51 of the
196 complaints filed about the Ford Redundant C-Max Hybrid
are about the electrical system —
26% of everything owners reported.
The worst model year for it is 2013.
The contact owns a 2013 Ford C-Max Hybrid. The contact stated that on several occasions, while the vehicle was parked, it failed to start. The vehicle was jump-started on several occasions but needed to be towed occasionally. The vehicle was taken to an independent mechanic, where it was diagnosed with battery failure. The contact was informed that the battery needed to be replaced. The battery was replaced; however, the failure reoccurred. The vehicle was then taken to the dealer, but was not diagnosed. The dealer suggested that a waiver be signed for the battery replacement. The vehicle was repaired. The contact stated that the vehicle had experienced electrical failures. The instrument panel intermittently malfunctioned, and the turn signals failed to operate properly. The manufacturer was made aware of the failure. The approximate failure mileage was 36,463.
NHTSA complaint #11719818 — an unverified report by a vehicle owner.
The contact owns a 2013 Ford C-Max Hybrid. The contact stated while driving approximately 15-20 MPH, the steering wheel was wobbly. The contact exited the highway immediately and was able to pull over to the side of the roadway. The contact then pulled into a parking lot and the vehicle was towed to the dealer, where it was diagnosed that the rear subframe was rusted, causing the control arms to separate. The dealer determined that the rear subframe and connecting parts needed to be replaced. Additionally, the dealer informed the contact that a high voltage wire was chewed on by rodents. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.
NHTSA complaint #11677787 — an unverified report by a vehicle owner.
The contact owns a 2013 Ford C-Max Hybrid. The contact stated while driving on three occasions at approximately 30-55 MPH, several unknown warning lights were flashing. The message to shift to park(P) was flashing. The vehicle was shifted to park, and the vehicle stalled and failed to restart. The contact's husband assisted with restarting the vehicle. The contact determined that the battery was working as designed. The vehicle was taken to the local dealer for five weeks, where it was diagnosed that the battery junction box had corrosion and defective fuses. Additionally, there was a failing control unit. The dealer informed the contact a Ford engineer was advising with the repairs. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 70,000.
NHTSA complaint #11629946 — an unverified report by a vehicle owner.
The contact owns a 2013 Ford C-Max Hybrid. The contact stated that upon exiting the vehicle, the driver’s side doors failed to latch closed. The contact also stated that while driving at an undisclosed speed and attempting to get another driver’s attention, he became aware that the horn was not functioning as needed. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Action Number: RQ19005 (Latches/Locks/Linkages, Structure); but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 80,000. The VIN was not available.
NHTSA complaint #11618860 — an unverified report by a vehicle owner.
The contact owns a 2013 Ford C-Max Hybrid. The contact stated that the small battery in the vehicle had malfunctioned on several occasions and the vehicle could not be started. The contact indicated that the battery had been replaced by the dealer on at least 5 separate occasions. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The VIN was not available. The failure mileage was 25,000.
NHTSA complaint #11442779 — an unverified report by a vehicle owner.
The contact owns a 2013 Ford C-MAX Hybrid. The contact stated that on several occasions, the vehicle failed to start up or unlock due to a defective battery. The contact had the vehicle towed to the dealer several times to have her battery replaced or her software updated; however, the failure persisted. The manufacturer was also notified of the failure but offered no assistance. The vehicle had been repaired as of her last visit. The failure mileage was approximately 48,000.
NHTSA complaint #11435541 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2013 FORD C-MAX HYBRID. THE CONTACT STATED THAT THE RADIO OPERATIONAL AFTER THE VEHICLE WAS TURNED OFF CAUSING THE BATTERY TO DRAIN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO RECALIBRATED THE RADIO FUSE HOWEVER, A YEAR LATER THE FAILURE RECURRED. THE MECHANIC THEN REMOVED THE RADIO FUSE FROM THE VEHICLE WHICH DISABLED ALL AUDIBLE SOUNDS FROM THE VEHICLE. THE CONTACT STATED THAT IT WAS A MAJOR SAFETY HAZARD FOR HER AS IT TOOK AWAY THE BACKUP ALERT SOUNDS THAT WOULD ALERT HER OF IMMINENT OBJECTS WHEN REVERSING THE VEHICLE. THE CONTACT THEN CALLED HANSEL FORD (3075 CORBY AVE, SANTA ROSA, CA 95407) AND WAS PROVIDED AN ESTIMATE FOR THE REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THERE WERE NO RECALLS ON THE VIN. THE CONTACT WAS THEN REFERRED TO NHTSA FOR ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11389773 — an unverified report by a vehicle owner.
MY CAR HAS BEEN COMPLETELY ELECTRICALLY DEAD APPROXIMATELY 4 TIMES. WHEN IT IS FIXED IT EVENTUALLY HAPPENS AGAIN. I HAVE TO USE THE KEY IN THE KEY FOB TO OPEN THE CAR AND WHEN I PUSH THE START BUTTON IT DOESN'T START. THE BATTERIES IN THE KEY FOB ARE NOT DEAD. IT IS VERY WORRISOME TO NOT KNOW IF MY CAR WILL START. THIS HAPPENS IN A PARKED AND TURNED OFF SITUATION.
NHTSA complaint #11234034 — an unverified report by a vehicle owner.
I BOUGHT THIS USED SUV ON MAY 14, 2019 WITH 87,420 MILES. IN THREE OCCASIONS THE DISPLAY ON THE DASHBOARD HAS SHOWN, WITH NO AUDIBLE SOUND, THE MESSAGE TO STOP THE VEHICLE. THE VEHICLE WILL THEN SHUT DOWN. ALL TIMES HAPPENED WHILE I WAS DRIVING ON THE HIGHWAY. I NOTICED THAT THE AIR CONDITION SHUT ITSELF OFF, THEN I SAW THE DISPLAY MESSAGE. IF I WOULD NOT HAVE SEEN THE DISPLAY MESSAGE, THE CAR WOULD HAVE STOPPED WITHIN 400 FEET. THIS IS EXTREMELY DANGEROUS SITUATION AS I WOULD NOT HAVE TIME TO CHANGE TO THE EMERGENCY LANE, LEAVING A STOPPED CAR ON THE FAST LANE. I NOW KEEP LOOKING GLANCING AT THE DASHBOARD WORRIED THAT THE DISPLAY WILL APPEAR AGAIN. I HAVE TAKEN THE CAR TO THE DEALER TWO TIMES. THE FIRST TIME THEY TOLD ME THAT A SCANNER SHOWED NO PROBLEMS. NOW THE CAR IS AT THE DEALER FOR A SECOND TIME WHERE THEY ARE DOING MORE TESTING. I JUST DO NOT HAVE ANY MORE CONFIDENCE ON THIS CAR. THE DASHBOARD HAS ALSO SHOWN A DISPLAY "SEE MANUAL".
NHTSA complaint #11210304 — an unverified report by a vehicle owner.
I PURCHASED MY CAR USED FROM A DEALERSHIP IN APRIL OF 2016. I LEASED THE SAME MODEL PREVIOUSLY WITH NO PROBLEMS. I WENT OUT OF TOWN FOR AN EXTENDED TIME AND CAME BACK TO FIND THE BATTERY DEAD. I WAS SURPRISED, AS I OFTEN TRAVEL AND HAD NO PROBLEMS LIKE THIS WITH THE OTHER C-MAX. I CALLED A SERVICE, THEY GOT IT STARTED (WITH SOME DIFFICULTY) I DROVE IT FOR ABOUT 45 MINUTES AND IT SEEMED FINE. SEVERAL MONTHS PASSED AND I WENT AWAY, CAME BACK AND CAR WAS DEAD. AAA STARTED IT. I DROVE IT FOR SOME MILES, THEN STOPPED IT . IT WOULDN'T START. I HAD IT TOWED TO THE DEALERSHIP. IT WAS SUNDAY, SO THEY WERE CLOSED. THEY WENT OUT THE NEXT MORNING AND IT STARTED. THEY WENT THROUGH MY CAR AND COULD NOT FIND ANY PROBLEMS. IT DROVE FINE FOR SEVERAL MONTHS, AND I WENT OUT OF TOWN AGAIN FOR EXTENDED TIME. CAME BACK-CAR WOULDN'T START. THIS TIME I HAD PURCHASED A BATTERY CHARGER, IN CASE THIS HAPPENED AGAIN, BUT IT WAS NOT POWERFUL ENOUGH TO GET THE CAR GOING. CALLED AAA AND THEY STARTED THE CAR. I DROVE THE CAR FOR ABOUT 1 HOUR, ON THE FREEWAY, CAME HOME AND EVERYTHING SEEMED FINE. DEALERSHIP TOLD ME THAT "SOMETHING MUST BE DRAINING THE BATTERY" BUT COULD NOT FIND A PROBLEM. TODAY, 2 WEEKS LATER, MY CAR IS ONCE AGAIN NOT STARTING. I NOTICED YESTERDAY EVENING, THAT EVERYTIME I GOT IN THE CAR, IT WOULD NOT START. A MESSAGE WOULD COME ON SAYING IT WAS SHUTTING DOWN TO SAVE THE BATTERY. A BLUE LINE WOULD APPEAR AND WHEN IT HAD "LOADED" ALL THE WAY, I COULD START MY CAR. TODAY IT IS TOTALLY DEAD, AND WOULDN'T START EVEN WITH A "JUMP". SO I AM STUCK UNTIL MONDAY. EVEN IF I GET IT STARTED, I DON'T TRUST THAT IT WON'T START THE NEXT TIME I TURN IT OFF.
NHTSA complaint #11187255 — an unverified report by a vehicle owner.
THE AUDIO SYSTEM OF THE VEHICLE STOPPED WORKING - WILL NOT TURN ON, LINK TO PHONE, ETC. PERFORMED A HARD RESET OF THE AUDIO SYSTEM AND THE SYSTEM WORKED. NEXT DAY 12V BATTERY WAS DEAD. JUMPED STARTED THE CAR AND TOOK TO THE SHOP WHERE THE BATTERY WAS REPLACED (ORIGINAL BATTERY). SYSTEM WAS TESTED AND BATTERY WAS REPORTED AS FINE. SINCE IT WAS THE ORIGINAL BATTERY I HAD THEM GO AHEAD AND REPLACE IT AND NO OTHER ISSUES WERE IDENTIFIED. CAR SAT IN GARAGE OVERNIGHT WITH EVERYTHING OFF. NEXT DAY CAR IS DEAD AGAIN.
NHTSA complaint #11163913 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2013 FORD C-MAX HYBRID. WHILE THE VEHICLE WAS STATIONARY, THE BATTERY SAVER WARNING INDICATOR TURNED OFF AND THE FOLLOWING MESSAGE DISPLAYED ACROSS THE INSTRUMENT PANEL: "911 ASSIST IS DISABLED, CONTACT DEALER". IMMEDIATELY AFTERWARDS, THE SHIFTER INDICATOR DISPLAYED ON THE INSTRUMENT PANEL. THE CONTACT TURNED THE KEY IN THE IGNITION, BUT THE MOTOR DID NOT INDICATE THAT IT WAS READY TO DRIVE UNTIL APPROXIMATELY ONE MINUTE LATER. THE CONTACT PLACED THE SHIFTER INTO REVERSE AND ATTEMPTED TO REVERSE, BUT A SUDDEN LOSS OF POWER STEERING OCCURRED. THE CONTACT PLACED THE VEHICLE IN THE DRIVE GEAR AND DEPRESSED THE ACCELERATOR PEDAL IN AN ATTEMPT TO STOP THE VEHICLE; HOWEVER, THE VEHICLE ACCELERATED BEYOND 35 MPH. THE CONTACT ATTEMPTED TO STOP THE VEHICLE BY DEPRESSING THE BRAKE PEDAL, BUT THE VEHICLE WOULD NOT STOP. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO BOB MOORE FORD (8948 S I-35 SERVICE RD, OKLAHOMA CITY, OKLAHOMA 73159) WHERE IT WAS DIAGNOSED THAT THE INNER CELL OF THE BATTERY WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 73,000.
NHTSA complaint #11121726 — an unverified report by a vehicle owner.
CAR ELECTRONICS WILL NOT SHUT OFF. RADIO REMAINS ON CONTINUOUSLY, EVEN WITH KEYS REMOVED AND DOORS LOCKED. NO CHIMES TO INDICATE IF CAR IS ON/OFF. AT OTHER TIMES, CAR NAVIGATION AND ELECTRONIC SYSTEMS WILL FAIL. FAILURES AND NON-RESPONSE CAN HAPPEN WHILE IN MOTION. RADIO NOT TURNING OFF AFTER ENGINE OFF AND PARKED.
NHTSA complaint #11111467 — an unverified report by a vehicle owner.
UPON STARTING MY CAR, I WAS AWARE THAT THERE WAS NO SOUNDS--NO AUDIO, INCLUDING WARNING BEEPS, GPS VOICE, RADIO, ETC. I WENT TO FORD SERVICE AND WAS TOLD IT WOULD REQUIRE TESTING NUMEROUS MODULES. IT WAS COSTLY, SO I OPTED NOT TO HAVE IT CHECKED. THE CAR WAS UNUSED AND IN MY GARAGE FOR TWO DAYS. ON THE THIRD DAY WHEN I GOT IN THE CAR, IT WAS COMPLETELY DEAD. A TOWING SERVICE CAME, JUMP STARTED MY CAR, AND I DROVE IT TO FORD. I HAD TO LEAVE IT OVERNIGHT. THE NEXT AFTERNOON, THE FORD SERVICE MANAGER TOLD ME IT STARTED UP WITH NO PROBLEM THE FOLLOWING MORNING. SERVICE TESTED EVERYTHING. THERE WERE NO FAULTY CODES, NO RECORD OF A PROBLEM. I WAS GIVEN A DISCOUNT OFF THE FULL PRICE, ALTHOUGH NOTHING WAS RESOLVED. ON CARCOMPLAINTS.COM I FOUND THAT MANY OTHER OWNERS OF THE FORD C-MAX HYBRID HAVE HAD THE SAME PROBLEM. FORD HAS NO ANSWERS.
NHTSA complaint #11111293 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2013 FORD C-MAX HYBRID. THE CONTACT STATED THAT THE 12-VOLT BATTERY DID NOT STAY CHARGED. THE BATTERY DIED OVERNIGHT AND WAS JUMPSTARTED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TOWED TO THE DEALER (KOERNER FORD OF SYRACUSE, SYRACUSE, NY, 315-474-4275) WHERE THE BATTERY WAS RECHARGED AND RESTARTED THE VEHICLE. A DIAGNOSTIC TEST WAS PERFORMED, BUT THE TECHNICIAN WAS UNABLE TO PINPOINT THE SOURCE OF THE FAILURE. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE WAS NOT REPAIRED. THE CONTACT COMPLAINED TO THE STATE ATTORNEY GENERAL AND WAS REFERRED TO NHTSA. THE FAILURE MILEAGE WAS 30,000.
NHTSA complaint #11047706 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2013 FORD C-MAX HYBRID. THE CONTACT STATED THAT THE 12-VOLT BATTERY DID NOT STAY CHARGED. THE BATTERY DIED OVERNIGHT AND WAS JUMPSTARTED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TOWED TO THE DEALER (KOERNER FORD OF SYRACUSE, SYRACUSE, NY, 315-474-4275) WHERE THE BATTERY WAS RECHARGED AND RESTARTED THE VEHICLE. A DIAGNOSTIC TEST WAS PERFORMED, BUT THE TECHNICIAN WAS UNABLE TO PINPOINT THE SOURCE OF THE FAILURE. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE WAS NOT REPAIRED. THE CONTACT COMPLAINED TO THE STATE ATTORNEY GENERAL AND WAS REFERRED TO NHTSA. THE FAILURE MILEAGE WAS 30,000.
NHTSA complaint #11047706 — an unverified report by a vehicle owner.
THIRD TIME, ELECTRICAL COMPONENTS WERE ACTING WONKY (RADIO, NO CONTROLS WORKED, NO SHUT OFF, NOT TURNING OFF WHEN DOOR OPENED, AFTER CAR TURNED OFF, PHONE PART OF SYNC DIDN'T WORK), THEN, NOT SURE WHEN, BUT, AFTER PARKING IN DRIVEWAY, AND NOT DRIVING FOR A DAY OR TWO, CAR WAS DEAD, NO RESPONSE TO FOB, WOULDN'T START. EACH TIME, DEALERSHIP HAS TOLD ME THEY'VE FIXED IT, BUT, IT HAPPENS AGAIN. VERY IRRITATING, TO NEVER KNOW FOR SURE, IF I'LL HAVE A WORKING VEHICLE. I HAVE ALSO EXPERIENCED HAVING THE WINDOWS ROLL DOWN, ALL AT ONCE, CAR WAS OFF, I'D PRESSED FOB TO LOCK DOORS. THERE ARE MANY COMPLAINTS ABOUT THESE PROBLEMS! FORD NEEDS TO FIGURE OUT WHAT IS WRONG! I AM DISABLED, NO ONE TO HELP. A DEAD CAR IS A VERY HARD THING FOR ME TO DEAL WITH.
NHTSA complaint #11046643 — an unverified report by a vehicle owner.
THE DEALER LOCATED IN MENA REGION JORDAN, NOT WORKING OR COOPERATE AS WELL. MOST RECALLS HE SAID NO NEED TO DO IT AND CLAIM THAT NO PARTS AVAILABLE AND ITS NEED MORE THAN 45 DAYS TO BE AVAILABLE AND AFTER 45 DAYS HE SAID STILL NOTHING COME BACK AFTER A MONTH ETC... AND WE ARE ALL CUSTOMERS FACING PROBLEM IN CONTACTING THEN AND THE WAYS THEY ARE TREAT US IN IT IS NOT PROFESSIONAL. NOT FEEL (NOT ONLY ME) THAT THE HAVE PROFESSIONAL TEAM, I WANT TO DO ALL RECALLS BUT AFFAIR IF THEY DID MOST PROBABLY THEY WILL MAKE NEW ISSUE AND START PAID FOR SOMETHING WRONG THEY MADE :(
NHTSA complaint #10928694 — an unverified report by a vehicle owner.
AFTER DRIVING FOR ABOUT 30 MILES AT NIGHT, I GET A BURNING SMELL IN THE INTERIOR OF THE CAR. I HAVE HAD PEOPLE STOP ME TO TELL ME THAT MY REAR TAIL LIGHTS ARE OUT. THIS HAS HAPPENED ONLY TWICE BUT I RARELY DRIVE AT NIGHT. I WAS ON THE FREEWAY THE LAST TIME AND SOME PEOPLE FOLLOWED ME TO TELL ME THAT THEY COULD BARELY SEE ME. I HAVE A BLACK CAR AND LICENSE PLATE. THE CAR IS OUR OF WARRANTY AND I DON'T KNOW IF MY EXTENDED WARRANT WILL COVE IT. I AM TERRIFIED TO DRIVE IT AT NIGHT NOW.
NHTSA complaint #10919130 — an unverified report by a vehicle owner.