1999 Ford F-250 transmission problems

POWER TRAIN:AUTOMATIC TRANSMISSION

TL*THE CONTACT OWNS A 1999 FORD F250. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE BEGAN VIBRATING. THE FAILURE WOULD OCCUR WHEN DRIVING AT SPEEDS GREATER THAN 40 MPH. THE FAILURE OCCURRED FOR APPROXIMATELY TWO YEARS. WHILE PARKED, THE CONTACT ALSO NOTICED OIL WAS LEAKING FROM THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE REAR COMB OF THE TRANSMISSION WAS BROKEN. THE VEHICLE WAS NOT TAKEN FOR REPAIRS BUT AN APPOINTMENT WAS MADE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.

NHTSA complaint #10374901 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

TL*THE CONTACT OWNS A 1999 FORD F250. WHILE DRIVING 25 MPH, THE OVERDRIVE LIGHT BEGAN FLASHING. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE TORQUE CONVERTER FAILED. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 149,000 AND FAILURE MILEAGE WAS 148,000.

NHTSA complaint #10223828 — an unverified report by a vehicle owner.

POWER TRAIN

1999 FORD F-250 WITH TRANSMISSION PROBLEMS. CONSUMER HAD THIS PROBLEM REPAIRED. SHE WAS THEN INFORMED THAT THERE WAS A TSB THAT SHE NEVER KNEW ABOUT. FORD IS REFUSING TO REIMBURSE HER FOR THE REPAIRS. *KB THE CONSUMER STATED THE MANUFACTURER WAS FULLY AWARE OF THE TRANSMISSION PROBLEM, BUT FAILED TO NOTIFY THEIR CUSTOMERS. THE PROBLEM WAS THE FLUID WOULD OVERHEAT DURING SEVERE DUTY AND WEAR OUT THE TORQUE CONVERTER, WHICH RESULTED IN THE RADIATOR, COOLER LINES AND HOSES FOR THE TRANSMISSION TO BE REPLACED. THE STABILIZER BAR LINK AND BATTERY WERE REPLACED.

NHTSA complaint #10207129 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

CERTIFIED LTR. FWD TO NHTSA RE PREVIOUS LTR SUBMITTED ON 9/23/04 RE DEFECTIVE CLUTCH/TRANSMISSION FOR A 1999 FORD F250 TRUCK. THE VEHICLE WOULD LURCH FORWARD, THE CLUTCH ENGAGED TOO CLOSE TO THE FLOOR, THERE WAS DIFFICULTY WHEN GOING UPHILL, AND WHEN SHIFTING GEARS. THE CORRECTION WAS DONE INCORRECTLY PER VERDE VALLEY FORD. THE CONSUMER WAS SHOWED A BROKEN TAB THAT WAS INSTALLED INCORRECTLY. THE LINE WAS ALSO FULL OF AIR. *SC THE CONSUMER STATED THAT HE HAS TO MAKE CERTAIN THE VEHICLE DOES NOT LURCH FORWARD BECAUSE THE CLUTCH RELEASES SO CLOSE TO THE FLOOR AS TO NOT REAR END ANOTHER DRIVER. THE CLUTCH CAN NOT BE FEATHERED TO GET IT STARTED AFTER SHUTTING OFF ON AN UPHILL GRADE. THE CONSUMER STATED THAT IT IS DIFFICULT TO SHIFT GEARS CAUSING A PAUSE THAT CAN RESULT IN BEING REAR ENDED. THE CLUTCH WAS REPAIRED AT CONSUMERS EXPENSE. *TC

NHTSA complaint #10101331 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

THE SECOND GEAR HAS GONE OUT OF THE TRANSMISSION. THE CONSUMER TOOK THE VEHICLE TO THE DEALER. *JB *SC THE LIGHTS AT THE BOTTOM OF THE DOOR WERE INOPERATIVE. THE STEERING WHEEL WAS OUT OF ALIGNMENT.

NHTSA complaint #10099104 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

FORD F 250 SAFETY ISSUE, CONSTANTLY HAVE TO MAKE CERTAIN THE TRUCK DOESN'T LURCH FORWARD ON RELEASE. *BF THE CONSUMER IS HAVING PROBLEMS WITH THE CLUTCH ON THE SIX SPEED MANUAL AND THE EMERGENCY BRAKE. THE CLUTCH RELEASES ONLY 1 TO 1 1/2 INCHES OFF THE FLOOR. THE CONSUMER WAS TOLD THAT THE ORIGINAL HAD A RUBBER HOSE PART THAT ALLOWED EXPANSION WHEN THE HYDRAULIC CLUTCH FLUID WAS COMPRESSED. THE VEHICLE WAS FOUND THAT THE PROBLEM WITH THE CLUTCH FORK WAS BENDING. THE CONSUMER STATED THAT IT IS DIFFICULT TO SHIFT GEARS CAUSING A PAUSE THAT COULD RESULT IN SOMEONE ELSE REAR ENDING HIM. THE VEHICLE EMERGENCY BRAKE WAS REPLACED DUE TO RECALL NOTICE HOWEVER THE CONSUMER STILL HAS TO LEAVE IT IN GEAR ON EVEN THESLIGHTEST GRADE BECAUSE THE EMERGENCY BRAKE DOES NOT HOLD THE TRUCK IN PLACE. FORD MOTOR COMPANY AGREED TO REPLACE THE PARKING BRAKE FRONT CABLE AND THE PEDAL CONTROL ASSEMBLY. *TC THE A/C BLEW HOT AIR.

NHTSA complaint #10095317 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

CONSUMER STATES THAT THE BUSHINGS IN CLUTCH KEPT BREAKING OFF. WHEN THIS HAPPENED THE CLUTCH PEDAL WENT ALL THE WAY TO THE FLOOR, AND CONSUMER COULD NOT STOP THE VEHICLE. THE PIECE THAT BROKE OFF WAS MADE OF PLASTIC, AND DID NOT DO THE JOB. THIS HAPPENED 3 TIMES. THE FIRST TIME AT 80,000 MILES. CURRENTLY, IT HAPPENED AGAIN AND THERE WAS NO RECALL ON IT.

NHTSA complaint #10081874 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION VIBRATES AND CUTS OUT WHEN ENGAGING SPEED , AND I HAVE NOT RECEIVED ANY RECALLS ON MY VECHIEL IT IS A 99 F250 4DR V8. SO COULD YOU PLEASE SEND ME SOMETHING TO HAVE MY VEHICLE REPAIRED AND ALSO MY AIR BAG SENSOR IS BAD , THE ENGINE LIGHT SENSOR IS ALSO ON.

NHTSA complaint #10062634 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

PROBLEMS WITH BRAKE EQUIPMENT/ VEHICLE SHOOK VIOLENTLY WHEN BRAKES WERE APPLIED. *MR THE VEHICLE HAD BEEN TO THE DEALER FIVE TIMES, AND EACH TIME THE CONSUMER WAS INFORMED THE PROBLEM WAS RESOLVED. AFTER THE SECOND REPAIR, THE WARRANTY HAD EXPIRED SO THE CONSUMER HAD TO PAY FOR THE REPAIRS. FINALLY, THE CONSUMER TOOK THE VEHICLE TO HIS PERSONAL MECHANIC WHO STATED THE PROBLEMS THE VEHICLE EXPERIENCED WAS CAUSED BY A FRONT SEAL LEAKAGE ON THE RIGHT AXLE. IN ADDITION, THE MECHANIC STATED WHEN THE GREASE LEAKED ONTO THE ROTOR, IT BECAME HOT AND WARPED THE ROTOR WHICH CAUSED THE VIBRATION. CONSUMER WANTED NEW ROTORS, CALIPERS, AND SEALS ON BOTH FRONT WHEELS AT NO COST TO HIM. HE ALSO WANTED TO BE REIMBURSED FOR THE THREE OUT OF POCKET REPAIRS. *PH

NHTSA complaint #10022276 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

CLUTCH SLAVE CYLINDER FAILED WITHOUT WARNING. THE CLUTCH PEDAL WENT ABOUT 1/2 WAY BEFORE ENGAGING. DIFFICULT TO ENGAGE CLUTCH AND SHIFT TRANSMISSION. I WAS TOWING A TRAILER AT THE TIME OF FAILURE. WHEN I CONTACTED THE FORD DEALER TO SCHEDULE REPAIR HE SAID NOT TO DRIVE THE VEHICLE VERY FAR BECAUSE COMPLETE FAILURE WOULD PROBABLY OCCUR. I WAS ALSO TOLD THAT FORD IS VERY AWARE OF THIS DEFECT AND HAS REDESIGNED THIS PART DUE TO MANY FAILURES. EVEN THOUGH AN ACCIDENT DID NOT OCCUR, I THINK A SAFETY RECALL IS NEEDED SINCE THESE VEHICLES ARE DESIGNED TO HAUL OR CARRY HEAVY LOADS AND THIS TYPE OF FAILURE COULD MAKE IT DIFFICULT TO ENGAGE THE CLUTCH WHEN TRYING TO STOP THE VEHICLE, WHICH COULD RESULT IN A CATASTROPHIC ACCIDENT. THE COST FOR REPAIR WAS $305.26

NHTSA complaint #767035 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

CONSUMER STATES THAT HE IS HAVING TROUBLE WITH A PART THAT ATTACHES TO THE CLUTCH RELEASE PEDAL, WHEN IT COMES OFF IT IS IMPOSSIBLE TO RELEASE THE CLUTCH OR TO SHIFT GEARS, THE PART IS MADE OF A PLASTIC TYPE MATERIAL WITH TEETH TO KEEP IT IN PLACE, HOWEVER CONSUMER HAS REPLACED THIS PART SEVERAL TIMES. *SLC

NHTSA complaint #565552 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

CONSUMER WOULD PUSH CLUTCH IN, AND THEN HE COULD NOT PUT VEHICLE IN GEAR. AFTER TAKING VEHICLE TO MECHANIC , HE FOUND OUT THAT TRANSMISSION BEARING WAS GONE/ ALL BURNED.

NHTSA complaint #8014552 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY

AXEL ASSEMBLY APPEARS TO HAVE BEEN DEVOID OF LUBRICANT SINCE MANUFACTURING.

NHTSA complaint #763454 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHILE AT A STOP TRANSMISSION MADE A LOUD NOISE. VEHICLE MADE IT ACROSS THE INTERSECTION, THEN ,VEHICLE WOULD NOT ACCELERATE. DEALER NOT CONTACTED YET.

NHTSA complaint #8012798 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

CAM POSTION SENSOR TURNED VEHICLE OFF WITHOUT PRIOR WARNING. DEALERSHIP WAS AWARE OF PROBLEM.

NHTSA complaint #8012504 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

WHILE DRIVING 10 MPH CONSUMER WAS NOT ABLE TO SHIFT GEARS. VEHICLE WAS TOWED TO DEALER. DEALER DETERMINED THAT CLUTCH FORK HAD BROKEN.

NHTSA complaint #8010565 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHEN DRIVING AND UPON DEPRESSING BRAKE PEDAL TO MAKE A GRADUAL STOP, TRANSMISSION SUDDENLY LOCKED UP. TRANSMISSION HUNG UP IN GEAR AND FAILED TO DISENGAGE FROM ANY GEAR. CONSUMER HAD VEHICLE TOWED TO A DEALER. *AK *SLC

NHTSA complaint #8004634 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY

WHILE REPLACING FRONT ROTORS, CONSUMER NOTICED THAT FRONT AXLE WAS INCORRECT FOR THIS VEHICLE AS LISTED IN PARTS OF CATALOG. FORD HAS BEEN NOTIFIED.*AK

NHTSA complaint #8003699 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

WHILE DRIVING 65 MPH TRANSFER CASE DROPPED OUT, BROKE THE CASING. DEALER REPLACED PART.

NHTSA complaint #899099 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHILE DRIVING ABOUT 20 MPH VEHICLE STALLED, THEN NOTICED A TRAIL OF TRANSMISSION FLUID BEHIND VEHICLE, ADDED TRANSMISSION FLUID TO VEHICLE, AND WAS ABLE TO DRIVE HOME. COULD NOT FIND WHERE FLUID WAS LEAKING FROM, VEHICLE AT DEALER AT THIS TIME.*AK CONSUMER STATED TRAMSMISSION HAD TO BE REBUILT, MECHANIC FOUND PIECES FLOATING INSIDE, ALSO FILTER WAS FLOTING AROUND.*SLC

NHTSA complaint #897042 — an unverified report by a vehicle owner.

POWER TRAIN

AT 20,000 MILES ONGOING PROBLEM WITH LOSS OF POWER AFTER 1/2 HOURS OF RUNNING AND STALLING OUT WHEN APPLYING ACCELERATOR PEDAL FROM A STOP POSITION. VEHICLE BEEN IN DEALER SHOP ON FIVE OCCASIONS, AND PROBELEM STILL REOCCURRING. *AK DEALER HAS REPLACED THE FUEL PUMP, AIR FLOW SENSOR, MASS AIR FLOW SENSOR, AND THE O2 SENSORS, SOME OF THESE HAVE BEEN REPLACED MORE THAN ONCE AND VEHICLE CONTINUES TO LOSE POWER AND STALL. DOOR AJAR LIGHT ILLUMINATED, DEALER ORDERED LEFT DOOR JAM SWITCH. FUEL GAUGE READS FULL WHEN IT IS NOT, DEALER REPLACED FUEL SENDER. CONSUMER STATES PASSENGER FRONT RIM IS WARPED. SHIFTER HANDLE BEZEL KEEPS POPPING OFF, TRANSMISSION WOULD NOT GO INTO ALL GEARS, WHEN BACKING IN REVERSE, THER IS A SQUEALING NOISE. LEFT DOOR CYLINDER REPLACED. ABS LIGHT ILLUMINATED WHEN GOING IN REVERSE. AIR CONDITIONER DOES NOT GET COLD. *SLC

NHTSA complaint #891723 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE

WHILE COMIMG OFF A RAMP ONTO THE FREEWAY AT 30 MPH VEHICLE COMPLETELY SHUT DOWN, CAUSING LOSS OF POWER BRAKES AND STEERING CONTROL AFTER GAINING CONTROL OF VEHICLE, VEHICLE RESTARTED, BUT DRIVELINE WOULD NOT ENGAGE. PLEASE GIVE ANY FURTHER DETAILS.

NHTSA complaint #890321 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE

WHILE COMING OFF A RAMP ONTO FREEWAY AT 30 MPH VEHICLE COMPLETELY SHUT DOWN, CAUSING LOSS OF POWER BRAKES AND STEERING CONTROL. AFTER GAINING CONTROL OF THE VEHICLE , VEHICLE RESTARTED, BUT DRIVELINE WOULD NOT ENGAGE. CAUSE HAS NOT BEEN DETERMINED. NO COLLISION OR INJURIES OCCURRED. PLEASE GIVE ANY FURTHER DETAILS.

NHTSA complaint #890325 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

ENGINE WAS LEAKING OIL AT 8577 AND 9830 MILES ON VEHICLE. DEALERSHIP EXAMINED VEHICLE, AND DETERMINED THERE WERE TWO LEAKS. REAR MAIN SEAL AND ENGINE OIL PAN WERE LEAKING ON FIRST OCCURRENCE. DEALERSHIP PATCHED LEAK WITHOUT PULLING ENGINE. ON SECOND OCCURRENCE, DEALERSHIP HAD TO PULL ENGINE, AND FOUND THAT OIL PAN AND TRANSMISSION PAN WERE LEAKING OIL.

NHTSA complaint #887925 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE

THERE WAS VIBRATION IN VEHICLE WHEN TRAVELING BETWEEN 35 AND 50 MPH. DEALERSHIP EXAMINED VEHICLE AND DETERMINED THAT ENTIRE DRIVELINE NEEDED TO BE REPLACED BECAUSE COMPONENT WAS WARPED.

NHTSA complaint #887926 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

GEM MODULE REPLACED 6 TIMES, FIRST DAY CONSUMER TOOK DELIVERY OF VEHICLE. 4 WHEEL DRIVE FUNCTION CAME ON ON IT'S OWN, WOULD NOT DISENGAGE UNTIL VEHICLE CAME TO A COMPLETE STOP. WILL NOT COME ON WHEN CONSUMER NEEDS IT TO COME ON.

NHTSA complaint #887491 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY

NO SUMMARY LISTED FOR ABOVE VEHICLE.

NHTSA complaint #744474 — an unverified report by a vehicle owner.