2018 Honda Civic fuel system problems

FUEL/PROPULSION SYSTEM

My 1.5L turbo had the error message "Emissions System Problem" appear on the dash. When I went to AutoZone for them to run their diagnostic, it threw error code P219E which is indicative of a sticking-open fuel injector-pushing raw fuel through the engine and venting toxic vapors directly into my climate control system. Premature fuel injector failure is a known issue on Honda's 1.5L engines, but they have failed to address the issue related to the fuel injectors for these vehicles, presenting a serious safety hazard for drivers of their vehicles.

NHTSA complaint #11750006 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My vehicle is currently experiencing severe performance defects that directly mimic the documented failures associated with the defective, improperly molded fuel pump impellers. Specifically, I have experienced the following symptoms: Engine Stalling: The vehicle has lost engine power or stalled unexpectedly while in motion, creating an immediate and severe traffic hazard. Hard Starting / No-Start Condition: The engine frequently takes multiple crank cycles to start or fails to start entirely, despite a fully functional and recently tested 12V battery.Erratic Power Delivery: I have noticed severe engine hesitation and a loss of acceleration power while driving at highway speeds.I understand that American Honda has recalled over one million vehicles globally for this exact Denso fuel pump defect. Despite my vehicle exhibiting all classic symptoms of a failing, low-density fuel pump impeller, my specific VIN is currently not showing as "active" or "eligible" on the manufacturer's lookup tool.Because a sudden loss of engine power while driving significantly increases the risk of a crash or injury, this represents a critical safety issue. I request that American Honda corporate reviews this data, coordinates a diagnostic review with an authorized dealership without a diagnostic fee liability to myself, and covers the complete cost of a replacement fuel pump assembly under the safety recall countermeasure guidelines.Thank you for your immediate attention to this safety hazard.

NHTSA complaint #11747864 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact stated that the fuel pump was surging, and the vehicle was jerking while idling or while driving at undisclosed speeds. The contact stated that the vehicle stalled. The Check Engine warning light was illuminated. The contact stated that the failure was associated with NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline), which was previously repaired. The vehicle was taken to the local dealer, where an unknown diagnosis was provided. The vehicle was repaired, but the failure reoccurred. The manufacturer was contacted and opened an investigation. The failure mileage was approximately 104,661.

NHTSA complaint #11744496 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact stated that while driving the vehicle at an undisclosed speed, the vehicle jerked forward roughly and stalled. A check engine warning light illuminated on the instrument cluster. The vehicle was taken to a dealership, where technicians diagnosed the issue and replaced an evaporative emissions (EVAP) sensor. Despite this repair, the symptoms persisted and the vehicle continues to experience rough jerking and stalling, but the waring light no longer illuminates. The contact referenced NHTSA Campaign Number: 20V314000 (Fuel System, Gasoline) however, the VIN was not included in the recall repair. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 105,007.

NHTSA complaint #11739521 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

After Honda Safety Recall 24‑027 (“Replace the fuel pump motor”) was performed on my 2018 Honda Civic Si at an authorized Honda dealership, the vehicle began exhibiting fuel‑system‑related issues that did not exist prior to the recall work. Within one day of the initial recall repair, the vehicle developed hard‑start/extended‑crank behavior. The dealership later reported they had pinched an O‑ring during the recall work and replaced it. Next, I detected a fuel odor. After multiple refueling cycles to isolate the source, I reported the issue, and the dealership replaced an unspecified seal. Approximately one week after that repair, the vehicle developed a rich‑running condition and illuminated the check engine light with DTC P0172. On 2026‑03‑27, the dealership diagnosed the issue as failed fuel injectors and recommended replacement of all injectors, the fuel joint pipe, and associated seals. Their testing showed: EVAP system functioning normally; no induction leaks; MAF swap produced no change; fuel rail pressure at idle ~500 psi; and cylinders 1, 2, and 4 running rich relative to cylinder 3. Because the fuel system was disassembled multiple times immediately before the onset of the rich condition, and because the dealership acknowledged that contamination during recall work could plausibly cause injector malfunction, I am concerned that the post‑recall defect may be related to the recall procedure or subsequent rework. The dealership's alternative rationale was that fuel injector failures are so common on this platform that the failure was coincidental. That would imply the need for a fuel injection system recall. I am submitting this complaint because the vehicle developed fuel‑system performance and emissions issues only after the recall repair and subsequent rework, and the root cause remains uncertain. I request that NHTSA document this case and evaluate whether the recall procedure or related components may contribute to downstream fuel‑system failures.

NHTSA complaint #11732851 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

NHTSA complaint #11729690 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The contact stated that the vehicle failed to accelerate as needed. The contact associated the failure with NHTSA Campaign Number: 20V314000 (FUEL SYSTEM, GASOLINE). The vehicle was repaired; however, the failure reoccurred. The vehicle was towed back to the residence. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 56,000.

NHTSA complaint #11715148 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

1. the vehicle has stalled twice now. both times when i tried to accelerate. 2. the vehicle is having problems starting 3. the starter was replaced once before but now i wonder if it was related to the fuel pump 4. there is a fuel pump recall on 2018 Hondas but mine is not part of it 5. the vehicle has issues when i come to a complete stop, sometimes the car seems like it doesn't want to accelerate. 6. the vehicle has not been inspected yet and there are no warning lights.

NHTSA complaint #11712971 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

We got notified of the recall by mail in early 2024. We called the Honda dealership in our locality, First Texas Honda (3400 Steck Ave, Austin, TX 78757) about it and they said the parts weren't available yet, and was estimated to be ready by Fall 2024. In July 2024, we were driving on a highway and the accelerator stalled as we reached 80 mph, with the check engine light flashing. Cars around us had to swoosh left and right to avoid colliding with our stalled car. By extreme luck we were able to use the car's momentum to safely exit the highway. Upon restarting the car, power was restored and the check engine light didn't illuminate again. There was slight shuddering in low gears. We made an appointment at the same First Texas Honda mentioned above to fix the problem, but after inspection they insisted that the problem was caused by loose battery cable unrelated to the fuel pump recall. Charged us $225 for the inspection and denied to replace the recalled part. Their predatory practice should be illegal and we are so disappointed in the system.

NHTSA complaint #11703994 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I own a 2018 Honda Civic. On August 4, 2025, I brought the vehicle to Honda of Greenbelt in Maryland for a fuel pump replacement required by a service recall. Immediately after this repair, the vehicle began producing a strong fuel odor, and after refueling, the smell persists for several days each time I add gas. This issue did not exist prior to the repair. I contacted American Honda customer service to request assistance and to ask whether I could have the vehicle serviced at a different Honda dealership, since the issue appears to have been caused by the original repair. A case manager was assigned, but despite multiple calls and several voicemails, I have received no response or follow-up. All responses from American Honda customer service have been generic email acknowledgments, and no substantive assistance or resolution has been provided despite my repeated attempts to contact the assigned case manager. Because the fuel odor consistently appears after refueling, I am concerned the repair may have resulted in a leak or improper installation involving the fuel pump or related components. The entire fuel delivery system should be thoroughly re-checked to ensure there are no leaks or safety hazards. This presents a clear safety risk, including the potential for fire. I am requesting that this matter be formally reviewed due to the ongoing fuel-system safety concern and Honda’s lack of meaningful response.

NHTSA complaint #11702884 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact stated that while driving at 60 MPH, the vehicle started to stall while depressing the accelerator pedal with the oil and battery warning lights illuminated. The contact then stated that the vehicle drifted backwards while attempting to accelerate up an incline. The contact shifted the vehicle into neutral(N) before shifting into park(P) to turn off and restart the vehicle. Once the vehicle was restarted, the contact coasted off to the shoulder of the highway and called for tow truck assistance. The vehicle was towed off the highway, and the contact restarted the vehicle and safely drove the vehicle to the residence. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 141,000.

NHTSA complaint #11692311 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

P0302 Cylinder 2 Misfire Detected, diagnosis concluded fuel injector is faulty, the rest are to follow the same path. Vehicle hesitation happened during highway traffic driving.

NHTSA complaint #11683085 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

The recall for my 2018 Honda Civic EX-L (VIN: [XXX] ) was completed at the Honda service center in Santee. I have contacted both Honda corporate and the service center, and each time I was told the recall would be cleared, but it is still showing as *open* on the NHTSA site. Because of this, the car cannot pass the required Vehicle Safety Systems Inspection, blocking registration. The bank is holding loan funds for the sale and may cancel the loan due to the delay. I am requesting immediate action to have the recall status updated. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11681608 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

To Whom It May Concern, I am writing to report an issue with a recall for my [Year, Make, Model, VIN]. The recall has been completed, and I have contacted both the Honda corporate office and the service center in [XXX] regarding the status. However, the recall is still not showing as completed on the NHTSA site. This delay is preventing the vehicle from passing the Vehicle Safety Systems Inspection, which is required to finalize registration. The bank is holding funds for the sale, and there is a risk that the loan may be canceled if the registration cannot be completed. I am requesting urgent assistance to ensure the recall status is updated so the vehicle can pass inspection and the transaction can proceed. Thank you for your attention, Vtek Motorsports [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11680735 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I own a 2018 Honda Civic that is subject to an open fuel pump recall. My vehicle suddenly became completely inoperable. When attempting to start the car, all of the dashboard lights come on, but the engine will not start or crank. The vehicle has power but will not turn over at all. This failure happened without any prior warning. I contacted Nalley Honda in Union City, GA, and they confirmed that the issue is related to the fuel pump recall. However, they refused to provide towing for the vehicle and told me the earliest appointment available would be over a week out, despite the vehicle being undrivable due to this known safety defect. This situation puts my safety and my family’s safety at risk, as I am now stranded without reliable transportation because of a manufacturer defect. The problem has been acknowledged by the dealership but has not been resolved because of their refusal to assist with towing or provide a timely repair. There were no warning lights or error messages prior to the failure—this happened suddenly. I am requesting that the NHTSA investigate this issue further, as it presents a serious safety concern. I also want to report that Honda has not provided towing assistance or a loaner vehicle while the safety recall repair is pending, which leaves me without any transportation.

NHTSA complaint #11669881 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact stated that she was informed at the State inspection that the vehicle had failed inspection due to the recall of NHTSA Campaign Number: 23V858000(Fuel System, Gasoline); however, the part to do the recall repair was not yet available. Several unknown dealers were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11666529 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Honda issued a recall for the fuel pump system. Initially, when the recall came out, I contacted them about the recall they stated that the parts were on back order and they had a waiting list of people who were supposed to be serviced first. It took about five months for the parts to come back into stock and another month for me to get an appointment. Now I’m continuing to have issues with my fuel line

NHTSA complaint #11665518 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact stated that while driving at an undisclosed speed, the vehicle stalled. There was no warning light illuminated. The vehicle was able to be restarted. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were not yet available, and the contact was placed on the waiting list. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000. Parts distribution disconnect.

NHTSA complaint #11659304 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

UNKNOWN

NHTSA complaint #11651321 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact received notification of NHTSA Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11648976 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

UNKNOWN

NHTSA complaint #11644695 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11641143 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated the vehicle was difficult to start. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000. Parts distribution disconnect.

NHTSA complaint #11640948 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Needs Fuel pump replacement

NHTSA complaint #11640253 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact received notification of NHTSA Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11638236 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact received notification of NHTSA Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11637942 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11636218 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11635706 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

There has been a recall for the fuel pump of my Year: 2018 Make: Honda Model: Civic Sedan, however I have continuously reached out to various Honda service and was told the part is still unable. Based on the recall information, If the fuel pump module is inoperative, the engine may not start or can stall while driving, increasing the risk of a crash or injury. Does it take for an injury or death for me and my loved ones for me to finally get the part repaired at Honda's cost?

NHTSA complaint #11635519 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda Civic. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11634555 — an unverified report by a vehicle owner.