1996 Dodge Grand Caravan transmission problems

POWER TRAIN:DRIVELINE

I HAVE A 1996 DODGE GRAND CARAVAN LE 3.8. IN THE LAST 2 MONTHS THE SERPENTINE BELT SLIPPED OFF 2 TIMES WHEN IT IS RAINING OUTSIDE OR THE VAN GOES THROUGH A PUDDLE OF WATER. I HAVE ALMOST BEEN KILLED TWICE. I HAVE READ THAT OTHER DODGE OWNERS HAVE ALSO HAD THIS PROBLEM. THE WHEEL CANNOT BE CONTROLLED WHEN THIS HAPPENS, AND MY WIFE IS SCARED TO DRIVE THIS CAR NOW. I THINK THAT DODGE HAS SOME EXPLAINING TO DO AS THEY HAVE BEEN MADE AWARE OF THIS DEFECT, AND ARE NOT TAKING ANY RESPONSIBILITY FOR THIS REPEATED SERIOUS SAFETY FAULT.

NHTSA complaint #10372161 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSMISSION BROKE FOR THE THIRD TIME IN JUST 30,000 MILES, THIS TIME MY WIFE AND 4 KIDS WERE NEARLY KILLED ON A BUSY INTERSTATE BECAUSE WE WERE ALMOST HIT . THIS VEHICLE IS A 1996 DODGE GRAND CARAVAN.

NHTSA complaint #10177453 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WE HAVE HAD THE CAR APPROX 6 YEARS AND HAD TO PUT IN FIVE TRANSMISSIONS. THEY KEEP BURNING UP AND NOBODY CAN TELL US WHY. WE USE THE VEHICLE FOR VERY LITTLE TRANSPORTATION TO AND FROM SCHOOL MOSTLY APPROX 2 AND 1/2 MILES EACH WAY. THE VAN CONSTANTLY BUCKS WHEN SLOWING DOWN FROM HIGH SPEEDS TO LOW SPEEDS AND WILL OFTEN DIE DOING THE SAME THING. THE TRANSMISSION ALWAYS SEEMS TO BE MAKING A SOUND THAT INDICATES IT IS BEING STRESSED WHILE IN 2 TO 3 GEARS.

NHTSA complaint #10164647 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

BOUGHT A 1996 CARAVAN NEW, IN AUGUST 1999 THE TRANSMISSION WENT WITH ABOUT 36,000 MILES AND REBUILT PUT IN - LASTED TILL JAN 2005. TRANSMISSION WENT OUT JAN 2005 AND A REBUILT WAS PUT IN AND LASTED UNTIL JULY 2005 AND ANOTHER REBUILT WAS PUT IN.

NHTSA complaint #10133409 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

- 96 DODGE GRAND CARAVAN W/3.8 V6 AND 41TE 4SPD TRANSMISION - 2 TRANSMISSION FAILURES - 1ST WENT TO ABOUT 125000, THEN KEPT HITTING THE "LIMP HOME MODE" - 2ND HAS "TORQUE CONVERTER LOCKUP" PROBLEM, SHOPS SAY REBUILD AGAIN, AFTER ONLY 38000 MILES. - FAN RELAY WENT OUT BEFORE RECALL WAS ISSUED, HAD TO REPLACE THE RADIATOR OUT OF POCKET. - HAD CLOCK SPRING REPLACED AFTER COMPONENT FAILURE RELATING TO IT (HORN, CRUISE ETC) - UNION CITY GA DEALER ATTEMPTED TO FIX THE FUEL RETURN LINE ISSUE, BOTCHED IT UP AND CAUSED MAJOR LEAK WHEN REFUELING. THEY RE-FIXED IT AFTER MUCH COMPLAINING.

NHTSA complaint #10110774 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

- 96 DODGE GRAND CARAVAN W/3.8 V6 AND 41TE 4SPD TRANSMISION - 2 TRANSMISSION FAILURES - 1ST WENT TO ABOUT 125000, THEN KEPT HITTING THE "LIMP HOME MODE" - 2ND HAS "TORQUE CONVERTER LOCKUP" PROBLEM, SHOPS SAY REBUILD AGAIN, AFTER ONLY 38000 MILES. - FAN RELAY WENT OUT BEFORE RECALL WAS ISSUED, HAD TO REPLACE THE RADIATOR OUT OF POCKET. - HAD CLOCK SPRING REPLACED AFTER COMPONENT FAILURE RELATING TO IT (HORN, CRUISE ETC) - UNION CITY GA DEALER ATTEMPTED TO FIX THE FUEL RETURN LINE ISSUE, BOTCHED IT UP AND CAUSED MAJOR LEAK WHEN REFUELING. THEY RE-FIXED IT AFTER MUCH COMPLAINING.

NHTSA complaint #10110774 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TOOK MY 1996 DODGE CARAVAN IN FOR TRANSMISSION REPAIR. SHOP WOULD NOT REPAIR AND SAID THE VEHICLE WAS INOPERABLE DUE TO RUSTING OUT OF STRUT MOUNT TOWER. HAVE NOT SEEN THIS ON ANY OTHER VEHICLE.

NHTSA complaint #10108471 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

AS I BROUGHT DOWN SPEED OF MY VEHICLE FROM 65 MPH TO STOP TODAY, JUST STOPPED DEAD AT THE STOP SIGN AND THE TRANSMISSION OF MY VEHICLE FAILED. WHEN I SEARCHED THE INTERNET, I FOUND A TONS OF PEOPLE HAVING THE SAME PROBLEM.*AK WITH SO MANY PEOPLE OUT THERE WITH THE SAME PROBLEM THERE HAS TO BE A RECALL OR A CLASS ACTION LAW SUIT .

NHTSA complaint #10105822 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

THE CONSUMER STATED THE TRANSMISSION MALFUNCTIONED. AS A RESULT THE VEHICLE HESITATED BEFORE SHIFTING GEARS. PLEASE PROVIDE ADDITIONAL INFORMATION.

NHTSA complaint #10094157 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

I BOUGHT A 1996 DODGE GRAND CARAVAN 3 YEARS AGO. THIS PAST JULY I HAD TO TAKE A LOAN OUT TO PAY $2000 FOR A TRANSMISSION. AFTER SPEAKING TO QUITE A FEW MECHANICS, I WAS TOLD THAT THE DODGES THAT HAVE THE 3.3 LITER ENGINES IN THEM HAVE TROUBLE WITH THE TRANSMISSIONS. THE MECHANICS STATED THAT HAVE HAD A LOT OF DODGES THAT THEY HAVE TO REPLACE THE TRANSMISSION IN AND THE DODGE IS AWARE OF THIS PROBLEM AND HAS DONE NOTHING ABOUT IT. I HAVE OWED 2 OTHER VEHICLES THAT ARE NOT DODGES AND HAVE NEVER HAD TO REPLACE A TRANSMISSION AT ALL AND THEY ARE OLDER THAN MY VAN. I HAD TO PURCHASE MY VAN, SO I COULD PUT MY HUSBAND'S WHEELCHAIR IN IT. IT IS EASIER TO GET IT IN AND OUT OF THE VAN. I AM ON A FIXED INCOME DUE TO MY HUSBAND BEING DISABLED AND WE HAVE SON IN SCHOOL. SO MONEY IS VERY TIGHT. I WAS LUCKY I QUALIFIED FOR THE LOAN TO GET A NEW TRANSMISSION, OR I WOULD BE UNABLE TO TRANSPORT MY HUSBAND BACK AND FORTH TO DOCTOR APPTS AND SHOPPING. I HAVE SPOKE WITH OTHER DODGE OWNERS WHO HAVE ALL TOLD ME THEY HAVE HAD TO REPLACE THE TRANSMISSION IN THEIR DODGE 3.3 LITER VEHICLES. BUT WHAT GETS ME IS THAT ALL THE TRANSMISSION EXPERTS THAT I SPOKE WITH SAID, THEY CHANGE AT LEAST 2 -3 TRANSMISSION A WEEK IN THESE DODGES. AND THAT DODGE IS FULLY AWARE OF THIS PROBLEM. IT SEEMS TO ME THAT DODGE DOESN'T MIND FIXING THE SMALL PROBLEMS, BUT OVER LOOK THAT FACT THAT THEY HAVE A DEFECT THAT CAUSING A TRANSMISSION TO GO OUT AND IT COSTING THE BUYER AT A MINIMUM OF $2000 TO REPLACE. THIS HAS TO BE STOPPED AND DODGE MADE TO BE HELD ACCOUNTABLE FOR OUR COST. THERE NEEDS TO BE A CLASS ACTION SUIT BROUGHT AGAINST THEM FOR THIS. ONE GUY I WORK WITH HAD HIS BRAND NEW DODGE TRUCK LEAVE HIM ON THE SIDE OF THE ROAD, WHEN THE TRANSMISSION WENT OUT AND HE HAD ONLY 57,800 MILES ON IT. DODGE KNOWS THEY PUT OUT A DEFECT TRANSMISSION, BUT THEY ARE MAKING THE CONSUMER PAY FOR IT. THIS IS WRONG AND THEY NEED TO BE HELD ACCOUNTABLE.

NHTSA complaint #10093085 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY

THERE ARE TWO MAJOR PROBLEMS WITH MY 1996 DODGE GRAND CARAVAN. FIRST THERE IS A SERIOUS VIBRATION IN THE FRONT WHEEL/TIRES. I HAVE REPLACED 8 TIRES (IN 30000 MILES!), BOTH FRONT AXLES, ALL THREE MOTOR MOUNTS, AND HAD THE TRANSMISSION OVERHAULED, AS WELL AS HAVING THREE ALIGNMENT CHECKS. THE VIBRATION IS STILL THERE. THE SECOND PROBLEM INVOLVES THE WINDSHIELD WIPERS. THE FRONT WIPERS WERE, FOR A TIME, COMING ON ANY TIME THEY FELT LIKE IT; THIS WAS REMEDIED BY REPLACING THE MULTI FUNCTION SWITCH ON 09/21/01. SINCE THEN, THE REAR WIPER WILL OCCASIONALLY COME ON FOR ONE SWIPE WHEN I FIRST START THE VEHICLE - ANNOYING, BUT NOT AN IMMEDIATE HAZARD. BUT TODAY, MY WINDSHIELD WIPERS QUIT WORKING AT ALL. THEY WILL ONLY WORK IF I PUT THE WIPERS ON INTERVAL - IN WHICH CASE THEY DO NOTHING FOR A TIME, THEN MAKE TWO TO FOUR SWIPES, THEN WAIT A WHILE, MAKE ONE OR TWO SWIPES, WAIT A WHILE, ETC. THEY WILL MAKE ONE HIGH SPEED SWIPE ACROSS THE WINDSHIELD IF I PRESS THE WASHER BUTTON IN. I SPENT $80 TODAY SO THE DODGE DEALER COULD TELL ME THIS WAS CAUSED BY A BODY CONTROL MODULE FAILURE. THIS REPAIR COSTS OVER $400...AND RESEARCHING A USED PART ONLINE, I LEARNED THAT BOTH THE WHEEL SHIMMY PROBLEM AND THE WINDSHIELD WIPER PROBLEMS ARE NOT UNIQUE TO MY CAR BUT ARE VERY COMMON ISSUES WITH THE DODGE CARAVAN/CHRYSLER TOWN & COUNTRY/PLYMOUTH VOYAGER FAMILY. LOSING YOUR WIPERS, HAVING THEM COME ON AT RANDOM WHEN THEY TAKE A NOTION TO, AND A NON-STOP SHIMMY IN THE FRONT ARE EACH, BY THEMSELVES, SERIOUS SAFETY ISSUES WARRANTING A RECALL. COLLECTIVELY, THEY SPELL OUT A LACK OF CONCERN THAT DAIMLER CHRYSLER HAS FOR THE SAFETY OF THOSE WHO DRIVE THEIR PRODUCTS. IT IS MY UNDERSTANDING FROM MY ONLINE RESEARCH THAT CHRYSLER WAS AWARE OF THE PROBLEM AS LONG AGO AS 1998 BUT DELIBERATELY IGNORED ITS OWN INFORMATION. IT IS APPARENT THAT THE ONLY WAY THESE SAFETY ISSUES ARE GOING TO BE ADDRESSED IS IF THE FEDERAL GOVERNMENT TAKES THEM TO TASK.

NHTSA complaint #10088514 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

THERE ARE TWO MAJOR PROBLEMS WITH MY 1996 DODGE GRAND CARAVAN. FIRST THERE IS A SERIOUS VIBRATION IN THE FRONT WHEEL/TIRES. I HAVE REPLACED 8 TIRES (IN 30000 MILES!), BOTH FRONT AXLES, ALL THREE MOTOR MOUNTS, AND HAD THE TRANSMISSION OVERHAULED, AS WELL AS HAVING THREE ALIGNMENT CHECKS. THE VIBRATION IS STILL THERE. THE SECOND PROBLEM INVOLVES THE WINDSHIELD WIPERS. THE FRONT WIPERS WERE, FOR A TIME, COMING ON ANY TIME THEY FELT LIKE IT; THIS WAS REMEDIED BY REPLACING THE MULTI FUNCTION SWITCH ON 09/21/01. SINCE THEN, THE REAR WIPER WILL OCCASIONALLY COME ON FOR ONE SWIPE WHEN I FIRST START THE VEHICLE - ANNOYING, BUT NOT AN IMMEDIATE HAZARD. BUT TODAY, MY WINDSHIELD WIPERS QUIT WORKING AT ALL. THEY WILL ONLY WORK IF I PUT THE WIPERS ON INTERVAL - IN WHICH CASE THEY DO NOTHING FOR A TIME, THEN MAKE TWO TO FOUR SWIPES, THEN WAIT A WHILE, MAKE ONE OR TWO SWIPES, WAIT A WHILE, ETC. THEY WILL MAKE ONE HIGH SPEED SWIPE ACROSS THE WINDSHIELD IF I PRESS THE WASHER BUTTON IN. I SPENT $80 TODAY SO THE DODGE DEALER COULD TELL ME THIS WAS CAUSED BY A BODY CONTROL MODULE FAILURE. THIS REPAIR COSTS OVER $400...AND RESEARCHING A USED PART ONLINE, I LEARNED THAT BOTH THE WHEEL SHIMMY PROBLEM AND THE WINDSHIELD WIPER PROBLEMS ARE NOT UNIQUE TO MY CAR BUT ARE VERY COMMON ISSUES WITH THE DODGE CARAVAN/CHRYSLER TOWN & COUNTRY/PLYMOUTH VOYAGER FAMILY. LOSING YOUR WIPERS, HAVING THEM COME ON AT RANDOM WHEN THEY TAKE A NOTION TO, AND A NON-STOP SHIMMY IN THE FRONT ARE EACH, BY THEMSELVES, SERIOUS SAFETY ISSUES WARRANTING A RECALL. COLLECTIVELY, THEY SPELL OUT A LACK OF CONCERN THAT DAIMLER CHRYSLER HAS FOR THE SAFETY OF THOSE WHO DRIVE THEIR PRODUCTS. IT IS MY UNDERSTANDING FROM MY ONLINE RESEARCH THAT CHRYSLER WAS AWARE OF THE PROBLEM AS LONG AGO AS 1998 BUT DELIBERATELY IGNORED ITS OWN INFORMATION. IT IS APPARENT THAT THE ONLY WAY THESE SAFETY ISSUES ARE GOING TO BE ADDRESSED IS IF THE FEDERAL GOVERNMENT TAKES THEM TO TASK.

NHTSA complaint #10088514 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHILE DRIVING 20 MPH, THE DRIVER WAS NOT ABLE TO SHIFT INTO THIRD GEAR. THE DRIVER TRIED TO SHIFT GEARS NUMEROUS TIMES BUT WAS NOT ABLE TO DO SO. THE VEHICLE WAS TAKEN TO A GARAGE FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THERE WAS NOTHING WRONG WITH THE VEHICLE. THE PROBLEM RECURRED AND THE DRIVER WAS NOT ABLE TO SHIFT GEARS AT ALL.

NHTSA complaint #10087807 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

1996 DODGE GRAND CARAVAN SE. TRANSMISSION COMPLETELY FAILED. THIRD OWNER AT 155,000 MILES. HAPPENED TO FIRST OWNER AS WELL. LEAKED TRANSMISSION FLUID EVERYWHERE, REAR GATE WAS COVERED WITH FLUID. WENT THROUGH OVER 2 QUARTS OF FLUID A DAY FOR A 5 MILE DRIVE TO WORK. DIAGNOSED AS A LOOSE PIN WHICH WORE A HOLE IN THE TRANSMISSION CASE. COULD NOT HAVE BEEN PREVENTED. A HOLE THE SIZE OF A FIST WAS BLOWN THROUGH THE TOP OF THE CASE WHEN IT FINALLY FAILED. ALSO, THIS PART IS IN SUCH DEMAND DUE TO THE NUMBER OF FAILURES WITH THIS MODEL THAT A REBUILT TRANSMISSION WAS ALMOST $2000. CHRYSLER WAS CONTACTED AND REFUSED TO PROVIDE ANY ASSISTANCE WITH THE COST OF THIS REPAIR. WAS ON THE ROAD IN A SNOW STORM WHEN TRANSMISSION FAILED, WHICH COULD HAVE IN TURN CAUSED A SERIOUS ACCIDENT WHILE STUCK IN THE MIDDLE OF THE ROAD.

NHTSA complaint #10086666 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

NAR 03-27-2003 MR THE CONSUMER EXPERIENCED PROBLEMS DRIVER SIDE WINDOWS, AND THE TRANSMISSION DIED OUT.

NHTSA complaint #10014534 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

AT 130000 MILE A PIN WITHIN THE TRANSMISSION BROKE OFF/OR GOT LOOSE AND WORE THROUGH THE SIDE OF THE TRANSMISSION CAUSING THE TRANSMISSION FLUID TO LEAK. THERE IS NO WAY TO REPAIR THE TRANSMISSION, SO IT NEEDS TO BE REPLACED.

NHTSA complaint #10086214 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHILE DRIVING VEHICLE SUDDENLY STOPPED ACCELERATING. TRANSMISSION FAILED TO CHANGE GEARS AND WAS REPLACED, BUT THE FAILURE RECURRED WITHIN 62,0000 MILES. THEN, TRANSMISSION WAS REPLACED AGAIN, BUT THE FAILURE RECURRED.

NHTSA complaint #10084039 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

SERPENTINE BELT OR TENSIONER CLIP HAS HAD TO BE REPAIRED 4 TIMES (TOWED EVERY TIME) ELECTRICAL PROBLEMS SINCE THE BEGINNING; TURN THE KEY AND THE WINDSHIELD WIPERS START GOING, TURN THE KEY OFF AND THE WIPERS "KEEP" GOING, TAKE THE KEY TOTALLY OUT OF THE IGNITION AND THE WIPERS GO AND THE "DINGING" ALARM THAT TELLS YOU THE LIGHTS ARE ON OR THE KEY IS IN, STARTS.(I SERIOUSLY THOUGHT THE CAR WAS POSSESSED) OR TURN THE KEY AND "NOTHING" COMES ON EXCEPT THE ENGINE. I'VE REPLACED THE BATTERY 5 TIMES AT LEAST - IT'S USUALLY BETTER W/ A NEW BATTERY FOR A LITTLE WHILE. HAVE HAD TO HAVE THE WINDOW MOTOR AND ASSEMBLY REPLACED ON DRIVERS SIDE TWICE AND 5 TIMES ON THE PASSENGER SIDE. MOST RECENT WAS 4/04, WHICH WAS REPLACED 7/04 AGAIN. THE SIDE SLIDING DOORS ON BOTH SIDE DO NOT LOCK, IF YOU PUSH THE BUTTON DOWN, YOU CAN'T GET IT BACK UP. THE REAR HATCH IS DAMAGED FROM CLOSING THE DOOR, LOOKS LIKE I WAS HIT IN THE REAR, BUT HAVE NOT BEEN. CHECK ENGINE LIGHT WAS ON FOR MONTHS IN FALL '03, NO MECHANIC COULD SAY WHY. WANTED TO GET THE A/C CHARGED BUT IT WOULDN'T HOLD A CHARGE. DEALER COULDN'T FIGURE IT OUT. TOOK IT TO ANOTHER MECHANIC WHO SAID THE A/C UNIT WAS TOTALLY MELTED. HAD IT REPLACED AND THEN THE COMPUTER RESET. REPLACED THE TRANSMISSION AT 100000, THE "PLANTATARY GEARS" WERE CRACKED. CHECK ENGINE LIGHT IS ON AGAIN IN 7/04, FAILED EMISIONS, REPLACED O2 SENSOR, LIGHT STILL ON, TACK STICKS AND CAR WON'T ACCELERATE AT TIMES - I CAN PUSH IT TO THE FLOOR AND IT WON'T GO?? FEELS LIKE IT'S CHOKING, NO POWER. HAVE A 3.8L, SHOULD HAVE POWER. THERE IS NO PANEL/DOOR FOR PASS. AIRBAG TO COME OUT. IF I EVER GOT IN AN ACCIDENT, WHAT WOULD IT DO...JUST BUST THROUGH MY DASH? OVER TIME, THE DASH ON THAT SIDE HAS GOTTEN SOFT AND MUSHY, WHAT'S THAT ABOUT? MY DAD BOUGHT THE SAME YEAR CARAVAN I DID, BUT HE DOESN'T HAVE THE GRAND CARAVAN LE AND HE DOESN'T HAVE THE 3.8L AND HE HASN'T HAD A SINGLE PROBLEM...I GUESS I GOT ALL OF THEM.

NHTSA complaint #10082978 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

DEALER REPLACED AUTOMATIC TRANSMISSION AT 37,000 MILES. THEN, TRANSMISSION FAILED, AGAIN, AND NEEDED TO BE REPLACED.

NHTSA complaint #10076153 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHILE DRIVING 55 MPH VEHICLE STOPPED BUT ENGINE WAS STILL RUNNING. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT PIN SLIPPED OUT AND BROKE THROUGH THE TRANSMISSION CASING. THIS CAUSED A LOSS OF TRANSMISSION FLUID, AND TRANSMISSION NEEDED TO BE REPLACED.

NHTSA complaint #10073663 — an unverified report by a vehicle owner.

POWER TRAIN

A/C INTERNAL FAN SWITCH FAILS IN AT LEAST TWO POSITIONS AND HAVE HAD SMOKE ENTER INSIDE THE VAN WHILE DRIVING, FROM I THINK THE FAN. ONCE THE FAN IS TURNED OFF THE SMOKE GOES AWAY.

NHTSA complaint #10068999 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

TRANSMISSION FAILURE. NUMEROUS REPAIR SHOPS REPORT THAT PREMATURE TRANSMISSION FAILURE IS A NEAR-CERTAINTY ON THIS MAKE AND MODEL YEAR VEHICLE, DUE TO A DESIGN FLAW IN THE DIFFERENTIAL GEAR LUBRICATION SYSTEM. THE MANUFACTURER IS AWARE OF THE PROBLEM BUT DENIES RESPONSIBILITY.

NHTSA complaint #10065613 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHILE DRIVING 55 MPH TRANSMISSION FAILED. VEHICLE WOULD NOT ACCELERATE. CONSUMER MANAGED PULL OVER, AND HAD THE VEHICLE TOWED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM.

NHTSA complaint #10063006 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

THE DIFFERENTIAL PIN CAME LOOSE MAKING A HOLE THROUGH THE TRANSMISSION CASE. TRANSMISSION FLUID LEAKED INTO THE TORQUE CONVERTOR AREA AND THEN ONTO MY GARAGE FLOOR. THIS VEHICLE HAS ONLY 74,789 MILES. THE MECHANIC TOLD ME THAT THIS IS VERY COMMON WITH THESE TRANSMISSIONS. HE SAID IT OCCURS WHEN ONE WHEEL SPINS WHILE THE OTHER WHEEL IS STOPPED. IN OTHER WORDS, IF YOU LIVE IN A CLIMATE WITH SNOW OR ICE, THIS FAILURE CAN OCCUR AT ANY TIME TO YOUR VEHICLE. I HAVE CONTACTED THE MANUFACTURER AND THEY TELL ME THIS IS NOT A DEFECT AND THAT THEY DO NOT KNOW OF ANY PROBLEMS WITH THEIR DIFFERENTIAL PINS. I CONTACTED THE SERVICE MANAGER AT THE LOCAL DEALERSHIP, HE SAID THAT HE HAS CERTAINLY SEEN THIS PROBLEM BEFORE, BUT SINCE IT OCCURED OUTSIDE OF WARRANTY, I AM ON MY OWN. THE MINIVAN HAS BEEN REPAIRED, BUT SINCE THE REPLACEMENT DIFFERENTIAL IS THE SAME AS BEFORE, A SERIOUS DEFECT STILL EXISTS IN MY VEHICLE. I HAVE RETAINED THE WORN/BROKEN DIFFERENTIAL UNIT IN CASE DODGE ENGINEERS WANT TO INSPECT IT.

NHTSA complaint #10060799 — an unverified report by a vehicle owner.

POWER TRAIN

THE DIFFERENTIAL PIN CAME LOOSE MAKING A HOLE THROUGH THE TRANSMISSION CASE. TRANSMISSION FLUID LEAKED INTO THE TORQUE CONVERTOR AREA AND THEN ONTO MY GARAGE FLOOR. THIS VEHICLE HAS ONLY 74,789 MILES. THE MECHANIC TOLD ME THAT THIS IS VERY COMMON WITH THESE TRANSMISSIONS. HE SAID IT OCCURS WHEN ONE WHEEL SPINS WHILE THE OTHER WHEEL IS STOPPED. IN OTHER WORDS, IF YOU LIVE IN A CLIMATE WITH SNOW OR ICE, THIS FAILURE CAN OCCUR AT ANY TIME TO YOUR VEHICLE. I HAVE CONTACTED THE MANUFACTURER AND THEY TELL ME THIS IS NOT A DEFECT AND THAT THEY DO NOT KNOW OF ANY PROBLEMS WITH THEIR DIFFERENTIAL PINS. I CONTACTED THE SERVICE MANAGER AT THE LOCAL DEALERSHIP, HE SAID THAT HE HAS CERTAINLY SEEN THIS PROBLEM BEFORE, BUT SINCE IT OCCURED OUTSIDE OF WARRANTY, I AM ON MY OWN. THE MINIVAN HAS BEEN REPAIRED, BUT SINCE THE REPLACEMENT DIFFERENTIAL IS THE SAME AS BEFORE, A SERIOUS DEFECT STILL EXISTS IN MY VEHICLE. I HAVE RETAINED THE WORN/BROKEN DIFFERENTIAL UNIT IN CASE DODGE ENGINEERS WANT TO INSPECT IT.

NHTSA complaint #10060799 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

AT 72,691 MILES, THE AUTOMATIC TRANSMISSION WOULD NOT SHIFT. THE TRANSMISSION WAS REPLACED WITH A REBUILT TRANSMISSION. AT 120,000 MILES TRANSMISSION SLIPPED OUT OF GEAR, CAUSING THE VEHICLE TO SLOW DOWN AND NOT MOVE. *AK

NHTSA complaint #10059528 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION FAILURE 1996 DODGE GRAND CARAVAN. WILL NOT GO INTO GEAR, WILL NOT DRIVE OR GO IN REVERSE. LOUD CLUNKING NOISE AND CAR JERKED. COULD HAVE CAUSED ACCIDENT.

NHTSA complaint #10056227 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

I HAVE A 1996 DODGE GRAND CARAVAN AND IT HAS HAD 4 TRANSMISSION FAILURES. CURRENTLY, THE 5TH TRANSMISSION IS IN THE VEHICLE. WE HAVE OWNED THE CARAVAN SINCE 1/97 WHEN IT WAS PURCHASED WITH ABOUT 50K MILES ON IT. IT WAS A LEASE TURN IN VEHICLE USED BY A SALESMAN NOT HAULING HEAVY LOADS BUT MAKING TOBBACCO SALES CALLS. I HAVE SPOKEN WITH OTHER SIMILAR VEHICLE OWNERS AND THERE HAS BEEN AN ISSUE WITH THE TRANSMISSION FAILING. I FEEL THAT DAIMLER CHRYSLER SHOULD RECALL THE TRANSMISSION FOR REPLACEMENT WITH A SATISFACTORY ONE.

NHTSA complaint #10052571 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHILE DRIVING, THE AUTOMATIC TRANSMISSION FAILED TO SHIFT GEARS. PLEASE PROVIDE FURTHER DETAILS.

NHTSA complaint #10052174 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

1996 DODGE GRAND CARAVAN SE. TRANSMISSION COMPLETELY FAILED (PARKED AND RUNNING IN DRIVEWAY) WITH NO ADVANCE WARNING. 81,000 MILES, METICULOUSLY MAINTAINED. DIAGNOSED AS A LOOSE PIN WHICH WORE A HOLE IN THE TRANSMISSION CASE. A HOLE THE SIZE OF A FIST WAS BLOWN THROUGH THE TOP OF THE CASE WHEN IT FINALLY FAILED. ALSO, THIS PART IS IN SUCH DEMAND DUE TO THE NUMBER OF FAILURES WITH THIS MODEL THAT A REBUILT TRANSMISSION WAS ALMOST $2000. CHRYSLER'S CHAIRMAN'S OFFICE WAS CONTACTED (CASE #11518366) AND REFUSED TO PROVIDE ANY ASSISTANCE WITH THE COST OF THIS REPAIR.

NHTSA complaint #10041802 — an unverified report by a vehicle owner.