GMC Envoy XL 370 fuel system problems

FUEL/PROPULSION SYSTEM

DRIVING CAR BRAKES GO GET IT FIX PAID 375 TO GET FIX NOW NO POWER STEERING FUEL GAUGE DOSEN. T WORK WHAT A MESS NEED HELP

NHTSA complaint #11153687 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

STALLING OUT IN INTERSECTION,FUEL GAGE AND SPEED ODOMETER ,AIR BAGS DEFAULTING,SHACKING IN FRONT END , WHEN DRIVING. VERRY DANGEROUS.

NHTSA complaint #10885262 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2004 GMC ENVOY XL 370. WHILE DRIVING AT VARIOUS SPEEDS, THE LEFT TURN SIGNAL, HEADLIGHTS, AND TAIL LIGHTS FAILED TO OPERATE. IN ADDITION, THE FUEL PUMP MADE AN ABNORMAL NOISE AFTER THE VEHICLE WAS STARTED. THE FAILURE RECURRED NUMEROUS TIMES. THE CONTACT STATED THAT THE TRUNK DOOR FAILED TO CLOSE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 177,687.

NHTSA complaint #10854328 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

GMC IS ADMITTING TO A FAULTY GAS TANK AND ONLY COVERS THIS UP TO 150,000 MILES I BOUGHT THE CAR AFTER THE 150,000 MILES AND NOW HAVE GAS LEAKING THE TANK WAS NEVER FIXED. WHY DOES THE MILEAGE MAKE A DIFFERENCE? THIS IS A MAJOR SAFETY ISSUE THAT GMC SHOULD COVER REGARDLESS OF THE MILEAGE. JUST BECAUSE MY GAS TANK DID NOT LEAK AS SOON AS OTHER ONES DID MEANS I SHOULD NOT BE COVERED? A RECALL IS A RECALL AND THEY SHOULD BE RESPONSIBLE FOR FIXING THE PROBLEM.

NHTSA complaint #10851210 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

THIS IS ALL OVER THE INTERNET. PLASTIC GAS TANK LEAKS. GMC DOES NOT CARE. I TALKED WITH THEM THEY IGNORE REPAIR IS $1,600.00 OR MORE. PEOPLE ARE FIXING WITH GLUE? GASOLINE SPILL FROM CRACKED PLASTIC FUEL TANK.

NHTSA complaint #10811425 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

2004 GMC ENVOY XL (98000 MILES) FUEL TANK INLET CHECK VALVE FRACTURES CAUSING FUEL TO LEAK FROM TANK. POTENTIAL FIRE OR EXPLOSION DUE TO CRACK IN TANK GMC RECALL BUT NOT FOR MY VIN# SINCE THIS IS AN APPARENT FLAW IN TANK IT SHOULD BE FIXED BY GM IT WILL COST ME OVER $1500 FOR REPLACEMENT OF DEFECTIVE PART.

NHTSA complaint #10703647 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FUEL GAUGE SENSOR 2005 ENVOY XL DENALI. 70153 MILES. AFTER FUELING THE VEHICLE FUEL GAUGE REGISTERS EMPTY UNTIL ABOUT AN EIGHTH OF A TANK HAS BEEN USED THEN THE FUEL GAUGE WORKS JUST FINE. HAVE TO DISCONNECT THE POSITIVE BATTERY TERMINAL FOR APPX. TEN MINUTES TO GET THE SERVICE ENGINE LIGHT TO STOP ILLUMINATING. OCCURS EVERYTIME I FILL THE VEHICLE. IT CAUSES AN INACCURATE FUEL READING. TURNING IN TO DEALER TOMORROW 06-19-2013 FOR REPAIRS. CODE PRODUCED P0463.

NHTSA complaint #10520340 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I FILLED MY TANK AT A GAS STATION AND WHEN LEAVING THE "CHECK ENGINE" LIGHT CAME ON AND THE FUEL GAUGE DROPPED DOWN TO "E" AND LOW FUEL LIGHT CAME ON. AFTER 10-15 SECONDS THE FUEL GAUGE WENT ALL THE WAY TO "FULL". A FEW MINUTES LATER IT DID THE SAME THING AGAIN, AND HAS CONTINUED.

NHTSA complaint #10520249 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WE STARTED NOTICING AFTER A FILL UP AT THE GAS STATION THE GAS GAUGE STILL SHOWED EMPTY. THE GAUGE TOOK OVER AN HOUR OF DRIVING TO MOVE UP TO FULL. IN THE MIDDLE OF THE WEEK LAST WEEK THE VEHICLE RAN OUT OF GAS AND STALLED. WE ADDED HALF A TANK, BUT THE GAUGE STILL SHOWED EMPTY THE NEXT FEW TIMES IT WAS DRIVEN SOMEWHERE. LAST WEEKEND I FILLED UP AGAIN AND THE GAUGE SHOWED EMPTY STILL WITH WARNING INDICATOR ON. AGAIN IT TOOK OVER AN HOUR OF DRIVING FOR THE GAUGE TO REGISTER THE TANK EVEN 3/4 FULL.

NHTSA complaint #10510240 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

AIR CONDITIONER QUIT WORKING ON LEVEL 5, WOULD WORK ON LEVEL 1-4, LEVEL 5 WOULD KEEP TURNING OFF. SHORTLY AFTER THIS WITHIN THE SAME DAY I COULD SMELL SOMETHING BURNING COMING THROUGH THE AIR VENTS. MECHANICS NOTED AND SHOWED ME THAT THE RESISTOR PLUGS ON THE BACK HAD BURNED AND MELTED TOGETHER, THAT'S WHAT WAS CAUSING THE BURNING SMELL. NEEDED A NEW RESISTOR, PIG TAIL, AND BLOWER. ALSO MY FUEL GAUGE AND RPM ARE BROKE, HAVE NOT BEEN WORKING FOR THE PAST 3 YEARS.

NHTSA complaint #10465981 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FUEL GAUGE DOES NOT WORK. I WILL FILL UP THE TANK AND TURN ON THE CAR AND IT READS LOW FUEL AND THE INDICATOR LIGHT COMES ON. THEN I CAN BE DRIVING AND IT WILL JUMP UP TO PAST 1/4 TANK THEN SLOWLY GO DOWN TO E AND READ LOW FUEL.

NHTSA complaint #10453450 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

THE FUEL SENSOR ON MY VEHICLE SWINGS WILDLY FROM EMPTY TO FULL EVEN WHEN THE FUEL TANK HAS JUST BEEN FILLED. THIS RESULTS IN THE CHECK ENGINE LIGHT TO CONSTANTLY BE ON. I AM UNABLE TO DETERMINE HOW MUCH GAS IS IN THE CAR DUE TO THE FAULTY SENSOR. I HAVE CHECKED THE INTERNET AND THIS APPEARS TO BE A WIDESPREAD PROBLEM THAT HAS BEEN REPORTED FOR YEARS. I CALLED GM AND THEY TOLD ME THAT THEY HAVE KNOWN ABOUT THE PROBLEM AND WILL COVER 50% OF THE COST ONLY IF I TAKE IT TO A GM DEALER AND THAT MY PORTION OF THE COST WOULD BE BETWEEN $500 - $600 DOLLARS. THEY WOULD NOT COVER ANY OF THE COST IF I TAKE IT TO MY LOCAL MECHANIC. THIS PROBLEM HAS BEEN KNOWN BY GM FOR YEARS AND THEY SHOULD HAVE ISSUED A COMPLETE RECALL TO REPAIR THE DEFECTIVE PART(S).

NHTSA complaint #10447242 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

AFTER FILLING FUEL TANK, SENSOR WENT TO EMPTY IMEDIATELY. CHIMES ACTIVATE AND FUEL GAUAGE READS EMPTY.

NHTSA complaint #10444390 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FAULTY FUEL GAUGE WENT OUT AGAIN FOR THE SECOND TIME. FIRST TIME IT HAPPEN THE VEHICLE WAS UNDER WARRANTY. THIS TIME IT IS NOT COVERED. WE HAVE TAKEN THIS TRUCK TO THE SHOP TWICE TO WORK ON THE DASH BOARD INSTRUMENT CLUSTER.(OIL, BATTERY , FUEL).

NHTSA complaint #10443627 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

MY FUEL GAUGE STOPPED WORKING IN MY 2005 ENVOY AT APPROXIMATELY 40,000 MILES. THE FUEL GAUGE INDICATES THAT THE CAR IS OUT OF FUEL AFTER FILL THE TANK FULL. I HAVE NOTICED NUMEROUS COMPLAINTS ABOUT THIS PROBLEM AND HAVE ALSO RECEIVED A LETTER FROM GM STATING THAT THEY ARE AWARE OF THE PROBLEM AND WILL COVER UP TO 50% OF REPAIR AS MY WARRANT HAS EXPIRED. THE PROBLEM WITH ONLY COVERING 50% IS PAYING WITH FOR MY HALF OF THE REPAIR. I HAVE BEEN UNABLE TO COME UP WITH APPROXIMATELY THE $200 FOR THE REPAIR THEREFORE UNABLE TO HAVE IT REPAIRED. I SPOKE WITH GM CUSTOMER SERVICE AND THEY INFORMED ME THAT WAS MY OPTION. WHEN I ASKED WHY THERE HAS NOT BEEN A RECALL ON THE PROBLEM THEY INFORMED ME THAT I SHOULD CONTACT THE NHTSA. MY CONCERN IS THAT I LIVE IN A STATE WITH COLD WEATHER THAT REQUIRES THAT CAR TO WARM UP PRIOR TO DRIVING. SO I WAS KEEPING TRACK OF MY MILEAGE KNOWING WHEN I NEEDED TO FILL UP WITH GAS. ALTHOUGH, THIS WILL NOT BE ACCURATE IN WINTER AND AFRAID THAT MY SPOUSE (PRIMARY DRIVER OF THIS VEHICLE) WILL GET STRANDED ON THE ROAD. I HOPE IF/WHEN THIS HAPPENS IT IS NOT DURING A SNOW STORM WHERE AN AUTO ACCIDENT WILL THEN BECOME LIKELY. WHEN TALKING TO GM ALONG WITH THE FUEL SENSOR I EXPRESSES CONCERNS ABOUT OTHER ISSUES THAT I HAVE BEEN HAVING. FOR EXAMPLE, MY LICENSE PLATE LIGHT STOPPED WORKING, CHANGED THE BULB AND CHECKED THE FUSES AND STILL DOES NOT WORK; ALONG WITH HEAT ISSUES AND WAS INFORMED TO TAKE IN FOR DIAGNOSIS.

NHTSA complaint #10439002 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FUEL SENSOR, LOCATED IN GAS TANK, HAS FAILED. NO MATTER HOW MUCH GAS IS IN THE TANK, BE IT FULL, HALF FULL, OR LESS, THE SENSOR BELL RINGS AND THE GAUGE REGISTERS EMPTY. THIS ALSO CAUSES THE CHECK ENGINE LIGHT TO COME ON. GMC SHOULD RECALL, AS THIS IS VERY DANGEROUS. I THOUGHT I HAD MORE FUEL BUT RAN OUT OF GAS ON A MAJOR ROAD, THANKFULLY NO ACCIDENT. GMC HAS ADMITTED THERE IS A PROBLEM AND HAS AGREED TO PAY 50% OF REPAIRS, BUT THIS IS ONLY DONE UNDER A VEHICLE WARRANTY EXTENSION, NOT RECALL.

NHTSA complaint #10427997 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FUEL GAUGE READINGS ARE INACCURATE, DEALER WANTS TO REPLACE THE GAUGING SYSTEM IN THE TANK AT CONSUMERS COST. I BELIEVE IT IS A KNOWN PROBLEM AND SHOULD BE A WARRANTIED ITEM.

NHTSA complaint #10423831 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

MY 2005 GMC ENVOY SL ONLY HAS 47,000 MILES. I EXPERIENCED DASH ELECTRONICS CONCERNING WARNING INDICATOR LIGHTS ("POWER TRAIN COOLOING FAN AT 46,000 MILES") AND GAS TANK LEVEL GAUAGE STOPPED WORKING AT 40,000 MILES. I HAVE BEEN TOLD THAT THIS ISSUE RELATED TO AN OVERALL SENSOR PROBLEM AND WILL EFFECT THE HEADLIGHTS AND OTHER SAFETY RELATED ISSUES.

NHTSA complaint #10421696 — an unverified report by a vehicle owner.

FUEL SYSTEM, OTHER

FILLED CAR UP WITH GAS AND LOW FUEL LIGHT CAME ON. SINCE THEN LOW FUEL LIGHT STAYS ON EVEN WHEN TANK IS FULL.

NHTSA complaint #10420957 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 2005 GMC ENVOY XL 370. THE CONTACT STATED THAT AFTER REFUELING THE TANK, HE NOTICED THAT THE FUEL GAUGE WOULD READ IMPROPERLY. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE MANUFACTURER WAS CONTACTED THROUGH EMAIL AND HAD NOT YET REPLIED. THE FAILURE MILEAGE WAS APPROXIMATELY 49,000. THE VIN WAS UNAVAILABLE. UPDATED 09/29/2011 *LN

NHTSA complaint #10420009 — an unverified report by a vehicle owner.