Owners have filed 12 complaints
about the 2025 Ford F-150 Lightning BEV with NHTSA between 2025 and 2026.
The largest single group is the driver assist & collision avoidance.
Across this model's run it ranks 4 of 4 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 6
Against the median year of the Ford F-150 Lightning BEV. 50 means typical for this
model; 100 means roughly double.
Severity — 100
100% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — not reported
Too few complaints recorded a mileage to measure this.
How 2025 compares with every other Ford F-150 Lightning BEV
Complaints filed with NHTSA, by model year. Bar colour is the FaultScore grade:
A
B
C
D
F
ungraded
What breaks on a 2025 Ford F-150 Lightning BEV
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
Driver Assist & Collision Avoidance
541.7%
4 crashes, 1 fires
Electrical System
216.7%
1 crashes, 1 fires · median 10,900 mi
Engine & Cooling
216.7%
1 crashes, 1 fires
Body & Structure
18.3%
Brakes
18.3%
Transmission & Drivetrain
18.3%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jul 2025peak 6Jul 2026
Complaints that involved harm
Reports where the owner recorded a crash, a fire, an injury or a death.
Narragansett, RICrash1 injured
FORWARD COLLISION AVOIDANCE: WARNINGS
On June 3, 2026 at approximately 3:48 PM, I was operating my 2025 Ford F-150 Lightning Flash in front of my home. The vehicle was at a stop or near-stop. I shifted the vehicle into Reverse, and it rapidly accelerated unexpectedly while in one-pedal driving mode. I then attempted to shift the vehicle into Park to stop it. The vehicle then stopped abruptly and surged forward, ultimately crashing into the front of my house. The vehicle movement and acceleration were not consistent with my intended driver input. One-pedal drive was on, cruise control/BlueCruise/driver assist were off, road conditions were dry, no warning lights or messages appeared, and I noticed no floor mat obstruction. The exact speed reached is unknown, but the impact caused substantial exterior and interior structural damage to the house. I sustained injuries to my head, neck, right leg, and left elbow and went to the hospital for evaluation and treatment. A police report is pending. I am filing this complaint because the vehicle appeared to experience rapid unexpected acceleration and movement not consistent with intended driver input.
NHTSA complaint #11742033 — an unverified report by a vehicle owner.
On June 3, 2026 at approximately 3:48 PM, I was operating my 2025 Ford F-150 Lightning Flash in front of my home. The vehicle was at a stop or near-stop. I shifted the vehicle into Reverse, and it rapidly accelerated unexpectedly while in one-pedal driving mode. I then attempted to shift the vehicle into Park to stop it. The vehicle then stopped abruptly and surged forward, ultimately crashing into the front of my house. The vehicle movement and acceleration were not consistent with my intended driver input. One-pedal drive was on, cruise control/BlueCruise/driver assist were off, road conditions were dry, no warning lights or messages appeared, and I noticed no floor mat obstruction. The exact speed reached is unknown, but the impact caused substantial exterior and interior structural damage to the house. I sustained injuries to my head, neck, right leg, and left elbow and went to the hospital for evaluation and treatment. A police report is pending. I am filing this complaint because the vehicle appeared to experience rapid unexpected acceleration and movement not consistent with intended driver input.
NHTSA complaint #11742033 — an unverified report by a vehicle owner.
Narragansett, RICrash1 injured
BACK OVER PREVENTION: WARNINGS
On June 3, 2026 at approximately 3:48 PM, I was operating my 2025 Ford F-150 Lightning Flash in front of my home. The vehicle was at a stop or near-stop. I shifted the vehicle into Reverse, and it rapidly accelerated unexpectedly while in one-pedal driving mode. I then attempted to shift the vehicle into Park to stop it. The vehicle then stopped abruptly and surged forward, ultimately crashing into the front of my house. The vehicle movement and acceleration were not consistent with my intended driver input. One-pedal drive was on, cruise control/BlueCruise/driver assist were off, road conditions were dry, no warning lights or messages appeared, and I noticed no floor mat obstruction. The exact speed reached is unknown, but the impact caused substantial exterior and interior structural damage to the house. I sustained injuries to my head, neck, right leg, and left elbow and went to the hospital for evaluation and treatment. A police report is pending. I am filing this complaint because the vehicle appeared to experience rapid unexpected acceleration and movement not consistent with intended driver input.
NHTSA complaint #11742033 — an unverified report by a vehicle owner.
Cape Coral, FLCrashFire
ELECTRICAL SYSTEM
On September 19, 2025, my wife was at the wheel of our 2025 Ford F-150 Lightning (VIN: [XXX] ), a vehicle we had leased just months earlier on June 22, 2025, from Sam Galloway Ford at [XXX] . Traveling at a mere 15-20 mph when she was involved in a routine multi-vehicle collision (no citations were issued). No collision warning was sounded. The front-end impact triggered an instantaneous and ferocious eruption of flames from the truck's forward section. The vehicle was swiftly consumed in a raging inferno, leading to its complete and irreparable destruction. My wife narrowly escaped with her life, scrambling from the cab amid the explosive intensification of the fire while relying on the urgent assistance of bystanders to reach safety—mere seconds from what could have been a fatal entrapment. She endured profound terror, acute anxiety, and an overwhelming fear for her very survival in the face of this abrupt and merciless blaze. Responding emergency crews, including the fire department, pinpointed the origin at the vehicle's front end, aligning with hallmarks of a catastrophic battery or electrical malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11691878 — an unverified report by a vehicle owner.
Cape Coral, FLCrashFire
ENGINE
On September 19, 2025, my wife was at the wheel of our 2025 Ford F-150 Lightning (VIN: [XXX] ), a vehicle we had leased just months earlier on June 22, 2025, from Sam Galloway Ford at [XXX] . Traveling at a mere 15-20 mph when she was involved in a routine multi-vehicle collision (no citations were issued). No collision warning was sounded. The front-end impact triggered an instantaneous and ferocious eruption of flames from the truck's forward section. The vehicle was swiftly consumed in a raging inferno, leading to its complete and irreparable destruction. My wife narrowly escaped with her life, scrambling from the cab amid the explosive intensification of the fire while relying on the urgent assistance of bystanders to reach safety—mere seconds from what could have been a fatal entrapment. She endured profound terror, acute anxiety, and an overwhelming fear for her very survival in the face of this abrupt and merciless blaze. Responding emergency crews, including the fire department, pinpointed the origin at the vehicle's front end, aligning with hallmarks of a catastrophic battery or electrical malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11691878 — an unverified report by a vehicle owner.
Cape Coral, FLCrashFire
FORWARD COLLISION AVOIDANCE: WARNINGS
On September 19, 2025, my wife was at the wheel of our 2025 Ford F-150 Lightning (VIN: [XXX] ), a vehicle we had leased just months earlier on June 22, 2025, from Sam Galloway Ford at [XXX] . Traveling at a mere 15-20 mph when she was involved in a routine multi-vehicle collision (no citations were issued). No collision warning was sounded. The front-end impact triggered an instantaneous and ferocious eruption of flames from the truck's forward section. The vehicle was swiftly consumed in a raging inferno, leading to its complete and irreparable destruction. My wife narrowly escaped with her life, scrambling from the cab amid the explosive intensification of the fire while relying on the urgent assistance of bystanders to reach safety—mere seconds from what could have been a fatal entrapment. She endured profound terror, acute anxiety, and an overwhelming fear for her very survival in the face of this abrupt and merciless blaze. Responding emergency crews, including the fire department, pinpointed the origin at the vehicle's front end, aligning with hallmarks of a catastrophic battery or electrical malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11691878 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Sarasota, FL
SERVICE BRAKES
I am writing to report a serious safety issue introduced by a recent firmware update regarding the Sport mode and 1-pedal driving behavior. After driving the vehicle in Sport mode, parking, and restarting, the dashboard prompts me to return to Sport mode. When I select "Yes," the dashboard indicates that the vehicle has switched to Sport mode. However, the vehicle silently reverts to Normal mode, which has a much more relaxed braking pattern for 1-pedal driving than the expected, shorter braking path of Sport mode. Compounding the danger, this issue occurs inconsistently. Sport mode occasionally does stick upon restart, which creates a false and dangerous level of confidence in the system. The unexpected drop in braking responsiveness has already caused multiple near-miss collisions.
NHTSA complaint #11750302 — an unverified report by a vehicle owner.
Long Beach, CA
POWER TRAIN
Description On your vehicle, the integrated park module ipm may not properly engage the park pawl, preventing the vehicle from locking into park when park p is selected. If this condition occurs, a wrench light and shift system fault message will be displayed in the instrument panel cluster. Additionally, the vehicles electronic parking brake epb will automatically apply. Safety Risk If the park pawl is not properly engaged and the electronic parking brake epb is not applied, your vehicle may experience a roll-in-park, increasing the risk of a crash. Remedy Software is available to repair your vehicle. Ford Motor Company has authorized your dealer to update your vehicles secondary on board diagnostic module c sobdmc software free of charge. Next Steps Contact your dealer for more information to schedule the free service.
NHTSA complaint #11744290 — an unverified report by a vehicle owner.
Long Beach, CA
STRUCTURE:BODY
Description On your vehicle, the integrated park module ipm may not properly engage the park pawl, preventing the vehicle from locking into park when park p is selected. If this condition occurs, a wrench light and shift system fault message will be displayed in the instrument panel cluster. Additionally, the vehicles electronic parking brake epb will automatically apply. Safety Risk If the park pawl is not properly engaged and the electronic parking brake epb is not applied, your vehicle may experience a roll-in-park, increasing the risk of a crash. Remedy Software is available to repair your vehicle. Ford Motor Company has authorized your dealer to update your vehicles secondary on board diagnostic module c sobdmc software free of charge. Next Steps Contact your dealer for more information to schedule the free service.
NHTSA complaint #11744290 — an unverified report by a vehicle owner.
Long Beach, CA
ENGINE
Description On your vehicle, the integrated park module ipm may not properly engage the park pawl, preventing the vehicle from locking into park when park p is selected. If this condition occurs, a wrench light and shift system fault message will be displayed in the instrument panel cluster. Additionally, the vehicles electronic parking brake epb will automatically apply. Safety Risk If the park pawl is not properly engaged and the electronic parking brake epb is not applied, your vehicle may experience a roll-in-park, increasing the risk of a crash. Remedy Software is available to repair your vehicle. Ford Motor Company has authorized your dealer to update your vehicles secondary on board diagnostic module c sobdmc software free of charge. Next Steps Contact your dealer for more information to schedule the free service.
NHTSA complaint #11744290 — an unverified report by a vehicle owner.
Narragansett, RICrash1 injured
FORWARD COLLISION AVOIDANCE: WARNINGS
On June 3, 2026 at approximately 3:48 PM, I was operating my 2025 Ford F-150 Lightning Flash in front of my home. The vehicle was at a stop or near-stop. I shifted the vehicle into Reverse, and it rapidly accelerated unexpectedly while in one-pedal driving mode. I then attempted to shift the vehicle into Park to stop it. The vehicle then stopped abruptly and surged forward, ultimately crashing into the front of my house. The vehicle movement and acceleration were not consistent with my intended driver input. One-pedal drive was on, cruise control/BlueCruise/driver assist were off, road conditions were dry, no warning lights or messages appeared, and I noticed no floor mat obstruction. The exact speed reached is unknown, but the impact caused substantial exterior and interior structural damage to the house. I sustained injuries to my head, neck, right leg, and left elbow and went to the hospital for evaluation and treatment. A police report is pending. I am filing this complaint because the vehicle appeared to experience rapid unexpected acceleration and movement not consistent with intended driver input.
NHTSA complaint #11742033 — an unverified report by a vehicle owner.
On June 3, 2026 at approximately 3:48 PM, I was operating my 2025 Ford F-150 Lightning Flash in front of my home. The vehicle was at a stop or near-stop. I shifted the vehicle into Reverse, and it rapidly accelerated unexpectedly while in one-pedal driving mode. I then attempted to shift the vehicle into Park to stop it. The vehicle then stopped abruptly and surged forward, ultimately crashing into the front of my house. The vehicle movement and acceleration were not consistent with my intended driver input. One-pedal drive was on, cruise control/BlueCruise/driver assist were off, road conditions were dry, no warning lights or messages appeared, and I noticed no floor mat obstruction. The exact speed reached is unknown, but the impact caused substantial exterior and interior structural damage to the house. I sustained injuries to my head, neck, right leg, and left elbow and went to the hospital for evaluation and treatment. A police report is pending. I am filing this complaint because the vehicle appeared to experience rapid unexpected acceleration and movement not consistent with intended driver input.
NHTSA complaint #11742033 — an unverified report by a vehicle owner.
Narragansett, RICrash1 injured
BACK OVER PREVENTION: WARNINGS
On June 3, 2026 at approximately 3:48 PM, I was operating my 2025 Ford F-150 Lightning Flash in front of my home. The vehicle was at a stop or near-stop. I shifted the vehicle into Reverse, and it rapidly accelerated unexpectedly while in one-pedal driving mode. I then attempted to shift the vehicle into Park to stop it. The vehicle then stopped abruptly and surged forward, ultimately crashing into the front of my house. The vehicle movement and acceleration were not consistent with my intended driver input. One-pedal drive was on, cruise control/BlueCruise/driver assist were off, road conditions were dry, no warning lights or messages appeared, and I noticed no floor mat obstruction. The exact speed reached is unknown, but the impact caused substantial exterior and interior structural damage to the house. I sustained injuries to my head, neck, right leg, and left elbow and went to the hospital for evaluation and treatment. A police report is pending. I am filing this complaint because the vehicle appeared to experience rapid unexpected acceleration and movement not consistent with intended driver input.
NHTSA complaint #11742033 — an unverified report by a vehicle owner.
at 10,900 milesDavisburg, MI
ELECTRICAL SYSTEM
The contact owns a 2025 Ford F-150. The contact stated that while driving at an undisclosed speed, the message "High Voltage Battery Fault" was displayed and then the message "Take Vehicle to Dealer" was displayed. The vehicle was taken to the dealer, but no cause of failure was found. The contact stated that while driving at an undisclosed speed, the message "Stop Safely Now" was displayed and the vehicle was towed to a second dealer, Szott Ford (8800 E Holly Rd, Holly, MI 48442). The vehicle was not yet diagnosed or repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 10,900.
NHTSA complaint #11728289 — an unverified report by a vehicle owner.
Cape Coral, FLCrashFire
ELECTRICAL SYSTEM
On September 19, 2025, my wife was at the wheel of our 2025 Ford F-150 Lightning (VIN: [XXX] ), a vehicle we had leased just months earlier on June 22, 2025, from Sam Galloway Ford at [XXX] . Traveling at a mere 15-20 mph when she was involved in a routine multi-vehicle collision (no citations were issued). No collision warning was sounded. The front-end impact triggered an instantaneous and ferocious eruption of flames from the truck's forward section. The vehicle was swiftly consumed in a raging inferno, leading to its complete and irreparable destruction. My wife narrowly escaped with her life, scrambling from the cab amid the explosive intensification of the fire while relying on the urgent assistance of bystanders to reach safety—mere seconds from what could have been a fatal entrapment. She endured profound terror, acute anxiety, and an overwhelming fear for her very survival in the face of this abrupt and merciless blaze. Responding emergency crews, including the fire department, pinpointed the origin at the vehicle's front end, aligning with hallmarks of a catastrophic battery or electrical malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11691878 — an unverified report by a vehicle owner.
Cape Coral, FLCrashFire
ENGINE
On September 19, 2025, my wife was at the wheel of our 2025 Ford F-150 Lightning (VIN: [XXX] ), a vehicle we had leased just months earlier on June 22, 2025, from Sam Galloway Ford at [XXX] . Traveling at a mere 15-20 mph when she was involved in a routine multi-vehicle collision (no citations were issued). No collision warning was sounded. The front-end impact triggered an instantaneous and ferocious eruption of flames from the truck's forward section. The vehicle was swiftly consumed in a raging inferno, leading to its complete and irreparable destruction. My wife narrowly escaped with her life, scrambling from the cab amid the explosive intensification of the fire while relying on the urgent assistance of bystanders to reach safety—mere seconds from what could have been a fatal entrapment. She endured profound terror, acute anxiety, and an overwhelming fear for her very survival in the face of this abrupt and merciless blaze. Responding emergency crews, including the fire department, pinpointed the origin at the vehicle's front end, aligning with hallmarks of a catastrophic battery or electrical malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11691878 — an unverified report by a vehicle owner.
Cape Coral, FLCrashFire
FORWARD COLLISION AVOIDANCE: WARNINGS
On September 19, 2025, my wife was at the wheel of our 2025 Ford F-150 Lightning (VIN: [XXX] ), a vehicle we had leased just months earlier on June 22, 2025, from Sam Galloway Ford at [XXX] . Traveling at a mere 15-20 mph when she was involved in a routine multi-vehicle collision (no citations were issued). No collision warning was sounded. The front-end impact triggered an instantaneous and ferocious eruption of flames from the truck's forward section. The vehicle was swiftly consumed in a raging inferno, leading to its complete and irreparable destruction. My wife narrowly escaped with her life, scrambling from the cab amid the explosive intensification of the fire while relying on the urgent assistance of bystanders to reach safety—mere seconds from what could have been a fatal entrapment. She endured profound terror, acute anxiety, and an overwhelming fear for her very survival in the face of this abrupt and merciless blaze. Responding emergency crews, including the fire department, pinpointed the origin at the vehicle's front end, aligning with hallmarks of a catastrophic battery or electrical malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11691878 — an unverified report by a vehicle owner.
Verona, NJ
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Vehicle unintentional cruise activation has happened two times now. The button requires no other 2nd action and at speed low enough to cause unintended forward and sudden acceleration. The button activates easily under turns due to its placements. In addition to this blue cruise gets very confused as sudden vehicles entering the lane in front of it cause severe lane drift due to programming.
NHTSA complaint #11672106 — an unverified report by a vehicle owner.