2009 Ford Escape fuel system problems

FUEL/PROPULSION SYSTEM

A quien corresponda Por medio de la presente me pongo en contacto con ustedes por motivo de falla mecánica en mi auto móvil Ford escape 2009 ya que hace aproximadamente dos meses atrás al llenar el tanque de gasolina me percaté que el interior olía a combustible y al revisarlo noté que se tiraba por debajo del vehículo lo cual me llevó a investigar posible causa encontrando que en ese modelo es falla del fabricante solicitando sea reparado para evitar posible incendio del mismo ya que según lo que encontré es muy probable sufrir accidente en este estado del vehículo

NHTSA complaint #11756827 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I change my brakes twice in not even a full month My alternator belt came off I replaced it when I put it in park it rolls it shakes and it takes a minute to go faster once I go 40 mph the acceleration pedal vibrates tire pressure sensor stays on and also it keep saying check fuel tank injector

NHTSA complaint #11470548 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Fuel tank leaks from seam or seal on side of tank

NHTSA complaint #11431440 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

3/28/2021 MILEAGE 138141, 1 DAY AFTER FILLING TANK NOTICED STRONG ORDER OF GASOLINE COMING FROM UNDER CAR AND GASOLINE LEAKING OUT OF TOP OF TANK WHILE PARKED IN DRIVEWAY. TRACKED SOURCE OF LEAK TO A 1 INCH CRACK IN TOP OF TANK ABOUT 2 INCHES FORWARD AND TO THE LEFT OF THE FUEL PUMP WHERE THE TANK HEIGHT CHANGES AND GETS TALLER, APPEARS TO BE STRESS CRACK. NO CHECK ENGINE LIGHT OR CODES PRESENT. THIS YEAR IS EQUIPPED WITH A STEEL TANK NOT PLASTIC. REPLACEMENT TANK DISCONTINUED BY FORD, SOURCED AFTERMARKET REPLACEMENT.

NHTSA complaint #11405670 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE

TL* THE CONTACT OWNS A 2009 FORD ESCAPE. THE CONTACT BECAME AWARE OF A FUEL LEAK UNDERNEATH THE VEHICLE. THE CONTACT STATED THAT THE LEAK CAME FROM THE SEAM OF THE FUEL TANK. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000.

NHTSA complaint #11329720 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

AUTO CREDIT NEVER FIXED THE RECALLS.

NHTSA complaint #11321159 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN PUSHING THROTTLE, ENGINE HESITATES. I HAVE COMPLAINED TO DEALER BEFORE, BUT THEY SAY THEY CAN'T FIND ANYTHING WRONG. I SUSPECT THROTTLE BODY BUT NOW NOT COVERED EVEN THOUGH UNDER RECALL. I BELIEVE TO BE A SAFETY HAZARD. 48000 MILES.

NHTSA complaint #11311156 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

I WAS DRIVING MY CAR TO WORK IN A BUSY INTERSECTION THE CAR LOST THE ABILITY TO MOVE BUT NOT THE POWER CAR CAME TO A STOP SHUT OFF CAR AND IT STARTED BUT WAS RIDING ROUGH. THIS HAPPENED TWO MORE TIMES ON MY WAY HOME . WAS ALMOST REAR ENDED. MY BROTHER WHO HAS BEEN A CERTIFIED MECHANIC FOR THIRTY YEAS DIAGNOSED THE CAR AND IT SAID THROTTLE BODY VALVE STUCK OPEN.I DID NOT GET HURT BUT IF I HAD BEEN ON A HIGHWAY OR IN FASTER TRAFFIC I COULD HAVE. I THINK OTHERS SHOULD BE WARNED. I HAVE NEVER RECEIVED ANYTHING FROM MONACO FORD IN GLASTONBURY WHERE I BOUGHT THE CAR THE AND MY ADDRESS IS THE SAME AS WHEN I BOUGHT IT NEW. MY BROTHER IS REPLACING THE PART FOR ME .

NHTSA complaint #11258690 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

DURING OPERATION VEHICLE LOST ABILITY TO ACCELERATE, ALL OTHER FUNCTIONS STILL EXISTED. YELLOW SERVICE RANCH APPEARED ON DASH HAD TO PULL OVER AND PUT CAR IN PARK, I DON'T WAS VERY ROUGH TURN ENGINE OFF. AFTER STARTING CAR BACK UP ALL LIGHTS WERE GONE, ABLE TO DRIVE AGAIN. THIS HAS NOW OCCURRED MORE THAN 20 TIMES. WE HAVE REPLACED BOTH OXYGEN SENSORS,THE PURGE CANISTER AND THE CATALYTIC CONVERTER. STILL HAVING THE SAME ISSUE. WHEN THIS HAPPENS ON LARGE HIGHWAYS OR A MULTILANE INTERSTATE IT BECOMES A VERY DANGEROUS SITUATION.

NHTSA complaint #11242685 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

VEHICLE SHUT DOWN WHILE IN MOTION.

NHTSA complaint #11240340 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

INTERMITTENT ROUGH IDLE/STALLING AT TRAFFIC LIGHTS AS WELL AS HESITATION WHEN ACCELERATING AT ALL SPEEDS. THROTTLE BODY REPLACED UNDER EXTENDED WARRANTY WHEN ISSUE FIRST PRESENTED LAST YEAR; SYMPTOMS PERSIST WITHOUT CHECK ENGINE LIGHT; INDEPENDENT MECHANIC UNABLE TO DIAGNOSE/REPRODUCE ISSUE. ISSUE HAS BEEN OCCURRING FOR THE LAST TWELVE MONTHS WITHOUT RESOLUTION.

NHTSA complaint #11142348 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

ELECTRONIC THROTTLE BODY ISSUE. CAR STALLS INTERMITTENTLY WHEN ACCELERATING AT INTERSECTION. VERY DANGEROUS. CHECK ENGINE LIGHT COMES ON CODE P2112. ISSUE HAPPENS WITHOUT WARNING AND CAR STARTS AGAIN AFTER STALL.

NHTSA complaint #11122332 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

TL* THE CONTACT OWNS A 2009 FORD ESCAPE. WHEN REFUELING THE VEHICLE, THE FUEL PUMP NOZZLE WAS DIFFICULT TO REMOVE. IN ADDITION, THE CHECK FUEL AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO SHAMALEY FORD (11301 GATEWAY BLVD W, EL PASO, TX 79936, (915) 591-8600) WHERE IT WAS DIAGNOSED THAT THE FUEL HOSE FOR THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 88,000.

NHTSA complaint #11119711 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2009 FORD ESCAPE. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR IN THE VEHICLE AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE FUEL VALVE REMAINED OPENED AND EVAPORATED. THE DEALER (COMMERCIAL MOTOR COMPANY, 160 S COMMERCIAL ST, ARANSAS PASS, TX 78336) INFORMED THE CONTACT THAT THE FUEL ODOR WOULD NOT AFFECT THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 125,897.

NHTSA complaint #11113018 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

LEE AUTO SALES LIED TO ME. THEY SAID NOTHING IS WRONG WITH THE VEHICLE. AFTER PURCHASING THE VEHICLE I FOUND A BUNCH OF DEFECTS.

NHTSA complaint #11093632 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

THE VEHICLE STALLS WHEN IDLING, EVEN IF ONLY FOR SECONDS AND SURGES FORWARD RANDOMLY WHILE TRAVELING ON THE ROADWAY. IT HAS STALLED ON ME UP TO 8-10 TIMES IN ONE TRIP FROM SCOTTSDALE TO PHOENIX. IT WILL STALL ROLLING TO A STOP AS WELL AND HAS STALLED ON BUSY ROADWAYS AND IN INTERSECTIONS, PUTTING ME IN GREAT DANGER. THIS HAS BEEN REPORTED T HUNDREDS OF OTHER DRIVERS WITH THE SAME VEHICLE AND SO FAR NO MECHANIC OR EVEN THE FORD DEALERSHIP CAN PIN POINT THE CAUSE. OTHER PEOPLE HAVE BEEN REPORTING THIS SAME ISSUE WITH THEIR CARS WITH ONLY 30,000 MILES AND OTHERS HAVE REPRTED THAT THE CAR STALLS AT HIGHWAY SPEEDS AND I AM NOW AFRAID IT WILL ESCALATE.

NHTSA complaint #11092043 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

THE 2010 TO 2012 HAS A RECALL INVOLVING THE FUEL SYSTEM LEAKING. MY VEHICLE IS ALSO LEAKING FUEL EVERY TIME THE TANK IS FILLED (NO, WE DO NOT "TOP OFF"), AND THE FUMES ARE NOTICEABLE IN AND OUT OF THE VEHICLE. THIS HAS BEEN HAPPENING SINCE APPROXIMATELY 90,000 MILES.

NHTSA complaint #11067320 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2009 FORD ESCAPE. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR FROM THE VEHICLE AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE FUEL VALVE REMAINED OPENED AND EVAPORATED. IN ADDITION, THE CONTACT OBSERVED A LEAK FROM THE REAR DRIVER SIDE FROM THE UPPER FUEL TANK WHERE THERE WAS A FRACTURE. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 192,000.

NHTSA complaint #11024986 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WAS ACCELERATING AFTER COASTING TO SLOW DOWN FOR A TURN ON CITY STREETS. ENGINE STALLED OUT AND SERVICE, OIL, AND BATTERY LIGHTS ALL ILLUMINATED ON THE PANEL. VEHICLE LOST ALL POWER AND HAD TO COAST TO A STOP. PUT IT IN PARK, TURNED OFF AND RESTARTED WITH NO ISSUE. THIS IS THE 5TH TIME THIS HAS HAPPENED IN THE LAST 18 MONTHS, ALL IN SIMLIAR SCENARIOS WHERE ACCELERATING AFTER COASTING.

NHTSA complaint #11012008 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

ELECTRONIC THROTTLE BODY: DRIVING DOWN THE HIGHWAY THE VEHICLE LOST POWER, I WAS ABLE TO AVOID TRAFFIC AND MAKE IT SAFELY TO THE SIDE OF THE ROAD. AFTER A FEW MINUTES I WAS ABLE TO RESTART THE VEHICLE AND CONTINUE ON. A FEW DAYS LATER THIS HAPPENED AGAIN, FORTUNATELY ON A LESS CROWDED STREET.

NHTSA complaint #10981002 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

PURCHASED USED 2009 ESCAPE IN APRIL 2016. CHECK ENGINE LIGHT ON AND GAS LEAKS OVER TIRE WELL WHEN THE TANK IS FILLED ALL THE WAY. TOOK IT IN AND UPON SMOKE TEST DEALERSHIP STATED THE TOP OF THE TANK IS RUSTED WITH PINHOLES. TRYING TO CHARGE ME $1600 TO REPAIR WITH THE FILLER PIECE. NOT DISCLAIMED UPON PURCHASE. CAR WAS INSPECTED PRIOR TO PURCHASE.

NHTSA complaint #10924669 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

THIS HAPPENS IN ALL CONDITIONS. ENGINE WILL LOSE POWER AND START STUTTERING LIKE IT IS MISSING. EXHAUST WILL STINK AND DARKEN ENOUGH SO THAT IT IS VISIBLE. ACCELERATOR WILL NOT WORK AS NORMAL. VEHICLE WILL EVENTUALLY STALL AS SERVICE LIGHT COMES ON. FUEL PUMP REPLACED TWICE IN 2 DAYS. MECHANICS FIND NO CODES STORED. THROTTLE BODY REPLACED UNDER FORD CUSTOMER SERVICE PROGRAM. IT REOCCURRED THE NEXT DAY. THIS NEEDS TO BE RECALLED AND FIXED. THE VEHICLE WILL SLOW AND STALL SUDDENLY AND IS A SAFETY ISSUE.

NHTSA complaint #10915415 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

GAS TANK. LOTS OF CORROSION WHERE FILLER NECK CONNECTS TO THE GAS TANK. WHEN GAS TANK IS FULL GAS LEAKS FROM THE CORROSION POINT. VEHICLE WAS PARKED IN MY GARAGE WHEN I NOTICED A STRONG GAS ODOR. I MOVED THE VEHICLE TO THE DRIVEWAY AND NOTICED A WET SPOT ON THE GARAGE FLOOR THAT REEKED OF GAS. THE SPOT CORRESPONDS TO THE AREA BELOW THE GAS TANK FILLER. I'M CONCERNED THE LEAKING GAS IS AN ENVIRONMENTAL HAZARD AND ALSO CONCERNED THE LEAKING GAS MAY IGNITE CAUSING A FIRE AND POSSIBLE EXPLOSION. HELP!!!

NHTSA complaint #10906123 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

VEHICLE NO POWER AND SURGING.

NHTSA complaint #10891975 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

PLEASE SEE THIS CLIP ON YOUTUBE THAT EXPLAINS OUR ISSUE. HTTPS://WWW.YOUTUBE.COM/WATCH?V=UCUSQJ3-EVK MY VEHICLE, WITHOUT WARNING WILL LOSE POWER AND THE WRENCH LIGHT APPEARS. SAME THING, MECHANIC HAS NO CLUE. WHY CAN'T FORD FIGURE THIS OUT. IT'S DANGEROUS. MY WIFE HAS STALLED SEVERAL TIMES IN TRAFFIC. WHAT CAN BE DONE? THANK YOU!

NHTSA complaint #10888100 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WRENCH LIGHT KEEP COMING ON IN MOTION

NHTSA complaint #10882344 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

MY FORD ESCAPE HAS INTERMITTENT STALLING OR SEEMS LIKE LOSS OF POWER, CAR WILL STAY ON BUT SEEM LIKE IT WANTS TO STALL. IF TRYING TO GIVE IT GAS IT DOES NOT RESPOND. ONCE TURNED OFF AND THEN ON AGAIN IT WORKS LIKE NORMAL UNTIL IT HAPPENS AGAIN. IT CAN HAPPEN AT TAKE OFF OR WHILE ON THE FREEWAY GOING WITH THE SPEED OF TRAFFIC ALL OF A SUDDEN. AT FIRST I THOUGHT IT WAS NOTHING BUT AS TIME HAS PASSED IT HAS BECOME MORE REGULAR AND NOW I AM HAVING TO GET IT REPAIRED.

NHTSA complaint #10881357 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

THE VEHICLE HAS BEEN LEAKING FUEL SINCE FEB. 2016 THE ENGINE LIGHT CAME ON AND I'VE REPLACED THE EVAP. CANISTER DUE TO THE LEAK, THE SEAL WITH IT AS WELL, AND THE CANISTER PURGE VALVE. ALL THIS WORK WAS DONE AT 2 DIFFERENT FORD DEALERSHIPS. I WAS STILL LEAKING FUEL AND WROTE TO FORD WHO TOLD ME TO TAKE IT TO THE DEALERSHIP AND THEY WOULD FIX IT GRATIS. AT THE DEALERSHIP THEY TOLD ME IT WAS THE GASKET GOING INTO THE TANK AND THAT "SHOULD" TAKE CARE OF THE PROBLEM. IT DIDN'T. GAS FUMES STILL FILLED MY CAR, AND LEAKED GAS ALL OVER THE GROUND WHEREVER I DROVE OR PARKED. I RETURNED TO THE DEALERSHIP AND TOLD THEM I WAS STILL LEAKING FUEL, BUT NO ENGINE LIGHT AS IN THE LAST VISIT. THEY COULD SMELL IT AND SEE IT HAD SOAKED THE REAR END OF MY VEHICLE. THIS TIME THE MECHANIC TOLD ME THERE IS A PLASTIC RING AROUND THE TOP OF THE TANK THAT WAS CRACKED AND I WOULD HAVE TO REPLACE THE WHOLE TANK AND SYSTEM FOR APPROXIMATELY $1000 ADDITIONAL ON TOP OF WHAT I HAD ALREADY REPLACED. I ASKED HIM HOW ALL THESE MECHANICS COULD MISS THIS?? AND HOW CAN IT CRACK IF IT'S SO TIGHT IN THERE UNLESS THE VEHICLE HAD BEEN IN AN ACCIDENT OR IS THERE A DESIGN FLAW, OR A FAILURE OF THE PART ITSELF BECAUSE OF SOME PROBLEM IN MANUFACTURING. THE CAR LEAKS WHILE PARKED, IN MOTION, AND FILLS WITH GAS FUMES. I AM TERRIFIED I MAY HIT A POT HOLE AND BLOW UP. MYSELF I DON'T MIND, BUT I HAVE MY 2YO GRANDSON WITH ME AND THAT IS JUST SCARY AS ALL GET OUT. AND THERE IS NO ENGINE LIGHT THAT COMES ON FOR THIS. HE TELLS ME THE PART SEALS AS THE SYSTEM COMPRESSES WHEN STARTING AND THE GAS EXPANDS WITH HEAT THAT'S WHY THE OVERFLOW.THAT MAY EXPLAIN SOME, BUT I LOSE A TANK OF GAS EVERY 2-4 DAYS. IF THE BREAK IS AT THE TOP HOW IS THE GAS LEAVING MY TANK IN SUCH EXTRAORDINARY AMOUNTS? AND THE ONLY PEOPLE WHO SERVICED THAT CAR WERE FORD "MECHANICS".COMPUTER ILLITERATE FOR UPLOADS, BUT I HAVE DOCUMENTATION& PICS

NHTSA complaint #10865203 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I HAD MY EVAP CANISTER LEAK WHICH I PAID TO HAVE REPLACED APPROXIMATELY 100 MILES AGO ON THIS VEHICLE DUE TO A GAS LEAK. NOW I'VE BEEN TOLD THEY HAVE TO REPLACE THE SEAL BECAUSE IT IS LEAKING FUEL AROUND THIS EVAP CANISTER AND IT'S A "CLOSED" SYSTEM. THEY CLAIM THE SEAL BLEW BECAUSE OF THE SYSTEM WHEN THEY PUT IN THE NEW EVAP CANISTER. THEY OFFERED TO DO THIS FOR AN ADDITIONAL $178.60 AT FORD'S QUICK LANE SERVICE. WHEN THEY REPLACED THE EVAP CANISTER WHY DIDN'T THEY REDO THE SEAL THEN? THEY CLAIM IT DIDN'T SHOW ON THE CODES IN THE COMPUTER. YET THE GAS SMELL NEVER WENT AWAY AND I FOUND GAS UNDER MY VEHICLE EVERYDAY FROM BEFORE AND SINCE THE "REPAIR" OF THE EVAP CANISTER. I WAS AWAY AND WHEN I RETURNED I CALLED THEM AND TOOK IT IN AND THAT'S WHEN I WAS GIVEN THIS INFORMATION. THEY ALSO TELL ME OTHER INTERNAL SEALS CAN ALSO GO WHEN THEY CHANGE THIS EVAP CANISTER. I GET THE "PRIVILEGE" OF PAYING THEM EACH TIME THEY DO A REPAIR TWICE! ONE FOR WHATEVER THEY REPLACED THE EVAP CANISTER WHICH THEY SWEAR WAS THE ONLY PROBLEM AND THEN WHEN IT DIDN'T RESEAL THE SYSTEM THE SEAL BLEW. I FIND IT VERY HARD TO BELIEVE THEY COULDN'T HAVE SEEN OR KNOWN ABOUT THIS SEAL FROM THIS HAPPENING BEFORE. AND EVEN IF THEY DIDN'T OR COULDN'T, WHY WASN'T THE SEAL REPLACED AS A PRECAUTION TO THEIR SEALED SYSTEM. MY VEHICLE IS A 2009 FORD ESCAPE, AND IT HAS BEEN IN THEIR SHOP FOR MORE REPAIRS THAN I CARE TO REMEMBER. EVERY TIME THEY FIX ONE PROBLEM ANOTHER ONE MIRACULOUSLY APPEARS WITHIN 100 MILES OR SO.

NHTSA complaint #10850973 — an unverified report by a vehicle owner.