2003 Ford Expedition transmission problems

POWER TRAIN

TRANSMISSION SLIPPING @ 30-50 MPH.

NHTSA complaint #10678912 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2003 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE JERKED VIOLENTLY AND STALLED INTERMITTENTLY ON SEVERAL OCCASIONS. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER SEVERAL ATTEMPTS. AN INDEPENDENT MECHANIC STATED THAT THE COIL SPRINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,880.

NHTSA complaint #10633257 — an unverified report by a vehicle owner.

POWER TRAIN

MY 03 FORD EXPEDITION STARTED CUTTING OFF EVERY TIME U PUT IT N DRIVE UNLESS U KEEP THE GAS PUSHED A LITTLE THIS IS HAPPENING EVERY TIME U PUT IT IN GEAR.

NHTSA complaint #10631715 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

TL* THE CONTACT OWNS A 2003 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO A DEALER WHO INDICATED THAT THE POWER TRAIN CONTROL MODULE NEEDED TO BE REPLACED TO REPAIR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 139,000.

NHTSA complaint #10586566 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2003 FORD EXPEDITION. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE SHIFTED INTO NEUTRAL INDEPENDENTLY AND BEGAN TO ROLL AWAY. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 90,000. UPDATED 10/29/13

NHTSA complaint #10537935 — an unverified report by a vehicle owner.

POWER TRAIN

I WAS ON INTERSTATE 95 SOUTHBOUND WHEN I HEARD A LOUD BOOM FOLLOWED BY A FLAPPING SOUND I PULLED ONTO THE SHOULDER TO SEE WHAT HAPPEND WHEN I NOTICED GAS COMING FROM THE AREA WHERE THE SPARK PLUG WAS AT I SHUT THE CAR OFF AND CALLED FOR A TOW.

NHTSA complaint #10505722 — an unverified report by a vehicle owner.

POWER TRAIN

FORD EXPEDITION 5.4L V8 SHUDDERS AND STALLS AT LOW RPM IN DRIVE AND IN REVERSE. THIS TRUCK ONLY HAS 49,000 MILES AND IT IS LIKELY TO BE A FAILED TORQUE CONVERTER OR TRANSMISSION WHICH CAN COST OVER $2,000 TO REPAIR. IT DRIVES MOSTLY NORMAL WHEN OD IS DISABLED, BUT THE ISSUE DOES NOT GO AWAY.

NHTSA complaint #10504638 — an unverified report by a vehicle owner.

POWER TRAIN

FORD EXPEDITION 5.4L V8 SHUDDERS AND STALLS AT LOW RPM IN DRIVE AND IN REVERSE. THIS TRUCK ONLY HAS 49,000 MILES AND IT IS LIKELY TO BE A FAILED TORQUE CONVERTER OR TRANSMISSION WHICH CAN COST OVER $2,000 TO REPAIR. IT DRIVES MOSTLY NORMAL WHEN OD IS DISABLED, BUT THE ISSUE DOES NOT GO AWAY.

NHTSA complaint #10504637 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

WHY IS THERE NO WARNING LIGHT,OR SIGNAL OF ANY KIND WHEN THE PCM FAILS? OUR PCM FAILED, WHICH CAUSED OUR CATALYTIC CONVERTERS, 02 SENSORS, & FUEL PUMP TO FAIL. OUR IGNITION COILS HAD TO BE REPLACED. WOULD HAVE BEEN NICE IF A WARNING LIGHT CAME ON THE DASH. THIS HAS CAUSED OUR EXPEDITION ENGINE TO RANDOMLY SHUT OFF WHILE DRIVING COUNTLESS TIMES! I HAVE MIRACULOUSLY BEEN ABLE TO MANEUVER MY EXPEDITION TO THE SIDE OF THE FREEWAY &HAVE IT TOWED EIGHT TIMES WITHOUT KILLING MYSELF, MY FAMILY OR ANY ONE ELSE! WE HAVE HAD ODD ELECTRICAL AND PERFORMANCE PROBLEMS SINCE AUGUST OF 2002 WHEN WE PURCHASED IT. NOT ONE FORD MECHANIC (3 DIFFERENT DEALERSHIPS) COULD EVER DIAGNOSE OR REPAIR ISSUES. BECAUSE THERE IS NO WARNING LIGHT/CODE WHEN THE PCM IS OUT, THE DAMAGE SNOWBALLS. THERE ARE NO COMPUTER CODES, OR WARNING LIGHTS TO SHOW UP ON THE DASH BOARD WHEN THE PCM IS OUT, WHICH BEFUDDLES THE MECHANICS. WE ARE LITERALLY $5,000 IN THE HOLE SO FAR! FORD DEALERSHIP "REPAIRED" OUR EXPEDITION BY REPLACING THE PCM ($1,300.00). 48 HOURS AFTER THEY REPLACED THE PCM, AND 18 MILES AFTER WE DROVE EXPEDITION OFF THE FORD LOT, THE "SERVICE ENGINE SOON" LIGHT CAME UP ON THE DASHBOARD -FOR THE FIRST TIME EVER! WE DROVE BACK TO THE FORD DEALERSHIP, AND HE SAID FOR $3,400 PLUS TAX HE COULD REPLACE OUR NEW CATALYTIC CONVERTERS IN "BANK ONE" THAT WERE DESTROYED AGAIN, & THE "BANK TWO" CONVERTERS WHICH ARE NOW VERY WEAK, NOT UP TO SPEC. THE DRIVER'S SEAT MOTOR THAT HAS BEEN FICKLE SINCE AUG OF 2002, STOPPED WORKING WHEN WE WENT TO PICK IT UP, SO I CAN'T DRIVE IT, BECAUSE I CAN'T REACH THE GAS OR BRAKE PEDALS. $800 WILL FIX THAT, FORD SAYS. IF YOU GOOGLE "2003 FORD EXPEDITION EDDIE BAUER ENGINE SHUTS OFF RANDOMLY", THOUSANDS OF PEOPLE ARE REPORTING THE SAME ISSUES. UNTIL SOMEONE CRASHES AND DIES, I DON'T THINK FORD CARES. THE CONSUMER ALSO STATED THE VEHICLE HAD ELECTRICAL PROBLEMS. THE CONSUMER STATED THE DRIVER'S SEAT MOTOR STOPPED WORKING WHILE BEING SERVICED AT THE DEALER, THERE WERE PROBLEMS WITH THE WINDOWS AS WELL.

NHTSA complaint #10458864 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

THE TRANSMISSION HAS FAILED TWICE IN MY FORD EXPLORER, FIRST AT ABOUT 2500 AND NOW, AFTER A REBUILT ENGINE WAS INSTALLED, AT 205,000. AS WELL, I HAVE HAD DIFFERENTIAL PROBLEMS, MOON ROOF ISSUES, PAINT ISSUES, CRACKED HEAD, ETC.

NHTSA complaint #10455435 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TL* THE CONTACT OWNS A 2003 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STALLED. THE VEHICLE RESTARTED AFTER TEN MINUTES AND WAS TAKEN TO A PRIVATE MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 180,000.

NHTSA complaint #10419666 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

2003 FORD EXPEDITION WOULD NOT START AFTER LONG TOW TO MECHANIC IT WAS A BURNT RELAY SWITCH BUT NOW IT TURNS OFF WHILE DRIVING, CHANGE THE RELAY SWITCH AND PROBLEM IS TEMPORARILY FIXED NOW SINCE THE RELAY IS FOR THE FUEL PUMP AND PCM MY TRANSMISSION IS ACTING UP NOT SHIFTING 3RD OR OVER DRIVE NO ONE CAN FIGURE OUT THE PROBLEM BUT WE ARE SCARED TO DRIVE THE TRUCK!

NHTSA complaint #10386038 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE

I HAVE A 2003 EXPEDITION WITH ONLY 31000 MILES. AT 26000 MILES I NOTICED A GRINDING VIBRATION WHEN I TURNED RIGHT OR LEFT.. I WENT TO THE DEALERSHIP AND WAS TOLD THIS IS A COMMON PROBLEM WITH 2003,04 EXPEDITIONS. THE CLUTHES IN THE REAR DIFFERENTIAL GOES BAD EVERY 30,000 MILE AND THE COST WILL BE $1250.00 DOLLARS TO REPAIR. IF FORD KNOW THIS IS A PROBLEM, WHY HAVEN'T THEY ISSUED A RECALL? WE AS OWNERS SHOULDN'T HAVE TO CONTINUE TO PAY THIS EVERY 30,000 MILES. MY E-MAIL ADDRESS IS [XXX] . PLEASE RESPOND. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #10341346 — an unverified report by a vehicle owner.

POWER TRAIN

MY WIFE AND I OWN A 2003 FORD EXPEDITION XLT 4WD SINCE 2004. EVERY SINCE WE OWNED THIS VEHICLE WE HAVE HAD PROBLEMS FROM THE REAR LSD BEING REPLACES TWICE, THE ELECTRICAL HARNESS REPLACEMENT, ALL POWER LOCKS REPLACED (DUE TO COMING OPEN BY THEMSELVES), AND RECENTLY THE TWO COIL PACKS BLOWING OUT OF THE MOTOR. WE SPENT OVER A THOUSAND DOLLARS TO GET VEHICLE TO PASS SMOG DUE TO OUTRAGEOUS SPARK PLUG PRICES ALONG WITH LABOR COST OF $400. I AM FED UP WITH FORD AND WANT EVERYONE TO KNOW HOW THEIR QUALITY IS SO SUB-STANDARD. THIS VEHICLE HAS BEEN IN THE SHOP AROUND 6-7 TIMES AND I HAVE TO WORRY EVERY TIME I DRIVE IT. PLEASE ISSUE A RECALL ON THE SPARK PLUG ISSUE AS FORD AGREES IT IS A DEFECT, THEY WILL NOT TAKE RESPONSIBILITY FOR THEIR SHABBY WORK- [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #10325439 — an unverified report by a vehicle owner.

POWER TRAIN

WE YOU MAKE A TURN YOU HER A NOISE FROM THE REAR END.

NHTSA complaint #10275616 — an unverified report by a vehicle owner.

POWER TRAIN

I HAVE A RUBBING / GRINDING NOISE COMING FROM MY REAR END ON MY 2003 FORD EXPEDITION. AND AS I LOOK ON THE INTERNET THERE ARE 100'S OF PEOPLE THAT ARE COMPLAINING ABOUT THE SAME PROBLEM. THIS HAS TO BE A KNOWN ISSUE WITH FORD AND THEY AREN'T STANDING BEHIND THERE PRODUCT.

NHTSA complaint #10233008 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TL*THE CONTACT OWNS A 2003 FORD EXPEDITION. WHILE DRIVING 50MPH, THE VEHICLE BEGAN TO HESITATE AFTER MAKING A LOUD NOISE. AFTER DESCRIBING THE SYMPTOMS TO THE DEALER VIA PHONE, HE STATED THAT THE FAILURE APPEARED TO BE THE TRANSMISSION. THE NOISE IS GETTING PROGRESSIVELY WORSE. THE WARRANTY HAS EXPIRED. THE DEALER IS DIAGNOSING THE FAILURE TODAY. THE CURRENT MILEAGE WAS 93000 AND THE FAILURE MILEAGE WAS 92900.

NHTSA complaint #10213926 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

CLUTCH FAILED, CAUSING THE TIRES TO PRODUCE A GRINDING NOISE WHEN TURNING. THIS PROBLEM WAS NOTICED, BY ME, WHILE STILL UNDER WARRANTY, BUT I THOUGHT IT WAS JUST SYSTEMATIC OF THE VEHICLE UNTIL PASSENGERS NOTICED AND EVENTUALLY IT GOT SO BAD THAT IT FELT LIKE A VERY UNSAFE AND SERIOUS PROBLEM. DEALER IS CHARGING $1600 HALF OF WHICH IS PARTS. NEXT WEEK WHEN I GET THE VEHICLE BACK, WILL DETERMINE IF I AM KEEPING THE CAR OR HAVE LOST CONFIDENCE IN THE SAFETY OR FUTURE PROBLEMS.

NHTSA complaint #10190748 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

TL*-THE CONTACT STATED THAT WHILE RESEARCHING THE SERVICE BULLETIN ON THE NHTSA WEBSITE, HE NOTICED THAT THERE WAS A BULLETIN ON THE 2003 FORD EXPEDITION. THE CONTACT OWNS A 2003 FORD EXPEDITION WITH THE CURRENT MILEAGE OF 40,000. THE CONTACT STATED WHILE DRIVING 45 MPH THE VEHICLE HAD A VIBRATION OF THE CLUTCH SLIP DIFFERENTIAL.

NHTSA complaint #10186585 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

TL*-THE CONTACT STATED THAT WHILE RESEARCHING THE SERVICE BULLETIN ON THE NHTSA WEBSITE, HE NOTICED THAT THERE WAS A BULLETIN ON THE 2003 FORD EXPEDITION. THE CONTACT OWNS A 2003 FORD EXPEDITION WITH THE CURRENT MILEAGE OF 40,000. THE CONTACT STATED WHILE DRIVING 45 MPH THE VEHICLE HAD A VIBRATION OF THE CLUTCH SLIP DIFFERENTIAL.

NHTSA complaint #10186585 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

I KEPT FEELING A "SLIPPING FEELING" IN THE REAR OF MY 2003 FORD EXPEDITION. LIKE A GEAR AND NOTCHES OF THE GEAR WERE NOT LINING UP PROPERLY TO INTER-LOCK AND TURN. IT WOULD FEEL LIKE A JUMPING, SLIPPING. I TOOK IT LOCAL DEALERSHIP, THEY REPLACED THE REAR CLUTCHES. SINCE THAT TIME, IT HAS BEEN IN TWO DIFFERENT DEALERSHIPS IN LESS THAN A YEAR AND THE REAR CLUTCHES HAVE BEEN REPLACED FIVE TIMES AND NOW I AM ABOUT TO TAKE IN FOR NUMBER SIX.

NHTSA complaint #10172281 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

CLUTCH PLATE AND PINION GEAR IS FAULTY AND FORD MOTOR COMPANY DOES NOT WANT TAKE FULL RESPONSIBILITY FOR THE PROBLEM.

NHTSA complaint #10162921 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

DT*: THE CONTACT STATED WHILE ATTEMPTING TO CHANGE GEARS THE GEAR SHIFTER BROKE. THE ENGINE WAS IDLING WHEN THE SHIFTER BROKE. THE VEHICLE WAS TOWED TO THE DEALERSHIP. UPON INSPECTION THE DEALER DETERMINED THE GEAR SHIFTER WAS DEFECTIVE. THE ENTIRE STEERING COLUMN WAS REPLACED. UPDATED 3/10/2006 -

NHTSA complaint #10149401 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

CONSUMER STATES: HAD CAR IN PARK WITH SLIGHT INCLINE, AND LEFT VEHICLE RUNNING ,AND THE VEHICLE SLIPPED OUT OF GEAR AND WENT INTO REVERSE. NO ONE WAS IN THE VEHICLE.

NHTSA complaint #10120115 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

SINCE WE HAVE OWNED THIS 2003 EXPEDITION WE HAVE HAD THE WINDSHIELD REPLACED DUE TO NOISE AND LOOSE STRIPPING, THEN, THE CONTRACTING PERSON PUT IN THE WRONG YEARS WINDSHIELD. THE EMISSIONS CANISTER WAS CRACKED AND WAS REPLACED. THE MUFFLER WOULD POP AFTER TURNING OFF THE ENGINE, BUT COULDN'T BE FIXED UNTIL VERIFIED BY FORD. I WAITED FOR 3-4 HOURS ONE DAY WITH 3 CHILDREN WHILE THEY LET MY CAR RUN AND SHUT OFF. WE FINALLY CALLED AHEAD, AND HAD THEM WAIT OUTSIDE ON US UNTIL WE KILLED THE ENGINE TO HEAR IT POP. IT WAS A POOR MUFFLER WELD AND WAS REPAIRED. THE SIDE MOLDING RATTLED BADLY, AND WAS TERRIBLY FADED, AND THAT WAS REPLACED. THE DOOR GETS A LOT OF WIND NOISE , AND A WHISTLE IN THE WINDOW. THEY SAID WINDOW PASSED THE DOLLAR BILL TEST AND WAS FINE BUT IT STILL WHISTLES. THEY, PUT A CLEAR STRIP ALONG INSIDE OF DOOR TO HELP NOISE. IT DOESN'T. THEN ,THE REAR CONTINENTAL TIRE HAD SUCH HORRIBLE, UNEVEN WEAR, IT WAS EXTREMELY DANGEROUS. BOUGHT NEW TIRES FOR $600. THEN REAR DIFFERENTIAL MALFUNCTIONED, AND WOULD MAKE A GRINDING ON TURNING LEFT OR RIGHT. THEY FIXED THAT IN MARCH 2005, AND IT JUST STARTED DOING IT AGAIN. NOW, THERE IS A STRANGE NOISE WHEN REVVING THE ENGINE TO DRIVE COMING FROM UNDER THE HOOD. IT IS GOING IN TOMORROW FOR THE NOISE AND THE REAR DIFFERENTIAL. ON TOP OF ALL THE REPAIRS, WE HAVE HAD A SQUEAKY BRAKE ISSUE. ALSO, THEY HAVE SAID THEY WERE GOOD. THEY JUST GET A LOT OF BRAKE DUST, JUST SAND THEM. OUR SIDE WINDOWS SHIMMIES ALL THE TIME. ! I DID INVEST IN AN EXTENDED WARRANTY!.

NHTSA complaint #10118197 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

THE VEHICLE WILL NOT ENGAGE INTO REVERSE KEEPING IT FROM MOVING OUT OF A PARKING SPACE. MANUFACTURER HAS BEEN NOTIFIED BY OWNER.

NHTSA complaint #10111729 — an unverified report by a vehicle owner.