2023 Ford Transit electrical problems

ELECTRICAL SYSTEM

The rearview/360-degree camera system on my 2023 Ford Transit 350 continues to fail, resulting in the rearview camera image and/or other camera views becoming unavailable. The vehicle is available for inspection upon request. This is a large passenger van with significant blind areas, and the loss of the rearview camera creates a serious safety concern when backing, parking, or maneuvering around pedestrians, children, vehicles, or other objects. When the system fails, I can place the vehicle in reverse and not have the rear camera image that I depend on to see the area immediately behind the vehicle. This is NOT the first occurrence. The vehicle has been taken to an authorized Ford dealer on three separate occasions related to the camera system. Multiple cameras have been replaced. The vehicle has also been subject to Ford safety recall repairs involving the rearview/360-degree camera system. Most importantly, the applicable recall repair was recently completed by an authorized Ford dealer, and the camera system is STILL failing after completion of the recall remedy. The same safety condition that resulted in the recall continues to occur. Ford and its authorized dealer have therefore had multiple opportunities to inspect and repair this vehicle, including replacement of camera components and completion of the safety recall, but the defect has not been permanently corrected. The failure can occur without adequate warning and results in the rearview/360-degree camera image becoming unavailable or otherwise malfunctioning. The problem has occurred repeatedly rather than as an isolated incident. I am filing this complaint because I am concerned that the recall remedy has not successfully corrected the safety defect on this vehicle. I am requesting that NHTSA document and investigate the continued failure of the rearview/360-degree camera system after Ford's recall remedy was performed, including whether the current recall remedy is adequate for affected Ford Tra

NHTSA complaint #11757625 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

This is a Ford Palladium Van, year 2024, the secondary alternator charging circuit that Thor has installed has a lot of problems. Specifically, the alternator from Balmar fails and you cannot charge lithium batteries while the van is in motion. The whole point of the secondary alternator is to charge these batteries while in motion. Its a safety issue when traveling with children or pets because battery voltage drops if you have to run AC while in a store or something. You proceed down the road and the battery is not recharged. Next stop you may not be able to run AC at all.

NHTSA complaint #11746224 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:ADAS:HILL DESCENT ASSIST:SENSOR

The contact owns a 2023 Ford Transit. The contact stated that while in drive, the transmission slammed into fourth gear. The hill assist feature was activated during the failure. The contact believed that the failure was caused by an inoperable back over prevention camera. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and offered a buyback, but no assistance was provided. The failure mileage was approximately 23,459.

NHTSA complaint #11729343 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

My cargo van has no rearward windows. It has front/rear/left/right exterior cameras which generate a simulated, 360-degree, overhead view on a monitor. The right camera functions about half of the time. Once it generated an all-orange view. Now it often generates an all-blue view. I know other Ford vehicles are subject to a recall for this software issue and Ford has (or is generating) a fix for the problem. The 2023 Transit is not part of that recall group, but it should be.

NHTSA complaint #11699408 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

This will be our second Balmar alternator that failed. The original alternator was replaced in March 2025 after the alternator basically melted. In April the new alternator was no longer charging the battery. It was finally serviced in July 2025. The dealership replaced a sensor and the recall to reduce the alternator output was performed. The recall was supposed to prevent the alternator from failing,however, two days later the alternator was no longer working. August 2025, the dealership has been discussing the issue with Winnebago and Balmar. September 2025 it was confirmed that the alternator needs to be replaced. This is a huge safety issue since the alternator will create a fire under the hood which was the case in our first incidence. This is also a continuos problem with the Winnebago Ekko’s and a solution should not be to keep replacing the alternator with the same exact make and model.

NHTSA complaint #11686053 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2023 Ford Transit. The contact stated that while driving at various speeds, the vehicle failed to accelerate properly while depressing the accelerator pedal. The contact stated that the vehicle eventually accelerated after repeatedly depressing the accelerator pedal. There was no warning light illuminated during the failure. The vehicle was taken to a dealer, where a diagnostic test was performed; however, no cause for the failure was found. The contact was informed by the mechanic that the failure was likely related to the computer system. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 75,000.

NHTSA complaint #11682813 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Odometer Fraud. The contact purchased a 2023 Ford Transit. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 20,813 and at the time of registration, it was discovered that the mileage was 125,055.

NHTSA complaint #11665368 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Vehicle shuts off completely off while driving intermittently. This issue has happened several times starting at 15000 miles. Vehicle has been back to dealership more than once regarding this issue. No codes are detected during diagnostics. UNSAFE

NHTSA complaint #11652187 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

After the recalll to fix the Balmer alternator and changing system. The Balmer alternator has failed. 21k miles. Recall repairs/fix did not resolve the issue.

NHTSA complaint #11649166 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The alternator and regulator failed. Parts are available for inspection. Safety was at risk as vehicle could stop or loose nighttime electrical lighting at highway speeds without any prior warning due to sudden loss of electric power. Selling dealer has inspected and confirmed failure of above parts. Components have not been otherwise inspected.The only symptom of imminent failure was a "whineing" noise form the engine compartment audible only when vehicle was not moving. There were no warning lamps, messages,or other signals . This failure occurred at 230 engine hours total and 7000 road miles on unit.

NHTSA complaint #11591496 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I've been waiting on a van for 500 days from Ford Motor Company. They built the van with a recall and now aren't giving me a time when the repair will be completed.

NHTSA complaint #11555933 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Blind spot detection system has frequent false alerts when no vehicles are present. Also, it often does not activate when a vehicle IS present. Totally unreliable and a safety risk if depended upon. As you can see in the attached photo, there are no vehicles in my blind spot yet the light continues to come on. He will often not come on when cars are present.

NHTSA complaint #11523875 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

NHTSA Recall Number 23V122. Ford advises that parts are anticipated to be available 3rd Quarter 2023. This is six (6) months from now.

NHTSA complaint #11512077 — an unverified report by a vehicle owner.