2005 Ford Focus window and wiper problems

VISIBILITY:SUN/MOON ROOF ASSEMBLY

TL* THE CONTACT OWNS A 2005 FORD FOCUS. WHILE DRIVING APPROXIMATELY 40 MPH, THE SUN ROOF SUDDENLY SHATTERED AND SEPARATED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 12V31600 (VISIBILITY). THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

NHTSA complaint #10779669 — an unverified report by a vehicle owner.

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

THE HVAC CONTROLS ARE FROZEN IN THE AIR CONDITION AND COLD AIR POSITION. IF IT STARTS RAINING THE WINDOWS AND WINDSHIELD FOG UP MAKING IT IMPOSSIBLE TO SEE.

NHTSA complaint #10626828 — an unverified report by a vehicle owner.

VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

TL* THE CONTACT OWNS A 2005 FOR FOCUS ZXW STATION WAGON. THE CONTACT STATED THAT WHEN THE KEY WAS IN THE IGNITION AND THE SHIFT OVER RIDE BUTTON WAS DEPRESSED, THE KEY WOULD BECOME LOCKED IN THE IGNITION. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE CONTACT GLUED THE SHIFT OVER RIDE BUTTON IN PLACE AND CHANGED THE IGNITION, WHICH RESOLVED THE FAILURE. THE CONTACT ALSO STATED THE METAL FRAME OF THE DRIVER'S SEAT BECAME CRACKED. THE CONTACT HAD TO PROP THE SEAT UP SO THAT HE COULD DRIVE THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 205,000. UPDATED 02/20/13*LJ THE CONSUMER STATED THE TRANSMISSION WAS POORLY DESIGNED. UPDATED 02/21/13 THE CONSUMER STATED THE EXPERIENCED NUMEROUS PROBLEMS WITH THE TRANSMISSION, AFTER HAVING THE FLUID FLUSHED. THE CONSUMER STATED THE SIDE VIEW MIRRORS WERE RIGID AND WERE EASY TO BREAK, THE REAR SUSPENSION SPRINGS WERE NOT DESIGNED TO CARRY WEIGHT, WHICH CAUSED THE VEHICLE TO BOUNCE ON THE HIGHWAY AND SECONDARY ROAD BUMPS. THE HEAT SHIELDS ATTACHED TO THE EXHAUST SYSTEM WERE DESIGNED POORLY, TO THE POINT THEY WERE BENT AND CAUSED A RATTLE. THE STEEL RIMS, BENT EASILY, WHICH CREATED A VIBRATION AND BALANCE PROBLEM. THE HEADLIGHTS LENSES WERE DISCOLORED, THE VALVE COVER GASKET LEAKED OIL ONTO THE SPARK PLUGS, THE HOOD CABLES WERE DEFECTIVE. THE HOOD CABLE FROZE AND BROKE. UPDATED 07/25/13

NHTSA complaint #10487466 — an unverified report by a vehicle owner.

VISIBILITY:REAR WINDOW WIPER/WASHER

THE DECKLID WIRE HARNESS HAS FATIGUED BREAKING 2 INTERNAL WIRES IN THE BEND AREA. AS A CONSEQUENCE, REAR WINDSHIELD WIPER AND DECKLID LATCH REMOTE RELEASE FUNCTION ARE LOST. BECAUSE IT IS IN THE SAME HARNESS, LOOSING STOP LAMP, DEFROST OR VEHICLE REGISTRATION LAMP FUNCTIONS IT JUST A MATTER OF TIME. THIS FAILURE MODE HAS ALREADY BEEN DESCRIBED ONLY THAT WITH A DIFFERENT EFFECT (LOSS OF STOP LAMP). PLEASE REFER TO YOUR CAMPAIGN ID: 00V411000.

NHTSA complaint #10323352 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

2005 FORD FOCUS WITH AIR BAG LIGHT ON, AND OTHER PROBLEMS. CUSTOMER STATES THAT ALONG WITH THE AIRBAG LIGHT ON THE PASSENGER SIDE WINDOW WILL NOT CLOSE AND THE KEY WOULD NOT COME OUT OF THE IGNITION.

NHTSA complaint #10208307 — an unverified report by a vehicle owner.

VISIBILITY:WINDSHIELD

DT*: THE CONTACT STATED THE MOLDING ON THE TOP OF THE WINDSHIELD WAS COMING LOOSE. THE CONTACT ATTEMPTED TO PRESS THE MOLDING BACK INTO PLACE. WATER LEAKED INTO THE VEHICLE FROM THE TOP OF THE WINDSHIELD WHEN IT RAINED. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER FOR REPAIR.

NHTSA complaint #10164177 — an unverified report by a vehicle owner.

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

DT: THE CONTACT STATED WHEN USING THE HEATER DUST BLEW IN HIS EYES. THE VEHICLE WAS TAKING BACK TO THE DEALER FOR INSPECTION. THE DEALER TOLD HIM THE PARTICLES WERE ACTUALLY FLUX FROM THE HEATER CORE. WHEN THE HEATER CORE GOT HOT THE FLUX BROKE UP AND SEPARATED FROM THE CORE. THE DEALER FLUSHED THE HEATER CORE. THIS STOPPED THE PARTICLES FROM ESCAPING FOR SEVERAL WEEKS. THE PROBLEM RECURRED. THE CONTACT'S EYES WERE BURNING AND STINGING WHEN THE FLUX BLEW IN HIS EYES. HE MUST TURN THE VENTS AWAY FROM HIS FACE TO AVOID ANY CONTACT WITH THE PARTICLES. THE VEHICLE IS SCHEDULED FOR ANOTHER HEATER CORE FLUSH NEXT WEEK. NO OTHER REPAIRS HAVE BEEN MADE AT THIS TIME.

NHTSA complaint #10145976 — an unverified report by a vehicle owner.

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

THE STORAGE TRAYS BECAME EXTREMELY HOT WHEN DRIVING FOR AN EXTENDED PERIOD OF TIME WITH THE HEATER ON, ESPECIALLY WHEN DIRECTED TO THE FLOOR ONLY. *NM IN THE OWNER'S GUIDE BOOK THERE WAS AN ERROR THAT STATED; AM/FM STEREO WITH SINGLE CD/MP3 PREMIUM SHOULD BE FOR A 6 CD UNIT AS NOTED BY THE CD 6 ABOVE THE CD SLOT. *SC

NHTSA complaint #10111082 — an unverified report by a vehicle owner.

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

SAFETY ISSUE WITH POTENTIAL TO CAUSE INJURY. WHEN THE HEATER IS ON, IT GET EXTREMELY HOT. *BF WHEN THE HEATER WAS DIRECTED TO THE FLOOR ONLY, THE BACK OF THE STORAGE TRAY BENEATH THE CONTROLS FOR THE HEATING AND AIR CONDITION SYSTEMS BECAME HOT.

NHTSA complaint #10109759 — an unverified report by a vehicle owner.