28 of the 354 complaints about the 1995 Dodge RAM 2500 are about the fuel system — 8% of everything reported for this model year. Half of the failures with a mileage on record happened before 71,000 miles.
28
Complaints
2
Crashes
2
Fires
0
Injuries
Filed with NHTSA, in their own words.
FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
LEAKING DIESEL FUEL LINES(ALL LISTED ARE WITH ORIGINAL PURCHASER); FUEL GAUGE FAILURE; THROTTLE CABLE WEARING OUT.
NHTSA complaint #10130929 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
AFTER DRIVING 5 OR 10 MINUTES VEHICLE LOST POWER AND STALLED. CONSUMER CONTACTED THE MANUFACTURER, AND HAD TAKEN IT TO DEALER ON SEVERAL OCCASIONS. BUT PROBLEM RECURRED. VEHICLE WAS UNDER WARRANTY. HOWEVER, THE WARRANTY DID NOT COVER THE PROBLEMS OF THE VEHICLE, AND CONSUMER HAD TO PAY OUT OF POCKET. *AK THE CONSUMER HAD LITTLE CONTROL OF THE VEHICLE'S STEERING WHILE DRIVING. ANTIFREEZE LEAKED FROM THE VEHICLE. THE ENGINE FLOODED AND STALL. THE VEHICLE RAN ROUGH PRIOR TO REACHING 75 MPH. OCCASIONALLY THE SERPENTINE BELT RAN CROOKED ON THE PULLEY AND BROKE. THE EXHAUST SYSTEM LEAKED. THE FUEL TANK WAS NOT PROPERLY FITTED TO THE HOLDERS. THE TRANSMISSION LEAKED FLUID.
NHTSA complaint #10091721 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
FUEL QUANTITY INDICATED LOWER THAN ACTUAL FUEL IN TANK OF '95 DODGE RAM 2500 P/U. REMOVED CARTER FUEL MODULE; FOUND FLOAT DETERIORATED WITH ABSORBED FUEL WHICH MADE FLOAT HEAVY AND CAUSED FAULTY INDICATION. INSTALLED WALBRO FUEL MODULE, CHECKS OK. HOW DO I INFORM DODGE TO PROCESS BULLETIN OR RECALL THE FAULTY CARTER FUEL MODULES? THIS IS A SAFETY CONCERN, OPERATORS NEED TO KNOW ACCURATE FUEL LOAD TO MAKE A SAFE TRIP.
NHTSA complaint #10023896 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
THE FUEL TANK LEAKED DUE TO A FAULTY CRACK PIPE.
NHTSA complaint #10017904 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY
CONSUMER STATES THAT A FUEL LINE WAS LEAKING.
NHTSA complaint #564778 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
FUEL SENSOR MALFUNCTIONS.
NHTSA complaint #562914 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
THE METAL HANGERS IN FUEL PUMP WAS RUSTED. THE RUST FROM THE METAL HANGERS WENT THROUGH FUEL LINE AND CLOGGED FUEL TANK. DEALER CONTACTED. NLMCONSUMER HAD DEALER CLEAN FUEL SYSTEM FROM FRONT TO BACK. PROBLEM REOCCURED. CONSUMER FOUND OUT IT WAS A PROBLEM WITH THE FUEL PUMP NOT JUST THE HANGERS. SERVICEMAN AT THE DEALER REFUSES TO LOOK AT THE FUEL PUMP FOR FURTHER DIAGNOSIS.
NHTSA complaint #8007865 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
FUEL SENSOR MALFUNCTIONS.
NHTSA complaint #562914 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY
THE FUEL LINE WAS LEAKING.
NHTSA complaint #563483 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
RUBBER FUEL HOSE IS SPRAYING FUEL ONTO ENGINE, CAUSING FIRE HAZARD. LEAK IS COMING FROM WHERE RUBBER FUEL LINE MEETS METAL FUEL LINE.*AK CONSUMER STATES HE FIRST NOTICED PROBLEM DUE TO VEHICLE WOULD NOT START AFTER IMMEDIATELY AFTER BEING PARKED OVERNIGHT, THIS PROBLEM BECAME WORSE OVER THE NEXT FEW WEEKS, CONSUMER FEELS THE LOCATION OF THE FUEL LINIE IS HAZARDOUS. *SLC
NHTSA complaint #893683 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
FUEL CUT OFF SWITCH WILL NOT SHUT OFF FLOW OF FUEL TO ENGINE, AND WILL NOT ALLOW FUEL TO FLOW INTO ENGINE FOR START UP. *AK *SLC
NHTSA complaint #884270 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
COULD NOT SHUT ENGINE OFF WITH KEY. SUBJECT SOLENOID HAD DISASSEMBLED. IN THE EVENT OF AN ACCIDENT OR FIRE DRIVER HAS NO WAY OF STOPPING ENGINE. DEALER OFFERED REPLACEMENT SOLENOID FOR $370.00
NHTSA complaint #741343 — an unverified report by a vehicle owner.
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
NEW SENDING UNIT FOR FUEL GAUGE INSTALLED. CJ
NHTSA complaint #559304 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
FOR LAST 18 MONTHS FUEL GAUGE HAS NOT WORKED. VAN WAS TAKEN TODEALERSHIP. DEALER STATED FUEL SENDING UNIT WOULD NEED TO BE REPLACED, WHICH WOULD COST CONSUMER $500.00. PROBLEM HAS NOT BEEN CORRECTED. PLEASE PROVIDE ANY FURTHER INFORMATION.
NHTSA complaint #873694 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
FOR LAST 18 MONTHS FUEL GAUGE HAS NOT WORKED. VAN WAS TAKEN TODEALERSHIP. DEALER STATED FUEL SENDING UNIT WOULD NEED TO BE REPLACED, WHICH WOULD COST CONSUMER $500.00. PROBLEM HAS NOT BEEN CORRECTED. PLEASE PROVIDE ANY FURTHER INFORMATION.
NHTSA complaint #873694 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY
RETURN FUEL HOSE FAILURE. THIS PROBLEM COULD RESULTS IN INJECTION PUMP LOSING PRIME WHICH WILL CUASE FAILURE TO START OR STALLING. ALSO THIS PROBLEM IS A FIRE HAZARD. THE CRACKED RUBBER HOSE CAUSES A FUEL LEAK WHICH COULD BE VERY HAZARDOUS. THIS PROBLEM IS VERY COMMON ON THE 1994-1998 DODGE DIESEL TRUCKS.
NHTSA complaint #732409 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY
RETURN FUEL HOSE FAILURE. THIS PROBLEM COULD RESULTS IN INJECTION PUMP LOSING PRIME WHICH WILL CUASE FAILURE TO START OR STALLING. ALSO THIS PROBLEM IS A FIRE HAZARD. THE CRACKED RUBBER HOSE CAUSES A FUEL LEAK WHICH COULD BE VERY HAZARDOUS. THIS PROBLEM IS VERY COMMON ON THE 1994-1998 DODGE DIESEL TRUCKS.
NHTSA complaint #732409 — an unverified report by a vehicle owner.
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
FLOAT WITHIN THE FUEL SENDING UNIT IS DEFECTIVE, CAUSING GAUGE NOT TO REGISTER WHICH COULD RESULT IN RUNNING OUT OF GAS. CONSUMER HAS REPLACED SENDING UNIT 3 TIMES ,EACH PART WILL ONLY LAST ABOUT 13-14 MONTHS.
NHTSA complaint #871403 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
FUEL SENSOR FLUTTERED BETWEEN HALF TO EMPTY,THEN WENT EMPTY, AND IT HAPPENED A SECOND TIME,AGAIN SAME HING, WE HAVE NOT REPLACED IT YET,BECAUSE YOU HAVE TO DROP THE TANK.THE EQUIPMENT IS FAULTY AS LEAST,DON'T KNOW HOW IT SURVIVED IN DIESEL, NO READING ON FUEL IN TANK,DANGEOUS IF YOU DON'T KEEP MILEGE/FILLUP, COULD CAUSE SERIOUS ACCIDENT ON INTERSTATE IF YOU RAN OUT AND DIDN''T KNOW WHAT WAS HAPPENING AT FIRST.
NHTSA complaint #725774 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
FUEL GAUGE RESPONDING ERRATICALLY.
NHTSA complaint #723968 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
THE ENGINE STARTED WITH THE TRANSMISSION IN GEAR AND NO ONE IN THE VEHICLE, STARTER WOULD NOT DISENGAGE AND THE HEATING ELEMENT ON THE INTAKE EXPLODED AND CAUGHT FIRE. THIS IS UNBELIEVABLE WITH ALL THE SAFETY EQUIPMENT TODAY.
NHTSA complaint #707091 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
FUEL FILTER LINE RUPTURED WHILD DRIVING ON THE HIGHWAY AT 60MPH. WILL BE TAKING VEHICLE TO DEALER.
NHTSA complaint #836806 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
THE FUEL GUAGE HAS BEEN REPLACED IN MY TRUCK TWICE AND STILL DOESN'T WORK(IT READS EMPTY ALL OF THE TIME) THE FUEL WARNING LIGHT IS ALWAYS ON ALSO. MY FATHER HAS A 1997 DODGE PICKUP WITH THE SAME PROBLEM, ALSO A GOOD FRIEND OF OURS HAS A 1995 DODGE PICKUP WITH THE EXACT SAME PROBLEM. TO SAY THE LEAST WE'RE ALL FED UP WITH IT.
NHTSA complaint #705471 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY
THE FUEL LINE THAT RUBS AGAINST THE TRANSMISSION CAUSED A FUEL LEAK WHICH MAY HAVE RESULTED IN A FIRE IF THERE WAS A SOURCE OF IGNITION.
NHTSA complaint #825070 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
FUEL GAUGE READING IS INACCURATELY.
NHTSA complaint #543339 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
FUEL SENSOR WILL FLUCTUATE AND THEN GO TO EMPTY AND REMAIN THERE. ALSO, IGNITION SWITCH BEGAN OVERHEATING, BURNING THE INSULATION AROUND THE A/C WIRING ATTACHED TO THE STEERING COLUMN. IN ADDITION, THROTTLE POSITION SENSOR , WITH HEAT ON, WOULD JUMP TO 3000-4000 RPMS.
NHTSA complaint #817746 — an unverified report by a vehicle owner.
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
FUEL SENDING UNIT FAILED.
NHTSA complaint #524931 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
FUEL TANK LINE BROKE WHILE DRIVING CAUSING A LOSS OF FUEL.
NHTSA complaint #982517 — an unverified report by a vehicle owner.