2008 Hyundai Sonata airbag problems

AIR BAGS

Car has a B1448 (ACTIVE) Passenger Occupant Detecting System (PODS) Circuit Fault Related to the passenger detecting pad in the front passenger seat problems started at 120,000 miles

NHTSA complaint #11725992 — an unverified report by a vehicle owner.

AIR BAGS

The contact owns a 2008 Hyundai Sonata. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 08V161000 (Air Bags); however, the dealer informed the contact that he had to pay for a diagnostic test prior to the recall repair. The contact declined. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 181,000.

NHTSA complaint #11611105 — an unverified report by a vehicle owner.

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:FRONT PASSENGER

The contact owns a 2008 Hyundai Sonata. The contact stated while driving at an undisclosed speed, the air bag warning light illuminated the instrument panel. The vehicle was taken to an independent mechanic, who diagnosed failures with the passenger's side occupancy sensor and occupant classification system. The vehicle was not repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was unknown.

NHTSA complaint #11569304 — an unverified report by a vehicle owner.

AIR BAGS

Took vehicle to independent Hyundai factory trained technician due to air bag light. Was advised this is due to failure of Occupant Classification System sensor in front passenger seat. This is related to NHTSA Campaign 08V161000, but technician advised my VIN was not listed under this recall. Technician advised me to contact Hyundai due to the recall and inquire if my vehicle could be covered, since leaving unaddressed could cause injury or death during collision. Manufacturer is aware of issue due to previous recall cited above. Spoke with Hyundai customer service phone line on 12/13/2022 and informed of issue, asking if the recall would cover my vehicle even though my VIN was not indicated in the previous recall. Customer service advised this could not be done. Asked customer service to file complaint about known safety issue and was given case #20713402. Customer service advised I could pay for repairs out of pocket and receive refund if recall was later issued. Action requested: expand recall 08V161000 to include additional 2008 Hyundai Sonatas exhibiting same manufacturer defect which is a risk to public safety.

NHTSA complaint #11497279 — an unverified report by a vehicle owner.

AIR BAGS

AIR BAG light is on, with defect in Occupant Classification System (passenger weight sensor), with OCS system lights flashing erratically with no passenger in seat. Hyundai dealer and corporation keep telling me that there is no relevant campaign related to my vehicle. There is information for "Campaign 083 – 2006 – 2008 Sonata – Occupant Classification System (OCS) Reprogramming" online. Internally labeled as 08-01-006 Body Electrical issue. Campaign clearly states that problem is to be fixed on individual customer basis, meaning it wouldn't show up as a official recall. Hyundai currently refuses to take responsibility.

NHTSA complaint #11493114 — an unverified report by a vehicle owner.

AIR BAGS

"AIR BAG" light stays on. Passenger side seatbelt light blinks on and off. Likely a Sensor issue, but seems to be a recurring problem with 2008 Sonatas.

NHTSA complaint #11417667 — an unverified report by a vehicle owner.

AIR BAGS

THE FRONT DRIVER SIDE DOOR HANDLE HAS CAME OFF AND SO HAS THE PASSENGER SIDE. THE INSIDE DOOR HANDLE ON THE DRIVER SIDE HAS CAME OFF AND THE DRIVER SIDE DOOR IS TOTALLY INOPERABLE. THIS S A TOTAL SAFETY HAZARD IN THE EVENT OF AN EMERGENCY, A CAR CRASH GOD FORBID OR EVEN THE CAR CATCHING FIRE. GETTING TO SAFETY WOULD BE VERY DIFFICULT. I CANT AFFORD TO CONTINUING FIXING AN ISSUE THAT IS DEFECTED TO BEGIN WITH. THE BRAKE LIGHTS DOESN'T ILLUMINATE ALL TIME WHEN ENGAGED AND MY AIR BAG LIGHTS ARE ON AND MY CAR SWAYS IN THE BACK DUE TO THE CONTROL ARM BEING RUSTED

NHTSA complaint #11383271 — an unverified report by a vehicle owner.

AIR BAGS

TL* THE CONTACT OWNS A 2008 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT INITIALLY TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO INFORMED HER OF NHTSA CAMPAIGN NUMBER: 08V161000 (AIR BAGS) WHICH HE LINKED TO THE FAILURE. THE CONTACT THEN TOOK THE VEHICLE TO GURNEE HYUNDAI (6251 GRAND AVE, GURNEE, IL 60031) WHERE A DIAGNOSTIC TEST WAS PERFORMED AND THE CONTACT WAS INFORMED THAT THE OCCUPANT CLASSIFICATION SYSTEM MAT NEEDED TO BE REPLACED. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED. THE CONTACT WAS PROVIDED AN ESTIMATE FOR THE REPAIR. THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 82,900.

NHTSA complaint #11377205 — an unverified report by a vehicle owner.

AIR BAGS

THE PASSENGER SEAT AIR BAG SENSOR MAT IS MALFUNCTIONED. THERE HAS BEEN A RECALL FOR THE ITEM AND IT'S EVERYWHERE ONLINE BUT YET MY CAR WASN'T IN THE RECALL BUT IT'S THE SAME EXACT PROBLEM. I HAVE CONTACTED COMPANY THEY WON'T SAY WHY ONLY SOME CARS WERE IN THE RECALL BUT YET MINE WASN'T EVEN THOUGH IT'S SAME PROBLEM.

NHTSA complaint #11351053 — an unverified report by a vehicle owner.

AIR BAGS

THE AIRBAG LIGHT WENT ON ON THE DASHBOARD AND THE 'PASSENGER AIRBAG OFF' LIGHT WAS NO LONGER ILLUMINATED WHEN THERE IS NO ONE SITTING IN THE SEAT. ERROR CODE B1448 WAS FOUND TO BE THE ERROR, WHICH IS A FAULTY PASSENGER SEAT SENSOR MAT. I HAVE SMALL CHILDREN AND THIS MAY BE AN ISSUE BECAUSE THE AIRBAG WILL ALWAYS DEPLOY REGARDLESS OF WHO IS SITTING THERE. THIS HAPPENED WHILE STATIONARY UPON TURNING THE CAR ON ONE DAY.

NHTSA complaint #11331346 — an unverified report by a vehicle owner.

AIR BAGS

RED AIRBAG WARNING LIGHT IS ON. PASSENGER AIR BAG LIGHT ALWAYS OFF, EVEN IF SEAT IS EMPTY. RED PASSENGER SEATBELT LIGHT ALWAYS FLASHING UNTIL SEAT BELT IS LATCHED, EVEN IF THERE IS NO ONE SITTING IN SEAT. THIS IS WHILE VEHICLE IS IN MOTION. RECEIVED B1448 ERROR CODE. DEALER SAYS VIN ISN'T IN THE RECALL. I HAVE CALLED 2 LOCAL HYUNDAI DEALERS AND HYUNDAI CORPORATE. SAME ANSWER.

NHTSA complaint #11322507 — an unverified report by a vehicle owner.

AIR BAGS

AIR BAG LIGHT HAS COME ON AND HASN'T GONE OFF...MECHANIC SAY IT MAY BE A SENOR BUT WHEN I LOOKED UP THE VIN TO CHECK OPEN RECALLS NOTHING POPS UP BUT FROM FURTHER READING THIS IS A MAIN ISSUE WITH THESE VECHILES

NHTSA complaint #11322190 — an unverified report by a vehicle owner.

AIR BAGS

AIRBAG LIGHT CAME ON WHILE THE VEHICLE WAS IN MOTION AND HAS NOT TURNED OFF.

NHTSA complaint #11310779 — an unverified report by a vehicle owner.

AIR BAGS

THE AIRBAG LIGHT IS ON AND THE PASSENGER SEAT BELT SIGN IS OFF. THE VEHICLE WAS IN MOTION.

NHTSA complaint #11298581 — an unverified report by a vehicle owner.

AIR BAGS

MY CAR IS AT THE DEALERSHIP AT PEARSON HYUNDAI, MIDLOTHIAN TPK RICHMOND VA SINCE NOV 21 2019 FOR AIR BAG RECALL REPAIR. THAT IS 3 WEEKS. THE DID NOT PROVIDE ME WITH A LOANER. I HAVE SPENT $700 ON A RENTAL AND HAD TO TURN IT BACK IN. EVERY TIME I CALL THEM, I GET THE RUN AROUND. I CAN'T GO TO WORK NOW. I AM A SINGLE MOTHER AND NOW I ONLY HAVE ONE PRESENT FOR MY DAUGHTER. IS THIS A TYPE OF COMPLAINT THAT CAN BE FILED WITH YOUR ORGANIZATION?

NHTSA complaint #11288558 — an unverified report by a vehicle owner.

AIR BAGS

MY AIR BAG LIGHT CAME ON IN MY CAR ABOUT 2 MONTHS AGO I DIDN'T PAY IT ANY MIND AT FIRST UNTIL I REALIZE THAT IT IS A SAFETY ISSUES WHEN DRIVING AND AN ACCIDENT OCCURS. NOT SURE WHAT IS THE PROBLEM WITH IT BUT IT NEEDS TO BE FIX

NHTSA complaint #11282080 — an unverified report by a vehicle owner.

AIR BAGS

THE PASSENGER BUCKLE WAS REPLACED IN APRIL 2017 AFTER AIRBAG LIGHT CAME ON. OCTOBER 2019 WENT TO DEALER TO HAVE AIRBAG LIGHT CHECKED AND THEY AGAIN SAY THE PASSENGER BUCKLE NEEDS TO BE REPLACED. THEY SAY IT IS NOT COVERED BY HYUNDAI 15 YEAR WARRANTY ON SEAT BELT BUCKLE ISSUES. CODE IS B1518. THEY SAY IT HAS TO FLASH A DIFFERENT CODE FOR THE EXTENDED WARRANTY. PAID $406 IN 2017 FOR THE REPAIR AND WILL NEED TO PAY $480 TO HAVE IT REPLACED AGAIN. I RARELY USE THE PASSENGER SEATING BECAUSE I USUALLY DRIVE ALONE. I AM THE ORIGINAL OWNER.

NHTSA complaint #11271197 — an unverified report by a vehicle owner.

AIR BAGS

I WOULD LIKE TO FILE A COMPLAINT DUE TO A FAULTY OCS SENSOR ON MY 2008 SONATA (ERROR CODE B1448). THIS IS A KNOWN ISSUE HYUNDAI INITIATED CAMPAIGN 083 TO ADDRESS. IN THIS CASE THE DEALERSHIP HUFFINES HYUNDAI DID FIX THE PROBLEM BY SENDING THE WHOLE SEAT OUT TO HAVE THE SENSOR REPROGRAMED. HOWEVER THIS SAME SENSOR FAILED AGAIN. THE DEALERSHIP CLAIMED THAT THEY CAN'T REPROGRAM THE SENSOR AGAIN AND OFFERED TO FIX IT AGAIN AT MY COST (EXTREMELY HIGH COST). THEY ARE CLAIMING THAT UNDER CAMPAIGN 083 THEIR RESPONSIBILITY IS TO ONLY REPAIR/REPROGRAMMING THE OCS SENSOR ONCE. THIS IS A SERIOUS SAFETY ISSUE SINCE THIS OCS SENSOR FAILED AND THE COMPLETE AIRBAG SYSTEM IS COMPROMISED AND WON'T ACTIVATE IN AN ACCIDENT. I ESCALATED THIS ISSUE TO HYUNDAI CORPORATE CUSTOMER CARE RESOLUTION TEAM AND THEY ECHOED THE SAME COMMENTS AS THE DEALERSHIP. THEIR RESPONSIBILITY IS TO ONLY TO REPAIR/REPROGRAMMING THE OCS SENSOR ONCE. I ASKED TO HAVE THIS ESCALATED THE NEXT LEVEL AND THIS PERSON BASICALLY SAID NO AND HE WOULDN'T ESCALATE IT. AFTER DOING SOME LENGTHY RESEARCH THERE IS NO OTHER SAFE WAY TO HAVE THIS FIXED OTHER THAN GOING THROUGH THE DEALERSHIP AT HIGH COST TO ME OR ANY OTHERS. THIS IS A KNOWN ISSUE WITH THE OCS SENSOR, HYUNDAI KNOWS IT'S PRONE TO FAILURE. THEY DON'T REPLACE THE SENSOR, JUST REPROGRAM THE SAME FAULTY SENSOR AND THEN WON'T FIX IT IF IT FAILS AGAIN. THIS SEEMS TO BE A DECISION BY HYUNDAI TO PUT PROFITS BEFORE CUSTOMER SAFETY. WHY WAS THIS NOT A FULL GOVERNMENT FORCED RECALL? WAS HYUNDAI GETTING AROUND THE RECALL RULES BY ISSUING A CAMPAIGN? CAMPAIGN 083 EFFECTED CLOSE TO 400,000 VEHICLES.

NHTSA complaint #11254215 — an unverified report by a vehicle owner.

AIR BAGS

THE AIRBAG LIGHT COMES ON AND OFF FROM TIME TO TIME. I NOTICE THAT THERE WAS A RECALL FOR THIS ISSUES ON 2008 MODEL. HOWEVER BY MY VIN NUMBER IT WON'T SHOW THAT NEEDS AN ATTENTION ON IT. PLEASE LET ME KNOW WHAT TO DO. ALSO, THERE IS MOOSE ON THE FRONT SIDE , PASSENGER SIDE. ON THE BACK THE CAR WIGGLES OVER 60MPH OR IF I HAVE 3 PEOPLE ON THE BACK. THANKS

NHTSA complaint #11254025 — an unverified report by a vehicle owner.

AIR BAGS

TL* THE CONTACT OWNS A 2008 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED AND REMAINED LIT WHILE THE VEHICLE WAS BEING OPERATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DISCOVERED THAT THERE WAS A PREVIOUS UNKNOWN RECALL ON THIS MODEL VEHICLE; HOWEVER, THERE WERE NO ACTIVE RECALLS ON THE CONTACT'S VEHICLE. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 140,000.

NHTSA complaint #11230863 — an unverified report by a vehicle owner.

AIR BAGS

THE AIRBAG LIGHT IS ON AND WHEN RAN ON DIAGNOSTIC MACHINE IT IS THE OCS MAT FAULT. IT HAS BEEN REPORTED AN ACKNOWLEDGED ISSUE ON THE 2008 HYUNDAI BUT WHEN I INFORMED THE DEALERSHIP THEY SAID MY BODY TYPE VEHICLE IS NOT COVERED? WHY WOULD THIS BE?

NHTSA complaint #11193225 — an unverified report by a vehicle owner.

AIR BAGS

AIR BAG LIGHT IS ON. WAS TOLD THE PASSENGER SEAT MAT SENSOR MAY BE DEFECTIVE. SEAT BELT LIGHT FLASHES ALL THE TIME UNLESS THE SEAT BELT IS HOOKED. THOUGHT THERE WAS A RECALL TO GET THE AIR BAGS FIXED. CAR NEEDS TO BE INSPECTED AND WON'T PASS WITH THE AIR BAG LIGHT ON.

NHTSA complaint #11181607 — an unverified report by a vehicle owner.

AIR BAGS

FOR THE PAST YEAR I HAVE HAD THIS CAR WHEN I BOUGHT IT USED. I HEARD THAT THERE WAS A RECALL ABOUT IT WHEN I LOOKED IT UP BUT NOT MY CAR SPECIFICLY. FOR THE PAST YEAR MY AIRBAG LIGHT HAS TURNED ON AND OFF EVERY NOW AND AGAIN AND NOW ITS JUST ON. I CONTINUED TO LOOK UP DETAILS CONCERNING THE SITUATION AND THERE HAVE BEEN MANY RECALLS FOR MY VEHICLE BUT NOT MINE SPECIFICALLY. AND SINCE IT IS A USED VEHICLE I DO NOT KNOW IF THE PREVIOUS OWNER OR DEALERSHIP HAS DONE THE RECALL FOR IT.

NHTSA complaint #11174408 — an unverified report by a vehicle owner.

AIR BAGS

HAVEN'T BEEN IN A CRASH RECENTLY, BUT AIR BAG LIGHT RANDOMLY CAME ON FOR NO REASON. WILL NOT GO AWAY (3 DAYS NOW)

NHTSA complaint #11151393 — an unverified report by a vehicle owner.

AIR BAGS

TL* THE CONTACT OWNS A 2008 HYUNDAI SONATA. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, THE PASSENGER SIDE AIR BAG INDICATOR ILLUMINATED AND REMAINED LIT. IN ADDITION, THE LOW BEAM HEADLIGHTS BECAME MISALIGNED TO THE LEFT AND FAILED TO ILLUMINATE THE FULL VIEW OF THE ROAD AHEAD. DOWNEY HYUNDAI (7550 FIRESTONE BLVD, DOWNEY, CALIFORNIA 90241, (562) 314-4331) WAS MADE AWARE OF THE AIR BAG INDICATOR FAILURE AND DISCONNECTED THE PASSENGER SIDE AIR BAG. THE DEALER STATED THAT THE PASSENGER SIDE AIR BAG NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. KEYES MISSION HILLS HYUNDAI (10240 SEPULVEDA BLVD, MISSION HILLS, CALIFORNIA 91345) WAS MADE AWARE OF THE HEADLAMP LIGHTING FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT PARTS AND LABOR WOULD NOT BE COVERED PER NHTSA CAMPAIGN NUMBER: 08E021000 (EXTERIOR LIGHTING) IN REGARDS TO THE HEADLIGHTS. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBERS: 08V161000 (AIR BAGS) AND 08E021000 (EXTERIOR LIGHTING) AS POTENTIAL CAUSES OF THE FAILURES. THE FAILURE MILEAGE WAS 121,605.

NHTSA complaint #11151457 — an unverified report by a vehicle owner.

AIR BAGS

AIR BAG LIGHT IS TURN ON AND NEVER GET TURN OFF FROM LAST TWO MONTH , I NEED TO FIX SO PLEASE MAKE A RECALL FOR AIR BAG.

NHTSA complaint #11122923 — an unverified report by a vehicle owner.

AIR BAGS

MY HYUNDAI SONATA 2008 GLS HAS AIRBAG SIGN ON AND WOULD NOT GO OFF. THE PASSENGER SEAT BELT SIGN IS FLASHING WITHOUT ANYBODY SEATING ON THE PASSENGER SIDE. THE DEALER SAID MY CAR IS NOT BEING RECALLED THEY SAID I HAVE TO GET IT FIXED. EVEN THOUGH MANY OTHER OWNERS THAT I CHECKED ONLINE HAD SAME ISSUES AND THEIR CARS GOT FIXED BY THE DEALERS AT NO COST BECAUSE THEY WERE RECALLED. PLZ RECALL MY CAR.

NHTSA complaint #11119456 — an unverified report by a vehicle owner.

AIR BAGS

AIR BAG LIGHT CAME ON AND IS STILL ON. I HAD DIAGNOSTICS DONE AT A HYUNDAI DEALERSHIP AND I PAID FOR IT. IT SAID IT IS B1448 DESCRIPTION PCS (OCCUPANTS CLASSIFICATION SYSTEM) MAT DEFECT. SHE EXPLAINED THAT THE AIR BAG MAY OR MAY NOT WORK WHEN SOMEONE IS SITTING IN PASSENGER SEAT.

NHTSA complaint #11104024 — an unverified report by a vehicle owner.

AIR BAGS

THE AIRBAG LIGHT PREVIOUSLY WOULD GO ON AND OFF AT TIMES. BUT NOW IT STAYS ON PERMANENTLY AND THE PASSENGER SEAT BELT LIGHT BLINKS ON AND OFF.

NHTSA complaint #11099472 — an unverified report by a vehicle owner.

AIR BAGS

SRS LIGHT CAME ON WHILE DRIVING WHEN THE PASSENGER SHIFTED SLIGHTLY IN THE FRONT PASSENGER SEAT. LIGHT REAPPEARS ON RESTARTS AND STAYS ON. OCS RECALL WAS DONE 9/23/11, BUT HAVE STILL HAD PROBLEMS WITH THIS. THINK THE CURRENT PROBLEM IS RELATED TO THE CUSHION, BUT KNOW HYUNDAI WON"T REPAIR A SECOND TIME. SEEMS TO BE A MAJOR PROBLEM WITH THIS MODEL FROM READING OTHER REPORTS OF THE SAME ISSUE.

NHTSA complaint #11093329 — an unverified report by a vehicle owner.