52 of the
408 complaints filed about the Ford F-150 Lightning BEV
are about the driver-assist systems —
100% of everything owners reported.
The worst model year for it is 2023.
52
Complaints
100%
Share of all complaints
19
Crashes
1
Fires
Driver Assist & Collision Avoidance complaints by model year
On August 19, 2026, I was involved in a collision in my 2025 Ford F-150 Lightning after a suspected malfunction involving the automatic emergency braking, adaptive cruise control, and/or acceleration controls. Cruise control was on; BlueCruise was not. While on an exit ramp, I heard a loud warning beep, experienced automatic braking, and then felt the truck suddenly accelerate into the vehicle ahead. The unexpected braking and acceleration compromised my ability to control the truck and avoid a collision, putting me and occupants of the other vehicle at risk. I am concerned about driving this vehicle again, including with my daughter. Before the collision, I experienced three incidents in which the automatic brakes activated when no vehicles were around. I also reported a warning/error during a December 2025 service visit. The service record documents that visit; I do not know whether that issue is related to the collision. The loud warning beep occurred immediately before the collision. The truck has been at a Ford dealership for evaluation and is available for inspection upon request. The dealership has not confirmed or reproduced the suspected malfunction. The service manager told me its diagnostic testing would not necessarily show what happened during the incident and indicated limitations in obtaining crash-related data. I am requesting further investigation into the braking, cruise control, and acceleration systems. Ford Corporate and State Farm have been notified. I cannot confirm whether Ford Corporate, police, or insurance representatives have performed a technical inspection of these systems or retrieved event data. The cause remains unconfirmed.
NHTSA complaint #11762056 — an unverified report by a vehicle owner.
While maneuvering the vehicle to park near a building, the truck unexpectedly accelerated forward and crashed into the building. I did not intend for the vehicle to accelerate into the structure. During the incident, I did not receive the expected assistance from the vehicle’s front sensing/collision-warning systems before impact. The vehicle struck the building, and no airbags deployed. Because of the nature of the incident, I am concerned about a possible malfunction involving the accelerator, braking system, electronic controls, driver-assistance systems, front sensors, or associated vehicle software. I am also aware that Ford previously issued Customer Satisfaction Program 24B56 and related Special Service Messages concerning inoperative front parking sensors on certain 2022–2024 F-150 Lightning vehicles
NHTSA complaint #11760024 — an unverified report by a vehicle owner.
While maneuvering the vehicle to park near a building, the truck unexpectedly accelerated forward and crashed into the building. I did not intend for the vehicle to accelerate into the structure. During the incident, I did not receive the expected assistance from the vehicle’s front sensing/collision-warning systems before impact. The vehicle struck the building, and no airbags deployed. Because of the nature of the incident, I am concerned about a possible malfunction involving the accelerator, braking system, electronic controls, driver-assistance systems, front sensors, or associated vehicle software. I am also aware that Ford previously issued Customer Satisfaction Program 24B56 and related Special Service Messages concerning inoperative front parking sensors on certain 2022–2024 F-150 Lightning vehicles
NHTSA complaint #11760024 — an unverified report by a vehicle owner.
While maneuvering the vehicle to park near a building, the truck unexpectedly accelerated forward and crashed into the building. I did not intend for the vehicle to accelerate into the structure. During the incident, I did not receive the expected assistance from the vehicle’s front sensing/collision-warning systems before impact. The vehicle struck the building, and no airbags deployed. Because of the nature of the incident, I am concerned about a possible malfunction involving the accelerator, braking system, electronic controls, driver-assistance systems, front sensors, or associated vehicle software. I am also aware that Ford previously issued Customer Satisfaction Program 24B56 and related Special Service Messages concerning inoperative front parking sensors on certain 2022–2024 F-150 Lightning vehicles
NHTSA complaint #11760024 — an unverified report by a vehicle owner.
I was the only person in the truck and there was no one nearby. I was slowly backing the Ford 150 Lighting into my driveway, going straight back. I was going slow because another car was parked at the back end corner. As I was rolling slowly back, the truck started to accelerate on its own, I had not increased pressure on the pedal. The truck was not making any beeping noises or alerts on the screen indicating that there was another car parked behind it. NO safety alerts at all. The truck was completely out of my control other than my ability to turn the steering wheel. I had lifted my foot off the gas pedal entirely at one point to make sure it was not me pressing it and the car kept moving faster without my foot. I tried to steer the truck straight back but upon realizing it would not stop and was only getting faster, I veered the steering wheel to avoid hitting our other small car and turned the truck which backed up directly into the south west corner of our house. The house is what stopped the truck. Upon impact with the house- NO airbags inflated. The truck touchscreen temporarily shined red and audibly said that it would “call 911” and no call was ever made. After this, and after I had gotten out of the truck, I realized that the entire truck shut down mechanically. The turn on button did nothing, the key did nothing, the gears would not shift - it was in a locked position. The driver's seat that I was in- got dislodged and crooked by the force of the truck to the house. My right calf is still sore because my right foot was on the pedal when the truck hit the house. My left side of my neck is very sore and I have a headache around tension around my temples and top of head, my forearms, wrists, trapezius muscles, and rhomboid muscles - all were sore after the crash.
NHTSA complaint #11746670 — an unverified report by a vehicle owner.
On June 3, 2026 at approximately 3:48 PM, I was operating my 2025 Ford F-150 Lightning Flash in front of my home. The vehicle was at a stop or near-stop. I shifted the vehicle into Reverse, and it rapidly accelerated unexpectedly while in one-pedal driving mode. I then attempted to shift the vehicle into Park to stop it. The vehicle then stopped abruptly and surged forward, ultimately crashing into the front of my house. The vehicle movement and acceleration were not consistent with my intended driver input. One-pedal drive was on, cruise control/BlueCruise/driver assist were off, road conditions were dry, no warning lights or messages appeared, and I noticed no floor mat obstruction. The exact speed reached is unknown, but the impact caused substantial exterior and interior structural damage to the house. I sustained injuries to my head, neck, right leg, and left elbow and went to the hospital for evaluation and treatment. A police report is pending. I am filing this complaint because the vehicle appeared to experience rapid unexpected acceleration and movement not consistent with intended driver input.
NHTSA complaint #11742033 — an unverified report by a vehicle owner.
On June 3, 2026 at approximately 3:48 PM, I was operating my 2025 Ford F-150 Lightning Flash in front of my home. The vehicle was at a stop or near-stop. I shifted the vehicle into Reverse, and it rapidly accelerated unexpectedly while in one-pedal driving mode. I then attempted to shift the vehicle into Park to stop it. The vehicle then stopped abruptly and surged forward, ultimately crashing into the front of my house. The vehicle movement and acceleration were not consistent with my intended driver input. One-pedal drive was on, cruise control/BlueCruise/driver assist were off, road conditions were dry, no warning lights or messages appeared, and I noticed no floor mat obstruction. The exact speed reached is unknown, but the impact caused substantial exterior and interior structural damage to the house. I sustained injuries to my head, neck, right leg, and left elbow and went to the hospital for evaluation and treatment. A police report is pending. I am filing this complaint because the vehicle appeared to experience rapid unexpected acceleration and movement not consistent with intended driver input.
NHTSA complaint #11742033 — an unverified report by a vehicle owner.
On June 3, 2026 at approximately 3:48 PM, I was operating my 2025 Ford F-150 Lightning Flash in front of my home. The vehicle was at a stop or near-stop. I shifted the vehicle into Reverse, and it rapidly accelerated unexpectedly while in one-pedal driving mode. I then attempted to shift the vehicle into Park to stop it. The vehicle then stopped abruptly and surged forward, ultimately crashing into the front of my house. The vehicle movement and acceleration were not consistent with my intended driver input. One-pedal drive was on, cruise control/BlueCruise/driver assist were off, road conditions were dry, no warning lights or messages appeared, and I noticed no floor mat obstruction. The exact speed reached is unknown, but the impact caused substantial exterior and interior structural damage to the house. I sustained injuries to my head, neck, right leg, and left elbow and went to the hospital for evaluation and treatment. A police report is pending. I am filing this complaint because the vehicle appeared to experience rapid unexpected acceleration and movement not consistent with intended driver input.
NHTSA complaint #11742033 — an unverified report by a vehicle owner.
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
I was driving by and received multiple warnings about brakes. Brake assist, one pedal driving, reverse brake assist, general brake warning. After the came on the brake were spongy with a hard brake after applying more pressure to the pedal. I needed to apply more pressure because the car was not stopping. I almost hit various cars on the way home because there is certainly an adjustment needed to my braking habits. Very dangerous and unsafe. I took the truck to the dealership and quoted me around $2,500. This is something I have no control over and see that there is a recall on this issue for a 2025 model, but my vehicle does not fall under this recall.
NHTSA complaint #11740632 — an unverified report by a vehicle owner.
I was driving by and received multiple warnings about brakes. Brake assist, one pedal driving, reverse brake assist, general brake warning. After the came on the brake were spongy with a hard brake after applying more pressure to the pedal. I needed to apply more pressure because the car was not stopping. I almost hit various cars on the way home because there is certainly an adjustment needed to my braking habits. Very dangerous and unsafe. I took the truck to the dealership and quoted me around $2,500. This is something I have no control over and see that there is a recall on this issue for a 2025 model, but my vehicle does not fall under this recall.
NHTSA complaint #11740632 — an unverified report by a vehicle owner.
On September 19, 2025, my wife was at the wheel of our 2025 Ford F-150 Lightning (VIN: [XXX] ), a vehicle we had leased just months earlier on June 22, 2025, from Sam Galloway Ford at [XXX] . Traveling at a mere 15-20 mph when she was involved in a routine multi-vehicle collision (no citations were issued). No collision warning was sounded. The front-end impact triggered an instantaneous and ferocious eruption of flames from the truck's forward section. The vehicle was swiftly consumed in a raging inferno, leading to its complete and irreparable destruction. My wife narrowly escaped with her life, scrambling from the cab amid the explosive intensification of the fire while relying on the urgent assistance of bystanders to reach safety—mere seconds from what could have been a fatal entrapment. She endured profound terror, acute anxiety, and an overwhelming fear for her very survival in the face of this abrupt and merciless blaze. Responding emergency crews, including the fire department, pinpointed the origin at the vehicle's front end, aligning with hallmarks of a catastrophic battery or electrical malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11691878 — an unverified report by a vehicle owner.
The vehicle has been in the shop two times due to rodents eating the wiring. Wiring insulation is derived from a plant (soy) based oil, which rodents eat. The truck could have had wiring eaten in any number of areas leading to loss of control.
NHTSA complaint #11673949 — an unverified report by a vehicle owner.
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Vehicle unintentional cruise activation has happened two times now. The button requires no other 2nd action and at speed low enough to cause unintended forward and sudden acceleration. The button activates easily under turns due to its placements. In addition to this blue cruise gets very confused as sudden vehicles entering the lane in front of it cause severe lane drift due to programming.
NHTSA complaint #11672106 — an unverified report by a vehicle owner.
I was driving down the interstate and the vehicle was struck by lightning. The vehicle lost all electrical power. As a result, the brakes did not work. Luckily, I was able to safely coast to a stop in the median. If the brakes can be more than 90% compromised during complete electrical failure, the vehicle should have a mechanical emergency brake.
NHTSA complaint #11654071 — an unverified report by a vehicle owner.
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
I was involved in a rear-end collision caused by a vehicle abruptly moving into my lane while traveling at a slower speed. From the time the vehicle entered my lane to the time of the collision was approximately one second. Despite this timeframe, the anti-collision warning system and automatic emergency braking (AEB) functionality in my Ford vehicle did not activate or alert me before the impact. Additionally, I have observed that the adaptive cruise control and Blue Cruise systems in my vehicle do not react until a vehicle in front is fully out of the lane (for acceleration) or fully in the lane (for deceleration). This delayed reaction may have contributed to the system’s failure to engage in this incident. I believe this represents a potentially unsafe functionality in the collision avoidance system, as it may not adequately respond to rapidly changing traffic conditions. I am reporting this to ensure it is investigated to help improve the safety of these systems and prevent similar incidents in the future.
NHTSA complaint #11638045 — an unverified report by a vehicle owner.
I was involved in a rear-end collision caused by a vehicle abruptly moving into my lane while traveling at a slower speed. From the time the vehicle entered my lane to the time of the collision was approximately one second. Despite this timeframe, the anti-collision warning system and automatic emergency braking (AEB) functionality in my Ford vehicle did not activate or alert me before the impact. Additionally, I have observed that the adaptive cruise control and Blue Cruise systems in my vehicle do not react until a vehicle in front is fully out of the lane (for acceleration) or fully in the lane (for deceleration). This delayed reaction may have contributed to the system’s failure to engage in this incident. I believe this represents a potentially unsafe functionality in the collision avoidance system, as it may not adequately respond to rapidly changing traffic conditions. I am reporting this to ensure it is investigated to help improve the safety of these systems and prevent similar incidents in the future.
NHTSA complaint #11638045 — an unverified report by a vehicle owner.
I was involved in a rear-end collision caused by a vehicle abruptly moving into my lane while traveling at a slower speed. From the time the vehicle entered my lane to the time of the collision was approximately one second. Despite this timeframe, the anti-collision warning system and automatic emergency braking (AEB) functionality in my Ford vehicle did not activate or alert me before the impact. Additionally, I have observed that the adaptive cruise control and Blue Cruise systems in my vehicle do not react until a vehicle in front is fully out of the lane (for acceleration) or fully in the lane (for deceleration). This delayed reaction may have contributed to the system’s failure to engage in this incident. I believe this represents a potentially unsafe functionality in the collision avoidance system, as it may not adequately respond to rapidly changing traffic conditions. I am reporting this to ensure it is investigated to help improve the safety of these systems and prevent similar incidents in the future.
NHTSA complaint #11638045 — an unverified report by a vehicle owner.
Extreme corrosion on connector for headlamp assembly and front camera. Also, extreme corrosion on connector that powers lightbar. Ford denied warranty claim by considering it a lamp issue even though lamp was good. The lightbar and connector w/ corrosion are one single part. Corrosion was so bad multiple pins had rusted off. This could cause electrical short and potential fire risk.
NHTSA complaint #11631668 — an unverified report by a vehicle owner.
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Using the 1 pedal drive mode, I was entering my driveway, which is 90 degrees adjacent to the street I was on. My approximate speed entering the driveway was 2 MPH. As I was finishing the turn and almost straightened out, my hand accidently glazed over and engaged the cruise control button. My truck lurched forward and started to accelerate towards the garage door. I quickly stepped on the brake and the truck came to rest mere inches from the garage door. I believe the speed it was trying to accelerate to was 15 MPH when I had looked down at the dash. This is a big safety hazard. I have tried to recreate it and cruise control wont engage on slow speeds. I'm not sure why this occasion was different.
NHTSA complaint #11628171 — an unverified report by a vehicle owner.