2019 Ford F-350 SD suspension problems

SUSPENSION

The contact owns a 2019 Ford F-350. The contact stated that on three occasions while driving approximately 60 MPH, the front end of the vehicle started to wobble violently. The contact stated that when the brake pedal was depressed and the vehicle decelerated below 30 MPH, the wobbling ceased. The contact stated that there were no warning lights illuminated. The contact’s wife observed an unknown recall that might be associated with the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 37,000.

NHTSA complaint #11670258 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2019 Ford F-350. The contact stated that while driving on the highway at 75 MPH, the vehicle started shaking violently. There was no warning light illuminated. The contact pulled over to inspect the vehicle; however, the contact found no fault with the vehicle. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact was informed that the VIN was not under recall. The manufacturer was notified of the failure. The approximate failure mileage was 66,500.

NHTSA complaint #11667804 — an unverified report by a vehicle owner.

SUSPENSION

Front steering/suspension system Severe wobble causes driver to stop in middle of Freeway, possible accidents or death in an accident. Not confirmed by dealer at this time. Hundreds have reported here, and the same occured. Not at this time. No warnings prior to all of the failures. So far 12 failures Yes, 12 failures.

NHTSA complaint #11616074 — an unverified report by a vehicle owner.

SUSPENSION

DEATH WOBBLE, front suspension and steering Danger of a rear end collision at freeway speeds, or loss of control hitting other vehicles or items on the side of the road, result possible death to passengers, other vehicle people or bystanders. NO NO NONE I am a former Mechanic and this is LIFE THREATENING.

NHTSA complaint #11616075 — an unverified report by a vehicle owner.

SUSPENSION

My truck has only 13000 miles on it. We were going on vacation pulling our camper. I was doing about 63 MPH when we hit a bump in the interstate and the truck started VIOLENTLY shaking out of control. They cal it the death wobble. After doing some research it seams to be a very common problem that ford will not fully address. They put a bandage over a serious issue. They put me, my family and others in very serious danger. It took everything I had to keep us from going in the ditch. A vehicle with only 13000 miles on it should not experience something like this.

NHTSA complaint #11608950 — an unverified report by a vehicle owner.

SUSPENSION

In June 2024, I experienced serious sustained steering wheel oscillation to the point of having to stop the vehicle while traveling over 70 mph to regain control before proceeding on my way. I scheduled an appointment with my dealer (Woody Anderson Ford, Huntsville, AL) after July 4th weekend and was assigned an appointment date of August 9, 2024 at 10:00am. In May 2024, after traveling about 47 mph over a semi-diagonal railroad tracks on level pavement, the steering became violent but was recoverable after reducing speed to under 20 mph. This was the second instance. In March 2024, after transitioning across a section of highway in town at about +/- 45 mph, which the highway had appeared to have been poorly repaired my steering began to oscillate but I was able to recover with no concern. This was the first instance.

NHTSA complaint #11608501 — an unverified report by a vehicle owner.

SUSPENSION

While on a ramp to merge onto a highway, slightly downhill, a small ripple in the pavement joint caused the front wheels and steering wheel to shake violently and nearly lost control of the vehicle. Was traveling at approximately 40-50mph and could not steer the truck and the out of control shaking did not stop until I was able to slow to maybe 5-10mph. I was towing a trailer and if I had not been on a wide roadway late at night, going straight with little traffic around me, it's very likely I would have had a serious accident. The truck has 40,000 miles on it and tires etc are in good condition as this is a federal government owned and maintained vehicle. I see no recalls or service bulletins for the vin, but found hundreds of complaints online of the exact situation and referred to as out of control "death wobble". This is a serious issue and people will very likely be in serious and fatal accidents if not already.

NHTSA complaint #11587667 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2019 Ford F-350. The contact stated while driving approximately 70 MPH and positioned between two tractor-trailers, the vehicle suddenly experienced the "Death Wobble". The vehicle began to violently shake and vibrate, and the steering wheel became extremely difficult to control, causing the driver to fear for his safety while driving between the two tractor-trailers. The contact stated that the failure had occurred on several occasions after driving over a bump in the road. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 86,000.

NHTSA complaint #11581962 — an unverified report by a vehicle owner.

SUSPENSION

I own a 2019 Ford F-350 SD. While driving 60 MPH and driving over a pothole, the vehicle started to shake uncontrollably and pulling the vehicle to the left. Luckily I was in the left lane and only went onto the berm, If I had been in the right lane I would have hit the vehicle beside me. I pulled over on the side of the road and once I got below 25 miles and hour the vehicle stopped shaking. The vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was 28,400. When is Ford going to be forced to fix this known problem, when someone is killed?

NHTSA complaint #11578413 — an unverified report by a vehicle owner.

SUSPENSION

Death Wabble Twice all 6 wheels shook as though falling off. Semi truck behind hit airhorn and locked up brakes to avoid hitting me at 75mph..i had to immediately slow to 20mph to stop castrophe

NHTSA complaint #11572155 — an unverified report by a vehicle owner.

SUSPENSION

Severe uncontrollable shaking of the front wheels. I had to slow down to about 10 miles an hour on the freeway, people has to swerve to avoid me. It has happened 4 times in the last 3,000 miles. The date below is the most recent time it happened. I'll be taking it to the Ford Dealership.

NHTSA complaint #11571379 — an unverified report by a vehicle owner.

SUSPENSION

EXCESSIVE SHAKE AND UNCONTROLABLE STEERING WHEN RIDING ON ROUGH SURFACE OR BUMPS IN THE ROAD. EFFECT WILL NOT DISSAPATE UNTIL VEHICLE IS BROUGHT TO A STOP. THIS HAS HAPPENED SEVERAL TIMES RECENTLY.

NHTSA complaint #11544445 — an unverified report by a vehicle owner.

SUSPENSION

Experiencing what’s known as the “death wobble.”

NHTSA complaint #11541984 — an unverified report by a vehicle owner.

SUSPENSION

Sustained steering oscillation on two (2) occasions. July 16th and Aug 4th. Had to slow down both times for it to stop.

NHTSA complaint #11537037 — an unverified report by a vehicle owner.

SUSPENSION

We are trying to make it out of the mountains of Colorado and back home to Missouri. We have the most horrific shaking on our truck. I am scared to death. This "death wobble" is TERRIBLE! I want someone to know now in case we die! We have a horse trailer loaded down with 4 horses and 2 dogs. There should be a recall for this!!!! Signed [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #11530830 — an unverified report by a vehicle owner.

SUSPENSION

When driving over 50 mph, or while driving on a bumpy surface, the entire truck aggressively shakes until you either slow extremely down or stop. This has occurred appropriately 8-10 times.

NHTSA complaint #11525064 — an unverified report by a vehicle owner.

SUSPENSION

Driving down i70 in Colorado and hit a section where there is concrete. One of the cracks in the concrete caused the steering wheel to vibrate uncontrollably until the speed dropped below 50 mph. During the incident braking made the vibration worse and it felt as though the front of the truck was bouncing at a rapid rate. Steering in any direction was nearly impossible. I have a service scheduled to look at this in a few weeks but until then I fear driving as it was a complete loss of control. This happened a few more times on the journey home and seems to be tied to bumps in the road when traveling over 55 mph. This incident happened without warning and did not cause any warning lights to appear. This truck has less than 15k miles on it so I was surprised it would behave this way.

NHTSA complaint #11521262 — an unverified report by a vehicle owner.

SUSPENSION

While driving at any speed above 30mph the front end wobbles violently whenever the truck hits potholes or big bumps in the road!

NHTSA complaint #11520162 — an unverified report by a vehicle owner.

SUSPENSION

Was driving in middle lane eastbound I-84 with cruise control set at 65 mph. Upon a lane bump from paving construction, the truck began a violent shaking, which is consistent with a problem know as "death wobble". slowed down immediately and stopped at side of interstate. Inspected tires, and there was no flat tire. No outward signs of tire damage . Drove at 20-25 mph to next exit. Was able to drive home about 20 miles at slow speed.

NHTSA complaint #11519704 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2019 Ford F-350 SD. The contact stated while driving 65 MPH and driving over a pothole, the vehicle started to shake uncontrollably. The contact pulled over on the side of the road and the vehicle stopped shaking. The vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was 21,000. The VIN was not available.

NHTSA complaint #11519240 — an unverified report by a vehicle owner.

SUSPENSION

I’ve experienced 3 nearly identical incidents: after driving over bumps in the road or uneven pavement, my F350 went into an uncontrolled wobble, violently shaking, causing total loss of steering control. In each case, the uncontrolled wobble only stopped after I slowed the vehicle to under 15 mph. Because these incidents occurred on major freeways with fast moving traffic, a significant danger was posed to me and my passengers and other drivers. After searching online resources, I read several similar instances of this happening to other F350/250 owners, aka “the death wobble.”

NHTSA complaint #11518452 — an unverified report by a vehicle owner.

SUSPENSION

08 Apr 2023 vehicle hit a pot hole and we almost went into ditch when it began to wobble uncontrollably. We were traveling on the hwy and almost caused an accident to the vehicles behind us. Very frightening. 16 Apr 2023, hit a small pot hole vehicle began to wobble uncontrollably, took us again almost into the ditch. It occurred four more times trying to get home from airport. We scared traveling in this vehicle now because of these incidents. We are filing an official complaint on Ford.

NHTSA complaint #11517330 — an unverified report by a vehicle owner.

SUSPENSION

Experienced the Ford Death Wobble approximately July 1, 2022. After going over a small pothole at 65 mph, vehicle experienced severe wobble and pulled from far right lane to shoulder and veered toward cement wall at 65mph! Braking caused increase in wobble. Was finally able to slow vehicle to exit highway. No prior issues with wobble nor any warning. Shaking and nearly crying, I slowly drove to Big O shop who confirmed wobble and recommended Dealer address problem. Slowly drove to Ford dealer which took two days to confirm issue and inform me that parts were backordered and would call when available. (As of 3/23/23 no call.) Ford told me to not drive over 45mph, essentially making my truck useless. Slowly drove back to Big O and had them repair at my cost ~$1600, Ford reimbursed ~$250. On 3/21/23, driving 65mph over small bump in road, experienced Death Wobble again and pulled to side of highway. Slowly drove to Big O and had additional parts installed ~$330. Scared to drive my truck over 45mph!

NHTSA complaint #11513385 — an unverified report by a vehicle owner.

SUSPENSION

I was accelerating to get on the freeway and there was a slight bump or crease in the pavement and my front end started to bounce and warble uncontrollably, fortunately I was able to pull off of the on-ramp and come to a stop with out incident. This was not the first time I noticed this, but it was definitely the worst.

NHTSA complaint #11508324 — an unverified report by a vehicle owner.

SUSPENSION

Death Wobble, the steering wheel shook violently. I could not control the vehicle and had to stop in the middle of the road to make it quit. This has happened before. It was serviced for this problem once.

NHTSA complaint #11508187 — an unverified report by a vehicle owner.

SUSPENSION

experiencing intermittent violent wobble of front suspension/steering. 2 significant events since October 2022. Traveling at highway speed and incurring rough road steering wheel wobbles severally. Only way to stop it is to slow down below approximately 50 mph, however latest event (02/14/23), had to go below 20 mph to get it to stop. very dangerous on the highway. Tractor trailer had to change lanes very quickly to avoid hitting me. Ford dealership is aware of the issue, however they only offer a new steering dampener that has not been available for almost 4 months. Had an independent service center look at the suspension. They found that the dampener is faulty and another suspension joint is showing premature wear.

NHTSA complaint #11507205 — an unverified report by a vehicle owner.

SUSPENSION

3 different occasions where my trucks front wheels and steering wheel shakes uncontrollably after hitting a pothole or bridge transition. Twice pulling a fifth wheel camper and once by itself. Very scary. Twice I had to come to a near stop before I could continue. Death wobble they call it. Took to Ford dealership who said the fix is a steering damper which is on national back order with no release date. It has happened once again since then for a total of 4 times. Never know when it will happen. Just depends on the bridge transition or pothole. Ford needs to correct this steering problem

NHTSA complaint #11506563 — an unverified report by a vehicle owner.

SUSPENSION

When I hit a bump with this truck the steering shakes violently. I brought to ford and they said it is a steering dampner and it is a recalled part and they would fix it as a recall however they said they dont have the part and they dont know when the part will be available. I am now left with an undriveable truck and no one can tell me when it can be fixed.

NHTSA complaint #11503545 — an unverified report by a vehicle owner.