2000 Ford E Series problems

WHEELS

We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph), causing the tire to explode. The violent separation destroyed the wheel well area and shook the entire vehicle violently. Our RV contained a [XXX] child, and we were forced to stop on the shoulder in a dangerous situation. The second tire separation happened two days later, again involving a rear tire. Fortunately, it was a slower separation and didn’t cause structural damage, but it further endangered our family and disrupted our trip. We believe these tires were not in a safe condition when the vehicle was rented to us. One of the separated tires showed severe dry rot and age. We had to pay for a replacement tire out-of-pocket during the first incident. The RV company has not responded to our compensation request. These issues could have resulted in serious injury or fatality, and we are filing this report so NHTSA can investigate if this vehicle or others of its kind have similar tire issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11671852 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph), causing the tire to explode. The violent separation destroyed the wheel well area and shook the entire vehicle violently. Our RV contained a [XXX] child, and we were forced to stop on the shoulder in a dangerous situation. The second tire separation happened two days later, again involving a rear tire. Fortunately, it was a slower separation and didn’t cause structural damage, but it further endangered our family and disrupted our trip. We believe these tires were not in a safe condition when the vehicle was rented to us. One of the separated tires showed severe dry rot and age. We had to pay for a replacement tire out-of-pocket during the first incident. The RV company has not responded to our compensation request. These issues could have resulted in serious injury or fatality, and we are filing this report so NHTSA can investigate if this vehicle or others of its kind have similar tire issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11671852 — an unverified report by a vehicle owner.

SUSPENSION

We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph), causing the tire to explode. The violent separation destroyed the wheel well area and shook the entire vehicle violently. Our RV contained a [XXX] child, and we were forced to stop on the shoulder in a dangerous situation. The second tire separation happened two days later, again involving a rear tire. Fortunately, it was a slower separation and didn’t cause structural damage, but it further endangered our family and disrupted our trip. We believe these tires were not in a safe condition when the vehicle was rented to us. One of the separated tires showed severe dry rot and age. We had to pay for a replacement tire out-of-pocket during the first incident. The RV company has not responded to our compensation request. These issues could have resulted in serious injury or fatality, and we are filing this report so NHTSA can investigate if this vehicle or others of its kind have similar tire issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11671852 — an unverified report by a vehicle owner.

TIRES

ONE OF OUR VANS' BCT JB42 FRONT TIRE BLEW UP LEAVING FROM A PARKED AREA WITHOUT GOING OVER ANY SHARP OBJECTS OR CURVES. FORTUNATELY NO ONE WAS HURT BUT IT COULD HAVE CAUSED A HUGE ACCIDENT ON THE ROAD. I CHECKED FOR RECALL ON THIS TIRE BUT IT WAS NOT... I WILL NOW HAVE TO REPLACE 12 OF THESE TIRES ON MY OTHER VEHICLES BECAUSE I CAN'T TAKE ANY MORE CHANCES WITH THESE TIRES ALTHOUGH THEY ARE IN DECENT CONDITIONS... I THINK SOMEONE NEEDS TO CHECK INTO THIS TIRE MODEL FOR FUTURE SAFETY.

NHTSA complaint #10643893 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

I HAVE A 2000 FORD EXPEDITION THAT WHEN DRIVING, AS SOON AS THE LOW FUEL LIGHT COMES ON, THE ENGINE SHUTS OFF. I HAD SEVERAL OCCASIONS WHEN I AM LESS THAN A MILE FROM A GAS STATION, AND THE TRUCK HAS TROUBLE MAKING IT TO THE GAS STATION. THERE ARE SEVERAL INSTANCES WHEN MY SUV IS PARKED UP HILL AND IT HAS MORE THAN A QUARTER TANK OF GAS, AND IT HAS A HARD TIME STARTING. I HAVE TO PUT IT ON NEUTRAL, LET IT ROLL BACKWARDS AND PUT IT ON LEVEL SURFACE BEFORE IT CAN START AGAIN. RECENTLY IT HAS STARTED SHUTTING OFF WHEN I DRIVE, WITH A REASONABLE AMOUNT OF FUEL. ALSO THE SERVICE ENGINE HAS COME ON, IT RUNS ROUGH. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS SUV. ON SEVERAL OCCASIONS, I HAVE COME CLOSE TO GETTING REAR ENDED AND OR GETTING STRANDED. I ALSO OWN A GMC TRUCK, AND WHEN THE LOW FUEL LIGHT COMES ON, I CAN STILL DRIVE THIS TRUCK FOR MORE THAN 15 MILES. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS VEHICLE, AND IT HAS NOT SHUT OFF ON ME EVER. THIS IS A COMPARISON ONLY. I AM TAKING MY 2000 FORD EXPEDITION TO GET SCANNED FOR PROBLEM CODES TOMORROW AND FIND OUT WHAT THE PROBLEMS ARE. I JUST WANTED TO KNOW IF THERE ARE OR HAVE BEEN COMPLAINTS OF THIS NATURE, AND IF THERE IS , WHY HAS FORD NOT MADE AN ANNOUNCEMENT.

NHTSA complaint #10171394 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

I HAVE A 2000 FORD EXPEDITION THAT WHEN DRIVING, AS SOON AS THE LOW FUEL LIGHT COMES ON, THE ENGINE SHUTS OFF. I HAD SEVERAL OCCASIONS WHEN I AM LESS THAN A MILE FROM A GAS STATION, AND THE TRUCK HAS TROUBLE MAKING IT TO THE GAS STATION. THERE ARE SEVERAL INSTANCES WHEN MY SUV IS PARKED UP HILL AND IT HAS MORE THAN A QUARTER TANK OF GAS, AND IT HAS A HARD TIME STARTING. I HAVE TO PUT IT ON NEUTRAL, LET IT ROLL BACKWARDS AND PUT IT ON LEVEL SURFACE BEFORE IT CAN START AGAIN. RECENTLY IT HAS STARTED SHUTTING OFF WHEN I DRIVE, WITH A REASONABLE AMOUNT OF FUEL. ALSO THE SERVICE ENGINE HAS COME ON, IT RUNS ROUGH. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS SUV. ON SEVERAL OCCASIONS, I HAVE COME CLOSE TO GETTING REAR ENDED AND OR GETTING STRANDED. I ALSO OWN A GMC TRUCK, AND WHEN THE LOW FUEL LIGHT COMES ON, I CAN STILL DRIVE THIS TRUCK FOR MORE THAN 15 MILES. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS VEHICLE, AND IT HAS NOT SHUT OFF ON ME EVER. THIS IS A COMPARISON ONLY. I AM TAKING MY 2000 FORD EXPEDITION TO GET SCANNED FOR PROBLEM CODES TOMORROW AND FIND OUT WHAT THE PROBLEMS ARE. I JUST WANTED TO KNOW IF THERE ARE OR HAVE BEEN COMPLAINTS OF THIS NATURE, AND IF THERE IS , WHY HAS FORD NOT MADE AN ANNOUNCEMENT.

NHTSA complaint #10171394 — an unverified report by a vehicle owner.

STRUCTURE:BODY

DT: PROBLEMS WITH THE FRAMES ; CRACKS IN THE FRAMES; RECEIVED A SVC. BULLETIN AND AN ARTICLE BY THE NATIONAL AMB. ASSOC. TO REPORT THIS

NHTSA complaint #10121938 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL:CRUISE CONTROL

MY CRUISE CONTROL NO LONGER WORKS ON MY 2000 FORD ECONOLINE. ALSO, I HAD TO REPLACE ME REAR AIR CONDITIONER LINES, THEY RUSTED OUT.

NHTSA complaint #10114549 — an unverified report by a vehicle owner.

EQUIPMENT:APPLIANCE:AIR CONDITIONER

MY CRUISE CONTROL NO LONGER WORKS ON MY 2000 FORD ECONOLINE. ALSO, I HAD TO REPLACE ME REAR AIR CONDITIONER LINES, THEY RUSTED OUT.

NHTSA complaint #10114549 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

BRAKE LIGHT ON THE DASH ILLUMINATES INTERMITTENTLY. NLM

NHTSA complaint #550038 — an unverified report by a vehicle owner.