15 of the
122 complaints about the 1994 Isuzu Rodeo are about the
engine — 12% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
145,000 miles.
TL* THE CONTACT OWNS A 1994 ISUZU RODEO. WHILE DRIVING APPROXIMATELY 40 MPH THE CONTACT NOTICED SMOKE COMING FROM UNDERNEATH THE HOOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THE CAMSHAFT SEAL END PLUG NEEDED TO BE REPLACED. THE MECHANIC REFERRED THE CONTACT TO THE MANUFACTURER BECAUSE THERE WAS A RECALL FOR THE COMPONENT UNDER NHTSA CAMPAIGN ID NUMBER: 94V132000 (ENGINE AND ENGINE COOLING:ENGINE). THE MANUFACTURER STATED THE VEHICLE HAD PREVIOUS RECALL REPAIRS PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 168,600 UPDATED 10/21/11 *BF THE CONSUMER STATED THE CAM SHAFT SEAL PLUG CAME OUT AGAIN CAUSING OIL TO LEAK ON THE EXHAUST, WHICH CAUSED SMOKE TO EMIT FROM THE VEHICLE. UPDATED 11/02/11
NHTSA complaint #10411773 — an unverified report by a vehicle owner.
at 158,000 milesOcola, FL
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 1994 ISUZU RODEO. WHILE DRIVING 35 MPH, THE VEHICLE BEGAN LEAKING OIL. THROUGH ONLINE RESEARCH, THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 94V132000 (ENGINE AND ENGINE COOLING:ENGINE). HE CALLED THE MANUFACTURER REGARDING THE RECALL AND WAS INFORMED THAT THE VEHICLE HAD PREVIOUSLY BEEN REPAIRED ACCORDING TO THE RECALL. THE CONTACT STATED THAT HE HAS BEEN THE ONLY OWNER OF THE VEHICLE AND THE REPAIR WAS NEVER PERFORMED. THE MANUFACTURER WOULD NOT REPAIR THE FAILURE. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALER. THE FAILURE MILEAGE WAS 158,000.
NHTSA complaint #10249285 — an unverified report by a vehicle owner.
at 132,000 milesCompton, CA
ENGINE AND ENGINE COOLING
NHTSA CAMPAIGN 94V132000; ISUZU ISSUED A CAM SHAFT RECALL ON THE ENGINE. THIS VEHICLE WAS INCLUDED IN THE RECALL, BUT THE ENGINE WAS STILL LEAKING OIL, EVEN AFTER REPAIRED TWICE FOR THAT RECALL.
NHTSA complaint #10113377 — an unverified report by a vehicle owner.
Salem, OR
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
THIS IS AN ONGOING DEGRADATION OF THE HYDRAULIC LIFTER SYSTEM THAT WILL LEAD TO AN EVENTUAL ENGINE FAILURE. ACCORDING TO ISUZU MECHANICS, THE HYDRAULIC LIFTER SYSTEM IN THE ISUZU V-6 IS PRONE TO OIL SLUDGE BUILD-UP AND THE PREMATURE FAILURE OF THE ENGINE CAN ONLY BE AVOIDED THROUGH THE REPLACEMENT OF THE HYDRAULIC LIFTER SYSTEM. WHEN FIRST DIAGNOSED, THE MECHANICS USED A OIL CLEANER TO QUIET THE VALVE TRAIN. HOWEVER, AFTER MULTIPLE CLEANINGS AND SWITCHING TO SYNTHETIC OIL AS ADVISED BY ISUZU THE VALVE KNOCK REMAINS AND CONTINUES TO WORSEN. SEARCHES ON THE INTERNET OVER THE PAST YEAR INDICATE THAT THIS IS A WIDESPREAD PROBLEM WITH THE ISUZU V-6 AND HAS OCCURED WITH SIGNIFICANT REGULARITY. SO MUCH SO, SEVERAL WEBPAGES ARE DEVOTED TO THE PROBLEM.
NHTSA complaint #10052483 — an unverified report by a vehicle owner.
at 70,000 milesThousand Oaks, CA
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ENGINE OIL LEAKS ONTO TOP OF SPARK PLUGS AND EXHAUST MANIFOLD. LEAKS SEEM TO BE MOST PREVELANT WHEN THE ENGINE IS WARMING UP. I'VE HAD THE ENTIRE GASKET KIT REPLACED TWICE. OCCASIONALLY THERE IS ENOUGH OIL ACCUMULATION TO CAUSE A LIGHT SMOKE TO BE SEEN FOR JUST A MINUTE AND THE VEHICLE HAS ALWAYS HAD AN ACCOMPANYING OIL SMELL. OIL IS NOT LEAKED INTO COMBUSTION CHAMBER AND NO OIL LEAKS ONTO THE GROUND. PROBLEM DOES NOT SEEM TO BE RECTIFIABLE AND DEALER WON'T FIX THE PROBLEM WITHOUT ME PAYING 100% EACH TIME. PROBLEM HAS CAUSED DEGRADATION OF SPARK PLUG WIRES AND ONCE ALMOST CAUSED AN ACCIDENT WHEN A PLUG LOOSENED AND FAILED WHILE CLIMBING A MOUNTAIN PASS.
NHTSA complaint #10025440 — an unverified report by a vehicle owner.
Northlake, IL
ENGINE AND ENGINE COOLING:ENGINE
VEHICLE WOULD NOT START. DEALER REPLACED ENGINE/STARTER/CIGARETTE LIGHTER.
NHTSA complaint #567717 — an unverified report by a vehicle owner.
Melrose Park, IL
ENGINE AND ENGINE COOLING:COOLING SYSTEM
MOTOR STAYS OVERHEATED.*AK THE WATER PUMP, TIMING BELT, AND BYPASS HOSE HAVE BEEN REPLACED, HOWEVER PROBLEM CONTINUES, VEHICLE ALSO EXPERIENCES HESITATION. CONSUMER COMPLAINS OF NOISY BRAKES, ROTORS WERE GLAZED, ROTORS, PADS, AND SEALS WERE REPLACED, BRAKES CONTINUE TO MAKE NOISE. BATTERY CABLE WAS CORRODED. VEHICLE LURCHES INTO REVERSE, FUEL INJECTOR WAS LEAKING AND CAUSED LONG CRANK, ALL INJECTORS WERE REPLACED. REAR DRIVER DOOR WOULD NOT OPEN FROM OUTSIDE DUE TO LATCH STICKING. *SLC ALSO THE CIGARETTE LIGHTER WAS INOPERATIVE.
NHTSA complaint #8008803 — an unverified report by a vehicle owner.
Yorktown, VA
ENGINE AND ENGINE COOLING:ENGINE
THE DRIVER'S SIDE CAMSHAFT END PLUG WAS LEAKING OIL. THERE WAS A RECALL ON THIS, BUT THE DEALER SAID THAT MY CAR WASN'T COVERED. THE FIX WAS SUPPOSEDLY A PLATE INSTALLED OVER THE PLUG, WHICH MY CAR HAS, SO I SUPPOSE IT WAS INSTALLED AT THE FACTORY. I REMOVED THE PLUG AND HAVE NOTICED THAT THE LIP IS NOT SYMMETRIC ALL THE WAY AROUND THE SEAL, INDICATING THAT THE PLUG IS DEFECTIVE. I WOULD LIKE TO REPLACE MY PASSENGER SIDE PLUG, BUT I CANNOT REACH IT DUE TO A BRACKET. I CANNOT TELL WHETHER OR NOT THAT SIDE IS LEAKING. HALL ISUZU OF NEWPORT NEWS LOOKED UP MY VIN AND STATED THERE WAS NO OUTSTANDING RECALL ON THIS ITEM.
NHTSA complaint #721406 — an unverified report by a vehicle owner.
Phoenix, AZ
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ENGINE OIL LEAK AROUND THE SPARK PLUG AREA, UNABLE TO RECTIFY LEAKAGE.
NHTSA complaint #520464 — an unverified report by a vehicle owner.
FT Benning, GA
ENGINE AND ENGINE COOLING:ENGINE
OIL LEAKS FROM THE CAMSHAFT.
NHTSA complaint #701035 — an unverified report by a vehicle owner.