Owners have filed 12 complaints
about the 2018 Forest River R-Pod with NHTSA between 2017 and 2024.
The largest single group is the body & structure.
Across this model's run it ranks 3 of 3 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 50
Against the median year of the Forest River R-Pod. 50 means typical for this
model; 100 means roughly double.
Severity — 0
0% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — not reported
Too few complaints recorded a mileage to measure this.
How 2018 compares with every other Forest River R-Pod
Complaints filed with NHTSA, by model year. Bar colour is the FaultScore grade:
A
B
C
D
F
ungraded
What breaks on a 2018 Forest River R-Pod
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
Tires
325.0%
Median failure at 2,273 miles
Body & Structure
325.0%
Median failure at 1,000 miles
Other & Unspecified
216.7%
Suspension
216.7%
Fuel & Propulsion
18.3%
Electrical System
18.3%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Sep 2017peak 2Oct 2024
Recalls on the 2018 Forest River R-Pod
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2020606361 units in Canada
Structure
Issue: On certain travel trailers, the sewer termination pipe bracket could fail. If this happens, the plumbing could fall and drag on the ground or detach from the trailer while driving. Safety Risk: Plumbing that falls from the trailer could create a road hazard for others and increase the risk of a crash. Corrective Actions: Forest River will notify owners by mail and instruct you to take your trailer to a dealer to secure to the sewer termination pipe.
In the owners' own words, exactly as filed with NHTSA.
Eugene, OR
SUSPENSION
The contact owns a 2018 Forest River R-Pod Towable. The contact stated while stepping on the RV floor, the contact noticed that the side of the floor located behind the axle was sagging. Additionally, the contact stated that the driver's side outriggers were significantly corroded, fractured, and bent. Additionally, the contact stated that there was less than an inch clearance between the driver's side wheel well and tire, and there was 2-inch clearance between the passenger's side wheel well and the tire. The contact also stated that the passenger's side wheel was protruding 3-5 inches outside of the wheel well. The RV was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure. The failure mileage was unknown.
NHTSA complaint #11621800 — an unverified report by a vehicle owner.
Woodland Park, CO
SUSPENSION
There is a problem with the Axel on this trailer. It is making the floor buckle and the slide is sagging.
NHTSA complaint #11611620 — an unverified report by a vehicle owner.
Woodland Park, CO
STRUCTURE
There is a problem with the Axel on this trailer. It is making the floor buckle and the slide is sagging.
NHTSA complaint #11611620 — an unverified report by a vehicle owner.
Shorewood, WI
FUEL/PROPULSION SYSTEM
I just encountered an issue that could have been disastrous with our Rpod 177 travel trailer camper. The other day I happened to pull back the bed plywood and noticed that the propane hose and also 120 wire were chewed up from two long, sharp screws that hold some of the wood together by the water pump and go through into the bed frame/panel wood. The wire and hose are held together by cable ties attached to to bed frame to keep it away from heater I assume but as a result hold the bundle close to the screws. The rubbing from vibrations during travel nearly cut clear through the propane hose insulation and also cut the wire insulation. Considering the hose is right next to the heater this could have easily created a massive fire if it suddenly started to leak when the heater was on. I can't believe the manufacturer would use long screws in this area; they're extremely sharp and extend nearly an inch beyond the wood. I would imagine there are many other Rpod models with the same or similar layout that might have this issue.
NHTSA complaint #11477159 — an unverified report by a vehicle owner.
Carrollton, TX
TIRES
The contact owns a 2018 Forest River R-Pod equipped with Lionhead Tires, Tire Line: Castle rock, Tire size: 225/75/R15, Dot Number: JULT-1MT. The contact stated while the RV was parked outside of the residence, he heard a load pop coming from the vehicle. The contact inspected the vehicle and noticed that the spare tire had exploded, and the thread of the tire was separated and split into two pieces and separated from the frame. The tire was the original spare tire and had never been used. The spare tire was not replaced. The manufacturer was made aware of the failure.
NHTSA complaint #11433854 — an unverified report by a vehicle owner.
Woodside, NY
UNKNOWN OR OTHER
This is a 2018 Forest River Rpod RPT180 travel trailer, total about 10 trips or 4500 travel mileage. The underneath 2 support carriage beam for the whole structure buckle and bent down due to the manufacturer design/material failure. Both supporting beams above the axle buckle and the passenger side is more sever. On passenger side: there's about 4 inch drop/bent start from the axle; the rear wall frame already separated to the carriage beam; the wheel tilt in and about to loose. On driver side: there's about 1/2 inch bent down right above the axle. Inside the trailer, the wall buckle, floor buck up. At the current stage, it is not road worthy and not towable. It poses hazardous to any road user. This is an inexcusable major structure failure to design a beam not been able to carry the designated load.
NHTSA complaint #11432185 — an unverified report by a vehicle owner.
at 2,347 milesMelbourne Beach, FL
TIRES
TL* THE CONTACT OWNS A 2018 FOREST RIVER R-POD TRAILER EQUIPPED WITH CASTLE ROCK TIRES, TIRE LINE: LIONSHEAD, TIRE SIZE: ST225/75/R15, DOT NUMBER(S): JULT1MT1917 AND JULT1MT2217. THE CONTACT STATED THAT WHILE DRIVING 65 MPH ON THE FREEWAY, THE FENDER OVER THE PASSENGER'S SIDE TIRE THREAD SEPARATED WHICH CAUSED FENDER TO COME OFF. THE TIRE WAS REPLACED WITH A SPARE. THE CONTACT THEN STATED UPON DRIVING FIVE MORE MILES, THE DRIVER'S SIDE TIRE EXPERIENCED A BLOWOUT. THE TIRE WAS REPLACED AND THE TRAILER WAS DRIVEN BACK TO THE RESIDENCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE OF THE TIRE WAS 2,347. CONSUMER UPDATE: STATED THE FENDER OVER THE PASSENGER'S SIDE TIRE THREAD SEPARATED WHICH CAUSED FENDER TO COME OFF. SECOND TIRE BLEW OUT.
NHTSA complaint #11413943 — an unverified report by a vehicle owner.
Fairfield, PA
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2018 FOREST RIVER R-POD. THE CONTACT STATED THAT THE BRACKET DETACHED FROM THE TRAILER. THE CONTACT TEMPORARILY REPAIRED THE FAILURE WITH A SCREW TO HOLD THE BRACKET TOGETHER. THE VEHICLE WAS NOT YET DIAGNOSED NOR REPAIRED. A DEALER WAS NOT CONTACTED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 20V763000 (EQUIPMENT) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE.*DT
NHTSA complaint #11400205 — an unverified report by a vehicle owner.
at 2,200 milesVilla Hills, KY
TIRES
TL* THE CONTACT OWNS A 2018 FOREST RIVER R-POD EQUIPPED WITH CASTLE ROCK RADIAL ST226 TIRES, SIZE: ST225/75/R15 (NA). WHILE DRIVING APPROXIMATELY 66 MPH, THE REAR PASSENGER SIDE AXIAL TIRE SUDDENLY BLEW OUT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 2,200. THE VIN AND DOT NUMBER WERE UNKNOWN.
NHTSA complaint #11230672 — an unverified report by a vehicle owner.
Chesapeake, VA
UNKNOWN OR OTHER
MANUFACTURING DEFECT IN THERMOSTAT WIRE TO LIQUID PROPANE TANK. (XXXXXX). PROPANE HEAT WOULD NOT TURN OFF. TOOK IN FOR WARRANTY WORK AND WAS ADVISED THE CAUSE WAS A CRIMPED WIRE IN THE MANUFACTURING PROCESS. IF WE WERE NOT PRESENT TO SHUT OFF THE PROPANE TANK, IT WOULD HAVE BURNT DOWN OR WORSE. *DT PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) CARFAX CANNOT PROCESS THIS REQUEST.
NHTSA complaint #11154513 — an unverified report by a vehicle owner.
Chesapeake, VA
ELECTRICAL SYSTEM
MANUFACTURING DEFECT IN THERMOSTAT WIRE TO LIQUID PROPANE TANK. (XXXXXX). PROPANE HEAT WOULD NOT TURN OFF. TOOK IN FOR WARRANTY WORK AND WAS ADVISED THE CAUSE WAS A CRIMPED WIRE IN THE MANUFACTURING PROCESS. IF WE WERE NOT PRESENT TO SHUT OFF THE PROPANE TANK, IT WOULD HAVE BURNT DOWN OR WORSE. *DT PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) CARFAX CANNOT PROCESS THIS REQUEST.
NHTSA complaint #11154513 — an unverified report by a vehicle owner.
at 1,000 milesCarlsbad, NM
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2018 (NA) FOREST RIVER R-POD 176 TRAVEL TRAILER. WHILE DRIVING, THE BLACK WATER TANK PIPE DETACHED AND DRAGGED ON THE GROUND WITHOUT WARNING. AS A RESULT, THE VALVE LEAKED OF SEWAGE. THE CONTACT INDEPENDENTLY REPLACED THE VALVE, THE TERMINATION CAP, AND THE THREE INCH BAYONET AND DOUBLE WACK NUT. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT, DUE TO THE CONTACT NOT PROVIDING PROOF OF THE FAILURE BEFORE THE REPLACEMENT, THEY COULD NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 1,000. UPDATED 11/01/17*LJ VIN INVALID UPDATED 7/17/18*JB
NHTSA complaint #11023636 — an unverified report by a vehicle owner.