Fiat 500 transmission problems

POWER TRAIN

The clutch went out while downshifting upon making a turn onto a street. The gear shift became wobbly and would not shift into any gear. This happened without warning. Minutes before, my passenger and I were driving across town on a freeway.

NHTSA complaint #11737416 — an unverified report by a vehicle owner.

POWER TRAIN

Systemic Hydraulic Defect & Safety Recall Circumvention I am reporting a critical safety defect in the clutch hydraulic system of my 2013 Fiat 500 Abarth, which directly mirrors the failures described in NHTSA Recalls 16V-302 and 20V-124. Diagnostic measurements confirm a 1.23mm hydraulic over-travel in the clutch release bearing/slave cylinder assembly. This over-travel causes the diaphragm spring to be over-extended, leading to the catastrophic failure of the pressure plate and subsequent inability to disengage the clutch. This poses an immediate safety risk of vehicle surge or inability to shift gears while in motion. Despite this objective engineering data, Stellantis (FCA US, LLC) Executive offices (specifically Mike Macdonald) have formally refused to perform the safety recall repair, citing my status as the "5th owner" as a justification for exclusion. This represents a willful circumvention of a federal safety recall, as the hydraulic over-travel is a latent design defect present since manufacture and is entirely unrelated to ownership history or vehicle maintenance. The vehicle is currently available for inspection to verify these measurements.

NHTSA complaint #11734738 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION:INTERNAL:GEARS

The contact owns a 2015 Fiat 500. The contact stated that while driving at 35 MPH and attempting to downshift, the vehicle failed to respond as intended while the RPM continued to rev. There was no warning light illuminated. The contact stated that the gear shifter was significantly difficult to move up or down, causing difficulty in engaging the brake as needed. The vehicle was taken to an independent mechanic, where it was diagnosed that the manual transmission gear pin had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted and confirmed that the VIN was not included in NHTSA Campaign Numbers: 16V302000(Power Train) nor 19E044000 (Power Train). The manufacturer was not notified of the failure. The failure mileage was approximately 42,000.

NHTSA complaint #11709068 — an unverified report by a vehicle owner.

POWER TRAIN

While driving 40mph, pressed clutch and the transmission would not shift into gear. Car began to slow in traffic ans I was unable to accelerate as the clutch would not engage a gear. Mamaged to sagely get iff road. No fluid leaks found. Would shift into gear with car off. Gear selection works, not a shift cable issue.

NHTSA complaint #11697531 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2015 Fiat 500. The contact stated that while driving at an undisclosed speed, the manual transmission was unable to shift into gear. The contact was able to pull over to the shoulder of the roadway, where the failure persisted. No warning lights were illuminated. The vehicle was towed to an independent mechanic. The contact was informed that the clutch diaphragm spring and clutch assembly needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 16V302000 (Power Train); but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 54,000.

NHTSA complaint #11683142 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2014 Fiat 500. The contact stated that while driving on a neighborhood street at 10 MPH, the transmission experienced an abnormal difficulty in the shifting gear. There was no warning light illuminated. The contact coasted to a stop on the side of the road, and had the vehicle towed to a local independent mechanic to be diagnosed. The contact was informed that the shifter cable assembly was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 50,222.

NHTSA complaint #11648100 — an unverified report by a vehicle owner.

POWER TRAIN

Dealer saw me that is needing a battery replaced On February 14, I took my fiat 500 E to the dealer for repairs. They then told me that it has a bad main battery problems and has to be replaced they gave me a price of $17,000. As a City employee. We do not make that much money. I bought this vehicle for my daughter. She’s is an A honor student.

NHTSA complaint #11647084 — an unverified report by a vehicle owner.

POWER TRAIN

2013 FIAT 500 - Manual Transmission. The clutch cover diaphragm spring on the vehicle has fatigue and/or fracture. A failed clutch cover diaphragm spring has resulted in the inability to disengage the clutch, or shift gears. There is an inability to disengage the clutch, shift gears. It is potentially available for inspection if needed. This occurred while driving at low speed (thank goodness). The car became stuck in place when the failure occurred (obviously a safety concern). The issue has been confirmed by a professional. The component has been inspected by service technician. There were no warnings (lamps, messages, etc.). I believe this failure is described in Recall S34 (NHTSA), and this vehicle should be included in that recall. FIAT disagrees and has denied responsibility. Can you help?

NHTSA complaint #11634558 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2013 Fiat 500. The contact received notification of NHTSA Campaign Number: 16V302000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving approximately 30 MPH, the clutch pedal was depressed; however, the pedal was sticking and failed to respond as designed. The contact was almost involved in a crash due to the failure. The contact stated that the vehicle then started operating as needed after the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage 195,000. VIN tool showed no open recall.

NHTSA complaint #11627352 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2013 Fiat 500. The contact stated that while driving at an undisclosed speed, the clutch was depressed; however, the vehicle failed to stop as intended. The contact stated that there was a jingling sound coming from the engine compartment. In addition, the contact stated that while the clutch was depressed, the vehicle jerked and then rolled forward. The contact stated that several unknown warning lights were illuminated. The contact stated that the hard braking warning light was illuminated. The vehicle was taken to the dealer and the dealer was made aware of the failure. The contact was informed that parts were not available to repair the vehicle. The contact was fearful of driving the vehicle due to the failure. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of NHTSA Campaign Number: 16V302000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 90,000. Parts distribution disconnect.

NHTSA complaint #11626590 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2013 Fiat 500. The contact stated that while reversing, the vehicle failed to shift into park after stopping. While shifting into gear, the vehicle failed to move after the gear selector was placed in the desired gear. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 19V817000 (Power Train). The contact called a towing company. The tow truck driver was able to re-attach the gear shifter cable, but the failure recurred. While reversing slowly to parallel park, the gear shifter cable detached again. The contact reattached the shifter cable. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 128,300.

NHTSA complaint #11621507 — an unverified report by a vehicle owner.

POWER TRAIN

A recall has been open on this vehicle for over 5 years. I have been waiting for a year and 2 Fiat dealerships cannot complete the recall because the manufacturer has failed to manufacture a spring part for the repair. The spring has been back ordered since May 2023 for my order, but according to the Madison dealership, owners before me were waiting for 8+ months with no parts available. Recall info: Manufacturer Recall NumberS34 NHTSA Recall Number16V-302 Recall Status: Recall Incomplete Summary THE CLUTCH COVER DIAPHRAGM SPRING MAY FATIGUE AND/OR FRACTURE. Safety Risk A FAILED CLUTCH COVER DIAPHRAGM SPRING MAY RESULT IN THE INABILITY TO DISENGAGE THE CLUTCH, SHIFT GEARS AND THE POTENTIAL FOR A LOSS OF MOTIVE POWER WHICH COULD CAUSE A CRASH WITHOUT WARNING.

NHTSA complaint #11613343 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2012 Fiat 500. The contact stated while driving at approximately 65 MPH, the accelerator pedal was depressed; however, the vehicle lost motive power and stalled. The contact stated no warning light was illuminated. The contact was able to exit the highway. The contact stated that while attempting to restart the vehicle, the clutch pedal went to the floorboard and the contact was unable to start the vehicle. The contact had the vehicle towed to a dealer. The dealer diagnosed the vehicle and determined that the clutch pedal limiter and a clutch pedal switch needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 16V302000 (Power Train) which had been completed in 2023 on the vehicle by the same dealer. The manufacturer was not informed of the failure. The failure mileage was approximately 214,000.

NHTSA complaint #11611834 — an unverified report by a vehicle owner.

POWER TRAIN

Front Wheel hub bearings grinding, very fast wear and tear Transmission still not shifting right after recall shifter cable replaced not grabbing gears

NHTSA complaint #11607886 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2012 Fiat 500. The contact received notification of NHTSA Campaign Number: 16V302000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while attempting to reverse, the transmission failed to respond as needed. There were no warning lights illuminated. The vehicle was towed to the dealer, and it was confirmed that the recall repair was not yet available and there was no expected date when parts would be available. The manufacturer was made aware of the issue. The failure mileage was 170,000. Parts distribution disconnect.

NHTSA complaint #11606101 — an unverified report by a vehicle owner.

POWER TRAIN

Manual Transaxle Clutch Pedal

NHTSA complaint #11585946 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2012 Fiat 500. The contact received notification of NHTSA Campaign Number: 16V302000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11584793 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

The contact owns a 2014 Fiat 500. The contact stated that while driving at an undisclosed speed, the check engine and TPMS warning lights illuminated and the vehicle began to hesitate while accelerating. The vehicle was diagnosed by an independent mechanic and the contact was informed that the powertrain control module needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 126,000.

NHTSA complaint #11581215 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2012 Fiat 500. The contact stated that while driving at an undisclosed speed, the clutch pedal briefly depressed to the floor and remained stuck before releasing. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the clutch diaphragm spring. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 16V302000 (Power Train); however, the vehicle had already been repaired under the recall. The manufacturer was not notified of the failure. The failure mileage was 106,000.

NHTSA complaint #11580480 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2015 Fiat 500 Pop Hatchback. The contact received notification NHTSA Campaign Number: 16V302000 (Power Train) however, the parts to repair were not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The local dealer was notified of the recall notice and confirmed that the parts were not available. The contact stated while driving 30 MPH, the manual clutch failed and the contact was unable to steer the vehicle. The manufacturer was notified of the failure and the contact was provided with a customer care case number 89214492. The failure mileage was approximately 48,000.

NHTSA complaint #11579913 — an unverified report by a vehicle owner.