJURIES HOWEVER NO MEDICAL ATTENTION WAS PROVIDED. A POLICE REPORT WAS FILED. THE VEHICLE WAS ABLE TO BE DRIVEN FROM THE SCENE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 212,000. THE VIN WAS NOT AVAILABLE.
NHTSA complaint #11395913 — an unverified report by a vehicle owner.
at 118,000 milesDubois, PA
POWER TRAIN
WHILE TRUCK IS SITTING IN PARK NO KEYS IN IT, OBVIOUSIY NOT RUNNING YOU CAN HEAR THE 4WD ACTIVATING, ALSO WHEN DRIVING IN 2WD THE 4WD LIGHT STARTS TO FLASH TRYING TO ENGAGE.
NHTSA complaint #11394402 — an unverified report by a vehicle owner.
at 171,000 milesSpring Grove, PAFire
ENGINE
TL* THE CONTACT OWNED A 2005 DODGE DAKOTA. THE CONTACT STATED THAT WHILE REVERSING INTO THE DRIVEWAY WHEN THE CONTACT ATTEMPTING TO APPLY THE BRAKES WHEN THE BRAKE PEDAL FLOORED FAILING TO STOP THE VEHICLE. THE CONTACT APPLIED THE EMERGENCY BRAKES AND LOOKED UNDER THE HOOD OF THE VEHICLE WHERE THEY NOTICED A BURNING ODOR. THE CONTACT SHORTLY NOTICED THAT THE VEHICLE HAD A FIRE NEAR THE ENGINE OF THE VEHICLE. THE CONTACT STATED THEY HAD THEIR WIFE CONTACT THE FIRE DEPARTMENT. THE FIRE DEPARTMENT PUT OUT FIRE. THERE WERE NO INJURIES AND NO MEDICAL ASSISTANCE NEEDED. VEHICLE TOWED. THE CONTACT CONTACTED THE MANUFACTURER TO INFORM THEM THAT THE FIRE REPORT REPORTED THAT THE VEHICLE'S MASTER CYLINDER BRAKE FLUID LEAK CAUSED FIRE. THE VEHICLE DEEMED TOTALED. THE MANUFACTURER OPENED A CASE REGARDING THE MATTER. THE APPROXIMATE FAILURE MILEAGE WAS 171,000.
NHTSA complaint #11331463 — an unverified report by a vehicle owner.
at 171,000 milesSpring Grove, PAFire
SERVICE BRAKES
TL* THE CONTACT OWNED A 2005 DODGE DAKOTA. THE CONTACT STATED THAT WHILE REVERSING INTO THE DRIVEWAY WHEN THE CONTACT ATTEMPTING TO APPLY THE BRAKES WHEN THE BRAKE PEDAL FLOORED FAILING TO STOP THE VEHICLE. THE CONTACT APPLIED THE EMERGENCY BRAKES AND LOOKED UNDER THE HOOD OF THE VEHICLE WHERE THEY NOTICED A BURNING ODOR. THE CONTACT SHORTLY NOTICED THAT THE VEHICLE HAD A FIRE NEAR THE ENGINE OF THE VEHICLE. THE CONTACT STATED THEY HAD THEIR WIFE CONTACT THE FIRE DEPARTMENT. THE FIRE DEPARTMENT PUT OUT FIRE. THERE WERE NO INJURIES AND NO MEDICAL ASSISTANCE NEEDED. VEHICLE TOWED. THE CONTACT CONTACTED THE MANUFACTURER TO INFORM THEM THAT THE FIRE REPORT REPORTED THAT THE VEHICLE'S MASTER CYLINDER BRAKE FLUID LEAK CAUSED FIRE. THE VEHICLE DEEMED TOTALED. THE MANUFACTURER OPENED A CASE REGARDING THE MATTER. THE APPROXIMATE FAILURE MILEAGE WAS 171,000.
NHTSA complaint #11331463 — an unverified report by a vehicle owner.
at 200,000 milesNorth LAS Vegas, NV
POWER TRAIN
TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. THE CONTACT STATED THAT THE VEHICLE FAILED TO START OR PARK WITH THE GEAR SHIFTER IN THE PARK POSITION. THE VEHICLE WAS ONLY ABLE TO START OR PARK WHEN PLACED IN NEUTRAL. NO WARNING LIGHT WAS ILLUMINATED. THE CONTACT SPOKE WITH CHAPMAN LAS VEGAS DODGE CHRYSLER JEEP RAM LOCATED AT (3175 E SAHARA AVE, LAS VEGAS, NV 89104) AND WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.
NHTSA complaint #11318617 — an unverified report by a vehicle owner.
at 112,855 milesCarlinville, IL
SEATS
HEATED DRIVER SEAT CAUGHT FIRE. CALLED DEALERSHIP AND WAS TOLD THERE WAS A RECALL ON THE DRIVER HEATED SEAT. THE DEALER SAID THERE WAS AIRBAG RECALL ON THE DRIVER AND PASSENGER SIDE OF THE TRUCK. THE DEALER SAID THEY WOULD NOT REPAIR AIRBAGS AND WOULD NEED TO CONTACT DODGE FOR A CASE NUMBER. CONTACTED DODGE AND WAS TOLD JUST DRIVE CAREFULLY.
NHTSA complaint #11311862 — an unverified report by a vehicle owner.
at 112,855 milesCarlinville, IL
AIR BAGS
HEATED DRIVER SEAT CAUGHT FIRE. CALLED DEALERSHIP AND WAS TOLD THERE WAS A RECALL ON THE DRIVER HEATED SEAT. THE DEALER SAID THERE WAS AIRBAG RECALL ON THE DRIVER AND PASSENGER SIDE OF THE TRUCK. THE DEALER SAID THEY WOULD NOT REPAIR AIRBAGS AND WOULD NEED TO CONTACT DODGE FOR A CASE NUMBER. CONTACTED DODGE AND WAS TOLD JUST DRIVE CAREFULLY.
NHTSA complaint #11311862 — an unverified report by a vehicle owner.
at 73,003 milesSavannah, GA
AIR BAGS
WAS REPAIRED 05/13/2016 BY CHRYSLER DODGE DEALERSHIP 0F SOUTH SAVANNNAH
NHTSA complaint #11306275 — an unverified report by a vehicle owner.
at 99,593 milesLudington, MICrash1 injured
AIR BAGS
TL* THE CONTACT OWNED A 2005 DODGE DAKOTA. WHILE DRIVING APPROXIMATELY 60 MPH ON A BRIDGE, THE VEHICLE SLID ON BLACK ICE, FISHTAILED, AND CRASHED INTO A CEMENT COLUMN. THE AIR BAGS DID NOT DEPLOY. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE CONTACT'S WIFE WAS SEATED IN THE FRONT PASSENGER SEAT AND STRUCK HER LEFT KNEE ON THE DASHBOARD. MEDICAL ATTENTION WAS NOT RECEIVED. THE CONTACT WAS NOT INJURED. POLICE REPORT NUMBER: 1916400110 WAS FILED. THE VEHICLE WAS TOTALED AND TOWED TO A GARAGE, BUT WAS LATER RETRIEVED BY THE CONTACT. THE CONTACT CALLED HEALY CHRYSLER DODGE AT 231-845-3900 (LOCATED AT 3632 W US-10, LUDINGTON, MI 49431) WHERE THE AIR BAGS WERE REPAIRED PER NHTSA CAMPAIGN NUMBERS: 16V352000 (AIR BAGS), 15V313000 (AIR BAGS), AND 14V770000 (AIR BAGS). THE TECHNICIAN INFORMED THE CONTACT THAT ALL THE RECALL REPAIRS WERE PERFORMED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT AN INVESTIGATOR WOULD CALL THE CONTACT. THE CONTACT WAS NOT CALLED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 99,593.
NHTSA complaint #11269921 — an unverified report by a vehicle owner.
at 80,000 milesWheat Ridge, CO
ELECTRICAL SYSTEM
VEHICLE GOES IN AND OUT OF 4 WHEEL DRIVE AND 4 WHEEL LO ON IT'S OWN, WHETHER THE VEHICLE IS RUNNING OR NOT AND MOVING OR NOT. THERE HAVE BEEN TIMES WHEN I OPEN THE DOOR, NOT UNLOCK, JUST OPEN, AND YOU CAN HEAR THE TRANSFER CASE SHIFTING . SOMETIME "SERVICE 4 WHEEL DRIVE" LIGHT COMES ON, OTHER TIMES JUST 4 WHEEL INDICATOR AND OTHER TIMES NO LIGHT AT ALL. THOUGH IT IS A 2005, I ONLY HAVE 80K ON IT. THIS HAS BEEN GOING ON FOR ABOUT 6 MONTHS NOW
NHTSA complaint #11268221 — an unverified report by a vehicle owner.
at 62,000 milesOrangeburg, SC
ENGINE
TICKING NOISE FROM EXHAUST MANIFOLD. EXHAUST MANIFOLD BOLTS & STUDS PREMATURELY BROKE! LEAKING EXHAUST FUMES ARE ABLE TO ENTER PASSENGER CABIN & CAUSE A SAFETY HAZARD! THIS ISSUE NEEDS A SAFETY RECALL TO REPLACE EXHAUST MANIFOLD GASKETS, BOLTS & STUDS THAT ARE OF AN IMPROVED GRADE TO CORRECT THIS FACTORY INSTALLATION SAFETY ISSUE ON BOTH LEFT & RIGHT HAND EXHAUST MANIFOLDS!!
NHTSA complaint #11246205 — an unverified report by a vehicle owner.
at 62,500 milesOrangeburg, SC
ENGINE
TICKING NOISE COMING FROM EXHAUST MANIFOLDS! EXHAUST MANIFOLD BOLTS & STUDS ARE BREAKING PREMATURELY ALLOWING EXHAUST GASES TO ENTER PASSENGER COMPARTMENT! NEW BETTER GRADE EXHAUST MANIFOLD BOLTS & STUDS PLUS GASKETS NEED TO BE INSTALLED ON BOTH LEFT & RIGHT HAND SIDE MANIFOLDS WITH A RECALL TO CORRECTLY REPAIR THIS DANGEROUS FACTORY INSTALLED DEFECT!!
NHTSA complaint #11246207 — an unverified report by a vehicle owner.
at 152,000 milesPhoenix, AZ
POWER TRAIN
CAME TO A STOP BEHIND 2 VEHICLES IN LEFT TURN LANE. WHEN TRAFFIC LIGHT GREEN ARROW CAME AND ACCELERATED THERE WAS A LOUD BANG AND TRUCK WOULD NOT MOVE. CAR BEHIND SKIDDED TO A STOP TO AVOID TRUCK. TRIED REVERSE AND DRIVE WITH NO AFFECT THEN LOOKING UNDER TRUCK THER WAS REAR DIFFERENTIAL OIL PUDDLING UNDER CENTER PUMPKIN. GROUP OF PEOPLE HELPED PUSHED TRUCK INTO LOT BACKWARDS SINCE WOULD ROLL FORWARD. TOWED BACK TO WORK AND INSPECTED NEXT DAY 8/3/19 AND PINION NUT HAD BACKED OFF. PULLED DIFF COVER AND FOUND SEVERAL CHUNKS OF METAL FROM DAMAGE. BUILD DATE 08/04 152,000 MILES WITH 9 1/4 REAREND. APPARENTLY THERE WAS A RECALL ON THE RAM 1500 WITH SAME REAR END AND WITHIN THIS BUILD DATE. WOULD NOT THE DAKOTA ALSO BE INCLUDED? L
NHTSA complaint #11241561 — an unverified report by a vehicle owner.
at 150,000 milesPhoenix, AZ
SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. WHILE DRIVING 45 MPH, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS ENGAGED TO STOP THE VEHICLE AT A STOP SIGN. THE CONTACT WAS ABLE TO COAST THE VEHICLE ONTO A CURB TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 150,000.
NHTSA complaint #11235178 — an unverified report by a vehicle owner.